Wilfa PO1B-G013 User manual

PIZZA OVEN
PO1B -G013 /PO1B -G113/ PO1B- G116/ PO1B-G016
EN ·Instruction manual DK ·Betjeningsvejledning
NO ·Bruksanvisning FI ·Käyttöohje
SE ·Bruksanvisning

LES ALLE ANVISNINGER FØR BRUK
LÄS IGENOM ALLA INSTRUKTIONER INNAN PRODUKTEN ANVÄNDS
READ ALL INSTRUCTIONS BEFORE USING
2

NO
SE
DK
FI
EN
LES ALLE ANVISNINGER FØR BRUK
LÄS IGENOM ALLA INSTRUKTIONER INNAN PRODUKTEN ANVÄNDS
LÆS ALLE VEJLEDNINGER INDEN BRUG
LUE OHJEET HUOLELLISESTI ENNEN KÄYTTÖÄ
READ ALL INSTRUCTIONS BEFORE USING

4
INSTRUCTION MANUAL ·PIZZA OVEN
EN
INSTRUCTION MANUAL ·PIZZA OVEN

5
EN
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/ PO1B-G016
CONTENTS
6 IMPORTANT SAFETY INSTRUCTIONS
10 PRODUCT OVERVIEW
11 ASSEMBLY
12 LEAK TESTING
12 USE
12 LIGHTING INSTRUCTIONS
12 PIZZA BAKING
13 CLEANING AND MAINTENANCE
14 TROUBLESHOOTING
16 GUARANTEE
17 SUPPORT AND SPARE PARTS
17 RECYCLABILITY

6
INSTRUCTION MANUAL ·PIZZA OVEN
EN
IMPORTANT SAFETY INSTRUCTIONS
• WARNING: To reduce the risk of re, burn or
other injury, read this safety manual carefully and
completely before using this appliance.
INSTALLATION AND ASSEMBLY
• Do not modify the appliance.
• This appliance is not intended to be installed in or
on recreational vehicles and or boats.
• Check all gas supply ttings for leaks before each
use. Do not use the appliance until all connections
have been checked and do not leak.
• Do not smoke while leak testing. Never leak test
with an open ame.
OPERATION
• For outdoor use only.
• Never leave the appliance unattended during pre-
heating or use. If a re should occur, keep away
from the appliance and immediately call your re
department. Do not attempt to extinguish an oil or
a grease re with water.
• Failure to follow these instructions could result in
re, explosion or burn hazard which could cause
property damage, personal injury or death.
• Use in well-ventilated location.
• If you smell gas:
– Shut off gas to the appliance.

7
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
– Extinguish any open ame.
– If the odour continues, keep away from the
appliance and immediately call your gas supplier
or your re department.
– Check for leaks as described in this manual.
• Keep the fuel supply hose away from any heated
surfaces.
• The use of alcohol, prescription or non-prescription
drugs may impair the consumers ability to properly
assemble, move, store or safely operate the
appliance.
• Keep children and pets away from the appliance at
all times.
• Do not move the appliance when in use.
• This appliance is not intended for and should never
be used as a heater.
• When lighting, keep your face and hands as far
away from the appliance as possible.
• This appliance must be kept away from ammable
materials during use.
• It is recommended that protective gloves (eg oven
gloves) be used when handling particularly hot
components.
STORAGE AND/OR NON-USE
• Before cleaning, make sure the gas supply and
control knob is in the OFF position and that the

8
INSTRUCTION MANUAL ·PIZZA OVEN
EN
burner and oven has cooled.
• Turn off the gas supply at the gas cylinder after use.
• Spiders and insects can nest inside the burner of the
appliance and disrupt gas ow. Inspect the burner
at least once a year.
• Do not store this appliance indoors unless the gas
cylinder is disconnected.
• Do not store gas cylinder in a building, garage or
any other enclosed area and keep out of reach of
children at all times.
• If you have any questions concerning assembly or
operation, consult your dealer or LPG Gas Company.
• When used on the ground always place the
appliance and cylinder on at level ground.
• Your barbecue can be used with gas cylinders
between 5 kg and 15 kg. Follow the technical
information as stated in the instruction manual and
Check with your local gas supplier to have a suitable
gas cylinder for your barbecue.
• NOTE FOR CONSUMER: Retain for future Reference
CONNECTING THE GAS CYLINDER TO THE APPLIANCE
• This appliance is only suitable for use with low-
pressure butane or propane gas or LPG mixtures,
tted with the appropriate low-pressure regulator
via a exible hose.
• The hose should be secured to the regulator and

9
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
the appliance with hose clips. Make sure the exible
hose could not come in contact with hot surface and
avoid twisting.
• Use a suitable regulator that is certied to EN
16129:2013. Make sure the regulator and exible
hose comply with local code.
• Please consult your LPG dealer for information
regarding a suitable regulator for the gas cylinder.
• Make sure the gas cylinder is lower than the gas
connection/gas inlet
• Always place gas cylinder/bottle on a at level
surface DO NOT x on trolley. Care should be taken
so the gas hose and gas cylinder do not come in
contact with hot surfaces or sharp edges, and should
not pass under the barbecue
REGULATOR AND HOSE
• Use only regulators and hose approved for LP Gas
at the above pressures. The life expectancy of the
regulator is estimated as 2 years.
• The use of the wrong regulator or hose is unsafe;
always check that you have the correct items before
operating the barbecue.
• The hose used must conform to the relevant standard
for the country of use. Worn or damaged hose must
be replaced. Ensure that the hose is not obstructed,
kinked, or in contact with any part of the barbecue
other than at its connection.

10
INSTRUCTION MANUAL ·PIZZA OVEN
EN
PRODUCT OVERVIEW
2
3
1. Pizza stone
2. Pizza peel (Not included in PO1B-G013 and PO1B-G016)
3. Gas hose and connector (Not included in PO1B-G013 and PO1B-G016)
1
• For Flexible hose:
• Avoid twisting the exible tube when the appliance
is in use. The length of exible hose
• shall not exceed 1.2m. The hose should certied
according to applicable EN Standard and comply
with local code.

11
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
ASSEMBLY
NOTE: Make sure all the plastic protection is ripped off before assembling!
1. Unfold legs
2. Insert the pizza stone
3. Connect the gas hose to your pizza oven

12
INSTRUCTION MANUAL ·PIZZA OVEN
EN
LEAK TESTING
NB! Never check for leaks with an open ame. Do not smoke while leak testing.
Before testing, make sure that all packing materials are removed from the
appliance. Make a solution with one part liquid detergent and one part water. Use
a spray bottle, a brush or a rag to apply the solution to the ttings.
1. Ensure the control valve is OFF
2. Make sure the gas hose is connected to the pizza oven, and turn the gas on.
3. Apply the solution to all the gas ttings. If bubbles appear, you have a leak.
4. If there is a leak, immediately turn the gas off. Tighten the ttings where the
leak appeared.
5. Turn the gas back on and re-check.
6. Should the leak continue, turn the gas off and contact customer service.
USE
• Make sure the oven is placed on a safe and at surface, and that the leak test
has been successful.
• Remove all packaging material.
LIGHTING INSTRUCTIONS
1. Make sure the knob is in OFF position. Turn the gas valve over to open position.
2. Push in and slowly turn the knob anticlockwise until you hear a click, and the
burner ignites.
3. If the burner does not light, turn it off and wait for 5 minutes before repeating.
4. Connect to gas tank

13
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
PIZZA BAKING
1. Preheat your oven for *12-15 minutes (*15-18 minutes for the 16”)
2. Place your pizza on the pizza peel, and slide it into the pizza oven.
3. Turn your pizza frequently to bake the pizza evenly.
4. NB! Watch your pizza closely, different toppings and dough will give different
results.
TIP
Use full effect when preheating, and turn the heat down 10-20% under baking, or
rotate the pizza more frequently for a better result. If the topping is nished before
the pizza crust, turn the heat down, and the pizza stone will continue to bake the
crust. If the pizza sticks to your pizza peel, use our on the pizza peel to make it
less sticky. Be aware that the our could burn.
CLEANING AND MAINTENANCE
Store the pizza oven out of direct sunlight. Store it indoors where it’s possible to
store for longer periods of time. The pizza oven should not be exposed to harsh
weather conditions such as snow, heavy rain and strong wind.
Wait for the pizza oven to cool completely before moving it.
The outer shell may fade over time, this will not affect the performance.
• Do not use the pizza stone over open ame.
• Avoid extreme temperature changes to the stone. This can cause your pizza
stone to crack.
– Do not put frozen foods on the pizza stone.
– Do not put a cold pizza stone into a hot oven.
– Do not cool the pizza stone with cold water when the stone is hot.
• Handle the pizza stone carefully. It is fragile and can break if bumped or
dropped.
• Do not use the pizza stone while it is wet. The moisture could cause cracking.
Make sure the pizza stone is completely dry before use. You could dry it in an
oven at 60°C for 2 hours.

14
INSTRUCTION MANUAL ·PIZZA OVEN
EN
TROUBLESHOOTING
Problem Possible reasons Solutions
Burner will not
light
1. No gas ow
2. Coupling nut and
regulator not fully
connected.
3. Obstruction of gas
ow.
4. Disengagement of
burner to valve
5. Incorrect assembly
6. Possible burner defect
1. Check if the gas tank is
empty.
2. Tighten the coupling nut
until it stops. Tighten with
hand only.
3. Clear burner tube.
4. Reengage burner and valve.
5. Check steps in assembly
instructions
6. Contact your supplier
Sudden drop in
gas ow or low
ame
Out of gas 1. Check for gas in propane
tank.
2. Turn off the gas knob, wait
30 seconds and light oven.
If the ames are still low,
turn off gas control knob
and propane tank valve.
Disconnect the regulator.
Reconnect regulator and
leak test. Turn on the
propane tank valve, wait
30 seconds and then light
the oven.
Flames blow out. 1. High or gusting winds
2. Low on gas
1. Turn front of oven away from
the wind.
2. Rell gas tank
Flare-up 1. Grease build up
2. Excessive fat in meat
3. Excessive cooking
temperature
4. Excess our in the
cooking surface
1. Clean oven
2. Trim fats from meat before
cooking.
3. Adjust the temperature
accordingly
4. Brush the our from the
cooking surface

15
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
Flashback (Fire in
the burner tube,
roaring sound from
burner
1. Burner and or burner
tubes are blocked
2. Pressure drop during
ignition
1. Turn gas control knob off.
Clean the burner and or the
burner tubes
2. Turn off oven, ensure the
tank valve is fully open and
relight.

16
INSTRUCTION MANUAL ·PIZZA OVEN
EN
GUARANTEE
Wilfa issues a 5 year guarantee on this product from the day of purchase is
done. The guarantee covers production failure or defects that arise during
the guarantee period. Your purchase receipt works as proof towards retailer if
claiming your guarantee.
The guarantee is valid only for products that are bought and used in private
households. The guarantee is not valid if the product is used commercially.
The guarantee is not valid if the product is misused, used by negligence, if not
following instructions given by Wilfa, if modied or if unauthorized reparation
is done. The guarantee is also not valid for normal wear of the product, misuse,
lack of maintenance, use of wrong electrical voltage or:
• Overloading of product
• Coating
• Parts which are normally worn down
• Parts you can expect being replaced regularly (e.g. lter, battery etc.)
Instructions manual is also available at our website wilfa.com

17
PIZZA OVEN ·PO1B-G013/ PO1B-G113/ PO1B-G116/PO1B-G016
EN
AS Wilfa Nydalsveien 24, 0484 Oslo, Norway
TECHNICAL SPECIFICATIONS
Pizza oven Model PO1B-G013/
PO1B-G113 Total heat output power 4kW G30: 291g/h G31: 286g/h
PO1B-G016/
PO1B-G116 5.6kW G30: 408g/h G31: 400g/h
Category I3+(28-30/37) I3B/P(30) I3B/P(37) I3B/P(50)
Type of gas Butane Propane Butane, propane or their mixture
Gas pressure 28-30 mbar 37 mbar 28-30 mbar 37mbar 50 mbar
Injector
size/
marking
PO1B-G013/
PO1B-G113 1.03mm/1.03 1.03mm/1.03 0.95mm/0.95 0.89mm/0.89
PO1B-G016/
PO1B-G116 0.84mm/0.84 0.84mm/0.84 0.80mm/0.80 0.74mm/0.74
Destination countries GB, FR, IT, LU, LV, IE, BE,
GR, PT, ES, CY, CZ, LT,
SK, CH, SI
LU, NL DK,
FI, SE, CY,
CZ, EE, LT, LV,
MT, SK, SI,
BG, IS, NO,
TR, HR, RO,
IT, HU
PL AT, DE, SK,
CH, LU
OUTDOOR USE ONLY
DO NOT OPERATE THIS APPLIANCE BEFORE READING THE
INSTRUCTION MANUAL
WARNING: Accessible parts may be very hot. Keep young children
away
SUPPORT AND SPARE PARTS
For support please visit us at wilfa.com, and see our customer service/support
page. Here you will nd frequently asked questions, spare parts, tips and tricks
and all our contact information.
RECYCLABILITY
This marking indicates that this product should not be disposed with other
household wastes throughout the EU. To prevent possible harm to the
environment or human health from uncontrolled waste disposal, recycle
it responsibly to promote the sustainable reuse of material resources. To
return your used device, please use the return and collection systems or
contact the retailer where the product was purchased. They can take this product
for environmentally safe recycling free of charge.

18
NO
BRUKSANVISNING ·PIZZAOVN

19
NO
PIZZAOVN ·PO1B-G013/ PO1B-G113/ PO1B-G116/ PO1B-G016
INNHOLD
20 VIKTIGE SIKKERHETSANVISNINGER
23 PRODUKTOVERSIKT
24 MONTERING
26 LEKKASJETESTING
26 BRUK
26 INSTRUKSJONER FOR TENNING
26 PIZZASTEKING
27 RENGJØRING OG VEDLIKEHOLD
28 FEILSØKING
30 GARANTI
31 SUPPORT OG RESERVEDELER
31 GJENVINNING

20
NO
BRUKSANVISNING ·PIZZAOVN
VIKTIGE SIKKERHETSANVISNINGER
• ADVARSEL: Les hele denne sikkerhetshåndboken
nøye før du bruker apparatet for å redusere faren
for brann, brannskader eller andre skader.
INSTALLASJON OG MONTERING
• Ikke modiser produktet.
• Dette apparatet er ikke beregnet for installasjon i
campingbiler eller fritidsbåter.
• Kontroller alle gasskoblinger for lekkasje før hver
bruk. Ikke bruk apparatet før alle koblinger er
kontrollert og ikke lekker.
• Ikke røyk mens du utfører lekkasjetesten. Bruk aldri
en åpen amme til å teste for lekkasje.
BRUK
• Kun for utendørsbruk.
• La aldri apparatet være uten tilsyn under forvarming
eller bruk. Hvis det oppstår brann, må du holde deg
unna produktet og umiddelbart ringe brannvesenet.
Ikke forsøk å slukke en olje- eller fettbrann med vann.
• Hvis disse instruksjonene ikke følges, kan det føre til
brann, eksplosjon eller brannskader, som igjen kan
medføre materielle skader, personskader eller død.
• Brukes på et godt ventilert sted.
• Hvis du lukter gass:
– Slå av gassen til apparatet.
– Slukk eventuell åpen amme.