ZURN ENVIRO HYG1ECO User manual

HYG1ECO
ENVIRO SERIES
Single Portable Handwash Station
Installation,
Operation, Maintenance
and Parts Manual
Patents Pending
Portable Handwashing Station
LIMITED WARRANTY
All goods sold hereunder are warranted to be free from defects in material and factory workmanship for a period of three years from the
date of purchase. Decorative nishes warranted for one year. We will replace at no costs goods that prove defective provided we are
notied in writing of such defect and the goods are returned to us prepaid at Atlanta, GA, with evidence that they have been properly
maintained and used in accordance with instructions. We shall not be responsible for any labor charges or any loss, injury or damages
whatsoever, including incidental or consequential damages. The sole and exclusive remedy shall be limited to the replacement of the
defective goods. Before installation and use, the purchaser shall determine the suitability of the product for his intended use and the
purchaser assumes all risk and liability whatever in connection therewith. Where permitted by law, the implied warranty of merchantabi-
lity is expressly excluded. If the products sold hereunder are “consumer products,” the implied warranty of merchantability is limited to
a period of three years and shall be limited solely to the replacement of the defective goods. All weights stated in our catalogs and lists
are approximate and are not guaranteed.
NOTICE: READ ENTIRE MANUAL PRIOR TO INSTALLING PRODUCT.
WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov
ADVERTENCIA: Cáncer y daño reproductivo - www.P65Warnings.ca.gov
AVERTISSEMENT: Cancer et e󰀨ets néfastes sur la reproduction - www.P65Warnings.ca.gov
NOTE: The information in this manual is subject to change at any time without notice. Installations may be performed at di󰀨erent times
of construction by di󰀨erent individuals. For this reason, these instructions should be left on-site with the facility or maintenance
manager.
US 1.855.ONE.ZURN CANADA 1.905.405.8272 ZURN.COM
ZURN INDUSTRIES, LLC 511 W. Freshwater Way, Milwaukee, WI U.S.A. 53204 · Ph. 1-855-ONE-ZURN, Fax [phone]
In Canada: ZURN INDUSTRIES LIMITED 7900 Goreway Drive, Unit 10, Brampton, Ontario L6T 5W6, Ph. 905-405-8272, Fax [phone]
Rev. B Date:
02/17/21 C.N. No. 143497 Prod. | Dwg. No. FV772

FV772 - Rev. B - 02/17/21
Page 2
Rough-In/Overview Dimensions:

FV772 - Rev. B 02/17/21
Page 3
Parts Checklist
1. Base cabinet assembly.
2. Fresh water feed hose line and drain hose.
3. Backsplash assembly including mounting hardware.
4. Handle assembly inbluding mounting hardware.
Assembly Instructions
1. To install: position slots on backsplash with the holes on the base and then carefully tighten mounting
hardware using a phillips head screwdriver.
2. Install handle using hardware provided.
Start-up
First time use of the Eco portable hand wash sink:
1. Open cabinet door.
2. Take stainless steel braided ll hose with garden hose end and route it through grommet hole in bottom of cabinet to
outside of cabinet.
3. A garden hose by others can be connected at this time. Fill only with cold tap water.
4. Take drain hose and route it through grommet hole in bottom of cabinet. A garden hose by others may be connected to
drain hose to run to oor drain location.
5. Activate sensor faucet to clear water lines of any trapped air.
6. Close cabinet door.
7. Unit is now ready to use.
Daily Operation
1. Open door.
2. Route drain hose and fresh water inlet hose outside cabinet through the grommet hole.
3. Hook up fresh water (cold only) garden hose connection.
4. Connect garden hose extension and route to proper drain system.
5. Close door.
Manual
paper towel
dispenser
Manual soap
dispenser
Large capacity
washbasin
prevents splashout
16 Gauge heavy-duty
stainless steel
Sensor faucet
Grab bar
O󰀨set drain
prevents aerosolization
of pathogens
EZ Roll
locking casters
Optional:
• CuVerro® antimicrobial
copper-nickel surface sink

FV772 - Rev. B - 02/17/21
Page 4
Care and Maintenance
Storage
1. When storing the unit, empty all water from the unit to prevent freeze damage and stagnant water from remaining in
plumbing lines.
2. To purge water from the system, disconnect the garden hose from the stainless ll hose and let water drain from the ll
hose.
3. Activate the faucet with the water disconected to release any water inside the system.
4. Check that all water has drained from sink and the drainage hose.
5. Check to ensure inside cabinet is dry so to avoid any lasting water damage to the inside.