3m Scalegard blend series User manual

for 3M™ScaleGard™Blend Series of Products

Cartridge Change-Out Instructions

For ALL 3M™ScaleGard™Blend (SGB) Series of Products

B145-CLS, B145H-CLS, B165-CLS, B165H-CLS, B195-CLS, B195H-CLS, B1175H-S,

B1175-S, ES145-CLS, ES165-CLS

Note: Installer - Please leave with owner/operator

3M™Water Filtration Products

WARNING:

Read entire manual: Failure to follow all guides and rules could cause personal injury or property damage.

• Check with your local public works department for plumbing codes. You must follow their guidelines as you install the Water Filtration system.

• Your Water Filtration system will withstand up to 125 pounds per square inch (psi) (862 kPa; 8,62 bar) water pressure. (100 psi (689 kPa; 6,89 bar) for B1175H-S &

B1175-S only). If your water supply pressure is higher than 80 psi (552 kPa; 5,52 bar), install a pressure reducing valve before installing the Water Filtration system.

To reduce the risk associated with choking:

• Do not allow children under 3 years of age to have access to small parts during the installation of this product.

To reduce the risk associated with the ingestion of contaminants:

• Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system.

NOTICE:

To reduce the risk associated with property damage due to water leakage or ﬂooding:

• Read and follow Use Instructions before installation and use of this system.

• Change the disposable ﬁlter cartridge at the recommended interval; the disposable ﬁlter cartridge MUST be replaced every 12 months or sooner.

• Failure to replace the disposable ﬁlter cartridge at recommended intervals may lead to reduced ﬁlter performance and failure of the ﬁlter, causing property damage from

water leakage or ﬂooding.

• Protect from freezing, remove ﬁlter cartridge when temperatures are expected to drop below 40° F (4.4° C).

• Do not install systems in areas where ambient temperatures may go above 100° F (38° C).

• Do not install on hot water supply lines. The maximum operating water temperature of this system is 100°F (38°C).

• Do not install if water pressure exceeds 125 psi (862 kPa; 8,62 bar). (100 psi (689 kPa; 6,89 bar) for B1175H-S & B1175-S only). If your water pressure exceeds 80 psi (552

kPa; 5,52 bar), you must install a pressure limiting valve. Contact a plumbing professional if you are uncertain how to check your water pressure.

CARTRIDGE CHANGE INSTRUCTIONS

STEP 1

Turn cartridge slowly to the left, about 1/4 turn, until it stops (when

arrows line up). At this position, both inlet and outlet ports are closed &

water pressure has been relieved. Inlet water will automatically turn off.

STEP 2

Pull used cartridge straight down & discard.

Note: There may be a small amount of residual water drainage after

pressure is relieved and during cartridge removal.

STEP 3

Remove sanitary cap from top of new

cartridge. Moisten o-ring with water and push new cartridge into

ﬁlter head. Turn cartridge 1/4 turn to the right until it stops. Top

surface of cartridge will become ﬂush with bottom of the head when

fully engaged. The label should be facing forward.

STEP 4

Inlet water will automatically turn on. Flush new ﬁlter cartridge in

accordance with Performance Data Sheet expelling any trapped air

and carbon ﬁnes. Water may run cloudy with air but will quickly clear.

System is now ready for use.

STEP 5

Complete water hardness test as per water hardness test kit instruc-

tions provided with new cartridge. The water sample used for com-

pleting the water hardness test should be taken upstream before the

location of the new 3M™ ScaleGard™ Blend product. If your site is a

new build, the water sample used for completing the water hardness

test should be taken at a nearby existing site.

STEP 6

Based on water hardness test results (Step 5), set blend setting in head as per

the food service application tables (see pages 3 - 11).

Cartridge Settings & Capacities

Vending

Inlet Water Hardness Vending Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 1,234

(4,671)

1,745

(6,606)

2,909

(11,010)

4,882

(18,480)

1,728

(6,539)

2,443

(9,249)

4,072

(15,414)

6,835

(25,872) 6

120 7 8 7 12 1,028

(3,893)

1,454

(5,505)

2,424

(9,175)

4,069

(15,400)

1,440

(5,450)

2,036

(7,707)

3,394

(12,845)

5,696

(21,560) 6

140 8 10 8 14 787

(2,977)

1,112

(4,210)

1,854

(7,017)

3,057

(11,571)

1,101

(4,168)

1,557

(5,894)

2,596

(9,824)

4,280

(16,199) 5

160 9 11 9 16 596

(2,255)

842

(3,189)

1,404

(5,315)

2,229

(8,437)

834

(3,157)

1,179

(4,465)

1,966

(7,441)

3,120

(11,812) 4

180 11 13 10 18 530

(2,004)

749

(2,835)

1,248

(4,725)

1,981

(7,500)

741

(2,806)

1,048

(3,969)

1,747

(6,615)

2,774

(10,499) 4

200 12 14 11 20 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 3

220 13 15 12 22 371

(1,406)

525

(1,988)

875

(3,313)

1,389

(5,259)

520

(1,968)

735

(2,783)

1,225

(4,639)

1,945

(7,363) 3

240 14 17 13 24 340

(1,289)

481

(1,822)

802

(3,037)

1,274

(4,821)

477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750) 3

260 15 18 15 26 275

(1,041)

389

(1,472)

648

(2,453)

1,029

(3,894)

385

(1,457)

544

(2,061)

907

(3,435)

1,440

(5,452) 2

280 16 20 16 28 255

(966)

361

(1,367)

602

(2,278)

955

(3,616)

357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062) 2

300 18 21 17 30 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 2

320 19 22 18 32 223

(846)

316

(1,196)

527

(1,993)

836

(3,164)

313

(1,184)

442

(1,674)

737

(2,791)

1,170

(4,429) 2

340 20 24 19 34 210

(796)

297

(1,126)

496

(1,876)

787

(2,978)

294

(1,114)

416

(1,576)

694

(2,626)

1,101

(4,169) 2

360 21 25 20 36 199

(752)

281

(1,063)

468

(1,772)

743

(2,812)

278

(1,052)

393

(1,488)

655

(2,480)

1,040

(3,937) 2

380 22 27 21 38 188

(712)

266

(1,007)

443

(1,679)

704

(2,664)

263

(997)

372

(1,410)

621

(2,350)

985

(3,730) 2

400 23 28 22 40 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 1

440 26 31 25 44 144

(547)

204

(773)

340

(1,289)

540

(2,045)

202

(765)

286

(1,082)

477

(1,804)

756

(2,863) 1

480 28 34 27 48 132

(501)

187

(709)

312

(1,181)

495

(1,875)

185

(702)

262

(992)

437

(1,654)

693

(2,625) 1

520 30 36 29 52 122

(463)

173

(654)

288

(1,090)

457

(1,731)

171

(648)

242

(916)

403

(1,526)

640

(2,423) 1

560 33 39 31 56 113

(430)

160

(607)

267

(1,012)

425

(1,607)

159

(601)

225

(850)

374

(1,417)

594

(2,250) 1

600 35 42 34 60 106

(401)

150

(567)

250

(945)

396

(1,500)

148

(561)

210

(794)

349

(1,323)

555

(2,100) 1

640 37 45 36 64 99

(376)

140

(532)

234

(886)

371

(1,406)

139

(526)

197

(744)

328

(1,240)

520

(1,969) 1

680 40 48 38 68 93

(354)

132

(500)

220

(834)

350

(1,323)

131

(495)

185

(700)

308

(1,167)

489

(1,853) 1

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Drip Coffee

Inlet Water Hardness Drip Coffee Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 1,234

(4,671)

1,745

(6,606)

2,909

(11,010)

4,882

(18,480)

1,728

(6,539)

2,443

(9,249)

4,072

(15,414)

6,835

(25,872) 6

120 7 8 7 12 1,028

(3,893)

1,454

(5,505)

2,424

(9,175)

4,069

(15,400)

1,440

(5,450)

2,036

(7,707)

3,394

(12,845)

5,696

(21,560) 6

140 8 10 8 14 787

(2,977)

1,112

(4,210)

1,854

(7,017)

3,057

(11,571)

1,101

(4,168)

1,557

(5,894)

2,596

(9,824)

4,280

(16,199) 5

160 9 11 9 16 596

(2,255)

842

(3,189)

1,404

(5,315)

2,229

(8,437)

834

(3,157)

1,179

(4,465)

1,966

(7,441)

3,120

(11,812) 4

180 11 13 10 18 530

(2,004)

749

(2,835)

1,248

(4,725)

1,981

(7,500)

741

(2,806)

1,048

(3,969)

1,747

(6,615)

2,774

(10,499) 4

200 12 14 11 20 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 3

220 13 15 12 22 371

(1,406)

525

(1,988)

875

(3,313)

1,389

(5,259)

520

(1,968)

735

(2,783)

1,225

(4,639)

1,945

(7,363) 3

240 14 17 13 24 340

(1,289)

481

(1,822)

802

(3,037)

1,274

(4,821)

477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750) 3

260 15 18 15 26 275

(1,041)

389

(1,472)

648

(2,453)

1,029

(3,894)

385

(1,457)

544

(2,061)

907

(3,435)

1,440

(5,452) 2

280 16 20 16 28 255

(966)

361

(1,367)

602

(2,278)

955

(3,616)

357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062) 2

300 18 21 17 30 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 2

320 19 22 18 32 223

(846)

316

(1,196)

527

(1,993)

836

(3,164)

313

(1,184)

442

(1,674)

737

(2,791)

1,170

(4,429) 2

340 20 24 19 34 210

(796)

297

(1,126)

496

(1,876)

787

(2,978)

294

(1,114)

416

(1,576)

694

(2,626)

1,101

(4,169) 2

360 21 25 20 36 199

(752)

281

(1,063)

468

(1,772)

743

(2,812)

278

(1,052)

393

(1,488)

655

(2,480)

1,040

(3,937) 2

380 22 27 21 38 188

(712)

266

(1,007)

443

(1,679)

704

(2,664)

263

(997)

372

(1,410)

621

(2,350)

985

(3,730) 2

400 23 28 22 40 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 1

440 26 31 25 44 144

(547)

204

(773)

340

(1,289)

540

(2,045)

202

(765)

286

(1,082)

477

(1,804)

756

(2,863) 1

480 28 34 27 48 132

(501)

187

(709)

312

(1,181)

495

(1,875)

185

(702)

262

(992)

437

(1,654)

693

(2,625) 1

520 30 36 29 52 122

(463)

173

(654)

288

(1,090)

457

(1,731)

171

(648)

242

(916)

403

(1,526)

640

(2,423) 1

560 33 39 31 56 113

(430)

160

(607)

267

(1,012)

425

(1,607)

159

(601)

225

(850)

374

(1,417)

594

(2,250) 1

600 35 42 34 60 106

(401)

150

(567)

250

(945)

396

(1,500)

148

(561)

210

(794)

349

(1,323)

555

(2,100) 1

640 37 45 36 64 99

(376)

140

(532)

234

(886)

371

(1,406)

139

(526)

197

(744)

328

(1,240)

520

(1,969) 1

680 40 48 38 68 93

(354)

132

(500)

220

(834)

350

(1,323)

131

(495)

185

(700)

308

(1,167)

489

(1,853) 1

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Tea

Inlet Water Hardness Tea Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 1,234

(4,671)

1,745

(6,606)

2,909

(11,010)

4,882

(18,480)

1,728

(6,539)

2,443

(9,249)

4,072

(15,414)

6,835

(25,872) 6

120 7 8 7 12 1,028

(3,893)

1,454

(5,505)

2,424

(9,175)

4,069

(15,400)

1,440

(5,450)

2,036

(7,707)

3,394

(12,845)

5,696

(21,560) 6

140 8 10 8 14 787

(2,977)

1,112

(4,210)

1,854

(7,017)

3,057

(11,571)

1,101

(4,168)

1,557

(5,894)

2,596

(9,824)

4,280

(16,199) 5

160 9 11 9 16 596

(2,255)

842

(3,189)

1,404

(5,315)

2,229

(8,437)

834

(3,157)

1,179

(4,465)

1,966

(7,441)

3,120

(11,812) 4

180 11 13 10 18 530

(2,004)

749

(2,835)

1,248

(4,725)

1,981

(7,500)

741

(2,806)

1,048

(3,969)

1,747

(6,615)

2,774

(10,499) 4

200 12 14 11 20 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 3

220 13 15 12 22 371

(1,406)

525

(1,988)

875

(3,313)

1,389

(5,259)

520

(1,968)

735

(2,783)

1,225

(4,639)

1,945

(7,363) 3

240 14 17 13 24 340

(1,289)

481

(1,822)

802

(3,037)

1,274

(4,821)

477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750) 3

260 15 18 15 26 275

(1,041)

389

(1,472)

648

(2,453)

1,029

(3,894)

385

(1,457)

544

(2,061)

907

(3,435)

1,440

(5,452) 2

280 16 20 16 28 255

(966)

361

(1,367)

602

(2,278)

955

(3,616)

357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062) 2

300 18 21 17 30 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 2

320 19 22 18 32 223

(846)

316

(1,196)

527

(1,993)

836

(3,164)

313

(1,184)

442

(1,674)

737

(2,791)

1,170

(4,429) 2

340 20 24 19 34 210

(796)

297

(1,126)

496

(1,876)

787

(2,978)

294

(1,114)

416

(1,576)

694

(2,626)

1,101

(4,169) 2

360 21 25 20 36 199

(752)

281

(1,063)

468

(1,772)

743

(2,812)

278

(1,052)

393

(1,488)

655

(2,480)

1,040

(3,937) 2

380 22 27 21 38 188

(712)

266

(1,007)

443

(1,679)

704

(2,664)

263

(997)

372

(1,410)

621

(2,350)

985

(3,730) 2

400 23 28 22 40 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 1

440 26 31 25 44 144

(547)

204

(773)

340

(1,289)

540

(2,045)

202

(765)

286

(1,082)

477

(1,804)

756

(2,863) 1

480 28 34 27 48 132

(501)

187

(709)

312

(1,181)

495

(1,875)

185

(702)

262

(992)

437

(1,654)

693

(2,625) 1

520 30 36 29 52 122

(463)

173

(654)

288

(1,090)

457

(1,731)

171

(648)

242

(916)

403

(1,526)

640

(2,423) 1

560 33 39 31 56 113

(430)

160

(607)

267

(1,012)

425

(1,607)

159

(601)

225

(850)

374

(1,417)

594

(2,250) 1

600 35 42 34 60 106

(401)

150

(567)

250

(945)

396

(1,500)

148

(561)

210

(794)

349

(1,323)

555

(2,100) 1

640 37 45 36 64 99

(376)

140

(532)

234

(886)

371

(1,406)

139

(526)

197

(744)

328

(1,240)

520

(1,969) 1

680 40 48 38 68 93

(354)

132

(500)

220

(834)

350

(1,323)

131

(495)

185

(700)

308

(1,167)

489

(1,853) 1

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Espresso

Inlet Water Hardness Espresso Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 1,234

(4,671)

1,745

(6,606)

2,909

(11,010)

4,882

(18,480)

1,728

(6,539)

2,443

(9,249)

4,072

(15,414)

6,835

(25,872) 6

120 7 8 7 12 918

(3,473)

1,298

(4,912)

2,163

(8,187)

3,567

(13,499)

1,285

(4,862)

1,817

(6,877)

3,028

(11,461)

4,993

(18,899) 5

140 8 10 8 14 681

(2,577)

963

(3,645)

1,605

(6,075)

2,547

(9,642)

953

(3,608)

1,348

(5,103)

2,247

(8,504)

3,566

(13,499) 4

160 9 11 9 16 596

(2,255)

842

(3,189)

1,404

(5,315)

2,229

(8,437)

834

(3,157)

1,179

(4,465)

1,966

(7,441)

3,120

(11,812) 4

180 11 13 10 18 454

(1,718)

642

(2,430)

1,070

(4,050)

1,698

(6,428)

635

(2,405)

899

(3,402)

1,498

(5,670)

2,377

(9,000) 3

200 12 14 11 20 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 3

220 13 15 12 22 325

(1,230)

460

(1,740)

766

(2,899)

1,216

(4,602)

455

(1,722)

643

(2,435)

1,072

(4,059)

1,702

(6,443) 2

240 14 17 13 24 298

(1,127)

421

(1,595)

702

(2,658)

1,114

(4,219)

417

(1,578)

590

(2,232)

983

(3,721)

1,560

(5,906) 2

260 15 18 15 26 275

(1,041)

389

(1,472)

648

(2,453)

1,029

(3,894)

385

(1,457)

544

(2,061)

907

(3,435)

1,440

(5,452) 2

280 16 20 16 28 255

(966)

361

(1,367)

602

(2,278)

955

(3,616)

357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062) 2

300 18 21 17 30 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 2

320 19 22 18 32 223

(846)

316

(1,196)

527

(1,993)

836

(3,164)

313

(1,184)

442

(1,674)

737

(2,791)

1,170

(4,429) 2

340 20 24 19 34 187

(707)

264

(1,001)

441

(1,668)

699

(2,647)

262

(990)

370

(1,401)

617

(2,335)

979

(3,706) 1

360 21 25 20 36 177

(668)

250

(945)

416

(1,575)

660

(2,500)

247

(935)

349

(1,323)

582

(2,205)

925

(3,500) 1

380 22 27 21 38 167

(633)

236

(895)

394

(1,492)

626

(2,368)

234

(886)

331

(1,253)

552

(2,089)

876

(3,316) 1

400 23 28 22 40 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 1

440 26 31 25 44 144

(547)

204

(773)

340

(1,289)

540

(2,045)

202

(765)

286

(1,082)

477

(1,804)

756

(2,863) 1

480 28 34 27 48 132

(501)

187

(709)

312

(1,181)

495

(1,875)

185

(702)

262

(992)

437

(1,654)

693

(2,625) 1

520 30 36 29 52 122

(463)

173

(654)

288

(1,090)

457

(1,731)

171

(648)

242

(916)

403

(1,526)

640

(2,423) 1

560 33 39 31 56 113

(430)

160

(607)

267

(1,012)

425

(1,607)

159

(601)

225

(850)

374

(1,417)

594

(2,250) 1

600 35 42 34 60 106

(401)

150

(567)

250

(945)

396

(1,500)

148

(561)

210

(794)

349

(1,323)

555

(2,100) 1

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Boiler Combi-Oven

Inlet Water Hardness Boiler Combi-Oven Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 817

(3,093)

1,155

(4,374)

1,926

(7,290)

3,057

(11,571)

1,144

(4,330)

1,618

(6,123)

2,696

(10,205)

4,279

(16,199) 3

120 7 8 7 12 681

(2,577)

963

(3,645)

1,605

(6,075)

2,547

(9,642)

953

(3,608)

1,348

(5,103)

2,247

(8,504)

3,566

(13,499) 3

140 8 10 8 14 511

(1,933)

722

(2,734)

1,204

(4,556)

1,910

(7,232)

715

(2,706)

1,011

(3,827)

1,685

(6,378)

2,675

(10,125) 2

160 9 11 9 16 447

(1,691)

632

(2,392)

1,053

(3,986)

1,672

(6,328)

625

(2,368)

885

(3,349)

1,474

(5,581)

2,340

(8,859) 2

180 11 13 10 18 397

(1,503)

562

(2,126)

936

(3,544)

1,486

(5,625)

556

(2,105)

786

(2,977)

1,311

(4,961)

2,080

(7,875) 2

200 12 14 11 20 318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500)

445

(1,684)

629

(2,381)

1,048

(3,969)

1,664

(6,300) 1

220 13 15 12 22 289

(1,093)

408

(1,546)

681

(2,577)

1,081

(4,091)

404

(1,531)

572

(2,165)

953

(3,608)

1,513

(5,727) 1

240 14 17 13 24 265

(1,002)

374

(1,417)

624

(2,362)

991

(3,750)

371

(1,403)

524

(1,984)

874

(3,307)

1,387

(5,250) 1

260 15 18 15 26 244

(925)

346

(1,308)

576

(2,181)

914

(3,461)

342

(1,295)

484

(1,832)

806

(3,053)

1,280

(4,846) 1

280 16 20 16 28 227

(859)

321

(1,215)

535

(2,025)

849

(3,214)

318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500) 1

300 18 21 17 30 212

(802)

300

(1,134)

499

(1,890)

792

(3,000)

297

(1,122)

419

(1,588)

699

(2,646)

1,109

(4,200) 1

320 19 22 18 32 199

(752)

281

(1,063)

468

(1,772)

743

(2,812)

278

(1,052)

393

(1,488)

655

(2,480)

1,040

(3,937) 1

340 20 24 19 34 187

(707)

264

(1,001)

441

(1,668)

699

(2,647)

262

(990)

370

(1,401)

617

(2,335)

979

(3,706) 1

360 21 25 20 36 177

(668)

250

(945)

416

(1,575)

660

(2,500)

247

(935)

349

(1,323)

582

(2,205)

925

(3,500) 1

380 22 27 21 38 150

(570)

213

(806)

355

(1,343)

563

(2,131)

211

(798)

298

(1,128)

497

(1,880)

788

(2,984) 0

400 23 28 22 40 143

(541)

202

(765)

337

(1,276)

535

(2,025)

200

(758)

283

(1,072)

472

(1,786)

749

(2,835) 0

440 26 31 25 44 130

(492)

184

(696)

306

(1,160)

486

(1,841)

182

(689)

257

(974)

429

(1,624

681

(2,577) 0

480 28 34 27 48 119

(451)

168

(638)

281

(1,063)

446

(1,687)

167

(631)

236

(893)

393

(1,488

624

(2,362) 0

520 30 36 29 52 110

(416)

156

(589)

259

(981)

411

(1,558)

154

(583)

218

(824)

363

(1,374)

576

(2,181) 0

560 33 39 31 56 102

(387)

144

(547)

241

(911)

382

(1,446)

143

(541)

202

(765)

337

(1,276)

535

(2,025) 0

600 35 42 34 60 95

(361)

135

(510)

225

(850)

357

(1,350)

133

(505)

189

(714)

315

(1,191)

499

(1,890) 0

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Boiler Steamer

Inlet Water Hardness Boiler Steamer Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 817

(3,093)

1,155

(4,374)

1,926

(7,290)

3,057

(11,571)

1,144

(4,330)

1,618

(6,123)

2,696

(10,205)

4,279

(16,199) 3

120 7 8 7 12 681

(2,577)

963

(3,645)

1,605

(6,075)

2,547

(9,642)

953

(3,608)

1,348

(5,103)

2,247

(8,504)

3,566

(13,499) 3

140 8 10 8 14 511

(1,933)

722

(2,734)

1,204

(4,556)

1,910

(7,232)

715

(2,706)

1,011

(3,827)

1,685

(6,378)

2,675

(10,125) 2

160 9 11 9 16 447

(1,691)

632

(2,392)

1,053

(3,986)

1,672

(6,328)

625

(2,368)

885

(3,349)

1,474

(5,581)

2,340

(8,859) 2

180 11 13 10 18 397

(1,503)

562

(2,126)

936

(3,544)

1,486

(5,625)

556

(2,105)

786

(2,977)

1,311

(4,961)

2,080

(7,875) 2

200 12 14 11 20 318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500)

445

(1,684)

629

(2,381)

1,048

(3,969)

1,664

(6,300) 1

220 13 15 12 22 289

(1,093)

408

(1,546)

681

(2,577)

1,081

(4,091)

404

(1,531)

572

(2,165)

953

(3,608)

1,513

(5,727) 1

240 14 17 13 24 265

(1,002)

374

(1,417)

624

(2,362)

991

(3,750)

371

(1,403)

524

(1,984)

874

(3,307)

1,387

(5,250) 1

260 15 18 15 26 244

(925)

346

(1,308)

576

(2,181)

914

(3,461)

342

(1,295)

484

(1,832)

806

(3,053)

1,280

(4,846) 1

280 16 20 16 28 227

(859)

321

(1,215)

535

(2,025)

849

(3,214)

318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500) 1

300 18 21 17 30 212

(802)

300

(1,134)

499

(1,890)

792

(3,000)

297

(1,122)

419

(1,588)

699

(2,646)

1,109

(4,200) 1

320 19 22 18 32 199

(752)

281

(1,063)

468

(1,772)

743

(2,812)

278

(1,052)

393

(1,488)

655

(2,480)

1,040

(3,937) 1

340 20 24 19 34 187

(707)

264

(1,001)

441

(1,668)

699

(2,647)

262

(990)

370

(1,401)

617

(2,335)

979

(3,706) 1

360 21 25 20 36 177

(668)

250

(945)

416

(1,575)

660

(2,500)

247

(935)

349

(1,323)

582

(2,205)

925

(3,500) 1

380 22 27 21 38 150

(570)

213

(806)

355

(1,343)

563

(2,131)

211

(798)

298

(1,128)

497

(1,880)

788

(2,984) 0

400 23 28 22 40 143

(541)

202

(765)

337

(1,276)

535

(2,025)

200

(758)

283

(1,072)

472

(1,786)

749

(2,835) 0

440 26 31 25 44 130

(492)

184

(696)

306

(1,160)

486

(1,841)

182

(689)

257

(974)

429

(1,624

681

(2,577) 0

480 28 34 27 48 119

(451)

168

(638)

281

(1,063)

446

(1,687)

167

(631)

236

(893)

393

(1,488

624

(2,362) 0

520 30 36 29 52 110

(416)

156

(589)

259

(981)

411

(1,558)

154

(583)

218

(824)

363

(1,374)

576

(2,181) 0

560 33 39 31 56 102

(387)

144

(547)

241

(911)

382

(1,446)

143

(541)

202

(765)

337

(1,276)

535

(2,025) 0

600 35 42 34 60 95

(361)

135

(510)

225

(850)

357

(1,350)

133

(505)

189

(714)

315

(1,191)

499

(1,890) 0

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Boilerless Combi-Oven

Inlet Water Hardness Boilerless Combi-Oven Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100)

801

(3,031)

1,132

(4,286)

1,887

(7,144)

2,996

(11,339) 0

120 7 8 7 12 477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750)

667

(2,526)

944

(3,572)

1,573

(5,953)

2,496

(9,450) 0

140 8 10 8 14 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 0

160 9 11 9 16 357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062)

500

(1,894)

708

(2,679)

1,179

(4,465)

1,872

(7,087) 0

180 11 13 10 18 318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500)

445

(1,684)

629

(2,381)

1,048

(3,969)

1,664

(6,300) 0

200 12 14 11 20 286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050)

400

(1,515)

566

(2,143)

944

(3,572)

1,498

(5,670) 0

220 13 15 12 22 260

(984)

368

(1,392)

613

(2,319)

973

(3,682)

364

(1,378)

515

(1,948)

858

(3,247)

1,362

(5,154) 0

240 14 17 13 24 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 0

260 15 18 15 26 220

(833)

311

(1,178)

518

(1,963)

823

(3,115)

308

(1,166)

436

(1,649)

726

(2,748)

1,152

(4,361) 0

280 16 20 16 28 204

(773)

289

(1,093)

481

(1,822)

764

(2,893)

286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050) 0

300 18 21 17 30 191

(722)

270

(1,021)

449

(1,701)

713

(2,700)

267

(1,010)

377

(1,429)

629

(2,381)

999

(3,780) 0

320 19 22 18 32 179

(676)

253

(957)

421

(1,595)

669

(2,531)

250

(947)

354

(1,339)

590

(2,232)

936

(3,544) 0

340 20 24 19 34 168

(637)

238

(900)

396

(1,501)

629

(2,382)

235

(891)

333

(1,261)

555

(2,101)

881

(3,335) 0

360 21 25 20 36 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 0

380 22 27 21 38 150

(570)

213

(806)

355

(1,343)

563

(2,131)

211

(798)

298

(1,128)

497

(1,880)

788

(2,984) 0

400 23 28 22 40 143

(541)

202

(765)

337

(1,276)

535

(2,025)

200

(758)

283

(1,072)

472

(1,786)

749

(2,835) 0

440 26 31 25 44 130

(492)

184

(696)

306

(1,160)

486

(1,841)

182

(689)

257

(974)

429

(1,624)

681

(2,577) 0

480 28 34 27 48 119

(451)

168

(638)

281

(1,063)

446

(1,687)

167

(631)

236

(893)

393

(1,488)

624

(2,362) 0

520 30 36 29 52 110

(416)

156

(589)

259

(981)

411

(1,558)

154

(583)

218

(824)

363

(1,374)

576

(2,181) 0

560 33 39 31 56 102

(387)

144

(547)

241

(911)

382

(1,446)

143

(541)

202

(765)

337

(1,276)

535

(2,025) 0

600 35 42 34 60 95

(361)

135

(510)

225

(850)

357

(1,350)

133

(505)

189

(714)

315

(1,191)

499

(1,890) 0

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Boilerless Steamer

Inlet Water Hardness Boilerless Steamer Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100)

801

(3,031)

1,132

(4,286)

1,887

(7,144)

2,996

(11,339) 0

120 7 8 7 12 477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750)

667

(2,526)

944

(3,572)

1,573

(5,953)

2,496

(9,450) 0

140 8 10 8 14 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 0

160 9 11 9 16 357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062)

500

(1,894)

708

(2,679)

1,179

(4,465)

1,872

(7,087) 0

180 11 13 10 18 318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500)

445

(1,684)

629

(2,381)

1,048

(3,969)

1,664

(6,300) 0

200 12 14 11 20 286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050)

400

(1,515)

566

(2,143)

944

(3,572)

1,498

(5,670) 0

220 13 15 12 22 260

(984)

368

(1,392)

613

(2,319)

973

(3,682)

364

(1,378)

515

(1,948)

858

(3,247)

1,362

(5,154) 0

240 14 17 13 24 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 0

260 15 18 15 26 220

(833)

311

(1,178)

518

(1,963)

823

(3,115)

308

(1,166)

436

(1,649)

726

(2,748)

1,152

(4,361) 0

280 16 20 16 28 204

(773)

289

(1,093)

481

(1,822)

764

(2,893)

286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050) 0

300 18 21 17 30 191

(722)

270

(1,021)

449

(1,701)

713

(2,700)

267

(1,010)

377

(1,429)

629

(2,381)

999

(3,780) 0

320 19 22 18 32 179

(676)

253

(957)

421

(1,595)

669

(2,531)

250

(947)

354

(1,339)

590

(2,232)

936

(3,544) 0

340 20 24 19 34 168

(637)

238

(900)

396

(1,501)

629

(2,382)

235

(891)

333

(1,261)

555

(2,101)

881

(3,335) 0

360 21 25 20 36 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 0

380 22 27 21 38 150

(570)

213

(806)

355

(1,343)

563

(2,131)

211

(798)

298

(1,128)

497

(1,880)

788

(2,984) 0

400 23 28 22 40 143

(541)

202

(765)

337

(1,276)

535

(2,025)

200

(758)

283

(1,072)

472

(1,786)

749

(2,835) 0

440 26 31 25 44 130

(492)

184

(696)

306

(1,160)

486

(1,841)

182

(689)

257

(974)

429

(1,624)

681

(2,577) 0

480 28 34 27 48 119

(451)

168

(638)

281

(1,063)

446

(1,687)

167

(631)

236

(893)

393

(1,488)

624

(2,362) 0

520 30 36 29 52 110

(416)

156

(589)

259

(981)

411

(1,558)

154

(583)

218

(824)

363

(1,374)

576

(2,181) 0

560 33 39 31 56 102

(387)

144

(547)

241

(911)

382

(1,446)

143

(541)

202

(765)

337

(1,276)

535

(2,025) 0

600 35 42 34 60 95

(361)

135

(510)

225

(850)

357

(1,350)

133

(505)

189

(714)

315

(1,191)

499

(1,890) 0

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

Cartridge Settings & Capacities

Warewashing

Inlet Water Hardness Warewashing Application [Capacity in Gallons (Litres)]

ppm

(mg/L) gpg

English

Degree

(Clarke or E)

German

Degree

(DH or KH)

French

Degree

(FH)

B145-CLS/

ES145-CLS

B165-CLS/

ES165-CLS B195-CLS B1175-S B145H-CLS B165H-CLS B195H-CLS B1175H-S Bypass

Setting

100 6 7 6 10 572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100)

801

(3,031)

1,132

(4,286)

1,887

(7,144)

2,996

(11,339) 0

120 7 8 7 12 477

(1,804)

674

(2,551)

1,123

(4,252)

1,783

(6,750)

667

(2,526)

944

(3,572)

1,573

(5,953)

2,496

(9,450) 0

140 8 10 8 14 408

(1,546)

578

(2,187)

963

(3,645)

1,528

(5,785)

572

(2,165)

809

(3,062)

1,348

(5,103)

2,140

(8,100) 0

160 9 11 9 16 357

(1,353)

505

(1,914)

842

(3,189)

1,337

(5,062)

500

(1,894)

708

(2,679)

1,179

(4,465)

1,872

(7,087) 0

180 11 13 10 18 318

(1,203)

449

(1,701)

749

(2,835)

1,189

(4,500)

445

(1,684)

629

(2,381)

1,048

(3,969)

1,664

(6,300) 0

200 12 14 11 20 286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050)

400

(1,515)

566

(2,143)

944

(3,572)

1,498

(5,670) 0

220 13 15 12 22 260

(984)

368

(1,392)

613

(2,319)

973

(3,682)

364

(1,378)

515

(1,948)

858

(3,247)

1,362

(5,154) 0

240 14 17 13 24 238

(902)

337

(1,276)

562

(2,126)

892

(3,375)

334

(1,263)

472

(1,786)

786

(2,977)

1,248

(4,725) 0

260 15 18 15 26 220

(833)

311

(1,178)

518

(1,963)

823

(3,115)

308

(1,166)

436

(1,649)

726

(2,748)

1,152

(4,361) 0

280 16 20 16 28 204

(773)

289

(1,093)

481

(1,822)

764

(2,893)

286

(1,082)

404

(1,531)

674

(2,551)

1,070

(4,050) 0

300 18 21 17 30 191

(722)

270

(1,021)

449

(1,701)

713

(2,700)

267

(1,010)

377

(1,429)

629

(2,381)

999

(3,780) 0

320 19 22 18 32 179

(676)

253

(957)

421

(1,595)

669

(2,531)

250

(947)

354

(1,339)

590

(2,232)

936

(3,544) 0

340 20 24 19 34 168

(637)

238

(900)

396

(1,501)

629

(2,382)

235

(891)

333

(1,261)

555

(2,101)

881

(3,335) 0

360 21 25 20 36 159

(601)

225

(850)

374

(1,417)

594

(2,250)

222

(842)

315

(1,191)

524

(1,984)

832

(3,150) 0

380 22 27 21 38 150

(570)

213

(806)

355

(1,343)

563

(2,131)

211

(798)

298

(1,128)

497

(1,880)

788

(2,984) 0

400 23 28 22 40 143

(541)

202

(765)

337

(1,276)

535

(2,025)

200

(758)

283

(1,072)

472

(1,786)

749

(2,835) 0

440 26 31 25 44 130

(492)

184

(696)

306

(1,160)

486

(1,841)

182

(689)

257

(974)

429

(1,624)

681

(2,577) 0

480 28 34 27 48 119

(451)

168

(638)

281

(1,063)

446

(1,687)

167

(631)

236

(893)

393

(1,488)

624

(2,362) 0

520 30 36 29 52 110

(416)

156

(589)

259

(981)

411

(1,558)

154

(583)

218

(824)

363

(1,374)

576

(2,181) 0

560 33 39 31 56 102

(387)

144

(547)

241

(911)

382

(1,446)

143

(541)

202

(765)

337

(1,276)

535

(2,025) 0

600 35 42 34 60 95

(361)

135

(510)

225

(850)

357

(1,350)

133

(505)

189

(714)

315

(1,191)

499

(1,890) 0

640 37 45 36 64 89

(338)

126

(478)

211

(797)

334

(1,266)

125

(474)

177

(670)

295

(1,116)

468

(1,772) 0

680 40 48 38 68 84

(318)

119

(450)

198

(750)

315

(1,191)

118

(446)

167

(630)

278

(1,051)

441

(1,668) 0

The stated capacities are intended as guidelines. The capacities may vary according to dispensed volume and machine type.

3M Puriﬁcation Inc.

400 Research Parkway

Meriden, CT 06450, U.S.A.

Tel: 866.990.9785

203.237.5541

Fax: 203.238.8701

www.3Mfoodservice.com • www.3Mpuriﬁcation.com

Product Use:

Many factors beyond 3M’s control and uniquely within user’s knowledge and control can affect the use and performance of a 3M product in a particular

application Given the variety of factors that can affect the use and performance of a 3M product, user is solely responsible for evaluating the 3M product

and determining whether it is ﬁt for a particular purpose and suitable for user’s method of application.

Warranty, Limited Remedy, and Disclaimer:

3M warrants the ﬁlter cartridge or membrane to be free from defects in material and manufacture for one (1) year from the date of purchase. No warranty

is given as to the service life of any ﬁlter cartridge or membrane as it will vary with local water conditions and water consumption. 3M MAKES NO OTHER

WARRANTIES OR CONDITIONS, EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OR CONDITION OF MERCHANTABILITY

OR FITNESS FOR A PARTICULAR PURPOSE OR ANY IMPLIED WARRANTY OR CONDITION ARISING OUT OF A COURSE OF DEALING, CUSTOM OR USAGE OF

TRADE. This warranty does not cover labor. If the 3M product does not conform to this warranty, then the sole and exclusive remedy is, at 3M’s option,

replacement of the 3M product or refund of the purchase price.

This warranty gives you speciﬁc legal rights, and you may have other rights which may vary from state to state, or country to country. For any warranty

questions, please call 866.990.9785 or mail your request to: Warranty Claims, 3M Puriﬁcation Inc., 400 Research Parkway, Meriden, CT 06450. Proof of

purchase (original sales receipt) must accompany the warranty claim, along with a complete description of the Product, model number and alleged defect.

Limitation of Liability:

Except where prohibited by law, 3M will not be liable for any loss or damage arising from the 3M product, whether direct, indirect, special, incidental