Advantech PCA-6135 Installation and operation manual

PCA-6135/6135L Startup Manual 1
PCA-6135/6135L Half-size 386-chip All-in-one
CPU Card with VGA/CRT/LCD/SSD
Startup Manual
PCA-6135/6135L Half-size 386-chip All-in-one CPU Card with VGA/CRT/LCD/SSD
Packing List
Before you begin installing your card, please make sure
that the following materials have been shipped:
• 1 PCA-6135/PCA-6135L all-in-one single board
computer
• 1 CD-ROM or disks for utility, drivers, and manual (in
PDF format)
• 1 3.5" IDE flat cable (P/N: 1701400601)
• 1 keyboard cable (P/N: 1700612500)
• 1 flat cable 30 cm 1S/1P adapter (P/N: 1701260303)
• 1 FDD cable (1701340700)
If any of these items are missing or damaged, contact your
distributor or sales representative immediately.
Note 1: For detailed contents of the PCA-6135/6135L,
please refer to the enclosed CD-ROM or disk
(in PDF format).
Note 2: Acrobat Reader is acquired to view any PDF
file.Acrobat Reader can be downloaded at:
www.adobe.com/Prodindex/acrobat/
readstep.html
(Acrobat is a trademark of Adobe.)
Specifications
Standard SBC Functions
•CPU with core logic: ALi M6117, 40 MHz
80386 SX CPU
•BIOS: AMI 128 KB Flash memory
•RAM:Two 72-pin SIMM socket. Supports standard
page mode/EDO DRAM from 1 to 32 MB (accepts 1, 4,
16 MB modules)
•Enhanced IDE hard disk drive interface:Supports up
to two enhanced IDE devices. BIOS auto-detect
•Multimode parallel port: Configured to LPT1, LPT2,
LPT3 or disabled. Supports SPP/EPP/ECP; D-SUB
25-pin connector on board
•Floppy disk drive interface:Supports up to two FDDs:
3.5" (720KB or 1.44MB) and/or 5.25" (360KB or 1.2MB)
•Serial ports: One serial RS-232 port, one serial RS-
232/422/485 port. Two 16C550 compatible UARTs
•PS/2 keyboard connector: Mini-din keyboard
connector
•SSD: 3 sockets for a 360 KB/1.44 MB Flash/RAM/ROM
disk and 1 socket for DiskOnChip®2000 Flash disk
SVGA/Flat panel interface (PCA-6135 only)
•Chipset: C&T 65545
•Display memory:1 MB DRAM
•HardwareWindows acceleration: 16-bit graphics
engine.
Hardware line drawing and 64 x 64 x 2 hardware cursor.
•Resolution: Panel resolution up to 640 x 480 @ 16 M
colors. Non-interlaced CRT resolutions up to 1024 x
786 @ 256 colors.
Mechanical and environmental
•Dimensions: 7.3" (L) x 4.8" (W) (185 mm x 122 mm)
•Power supply voltage: +5 V (4.75 V to 5.25 V)
•Max. power requirements: +5V @ 1.5 A (typical)
•Operating temperature: 32°F to 140°F (0°C to 60°C)
•Weight:0.2 kg
For more information on this and other Advantech
products, please visit our website at:
http://www.advantech.com
http://www.advantech.com/epc
For technical support and service, please visit our support
website at:
http://support.advantech.com
This manual is for the PCA-6135/6135L series Rev.B2
Part No.2006613510 1st Edition
Printed in Taiwan Nov.1999

2PCA-6135/6135L Startup Manual
Jumper Settings
CMOS clear(J14)
*3.0V Battery On Clear CMOS
J14 1-2 1-3
SSD I/O address select (J6, J7)
J6 J7 SSD
close close disable
open close 210H
close open 210H
open open 210H
Watchdog timer system reset/IRQ 15 select
Reset IRQ15
J15
Battery (internal/external) select
Internal Battery External Battery
J9
Note:You must apply battery when using SRAM
LCD type control select
LCD* EL
J1
COM2 settings for RS-232/422/485
RS-232 RS-422 RS-485
J4
default setting*
Jumpers and Connectors
Connectors on the board link it to external devices such as
hard disk drives, a keyboard, or floppy drives. In addition,
the board has a number of jumpers that allow you to
configure your system to suit your application.
The table below lists the function of each of the board
jumpers and connectors:
Jumpers
Label Function
JP1 LCD/EL select
JP2 SSD battery backup select
JP3 SRAM
JP4 COM2 RS-232/422/485 select
JP5 Flash/EPROM
JP6 SSD/IO/address select
JP7 SSD/I/O address select
JP8 Keyboard lock CON
JP9 Battery select
JP10 Speaker connector
JP12 HDD LED connector
JP13 RESET connector
JP14 CMOS clear
JP15 Watchdog select
Connectors
Label Function
CN1 IDE hard drive connector
CN2 Floppy drive connector
CN3 Parallel port connector
CN4 LCD connector
CN5 Power connector
CN6 VGA connector (PCA-6135 only)
CN7 COM2 (RS-422/485)
CN8 COM2 (RS-232)
CN9/CN11 PC/104
CN10 COM1
CN12 PS/2 keyboard connector
CN13 External keyboard connector
U9,U14,U18 SSD memory socket
11
1
3~5 VDC
11
2
1
6
5
2
1
6
5
2
1
6
5

PCA-6135/6135L Startup Manual 3
J7 J6
Locating Jumpers
Legend:
J1 LCD/EL select
J2, J3, J5 SSD battery backup select
J4 COM2 RS-232/422/485 select
J6, J7 SSD I/O address select
J8 Keyboard lock CON
J9 Battery select
J10 Speaker connector
J12 HDD LED connector
J13 RESET connector
J14 CMOS clear
J15 Watchdog select
J12 J14 J9 J8
+
J13 J15 J10
Legend:
CN1 IDE hard drive connector
CN2 Floppy drive connector
CN3 Parallel port connector
CN4 LCD connector
CN5 Power connector
CN6 VGA connector (PCA-6135 only)
CN7 COM2 (RS-422/485)
CN8 COM2 (RS-232)
CN9/CN11 PC/104
CN10 COM1
CN12 Keyboard connector
CN13 External keyboard connector
Locating connectors
J1 J2 J3 J5 J4
ROM3
ROM2
ROM1
SIMM 2
SIMM 1 CN4CN1 CN2 CN3
CN5
CN6
CN7
CN8
CN10
CN12
CN9CN11 CN13