Arjo Maxi 500 User manual

001.20815.EN Rev 17 • 08/2019
INSTRUCTIONS FOR USE
Maxi 500

Design Policy and Copyright
® and ™ are trademarks belonging to the Arjo group of companies.
© Arjo 2019.
As our policy is one of continuous improvement, we reserve the right to modify designs without
prior notice. The content of this publication may not be copied either whole or in part without the
consent of Arjo.
To avoid injury, always read this Instructions for Use and accompanied documents
before using the product.
Mandatory to read the Instructions for Use.

Table of Contents iii
Table of Contents
Foreword ......................................................................................................................................1
Please Read this Manual Thoroughly!..................................................................................................... 1
Service and Support ................................................................................................................................ 1
Manufacturer Information......................................................................................................................... 1
'H¿QLWLRQV8VHGLQWKLV0DQXDO ............................................................................................................... 1
Safety Instructions ......................................................................................................................2
,QWHQGHG8VH ........................................................................................................................................... 2
Operational Life ....................................................................................................................................... 2
Important Safety Instructions................................................................................................................... 2
Policy on Number of Staff Members Required for Patient Transfer......................................................... 3
Safe Working Load (SWL)....................................................................................................................... 3
Battery and Battery Charger Safety Practices......................................................................................... 4
Shock Prevention..................................................................................................................................... 4
Fire and Explosion Prevention................................................................................................................. 4
Human and Environmental Safety Practices ........................................................................................... 4
Homecare Environment Considerations................................................................................................................ 4
Symbols Used..............................................................................................................................5
General Symbols ..................................................................................................................................... 5
Charger Related ...................................................................................................................................... 5
Product Description ....................................................................................................................6
How to use the Maxi 500 ............................................................................................................7
Adjusting Legs Spreading........................................................................................................................ 7
Brakes...................................................................................................................................................... 7
Emergency Stop ...................................................................................................................................... 7
Boom Control........................................................................................................................................... 7
To Raise the Patient .............................................................................................................................................. 7
To Lower the Patient.............................................................................................................................................. 7
Moving the Maxi 500 ............................................................................................................................... 8
Emergency Lowering............................................................................................................................... 8
Automatic Cut-out.................................................................................................................................... 8
During lifting .......................................................................................................................................................... 8
During lowering ..................................................................................................................................................... 8
Hour Meter............................................................................................................................................... 8
Battery Charge Indicator.......................................................................................................................... 9
Battery Charging ..........................................................................................................................9
,QVHUWLQJ௘௘5HPRYLQJWKH%DWWHU\3DFN...................................................................................................... 9
Scale (optional)........................................................................................................................................ 9
Clip Slings Application .............................................................................................................10
Clip Sling Compatibility.......................................................................................................................... 10
Sling Selection........................................................................................................................................11
Spreader Bar Compatibility.....................................................................................................................11
Attaching the Sling to the DPS .............................................................................................................. 12
Detaching the Sling from the DPS......................................................................................................... 12
Operating the DPS................................................................................................................................. 12
7UDQVIHUULQJ3DWLHQWV8VLQJ&OLS6OLQJV ................................................................................................. 13
Lifting Patient from a Seated Position ................................................................................................................. 13
Lowering Patient to a Seated Position ................................................................................................................ 13
Lifting Patient from a Bed .................................................................................................................................... 14
Lowering Patient to a Bed ................................................................................................................................... 14
Lifting Patient from the Floor ............................................................................................................................... 15
Lowering Patient to the Floor .............................................................................................................................. 15

Table of Contentsiv
Loop Slings Application ...........................................................................................................16
Compatible Loop Slings......................................................................................................................... 16
Sling Selection....................................................................................................................................... 17
Spreader Bar Compatibility.................................................................................................................... 17
Attaching the Sling to the Spreader Bar ................................................................................................ 17
Positioning the Patient ........................................................................................................................................ 17
Attachment Methods ........................................................................................................................................... 18
7UDQVIHUULQJ3DWLHQWV8VLQJ/RRS6OLQJV ............................................................................................... 19
Lifting Patient from a Seated Position ................................................................................................................. 19
Lowering Patient to a Seated Position ................................................................................................................ 19
Lifting Patient from a Bed .................................................................................................................................... 20
Lowering Patient to a Bed ................................................................................................................................... 20
Lifting Patient from the Floor ............................................................................................................................... 21
Lowering Patient to the Floor .............................................................................................................................. 21
Care and Maintenance ..............................................................................................................22
Lift Cleaning and Care........................................................................................................................... 22
Preventive Maintenance Schedule...........................................................................................23
Troubleshooting ........................................................................................................................25
Labels on the Lift.......................................................................................................................26
7HFKQLFDO6SHFL¿FDWLRQV...........................................................................................................27
Dimensions.......................................................................................................................................................... 28
Electromagnetic Compatibility.................................................................................................29
Electromagnetic Compliance................................................................................................................. 29
Electromagnetic Emissions.................................................................................................................... 29
Electromagnetic Immunity ..................................................................................................................... 30

Foreword 1
Please Read this Manual Thoroughly!
The information in this manual is crucial to the
proper use and maintenance of the Maxi 500
ÀRRUOLIW. It will help protect your product as well
as ensure that it performs to your satisfaction.
Lifting and transferring a person always
presents a potential risk. This manual contains
safety related information that must be read
and understood to help prevent injuries.
Arjo strongly advises and warns that to avoid
injuries that can be attributed to the use of
inadequate parts, only parts designated by Arjo
should be used on product and other appliances
supplied by Arjo.
8QDXWKRUL]HGPRGL¿FDWLRQVRQDQ\$UMRSURGXFW
may affect its safety. Arjo will not be held
responsible for any accidents, incidents or lack
of performance that occur as a result of any
XQDXWKRUL]HGPRGL¿FDWLRQWRLWVSURGXFWV
If a serious incident occurs in relation to this
medical device, affecting the user, or the patient
then the user or patient should report the
serious incident to the medical device
manufacturer or the distributor. In the European
8QLRQWKHXVHUVKRXOGDOVRUHSRUWWKHVHULRXV
incident to the Competent Authority in the
member state where they are located.
Service and Support
A service routine has to be done on your Maxi
500 ÀRRUOLIWE\$UMRWUDLQHGVHUYLFHSHUVRQQHO
This will ensure it remains safe and functional.
Please contact your local Arjo vendor for any of
the following:
• If you require further information.
• Want to report an unexpected event,
change in the performance or a
malfunction.
• Need any help in setting up, using or
maintaining your Maxi 500.
• Need replacement parts.
Your Arjo vendor can offer support and service
SURJUDPV WR PD[LPL]H WKH ORQJWHUP VDIHW\
reliability and value of the product.
Manufacturer Information
This product was manufactured by:
ArjoHuntleigh AB
Hans Michelsensgatan 10
211 20 Malmö,
SWEDEN
: [phone]
: [phone]
Þ: www.arjo.com
'H¿QLWLRQV8VHGLQWKLV0DQXDO
WARNING:
Means: Failure to understand and follow this
instruction may result in injury to yourself and
others.
CAUTION:
Means: Failure to follow this instruction may
cause damage to the product(s).
NOTE:
Means: Important information regarding correct
use of the product.
Foreword

Safety Instructions2
The Maxi 500 ÀRRUOLIWPXVWDOZD\VEHKDQGOHG
by a trained caregiver, as per instructions
herein, who shall attend to the patient during lift
operation.
Intended Use
7KH 0D[L  ÀRRU OLIW KDV EHHQ GHVLJQHG WR
assist caregivers in hospitals, long-term care,
nursing homes and home care environments,
including private homes. It is intended for lifting
patients with reduced mobility for the following
purposes:
• Transferring to or from adjacent
location, such as chair, wheelchair, bed,
EDWKWRLOHWÀRRURUVWUHWFKHU
• Assisting patient with tasks such as,
toileting.
WARNING: This product is not intended to
be operated by the patient.
Patient could get stuck in many
circumstances.
WARNING: The Maxi 500ÀRRUOLIWPXVWEH
solely used for the purposes stated above.
Do not use the lift for any other purpose, it
could compromise product’s reliability
DQG௘௘RUSDWLHQW¶VVDIHW\
Operational Life
The Maxi 500ÀRRUOLIWKDVEHHQGHVLJQHGDQG
tested to achieve up to 10 000 cycles with a
load of 227 kg (500 lb).
,WLVVXEMHFWWRPDLQWHQDQFHDVVSHFL¿HGLQWKH
“Care and Maintenance” section in this manual.
The following table shows number of years in
UHODWLRQWRF\FOHVSHUGD\2QHF\FOHLVGH¿QHG
as transferring a 227 kg (500 lb) patient including
a raising action, a lateral displacement and a
descending action.
Cycles per Day Years
(10,000 transfers)
47
64.5
83.5
WARNING8VLQJDÀRRUOLIWRUDQDFFHVVRU\
beyond its life span may result in an incident
causing serious injuries.
Following are factors that have an impact on
the lift’s life span:
• aging of the unit;
• transfers per day;
• weight of the patient;
• maintenance frequency.
The expected life for other consumable items,
such as batteries, fuses, slings, straps and
cords is dependent upon the care and usage of
the product. Consumable must be maintained
in accordance with published Instructions for
Use and “Preventive Maintenance Schedule”.
Important Safety Instructions
• Before using the Maxi 500, a clinical
assessment of the patient’s suitability for
transfer must be carried out by a
TXDOL¿HGKHDOWKSURIHVVLRQDOFRQVLGHULQJ
that, among other things, the transfer
may induce substantial pressure on the
patient’s body.
• Keep this manual at proximity from the
lift and refer to it as required. Make sure
that all users are regularly trained in the
use of the Maxi 500 ÀRRUOLIWDVSHUWKH
information found therein.
• All controls and safety features are used
RQO\DVSHUWKHUXOHVVSHFL¿HGLQWKLV
manual. Never attempt to force a control
or button on the lift.
•
WARNING'RQRWSXW¿QJHUVKDQGVRUIHHW
where space is limited (see “Fig. 1”). This
could pinch, cut, or seriously harm body parts.
• Avoid any impact during transfer.
Safety Instructions

Safety Instructions 3
Fig. 1
1) Around the boom pivot.
2) Around the spreader bar attachment.
3) Between the castors and the base assembly.
4) %HWZHHQWKHEDVHDVVHPEO\DQGWKHÀRRU
5) Between the actuator and mast.
1
2
3
4
5
WARNING: Arjo warns of possible
strangulation risks related to the hand control
cable.
WARNING: Some plastic parts hiding screw
heads on the lift may represent a choking
KD]DUG IRU \RXQJ FKLOGUHQ 0DNH VXUH WR
replace them if they become loose or
damaged.
CAUTION: Do not drop either the lift or the
battery pack, as it may cause internal
damage that is not easily seen. If the lift is
suspected to be damaged, contact your local
Arjo vendor for servicing.
CAUTION 8VLQJ WKH Maxi 500 in humid,
salty, or chlorinated conditions may cause
premature wear of the lift.
In such cases, we recommend to perform a
proactive maintenance program with more
frequent inspections.
Policy on Number of Staff Members
Required for Patient Transfer
$UMR¶VÀRRUOLIWVDUHGHVLJQHGIRUVDIHXVDJHZLWK
one caregiver. There are circumstances that
may dictate the need for a two-person transfer.
It is the responsibility of the caregiver to
determine if a one or two person transfer is
more appropriate, based on the following:
• resident’s condition (combativeness;
obesity, contracture etc.);
• the task;
• resident’s weight;
• environment;
• capability;
• skill level of the caregiver.
Do not hesitate to contact your medical
professional for guidance.
Safe Working Load (SWL)
The Maxi 500 ÀRRU OLIW KDV EHHQ PDGH IRU D
maximum lifting capacity of 227 kg (500 lb) .
Do not attempt to lift more than the lowest
weight limit indicated on the following:
• the “maximum load” label on the lift;
• on the spreader bar;
• on the accessories;
• on the sling.

Safety Instructions4
Battery and Battery Charger Safety
Practices
WARNING: Following the instructions is
important for the safe use of the battery and
to keep the user (resident/caregiver) from
harm.
Make sure the battery belongs to the device by
comparing the battery label with the “Technical
6SHFL¿FDWLRQV´ VHFWLRQ RQ SDJH  ,I EDWWHU\
W\SHFDQQRWEHFRQ¿UPHGFDOO\RXUYHQGRUIRU
assistance.
CAUTION: Do not expose the battery
connectors or the battery charger to water.
Humid air or water can cause premature
wear to the battery or the charger.
Refer to the Wall Mounted Battery Charger -
,QVWUXFWLRQVIRU8VH;;
Shock Prevention
• Electrically live equipment can result in
serious injuries. If the lift or charger has
any exposed or damaged wires, contact
your local Arjo vendor immediately.
• Do not attempt to expose, service or
repair the lift, battery or charger. If any
unit is malfunctioning, contact your local
Arjo vendor.
Fire and Explosion Prevention
• Do not place or store the battery under
direct sunlight or near a heat source.
• Do not expose the batteries or battery
FKDUJHUWRÀDPHV
• Do not use the charger in the presence
RIÀDPPDEOHDQDHVWKHWLFJDVHV
• Do not short circuit the battery terminals.
Human and Environmental Safety
Practices
• Should the battery casing crack,
allowing its contents to come into
contact with skin or clothing, rinse
immediately with water. If the contents
comes in contact with the eyes, rinse
immediately with plenty of water and
seek medical attention.
• Inhalation of the contents can cause
respiratory irritation. Seek out fresh air
and medical attention.
• For recycling and disposal of the
batteries, the rules according to the
WEEE directive (Waste of Electronic
and Electrical Equipment) as well as
local laws and regulations must be
followed. When returning batteries,
insulate their terminals with adhesive
tape. Otherwise, the residual electricity
LQXVHGEDWWHULHVPD\FDXVH¿UHRU
explosion.
In case of doubt about the way to proceed,
please contact your local authorities to
determine the proper method of disposal.
Homecare Environment Considerations
WARNING: The Maxi 500 is not intended to
be operated by children. Serious injuries
could occur.
NOTE: Cleaning actions should be done
rigorously when the Maxi 500 is exposed to
an animal.
Pet hair trapped around mobile parts can
affect lift’s performance.

Symbols Used 5
General Symbols
This symbol points out the
manufacturer’s name and
address. May also point out
manufacturing date.
CE marking indicating
conformity with European
Community harmonised
legislation.
This symbol means that the
SURGXFWLVFHUWL¿HGDFFRUGLQJ
to NTRL through TÜV SÜD.
This symbol means that the
SURGXFWLVFHUWL¿HGWKURXJK
TÜV SÜD.
This symbol points out the
manufacturer’s catalogue
number.
This symbol points out the
manufacturer’s serial number.
Waste Electrical and
Electronic Equipment (WEEE)
– do not dispose of this
product in general household
or commercial waste.
This symbol means that the
item can be recycled.
This symbol means that you
must refer to the Instructions
IRU8VH,)8
This symbol points out a Type
BF applied part.
This symbol points out a Type
B applied part.
This symbols points out a risk
of pinching.
SWL SWL is the maximum load the
device is rated for safe usage.
This symbol points out the
emergency stop device.
This symbol points out the
reset switch.
Correct.
Incorrect.
+=kg / lb
SWL Maximum total mass of
equipment including its safe
working load.
Indicates the product is a
Medical Device according
WRWKH(80HGLFDO'HYLFH
Regulation 2017/745.
Charger Related
Refer to the Wall Mounted Battery Charger -
,QVWUXFWLRQVIRU8VH;;
When applicable, symbol reference can be
found in EN 60601-1 and WEEE Directive.
Acronyms
DPS Dynamic Positioning System
Symbols Used

Product Description6
Product Description
Fig. 2
5
21
9
6
7
1
4
4
3
1
2
27
26
25 24
11
12
23
22
19
20
8
10
13
18
14
17
15
16
Legend
1) Down Button
2) Reset Button
3) Emergency Stop Button
4) 8S%XWWRQ
5) Hand Control
6) Leg Opening Button
7) Leg Closing Button
8) Handle
9) Battery Release Button
10) Boom
11) 2-Point Spreader Bar
12) Safety Latch
13) DPS Spreader Bar
14) Charger Status LED
15) Wall-Mounted Charger
16) Charger Power Cord
17) Right Leg
18) Left Leg
19) Actuator
20) Emergency Lowering Handle
21) Mast
22) Battery Pack
23) Castor Break
24) Control Box
25) Hand Control Connector
26) Battery Status Display
27) Hour Meter

How to use the Maxi 500 7
Adjusting Legs Spreading
Fig. 3
Close Legs
Open Legs
The legs’ opening width
can be adjusted by using
the two bottom buttons on
the hand control.
Brakes
)RRW RSHUDWHG EUDNHV DUH ¿WWHG RQ ERWK UHDU
castors.
To apply brakes, step on the back portion of
pad.
To release brakes, push the top portion of the
pad forward.
Fig. 4
Emergency Stop
The operator can shut off the power at any time
by pressing the red emergency button on the
control panel or by pressing the red button on
the battery while pulling it backward to remove
it.
Reset the emergency stop function by pressing
on the green power button or by replacing the
battery.
First-time users should practice the emergency
stop manoeuvre before operating the lift with a
patient in it.
Fig. 5
Fig
F
F
F
. 5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
Emergency
Stop
Button
Battery
release
button
Pull
Boom Control
The electrical actuator can be operated in both
directions. It allows the operator to raise or
lower the patient without any physical effort.
7KHERRPUDLVLQJ௘௘ORZHULQJDFWLRQLVFRQWUROOHG
E\ WKH ³8S´௘௘௘³'RZQ´ EXWWRQV ORFDWHG RQ WKH
control box and on the hand control.
If two buttons are pressed simultaneously, the
¿UVWIXQFWLRQEXWWRQSUHVVHGRYHUULGHVWKHRWKHU
function until it is released.
Fig. 6
To Raise the Patient
WARNING: Always make sure that the
spreader bar is above the patient before
lifting.
Failure to follow this instruction may cause
the patient to swing resulting in injury.
7KH³83´EXWWRQVDUHXVHGWRUDLVHWKHERRP
The boom keeps rising as long as the button is
pressed or until it reaches its upper travel limit.
To Lower the Patient
The “Down” buttons are used to lower the boom.
The boom keeps lowering as long as the button
is pressed or until it reaches its lower travel
limit.
How to use the Maxi 500
Raise Patient
Lower Patient
Locked 8QORFNHG

How to use the Maxi 5008
Moving the Maxi 500
Always use the handles to manoeuvre the lift.
Close the legs and move the lift in the direction
RIWUDYHODVVKRZQLQWKH¿JXUHEHORZ
If necessary, initiate the movement by pushing
on the back of the base with your foot. Do not
push on the legs.
WARNING: Never attempt to manoeuvre
the lift by pulling on the mast, boom, actuator
or patient. Doing so could cause incidents
resulting in injuries.
Fig. 7
Never attempt to push or pull a loaded lift over
DÀRRUREVWUXFWLRQZKLFKWKHFDVWRUVDUHXQDEOH
to ride over easily, including steps, door
thresholds or moving sidewalk.
Do not push the lift at a speed which exceeds a
slow walking pace (3 km/hour or 0.8 meter/
second).
Emergency Lowering
This feature allows the boom to be lowered in
the event of a main control failure.
In the event of a hand control or control box
failure, locate the red handle above the actuator.
Gradually pull the handle up and hold it until the
actuator is lowered to the desired level. The
force exerted on the handle and the patient
weight affects the speed of descent.
Fig. 8
WARNING: Before operatingthe“emergency
lowering”, always ensure that a suitable
support is underneath, ready to receive, the
patient.
The handle is spring loaded and will return to
normal position and stop the lowering process
when released. Note that a load must be applied
to the boom for the device to function.
CAUTION: This function should only be used
in the event of control failure, and not as a
regular lowering function for the equipment.
Automatic Cut-out
During lifting
This feature will stop the lifting motion in the
event where the Maxi 500 is trying to raise a
patient heavier than the SWL.
During lowering
This feature disables the down motion when
the boom is being lowered onto the patient or
any other obstruction.
Sleep Mode
The control box includes an automatic switch-
off control that disables part of the circuitry, after
2 minutes of inactivity, to prevent battery from
draining.
Power is re-established when a control button
is pressed.
Hour Meter
HRS
Fig. 9
The hour meter is
an LCD display
which shows the
total duration of
powered operation
(in hours).
This is primarily
intended as an aid
for scheduling maintenances.
Transfer Direction

How to use the Maxi 500 9
Battery Charge Indicator
Fig. 10
The battery charge
indicator is a bar
graph display,
located on the
battery pack holder,
which shows the
charge condition of
the battery.
The lift is equipped
with an audible warning device, which will
beep when the battery level reaches the critical
range.
CAUTION: When the indicator reaches the
critical range, recharge the battery
immediately to prevent reducing its lifespan.
When a fully charged battery is inserted into the
lift, the display will return to the green fully
charged position, regardless of the level the
indicator had reached previously. However, if a
partially charged battery is inserted, the
previous indicator level will be maintained, even
though the recently inserted battery may be in a
better state of charge than indicated. To achieve
a true indication of battery condition, a fully
charged battery must be inserted into the lift.
Battery Information
For safe handling and to extend the battery
lifetime, please follow and remember these
instructions.
The Maxi 500 uses a 24 volts sealed lead-acid
battery pack that can deliver up to 100 lifts per
charge.
Battery life is variable (2-3 years) and is
LQÀXHQFHG E\ IUHTXHQF\ RI XVH IUHTXHQF\ RI
FKDUJLQJ WHPSHUDWXUH RI RSHUDWLRQ௘௘VWRUDJH
and storage time.
To prolong the battery pack life, recharge it
before the indicator reaches the Low Battery
range.
To ensure that the Maxi 500 is always ready for
use, it is recommended that a fully charged
battery pack always be available. Do this by
having additional battery packs, and keeping
one battery pack charging while the other is in
use.
Remove the battery pack from the lift when
storing for an extended period of time. Stored
batteries should be recharged at least every
WZRZHHNVWRPD[LPL]HWKHLUOLIHVSDQ
Battery Charging
The battery should be recharged as soon as
the discharge indicator displays amber.
Refer to the Wall Mounted Battery Charger -
,QVWUXFWLRQV IRU 8VH ;; IRU
charging details.
Note that the battery pack may remain
connected to the charger when fully charged.
,QVHUWLQJ௘௘5HPRYLQJWKH%DWWHU\3DFN
7KHVDPHPHWKRGDSSOLHVIRULQVHUWLQJ௘௘UHPRYLQJ
WKHEDWWHU\SDFNLQWR௘௘IURPWKHOLIWRUWKHFKDUJHU
Inserting the Battery Pack
1) Align the bottom of the battery pack with the
bottom of the battery support.
2) Insert the battery pack until it rests into the
support base.
3) Push the top of the battery until it latches to
the support.
Fig. 11
123
Removing the Battery Pack
1) Push the release button.
2) Pull the battery back.
3) Lift the battery to pull it out of the battery
rack.
Scale (optional)
To use the scale, if available, refer to the Scale
IFU.
Normal
operating
Low
battery
Critical

Clip Slings Application10
Clip Sling Compatibility
This section only applies for model supplied with the DPS spreader bar.
Following is a list of typical Arjo clip slings that are compatible with the Maxi 500ÀRRUOLIW
0$$;;
Four-Point Amputee
0$$;;
Four-Point Hygienic
0$$;;
Four-Pointed Padded
0$$;;
Four Point Non-padded
0$$;;
Four-Pointed Mesh
NOTE: Other sling models are available. Contact your Arjo vendor for more information about
clip slings and how to use them.
Clip Slings Application

Clip Slings Application 11
Sling Selection
The spreader bar that is attached to the lift
determines what slings can be used to transfer
a patient.
6OLQJV DUH FRORXU FRGHG IRU VL]H E\ KDYLQJ D
different colour edge binding or attachment
strap colouring:
• 7HDO([WUD([WUD6PDOO;;6
• %URZQ([WUD6PDOO;6
• Red - Small - S
• Yellow - Medium - M
• Green - Large - L
• Purple - Large Large - LL
• %OXH([WUD/DUJH;/
• 7HUUDFRWWD([WUD([WUD/DUJH;;/
Note that some sling models are not available
LQDOOVL]HV
A wide variety of slings are available for each
application. Please contact your local Arjo
vendor for more information.
Flites®(single patient multi-use slings) are also
available for most sling models. If Arjo Flites
slings are to be used with the MAXI 500ÀRRUOLIW
refer to the separateArjo Flites slings Instruction
for Use.
Spreader Bar Compatibility
The Maxi 500ÀRRUOLIW
is only compatible
with the spreader bar
that is delivered with
the lift.
Maxi 500 ÀRRU OLIW
model that is
designed for use with
clip slings is delivered
with a manual DPS
spreader bar.
WARNING 8VLQJ WKH '36 ZLWK DPSXWHH
sling may cause injuries if not used correctly.
Fig. 12
Legs
Shoulders
Attachments Lugs

Clip Slings Application12
Attaching the Sling to the DPS
Fig. 13
1
2
Insert the clip attachment over the lug on the DPS.
Secure the clip in place by pulling the sling down so
that the lug is in the top portion of the clip hole.
WARNING: Make sure all clips are correctly
engaged. Failure to do so could result in patient
fall.
Method 1 - Straight Attachment
Fig. 14
Apply the leg clips of
the sling onto the lugs
so that they become
positioned vertically.
For most patients, the straight attachment of the leg
clips is recommended.
Method 2 - Crossed Legs Attachment
Fig. 15
Cross the legs pieces
of the sling when
attaching to the lugs.
If the patient is prone to kicking off the leg clip, the
crossed attachment of the leg clips shall be applied,
which will prohibit the clip from being kicked off.
Detaching the Sling from the DPS
1
2
Fig. 16
Pull the sling up to release the lock.
Remove the clip attachment from the lug on the
DPS.
Operating the DPS
Fig. 17
Note: To ensure maximum patient comfort, do
not allow them to hold onto the spreader bar.
The DPS spreader bar is adjusted by rising or
lowering the tilt handle until the patient is in the
desired position.
Lying
Position
Seated
Position

Clip Slings Application 13
Transferring Patients Using Clip
Slings
Before using the Maxi 500 ensure that:
• A clinical assessment of the patient’s
suitability for transfer is carried out by a
TXDOL¿HGKHDOWKSURIHVVLRQDOFRQVLGHULQJ
that, among other things, the transfer
may induce substantial pressure on the
patient’s body.
• Special consideration is taken when
transferring a patient who is connected
to electrodes, catheters, or other
medical devices.
• Always carry out the items marked as
“Before every use” in the “Preventive
Maintenance Schedule” before using
the lift.
WARNING: Always hold the spreader bar
when near a patient. The spreader bar could
hit the patient resulting in injury.
WARNING: To avoid injury or discomfort, do
not lower the spreader bar onto the patient.
WARNING: Before raising the patient,
always make sure the sling is not caught on
any obstructions (for instance, the wheelchair
brakes or armrests). Sling catching in such
obstructions could result in patient fall.
WARNING $OZD\V FRQ¿UP WKDW WKH VOLQJ
clips remain attached as the weight of the
patient is gradually taken up. A wrongly
clipped attachment could detach resulting in
patient fall.
Lifting Patient from a Seated Position
1) Place the sling around the patient so that
the base of the sling sits slightly below the
tail bone.
A MaxiSlide®or MaxiTube®positioning aid
can be used to assist with placement of the
sling.
Fig. 18
2) Ensure that the head support area of the
sling is behind the head covering it.
3) Pull each leg strap under the thigh so that it
emerges on the inside of the thigh.
Fig. 19
4) Approach the patient with the lift, ensure
that:
• The spreader bar is in sitting position.
• The wide part of the spreader bar is at
or just below shoulder level.
• The spreader bar is close enough to be
able to connect the shoulder strap clips
of the sling to the frame.
5) Connect the shoulder strap clips, then tilt
the frame and attach the leg sections. If
necessary, lower the spreader bar a little
further, being careful not to lower it onto the
patient.
Fig. 20
6) Raise the patient using the hand control,
positioning him comfortably to a semi-
reclined position for the transfer. The patient
should not be lifted above the caregiver’s
eye level.
7) Turn the patient to face the caregiver, and
keep at a normal chair height.
8) Proceed with the transfer.
Lowering Patient to a Seated Position
1) Once the patient has arrived at destination,
reposition the patient according to the
destination position.
2) Lower the patient down onto the new
location by making small adjustments
during the descent.
3) When the patient’s body weight is fully
supported, detach the connections clips.
4) Move the lift away from the patient.
5) Remove the sling from under the patient.

Clip Slings Application14
Lifting Patient from a Bed
Before you start, make sure the bed is in correct
working height.
WARNING: Make sure that the bed safety
side is installed to prevent the patient from
falling.
1) Roll the patient onto their side.
2) Fold the sling in half and place on the bed
land marking it, along the back of the patient
so that the base of his spine is aligned with
the base of the sling, making sure the sling
extends to the top of the patient’s head.
Fig. 21
3) Roll the patient back onto the sling and then
slightly further in the opposite direction, so
that the folded part of the sling can be
unfolded.
Fig. 22
4) If possible, slightly raise the head of the
bed.
5) Approach the patient with the lift, and ensure
that:
• the spreader bar is in reclined position;
• the spreader bar is close enough to be
able to connect the shoulder strap clips
of the sling to the frame.
6) 8VLQJWKHKDQGFRQWUROORZHUWKHVSUHDGHU
bar taking care not to lower the frame onto
the patient.
7) Connect the sling shoulder and leg strap
clips to the spreader bar.
Fig. 23
8) Raise the patient using the hand control,
positioning him comfortably to a semi-
reclined position for the transfer. The patient
should not be lifted above the caregiver’s
eye-level.
9) Turn the patient to face the caregiver, and
keep at a normal chair height.
10) Proceed with the transfer.
Lowering Patient to a Bed
1) Once the patient has arrived at destination
reposition the patient according to the
destination position.
2) Lower the patient down onto the new
location by making small adjustments
during the descent so that the patient is
always in the best comfortable position.
3) When the patient’s body weight is fully
supported, detach the connections clips.
4) Move the lift away from the patient.
5) Remove the sling from under the patient.

Clip Slings Application 15
Lifting Patient from the Floor
The technique described here can be used for
WUDQVIHUULQJSDWLHQWVO\LQJRQWKHÀRRU
3DWLHQWVEHLQJOLIWHGIURPWKHÀRRUGXHWRDVOLS
or fall should only be lifted after examination by
TXDOL¿HGPHGLFDOSHUVRQQHO7KHSDWLHQWFDQEH
lifted from a completely reclined position on the
ÀRRUEXWIRUKLVFRPIRUWSXWDSLOORZXQGHUKLV
KHDG¿UVW
1) Roll the patient onto their side.
2) )ROGWKHVOLQJLQKDOIDQGSODFHRQWKHÀRRU
land marking it, along the back of the patient
so that the base of his spine is aligned with
the base of the sling, making sure the sling
extends to the top of the patient’s head.
Fig. 24
3) Roll the patient back onto the sling and then
slightly further in the opposite direction, so
that the folded part of the sling can be
unfolded.
Fig. 25
4) Depending on circumstances, space or
position of patient, approach the patient
with the open part of the chassis.
5) Adjustment of the spreader bar height may
have to be made before connection is
possible.
6) $WWDFK WKH VKRXOGHU VWUDS FOLSV ¿UVW WKHQ
with the open part of the sling, support
frame pointing downwards towards the
shoulders, connect the leg strap clips.
Fig. 26
7) When all the clips are securely attached,
UDLVH WKH SDWLHQW IURP WKH ÀRRU LQ D VHPL
recumbent position.
8) 2QFH UDLVHG IURP WKH ÀRRU HQVXUH WKH
patient’s legs are clear of the chassis before
continuing to lift.
9) Turn the patient to face the caregiver, and
keep at a normal chair height.
10) Proceed with the transfer.
Lowering Patient to the Floor
1) Lower the patient down onto the new
location by making small adjustments
during the descent so that the patient is
always in the best comfortable position.
2) When the patient’s body weight is fully
supported, detach the connections clips.
3) Move the lift away from the patient.
4) Remove the sling from under the patient.
.

Loop Slings Application16
Loop Slings Application
Compatible Loop Slings
This section only applies for lifts supplied with a 2-point spreader bar.
$UMRORRSVOLQJSUR¿OHVWKDWFDQEHXVHGZLWKWKHMaxi 500.
Hammock Hammock 6 4XLFN¿W7,5
Hygienic (THY) Combi Repositioning
NOTE: Other sling models are available. Contact your Arjo vendor for more information about
loop slings and how to use them.