DeVilbiss 5650D User manual

DeVilbiss
Pulmo-Aide
Compressor/Nebulizer
Service Manual
Models 5650D & 5650C
Printed in the U.S.A.
©1996 DHC, Inc.
LT-1469 Rev. B

Purpose
To provide a portable means of supplying
compressed air to devices which do not
require a large volume of air, such as
nebulizers, atomizers, and syringes. The
compressor displaces clean, oil-free air at 12
1pm. It can be operated at 20 psi
continuously or at 30 psi intermittently at a
minimum of 110 VAC.
Installation
Lower access door to expose the air outlet
connector. The compressor is set up for use
with slip-on hose connectors. Attach the
tubing to the unit by sliding the tubing over
the connector.
Maintenance
The air filter (14) should be changed
whenever it turns completely gray in color.
Remove the filter cap (15) by pulling
outward. To remove the filter from the
holder, pull out with fingers. Push the new
filter in place and push the cap back into the
front of the Pulmo-Aide.
CAUTION— Do not use cotton or any other
material as a filter, nor attempt to wash or
clean filter. It may cause damage to the
compressor.
DANGER— Electric shock hazard. Always
disconnect the unit from the power source
before servicing.
Service
To replace head, valve plate, and/or
diaphragm:
1. Remove the six T20 torx screws from the
rear cabinet.
2. Lay unit face down and lift the rear
cabinet off of the unit.
3. Only disconnect the tubing (10) from the
compressor fittings if you are going to
replace the head assembly.
4. Remove the four T5 torx screws from the
head. Using a flat-bladed screwdriver, pry
in between the head and motor to loosen
the head from the diaphragm.
5. Lift the head (6) from the motor.
6. Remove diaphragm screw (5) from the
connecting rod retainer plate for
diaphragm replacement.
7. Remove the valve plate retainer screw (5)
from the head for valve plate
replacement.
8. Reverse the procedure to re-assemble the
unit.
Specifications
Size ..10.1” W x 10.5" H x 6.5" D
Weight.
Sound Level.
Electrical Requirements .
Power Consumption.
Maximum Compressor Pressure .
Maximum Compressor Liter Flow
Nebulizer Operating Pressure . . .
Nebulizer Liter Flow.
Nebulizer Capacity . . ..
Nebulizer Nebulization Rate
MMAD .
Warranty.
(26 cm x 27 cm x 17 cm)
7.0 lbs (3.2 kg)
51 dBA
1.3 amps, 115 VAC 60 Hz
90 watts maximum
30-45 psig*
9.4 -16 1pm*
12-18 psig
5-7 1pm
10 ml (cc)
0.15 ml/minute or greater
Less than 5 microns
5-year limited warranty on
compressor parts
Conditions may vary based on altitude above sea level, barometric pressure changes.

iIO 4 rmi
mmmm
REPLACEMENT PARTS
1. 5650D-606
2. 5610D-609
3. 5610D-614
4. 5610D-617
5. 5610D-614
6. 5650D-613
7. 5610D-614
8. 5610D-614
9. 5650D-604*
10. 5650D-615
11. 5650D-610
5650H-610
12. 5650D-614
13. 5650D-609
14. 5650D-602
5650D-601
15. 5650D-612
16. 5650D-603*
17. 5650D-605*
18. 5650D-611
Compressor/Motor Assembly
Connecting Rod Kit
Diaphragm & Valve Plate Assembly
Kit (diapinragm) (3 kits)
Connecting Rod Plate
Diaphragm & Valve Plate Assembly
Kit (screw) (6/pkg)
Head Assembly Kit
Diaphragm & Valve Plate Assembly
Kit (gasket) (3/pkg)
Diaphragm & Valve Plate Assembly
Kit (valve plate) (3/pkg)
Rear Cover Assembly
7" Vinyl Tubing (6/pkg)
Line Cord Assembly (2-prong cord)
Line Cord Assembly (3-prong cord)
Power Switch
Push-In Feet (4/pkg)
Long-Life Air Inlet Filter (5/pkg)
Long-Life Air Inlet Filter (25/pkg)
Filter Cap
Front Cover Assembly
Storage Compartment Door
Assembly
Tubing Connector w/Pal Nut (6/pkg)
* MODEL 5650C
5650C-604
Rear Cover Assembly
Front Cover Assembly
5650C-603
5650C-605
Storage Compartment Door
Assembly

T roubleshooting
SYMPTOMS
POSSIBLE CAUSES
REMEDIES
A. Reduced air output.
1. Dirty air inlet filter.
1. Replace filter.
2. Worn diaphragm or
valve plate.
2. Replace diaphragm or
valve plate.
3. Air leak.
3. Tighten hose connections
and tighten head screws.
B. Compressor labors when
air device is not being
used.
1. Occluded nebulizer or
tubing.
1. Install some means of
venting excess air when
device is not in use or
use P/N 656 pressure
regulator.
Pulmo-Aide Five-Year Limited Warranty on Compessor Parts
DeVilbiss Model 5650D & 5650C compressors are warranted to be free from defective workman¬
ship and material for a period of five years from date of purchase. Any defective part(s) will be
repaired or replaced at DeVilbiss’ option if the unit has not been tampered with or used improper¬
ly during that period. Make certain that any malfunction is not due to inadequate cleaning or
failure to follow instructions. If repair is necessary, contact your DeVilbiss provider or DeVilbiss
Service Department for instructions: U.S.A. 814-443-4881, Canada 905-660-2459. NOTE— This
warranty does not cover providing a loaner compressor, compensating for cost incurred in rental
while said unit is under repair, or cost for labor incurred in repairing or replacing defective
part(s).
THERE IS NO OTHER EXPRESS WARRANTY. IMPLIED WARRANTIES, INCLUDING THOSE OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE
DURATION OF THE EXPRESS LIMITED WARRANTY AND TO THE EXTENT PERMITTED BY LAW
ANY AND ALL IMPLIED WARRANTIES ARE EXCLUDED. THIS IS THE EXCLUSIVE REMEDY AND
LIABILITY FOR CONSEQUENTIAL AND INCIDENTAL DAMAGES UNDER ANY AND ALL
WARRANTIES ARE EXCLUDED TO THE EXTENT EXCLUSION IS PERMITTED BY LAW. SOME
STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS, OR
THE LIMITATION OR EXCLUSION OF CONSEQUENTIAL OR INCIDENTAL DAMAGES, SO THE
ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU.
This warranty gives you specific legal rights, and you may also have other rights which vary from
state to state.
DEVILBISS
a division of ™
SUNRISE MEDICAL
DeVilbiss Health Care, Inc.
P.O. Box 635
Somerset, Pennsylvania
15501-0635 U.S.A.
[phone]
Sunrise Medical Canada
237 Romina Drive, Unit 3
Concord, Ontario
L4K 4V3 CANADA
[phone]
Authorized DeVilbiss Provider: