Dometic CoolAir SP950C User manual

SP950C, SPX1200C
Fastening frame
for MAN TGS/TGX XXL, XLX
Installation Manual
EN
CLIMATE CONTROL
COOLAIR
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 1 Donnerstag, 7. März 2019 2:16 14

CoolAir SP950C, SPX1200C
3
1.
2.
4x
1.
2.
4x
4.
5.
3.
4.
4x
6x
5.
8x
3.
4x
SPX1200C
SP950C
1 2 3
1
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 3 Donnerstag, 7. März 2019 2:16 14

CoolAir SP950C, SPX1200C
4
1
2
2
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 4 Donnerstag, 7. März 2019 2:16 14

CoolAir SP950C, SPX1200C
5
SPX1200C
SP950C
3
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 5 Donnerstag, 7. März 2019 2:16 14

EN
General safety instructions CoolAir SP950C, SPX1200C
6
Please read this instruction manual carefully before installation and first
use, and store it in a safe place. If you pass on the product to another
person, hand over this instruction manual along with it.
1 General safety instructions
The manufacturer accepts no liability for damage in the following cases:
• Damage to the product resulting from mechanical influences and incorrect
connection voltage
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in the operating manual
A
I
2Scopeofdelivery
Installation kit for MAN TGA/TGX XLX, XXL
NOTICE!
The freedom of movement of semi-trailers (of the outer edges of the
semi-trailer when turning or jackknifing) and other vehicle attachments
must not be restricted.
NOTE
Observe the safety instructions in the installation manual for the parking
cooler.
Quantity Designation
1 Fastening frame
1 Installation manual
7 U washer M8 (d1 = 8.4 mm, d2 = 20 mm)
2 Bolt M8 x 16
4 Bolt M8 x 30
12 U washer M8 (d1 = 8.4 mm, d2 = 16 mm)
13 Nut M8, self-locking
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 6 Donnerstag, 7. März 2019 2:16 14

EN
CoolAir SP950C, SPX1200C Target group for this manual
7
Before starting the system, check that all the parts belongingto the scope of delivery
are present.
3 Target group for this manual
The installation information in this manual is only intended for qualified personnel at
workshops, who are familiar with the guidelines and safety precautions to be applied
during the installation of vehicle accessory parts.
4 Intended use
The fastening frame is used for installing the condenser unit SP950C or SPX1200C
for the parking cooler SP950 or SPX1200, respectively, to the following vehicles:
MAN TGA/TGX XLX, XXL. The fastening frame is attached on the left of the rear cab
wall.
When fastening the fastening frame, use existing fastening points on the vehicle. You
do not need to drill new holes.
5 Fitting the fastening frame
A
I
Basic assembly is described in fig. 1, page 3:
NOTICE!
Observe the information in the installation manual when fitting the park-
ing cooler.
NOTE
Operating instructions can be found in the operating manual for the
parking cooler.
Item Designation
1 Fastening frame
2Condenserunit
3Cover
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 7 Donnerstag, 7. März 2019 2:16 14

Guarantee CoolAir SP950C, SPX1200C
Fit the fastening frame and the condenser at the MAN TGA/TGX XLX, XXL as follows:
I
➤Insert and tighten the four M8 x 30 bolts, eight U washers M8 8.4 x 16 mm and
four M8 retaining nuts (fig. 1, page 3) in the mounting frame for the condenser
unit.
➤Remove the existing nuts (fig. 21, page 4) from the fastening of the air filter
housing.
➤Fasten the fastening frame to the fastening bolts using the M8 8.4 x 20 mm U
washers and M8 retaining bolts provided (fig. 21,page 4).
➤Attach the mounting frame to the bottom of the bracket with the M8 x 16 bolts,
U-washers M8 8.4 x 20 mm and M8 retaining nuts provided (fig. 22,page 4).
➤Place the condenser unit on the projecting bolts of the mounting frame and bolt
to the four U washers M8 8.4 x 16 mm and four M8 retaining nuts.
➤Check that all bolts are still tight after travelling approximately 200 km.
6Guarantee
The statutory warranty period applies. If the product is defective, please contact the
service partner in your country (addresses on the back on the instruction manual).
Our experts will be happy to help you and will discuss the warranty process with you
in more detail.
NOTE
Only install the condenser unit after you have attached the mounting
frame on the rear wall of the truck.
SP950C-SPX1200C-MAN-XXL--I-16s.book Seite 8 Donnerstag, 7. März 2019 2:16 14
Discover other RV air conditioners on our website.