Esco 10961 User manual

Operating Instructions
Model 10961
DIGITAL T I RE INFLATOR
COMPLIES WITH
EN12645: 2014*
COMPLIES WITH
EN12645: 2014*

2
Thank you for selecting this ESCO Digital
Tire Inflator. Please read this manual before
carrying out any installation or service
procedure.
This manual is an integral and essential part
of the product, please keep it away from
damp, heat, dust, oils, do not remove, tear
or amend any parts of the manual for any
reason. It must be made available to the
operator and to maintenance personnel, also
to ensure staff training.
If you lose or damage the manual, ask the
manufacturer for a copy, quoting the Part
No. The manual must always remain with the
machine, in the event of the machine
being sold, it must be given to the new user.
The manufacturer reserves the right to
change product features at any time
without notice.
FEATURES
• Unitsofmeasure(psi.,bar,kPa)
• Inflatesto12bar,174psi,1200kPa,
12kgF
• Easytoreadbacklit LCDdisplay
•Onebuttonoperationhas3functions:
inflates,deflates&measurestirepressure
• 90secondautoofffunction
•Toughaluminumdiecastbodywith rubber
sleeve
• Individuallycalibratedandtested
(seecalibrationcertificate)
OPER ATION
1) Removetirevalvecap.
2) Withclip-onairchuckleverdepressed,
firmlypresschuckontotirevalvestemand
releaselever,ensurethatnoairleaks.
3) Pressthetireinflatorlevertoinflate,press
theleverhalf-waytodeflate.
4) Onbutton:Presstheon/unit/lightbuttonto
turnontheinflator,iftheunitisnotusedthe
inflatorwillbeturnedoffautomaticallyafter
90seconds.
5) Backlight:Whentheinflatorison,pressthe
on/unit/lightbuttontoturnonthebacklight
whenusedinlowlight.Thebacklight
willturnoffautomaticallyin5seconds.
Backlightwillnotbeactivatedbyturning
ontheinflatorandcanonlybeactivatedby
pressingthe on/unit/light buttononce the
unitisturnedon.
6) Changingtheunitofmeasure:Presson/
unit/lightbuttonforatleast3secondsto
enterunitchangemode,thenonequick
pressoftheon/unit/lightbuttontochoose
thedesiredunit.Theunitchosenwill
bethedefaultunituntilchangedbythe
aboveprocedure.
7) Thebatteryusedisa2xAAA,oncethe
voltagegoesbelow2.4V,thelowbattery
signalonthetopleftwillflashcontinuously
untilanewbatteryisinstalled.
WARNING
To avoid the risk of personal injury, especially
to the eyes, face or skin, DO NOT direct
the air stream at any person, or any part of
the body.
This equipment is not intended for use by
children without adult supervision.
The manufacturer reserves the right to
change product features at any time
without notice.

3
BATTERY REPLACEMENT
1
2
3
4
5
Peelbackrubberbootto
revealthebatteryholder
Openbatteryholder
Replacebatteries
Closebatteryholder
Replacerubberboot

CALIBRATION CERTIFICATE
ThisDigitalAutomaticTireInflatorhasbeen
calibratedinitsnormalworkingpositionontest
equipmentwithanaccuracythatistraceable
toStandardsaccordingto:EN12645:2014
ALLOWABLE TOLERANCE
bar
+/- 0.08 up to and including 4 bar
+/- 0.16 between 4 bar and 10 bar
inclusive
+/- 0.25 greater than 10 bar
p.s.i.
+/- 1.2 up to and including 58 p.s.i.
+/- 2.3 between 58 and 145 p.s.i.
inclusive
+/- 3.6 greater than 145 p.s.i.
TEST RESULT
REFERENCE PRESSURE
bar p.s.i.
DISPLAY PRESSURE
bar p.s.i.
SPECIFICATION S
Hose length 20 in. with swivel
Chuck type Clip on
Units of measure bar, psi, kPa
Ination range
0-12 bar
0-174 p.s.i.
1200 kPa
Weight 2 lbs. | 0.8 kg
Accuracy +/- 2 psi @ 25-75psi
Inlet thread 1/4'' NPT
Dimensions 10L x 4W x 4.3H in.
Battery 2 x AAA Batteries (Included)
COMPLIES WITH
EN12645: 2014*
* Tire pressure measuring Instruments,
devices for Inspection of pressure and/or
Inflation/Deflation of tires for motor
vehicles.
Serial Number:
Date:
www.esco.net
Distributed by
ESCO - Equipment Supply Co.
15270 Flight Path Drive, Brooksville FL, 34604
[email protected]
For more information contact Customer Service on
1-800-352-9852