HOMCOM 370-187V70 User manual

ASSEMBLY INSTRUCTION
INfda008_UK
370-187V70
IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLY
*Suitable for children of years old.3-6
*Max weight: kg.30
● R/C controls forward/backward and left/right
● Volume adjustment
● Power display
● Forward and backward
● High and low speed

L1
K14
J6
I2
E1 D4
C4
B1 A1
H2 G1
F1
Windshield
Rearview mirror Washer
Screw
Wheel Rear wing
Seat
+1(spare)
Main Steering wheel Wheel Cover
Right and left bracket
M1
N4
+1(spare)
Screw Cotter pin
O1P1
Remote Control Charger

③ ④ ⑤ ⑥
②
①
Product Specifications :
Battery
Generator
Applicable Age Range
Maximum load
Speed
Hours of Use
Charger
Remote Control Battery
12V/4.5AHx1
Drive Motor 12V,30W #390 x2
Steering Motor 12V #380 x1
37-72 months
30KG
3-5 KM/H
Using 1-2 hours after charging 8-12 hours
Input: AC120V-240V ,50-60Hz,0.2A;
Output: DC12V,500mA,6W
AAA1.5Vx2(not provided)
Function
Button function
Power display
Charging hole
Power button
Siren button
High and low speed
Forward and backward
1
2
3
4
5
6

● Never switch forward and backward operations in the moving, or the gear box and
motor will be damaged.
● Use the remote control with battery.
● Only the baby's legal guardian can use the remote control.
●The product is operated mainly by remote control.
Code Method:
Hold down Forward & Backward for 3 seconds start
match code, The first LED flicker;
Turn on the car's power now, The first LED lit up, Match
code Success.
Remote Control Function and explaination
Battery Operating Specifications:
Never mix new and old batteries, or different kinds of batteries.
Never mistake positive and negative electrode of battery, or short circuit will happen.
Non-rechargeable batteries are not to be recharged.
Install batteries in a right polarity.
Only adults can recharge or change batteries.
Never make power port' s short circuit happen.
Recharge the battery only when it is taken out of the toy car.
Take exhausted battery out of the toy car and keep it out of Children's reach.
Remove battery screws with a screwdriver, open battery cap as the arrow signals, and
in the 2.4G remote control model install two AAA 1.5V batteries in a right polarity.
1.Right and left bracket assembly
Place the right and left brackets at the corresponding holes on the body and use 10
pcs screw to tighten.

2. Front and rear wheels assembly
3.Steering wheel assembly
4.Windshield assembly
Assembling washer, front wheel, washer step by step, then using cotter pin to
tighten, finally inserting wheel cover. Assembling rear wheel, washer step by step,
then using cotter pin to tighten, finally inserting wheel cover. Same way to the other
side.
Connecting two lines like the picture, then inserting the steering wheel to the
direction lever, finally use screw and nut to tighten.
Open the hood, connecting the lines which are in the windshield and under the
hood, inserting the windshield into the right place on the platform, finally use 2pcs
screw to tighten.

5. Rear wing assembly
6.Battery line connecting
Connecting the lines which are in the rear wing and car body, then inserting rear
wing into the right hole on the car.
Connect the battery line correctly, red to red, black to black.
7.Seat assembly
Inserting the seat into the right place in the car, then use 2pcs screw to tighten.

8.Rearview mirror assembly
Inserting right and left rearview mirror into the right place.

WARNING
The toy is to be assembled by an adult. ln unassembled state contain potentially
hazardous sharp points, sharp edges and small part, so please keep out of baby's
reach.
Not to be used in traffic.
Only adults can install parts and adjust the car, and keep moving parts out of
children’s reach.
Children under 36 months cannot use the toy car as it has many small parts.
Children must take the seat belt when using the car, and keep the car out of the fire.
Children can use the product only in the company of adults, and the adult cannot
leave during the process.
Never let Children stand or play onto the pedal or in the car.
Only adults can complete storage battery charging, and must charge the product
before its first use.
Keep such package materials as plastic bags out of children, or they will suffocate
or kill children.
Never use parts provided by non-manufacturers.Never let children play with the
charger.
The number of connected power by the product can never be over the
recommended number.
Notice of use:
Never use the product in such dangerous zones as street, road, slope or drain.
Never change the circuit and additional electric devices.
Never use remote control in rainy days or in the water, never pour water or other liquid
into the car, keep the product out of the fire, otherwise the car will be damaged.
Turn off the power when not in use and remove battery connector when not using it for a
long time.
As the product has battery charger, check whether wire plug shell and other parts are
damaged or not , and fix those damaged parts.
The product must be assembled by the adult! Before assembling, screws and pins are
dangerous sharp points.
Charge storage battery less than 10 hours, or the storage battery will be damaged
forever.
ln charging, put DC Plug into the power socket , put charger into power plug; never
use the product during charging it.
The product can be used for one hour, and the charging time is 8-10 hours,
exceeding no more than 18 hours.
lt is common for charger and storage battery to have not become
heated(temperature under 60 degrees)in charging.
Never use the connector with the water, or short circuit will happen.
Use the product's own charger, or cause charger and storage battery to be
damaged or short circuit.
Charge the product when not using it for a long time.
Charging notice:

Charging steps are as follows:
Trouble Clearing
Type Analysis Solutions
The car can not get
started.
The battery can not
be charged.
The car has a short
range.
There appear slight
noise and heat of
the car in charging.
The car has a slow
speed.
Low battery voltage;
Protection of electric devices;
Failure to press the switch
button correctly;
Falling of power connector;
Battery breakdown;
Damage of electric devices;
Generator breakdown.
Falling of battery connector;
No charging for the charger;
Charger breakdown.
Not full charging of battery;
Much-used battery.
Chemical reactions.
Much-used battery;
No electricity for battery;
Overload;
Uneven driving surface.
Charge battery fully;
Use the car a few minutes later;
Use the car according to
instructions;
Install the connector again;
Change battery;
Change electric devices;
Change generator.
Install the connector again;
Plug the charger again;
Change the charger.
Charge fully the battery again;
Change the battery.
Normal reactions.
Change the battery;
Charge fully the battery again;
Reduce the load below 25
kilograms;
Drive on uneven surface.
Step 1: The charging hole is under the steering wheel.
Step 2: Put the charger plug into the plug hole.
Step 3: Connect the charger to the power socket.
Warning: Car must be charged by adults only. Car is useless during charging.

Maintenance and Service
Before use children’s parents should check whether charge' s wiring, plug, shell
and other parts are damaged, and fix those damaged parts.
After using the product for a time, parents should lubricate iron castings with lube,
or those castings will get rusted; they should keep the product out of fire and lay it
flat in dark places; they should put the product inside the house or cover it with one
water-proof cloth in wet whether.
Parents should keep the product out of such hot objects as stove and heater, or its
plastic parts may be thawed; they should keep the product out of combustible
objects in charging, or the fire may happen.
Parents should clean car surface with one dry cloth, or clean plastic parts with non-
waxy furniture polish; they shouldn’t clean plastic parts with chemical solutions or
clean the car with water; children cannot drive the car in wet or rainy weather, or the
car' s generator, circuit system and battery will be damaged.
when not using or laying the product, parents should cut off car power, keeping all
the switches into "STOP" or "OFF" model.
Parents mustn’t use the fuse which doesn’t conform with the agreed specifications.
Parents should' t change product structure and circuit system, and should have the
product checked and fixed by professionals or under the guidance of professionals.