Sealey SEKC25 User manual

ELECTRONIC KEY CABINETS
MODEL NO: SEKC25, SEKC50, SEKC100
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
I
MPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURYAND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! These cabinets are heavy and care should be exercised in transit and handling to ensure that no one is injured.
WARNING! These key cabinets are a 2 person job for installation.
9 Formaximumsecurity,thesecabinetsmustbesecurelyxedtoawall.
9 Ensurethatanywallusedissufcientlystrongtocarrytheweightofthecabinetanditscontents.
8DO NOTinstallinareaswheredampandcondensationarepresent.
WARNING!Thewarnings,cautionsandinstructionsreferredtointhisinstructionmanualcannotcoverallpossibleconditionsand
 situationsthatmayoccur.Itmustbeunderstoodthatcommonsenseandcautionarefactorswhichcannotbebuiltintothisproduct,
but must be applied by the operator.
2. INTRODUCTION
Heavy-dutyconstructionwithtwinlockingbolts.Simpletooperateelectronickeypadacceptsnumbersofbetweenthreeandeightdigits,giving
millionsofcombinations.ThreeLEDsshowsecurity,powerandoperatingstatus.
Alsosuppliedwithtwokeysformanualoverrideshouldbatteriesfail.Numbered,colourcodedhookbarsareadjustabletosuitvaryingkey 
sizes. Includes anchor bolts.
• CAUTION: Ifyou,oranintruder,usesanincorrectgroupofnumbers,thecabinetwillnotopenandayellowlightwillilluminate.Entering
 anincorrectPIN3timeswillfreezethesystemfor20seconds.
• Keepthecabinetkeyandanyrecordofthecombinationseparatefromthecabinetandunidentified.
3. SPECIFICATION
Model no.................................................................. SEKC25
Overall size.............................................320x120x210mm
Key capacity.......................................................................25
4. INSTALLATION
4.1.  Considerationshouldbegiventotheplacingofthecabinettoensure
 thatitisplacedinadiscreetlocationandwillnotbeeasilyfoundbyintruders.
4.2.  Eachcabinetissuppliedwithtwoanchorboltssuitableforfixingtobrickand
concrete.
4.3.  Fixingtohollowpartitionwallsisnotrecommended.Iffixedtowooditmust
 betoasolidwoodenstructure.
4.4. Open the door of the cabinet (see 5.1 / 5.3 for opening instructions) and
 withthehelpofasecondperson,positionitwhererequiredandmarkthe
mounting positions through the pre-drilled holes in the back of the cabinet.
4.5.  Whenmountingtoawall,ensurethatthecabinetisadequatelysupported
during the marking process.
4.6.  Drill10mmholestoadepthof38mm(fig.1.1)andinserttheanchorbolts
 withnutsandwashersremoved(fig.1.2).WearappropriatePPE(goggles
 andmask.)
4.7.  Positionthecabinetoverthetwoprotrudingmountingstudsandsupportit
 therewhilstplacingawasher,splitwasherandnutontoeachstud(fig.1.3).
4.8.  Continuetosupportthecabinetwhilsttighteningthefixings(fig.1.4).
SEKC25,SEKC50,SEKC100|Issue:5(H4F)16/04/18
Original Language Version
©JackSealeyLimited
Refer to
instruction
manual
Model no.................................................................. SEKC50
Overall size.............................................400x120x340mm
Key capacity.......................................................................50
Model no................................................................ SEKC100
Overall size.............................................400x120x550mm
Key capacity.....................................................................100
g.1

5. OPERATION
5.1. Key operation.
5.1.1. For the first opening or if you forget your combination, you can use the manual override key: DO NOT keep override key in cabinet.
 Theoverridelockissituatedunderthelogopanelinthecentreofthemaincontrolpanel.Priseoutthepanelusingasmallscrewdriver.
 Insertkeyandturnknobandthecabinetwillbeunlocked.Snappanelbackintoplaceafterwards.
5.1.2. Pleasemakeanoteofthekeynumberwhichcanbefoundonthekeyoronthebarrelinthecabinet.
5.2. Entering a new combination.
The combination must consist of between 3 and 8 numbers and should be safely recorded before being entered into the
cabinet electronics.
5.2.1. Open cabinet using the override key
5.2.2. Insert 4 x AA batteries, ensuring correct polarity.
5.2.3. Press the red button on the inside of the door near the hinges.
5.2.4. Now enteryourpersonalcombination(3-8numbers),andthenpresstheletter‘B’toconfirmyourcombination.Abeepwillsoundfor
 eachkeypressed.Aftertheletter“B”ispressed,thegreenlightwillshowtoindicateyoursuccess.Besuretorecordthiscombination
immediately, so you do not forget.
5.3. Opening.
5.3.1. T o openthedoorofthecabinetenteryourpersonalcombination,thentheletter‘B’ toconfirm.
5.3.2. Within5secondsofcorrectcombinationentryturnknobtoopenthecabinetdoor.
5.3.3. I f thecabinetre-locks,entercombinationagain.Don’tforgettopresstheletter‘B’afterenteringthecombination.
NOTE! After entering the correct combination, if you do not open the door within 5 seconds it will re-lock.
NOTE! If the incorrect combination is used 3 times the system will freeze for 20 seconds.
5.4. Low battery warning and replacement.
5.4.1. I f redlightshowsinthetoprightofthecontrolpanelthisindicateslowbatteries.Changebatteriesbyopeningthecabinetandremoving
themfromthebackofthedoor.Thenreplaceallbatterieswithnewones.
5.4.2. I f thekeypaddoesnotworkbecausethebatteriesinthecabinetareexhausted,usetheoverridekeytoopenthecabinet,andthen
replace all batteries.
5.5. Lost keys.
5.5.1. Shouldyouloseyourkeys,wecansupplyreplacements.Toorderthesepleasecontactoursalesofficeon01284757500andquotethe
 uniquenumberonthekeycabinetlock.Wewillalsorequireacopyofyourpurchaseinvoiceforthekeycabinettoconfirmthatyouare
 theowner.
5.5.2. Pleasenotethatreplacementkeysarespecialorderonly(wedonotcarrytheseinstockforsecurityreasons)andassuchtheycantake
 14–28daystoarrive.
SEKC25,SEKC50,SEKC100|Issue:5(H4F)16/04/18
Original Language Version
©JackSealeyLimited
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
according to local regulations.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.
Important: No Liability is accepted for incorrect use of this product.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
BATTERY REMOVAL SEE SECTION 5.4
UndertheWasteBatteriesandAccumulatorsRegulations2009,JackSealeyLtdarerequiredtoinformpotentialpurchasersofproducts
containingbatteries(asdefinedwithintheseregulations),thattheyareregisteredwithValpak’sregisteredcompliancescheme.Jack
SealeyLtdBatteriesProducerRegistrationNumber(BPRN)isBPRN00705.
WEEE REGULATIONS
DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment
(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid
wasteauthorityforrecyclinginformation.