Steris V-PRO 60 User manual

One Integrated Approach to Healthcare
Central Sterile Services
DEVICE
REFERENCE GUIDE

LUMEN
LENS
LIGHT
IMAGE
KEY
Lumen Length (410 mm)
0 mm
310 mm
317 mm275 mm
410 mm
LUMEN LENGTHS
50 mm 100 mm 150 mm
Non Lumen
Cycle
Flexible
Cycle
Lumen
Cycle
INSIDE LUMEN DIAMETERS 4.0 Millimeters
0.157 Inches
12.0 French
3.0 Millimeters
0.118 Inches
9.0 French
2.0 Millimeters
0.078 Inches
6.0 French
1.0 Millimeters
0.039 Inches
3.0 French
.77 Millimeters
0.030 Inches
2.3 French
Non Lumen Cycle
•Non-lumened rigid and
semi-rigid endoscopes
•Non-lumened flexible endoscopes
•Stainless steel or Titanium diffusion-
restricted spaces
Flexible Cycle
•Single or Dual Lumen Devices
- ≥ 1 mm ID and ≤ 990 mm L
•Polyethylene (PE)/PTFE (Teflon®) Tubing*
- ≥ 1 mm ID and ≤ 4,000 mm L
Pictorial representation of device measurements are
approximate and for reference only.
* Tubing claims have not been reviewed by the Food and Drug Administration
Examples of Representative Devices
Refer to the complete Indications for Use and validation loads on the reverse side.
See device matrix to identify the correct cycle for your device.
Orthopedic
Drill
da Vinci®2
Endoscopes
Non-Lumened Flexible
Endoscope
Camera
Battery
Scissors /
Forceps
Non-Lumened
Telescope
Single Lumen
Endoscope
(Teflon®) PTFE+PE
Tubing*
Dual Lumen
Endoscope
Single Lumen
Endoscope
Light Cord
Dual Lumen
Endoscope
Triple Lumen
Endoscope
LIMITS
PER CYCLE
12 POUNDS
(5.4 kg)
LIMITS
PER CYCLE
1 ENDOSCOPE
LIMITS
PER CYCLE
14 pieces
no additional
load
LIMITS
PER CYCLE
11 POUNDS
(5.0 kg)
12 LUMENS
Lumen Cycle
•Single or Dual Stainless Steel Lumen Devices
- ≥ 0.77 mm internal diameter (ID) and ≤ 410 mm in length (L)
•Triple Stainless Steel Lumen Devices
- ≥ 1.2 mm ID and ≤ 275 mm L
- ≥ 1.8 mm ID and ≤ 310 mm L
- ≥ 2.8 mm ID and ≤ 317 mm L

INDICATIONS FOR USE
Document # M4070EN.2016-03, Rev. B ©2016 STERIS Corporation.
All rights reserved.
The V-PRO 60 Low Temperature Sterilization System, with VAPROX®HC Sterilant, is a vaporized hydrogen peroxide
sterilizer intended for use in the terminal sterilization of cleaned, rinsed and dried reusable metal and nonmetal
medical devices used in Healthcare facilities. The pre-programmed sterilization cycles (Lumen Cycle, Non Lumen
Cycle, and Flexible Cycle) operate at low pressure and low temperature and are thus suitable for processing medical
devices sensitive to heat and moisture.
a The validation studies for all lumen configurations were conducted using a maximum of twelve (12) lumens per load. Hospital loads should not exceed the maximum number
of lumens validated by this testing. The validation studies were performed using a validation load consisting of one instrument tray with instrument organizers and mat and two
pouches for a total weight of 11 lbs (5.0 kg).
b The validation studies were performed using a validation load consisting of one instrument tray with instrument organizers and mat and one pouch for a total weight of 12 lbs
(5.4 kg).
c The validation studies were conducted with one flexible endoscope, packaged into a tray with silicone mat, instrument organizers and light cord (if not integral to scope) and
no additional load.
V-PRO 60
Sterilizer Cycle Indications for Use Total Load
Lumen Cycle
Can sterilizea:
• Instruments with diffusion-restricted spaces such as the
hinged portion of forceps and scissors
• Non-lumened devices including non-lumened rigid and
semi-rigid endoscopes
• Medical devices, including single, dual and triple
channeled rigid and semi-rigid endoscopes, with the
following configurationsa:
1. Single or dual lumen devices with stainless steel
lumens that are ≥ 0.77 mm (~1/32”) internal diameter
(ID) and ≤ 410 mm (16-9/64”) in length
2. Triple lumen devices with stainless steel lumens that are:
≥ 1.2 mm (~3/64”) ID and ≤ 275 mm (~10-55/64”) in length
≥ 1.8 mm (~5/64”) ID and ≤ 310 mm (~12-13/64”) in length
or
≥ 2.8 mm (~7/64”) ID and ≤ 317 mm (12-31/64”) in length
11 lbs (5.0 kgs)
and
12 Lumens
Non Lumen Cycle
Can sterilizeb:
• Non-lumened devices including non-lumened rigid, semi-
rigid and flexible endoscopes and non-lumened devices
with stainless steel or titanium diffusion-restricted spaces
such as the hinged portion of forceps and scissors.
12 lbs (5.4 kgs)
Flexible Cycle
Can sterilizec:
•One flexible surgical endoscope or bronchoscope with
a light cord (if not integral to endoscope) and mat without
any additional load. The flexible endoscope may be a:
Single or dual lumen device with lumens that are > 1 mm
(~3/64”) ID and < 990 mm (38-63/64”) in length
NA
1Teflon is a registered trademark of the E.I. du Pont de Nemours and Company.
2da Vinci®is a registered trademark of Intuitive Surgical, Inc.