Sunjoy HDO Arched Pergola A106004620 User manual

HDO 10x10 Arched Pergola
Model No.: A106004620
Model UPC: 041226176469
Quality Guaranteed:
If you are not completely satisfied with this product, return it
for refund or replacement.
Comments or questions? 800-697-2448
www.interamericanproducts.com
Distributed by Inter-American Products, Cincinnati, OH 45202

•Pleasereadandunderstandthisentiremanualbeforeattemptingtoassembleorinstalltheproduct.
•Beforebeginningassemblyofproduct,makesureallpartsarepresent.Comparepartswithpackage
contentslistandhardwarecontentslist.Ifanypartismissingordamaged,donotattempttoassemblethe
product.
• Theassembledgazeboshouldbelocatedatleast6feetfromanyobstructionsuchasfence,garage,house,
overhangingbranches,laundrylinesorelectricalwires.
• Somepartsmaycontainsharpedges.Wearprotectiveglovesifnecessary,duringassembly.
• Checkallnutsandboltsperiodicallyfortightnessand,whenrequired,tightenthemagain.
•Payattentiontothepartsorientation.
• Installthegazeboonlevelground.Stakesareprovidedtosecurethegazebototheground.
•Donotassemblethegazeboonsandy,muddyorloosesoil,asstakesdonothaveenoughanchoragein
thesetypesofsoil.
•Ifyouwishtosecurethegazebotoawooddeckorconcretesurface,useanchorssuitedtothese surfaces.
•Remove all excess snow from the roof.
•Donotleavethegazebowherethereisariskofhighwind,aspossibledamagewilloccurtothestructure.
•Anyassemblyormaintenanceoftheproductmustbecarriedoutbyadultsonly.
•Pleasecheckyourstateandlocalregulationspriortopurchasing.Somejurisdictionsmayrequirepermits
forinstallationanduse.Somespecialproceduresmaybevalidinyourarea.
•Ifanyscratchpaint,pleasetouchuptopreventrusting.
•Foroutdooruseonly.
GENERAL BEST PRACTICES F
OR ASSEMBLY
WARNINGS
WARNING
KEEP ALL FLAME AND HEAT SOURCES AWAY FROM THIS TENT FABRIC
THIS TENT IS MADE WITH FLAME RESISTANT FABRIC WHICH MEETS CPAI-84 SPECIFICATIONS. IT IS NOT
FIREPROOF. THE FABRIC WILL BURN IF LEFT IN CONTINUOUS CONTACT WITH ANY FLAME SOURCE. THE
APPLICATION OF ANY FOREIGN SUBSTANCE ON TO THE TENT FABRIC MAY RENDER THE FLAME
RESISTANT PROPERTIES INEFFECTIVE.

•Steelcomponentsforthisgazeboaretreatedwithrustinhibitingpaintthatprotectsitfromrusting.
However,duetothenatureofsteel,surfaceoxidation(rusting)willoccuriftheseprotectivecoatingsare
scratched.Thisisnotadefectandthusnotcoveredbythewarranty.
•Tominimizethiscondition,itisrecommendedtousecarewhenassemblingandhandlingtheproductto
preventscratchingthepaint.Shouldanyscratchingordamageoccur,itisrecommendedtocoverthe
scratchimmediatelywithrustinhibitingpaint(notincluded).
• SurfacerustcanalsobeeasilyremovedwithaverylightapplicationofregularcookingoilorWD‐40.If
surfaceoxidation(rusting)occursandifnomeasureistakentopreventthis,theoxidationmaystart
drippingontodeckorpatioandcauseddamagingstains,whichmaybedifficulttoremove.Thiscanbe
preventediftheabove‐mentionedmeasuresaretakentokeeptheproductfromoxidizing.
•Donotusebleach,acid,orotherabrasivecleanersontherooforframeparts.
• Keepinstructionmanualforfuturereference.
• Keeptheoriginalpackagingtostorethegazebo.
• Periodicallycheckandensurethatallboltsarewell‐tightenduringuse.
Tools Recommended (Not Included)
MAINTENANCE
Included

Exploded Drawing

Parts List
Label Part Number Description Qty Part Image
A1 P000200545 Post 1 2
A2 P000200546 Post 2 2
B P006100202 Base Cover 4
C P000100400 Base 4
D P005600431 Decoration 1 4
E P005600432 Decoration 2 4
F P005000527 Brace (Short) 4
G P005000528 Brace (Long) 4
H1 P000601829 5
H2 P000601828 5
I1 P000601830 Top Beam 1 2
I2 P000601831 Top Beam 2 2
J1 P000401061 Cross Beam 1 2
J2 P000401062 Cross Beam 2 2
K P000501499 Connector 1 2
L P005700772 Rail 4
M P000501500 Connector 2 8
Long Beam
Short Beam

N1 P005700771 Fabric Tube 1 2
N2 P005700770 Fabric Tube 2 2
O P006400019 Canopy 1
Hardware Pack
Label Part Number Description Qty Spare Part Image
AA H010010003 Bolt M6*15 62 4
BB H050030001 Flat Washer M6 120 6
CC H010010110 Bolt M6*45 50 3
DD H010030522 Bolt M6*10 4 1
EE H010030022 8 1
FF H070010003 Stake Φ8*180 8 0
GG H010030030 Bolt M6*15 41
Z1 H090010017 Wrench M6 2 0
Z2 H090030002 Allen Key M6 2 0
Bolt M6*75

1
1

2

1 3

1 4