Technogym Recline 500SP User manual

SERVICE & MAINTENANCE MANUAL
REV. 2.4

The information contained in this manual is intended for QUALIFIED TECHNICIANS who have
completed a specific TECHNOGYM training course and are authorized to perform machine start-
up and adjustment procedures as well as extraordinary maintenance or repairs which require a
thorough knowledge of the machine, its operation, its safety devices and working procedures.
CAREFULLY READ THE INFORMATION CONTAINED IN
THIS MANUAL BEFORE PERFORMING ANY MAINTENANCE
PROCEDURES ON THE MACHINE
DANGEROUS VOLTAGES
PRESENT
NOTE
The information contained in this document is subject to change without notice.
Technogym does not guarantee this documentation in any way. Technogym shall not be held
responsible for any errors contained in this manual and declines all liability for accidents or
damages resulting from the supply, characteristics or use of this manual.
This document contains proprietary information that is protected by copyright. All rights reserved.
No part of this document may be photocopied, reproduced or translated into another language
without the prior written consent of Technogym.
The Technogym™ trademark is property of Technogym S.p.A.
The Recline Excite™ trademark is property of Technogym S.p.A.

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Contents
1. GENERAL NOTICES...........................................................................................................................................1.1
1.1. INTRODUCTION.................................................................................................................................................1.1
1.2. RECOMMENDATIONS ........................................................................................................................................1.1
1.3. GENERAL RULES FOR REPAIR PROCEDURES ......................................................................................................1.2
2. TECHNICAL CHARACTERISTICS..................................................................................................................2.1
2.1. PRODUCT CODES...............................................................................................................................................2.1
2.2. AVAILABLE VERSIONS......................................................................................................................................2.3
2.3. PRODUCT CHARACTERISTICS............................................................................................................................2.4
2.4. MECHANICAL CHARACTERISTICS .....................................................................................................................2.4
2.5. ELECTRICAL CHARACTERISTICS .......................................................................................................................2.5
2.6. AMBIENT SPECIFICATIONS................................................................................................................................2.5
2.7. CONFORMITY TO REGULATIONS........................................................................................................................2.5
2.8. WIRING DIAGRAM ............................................................................................................................................2.6
2.8.1. 500 model.............................................................................................................................................2.6
2.8.1.1. Powered version..............................................................................................................................................................2.6
2.8.1.2. Cordless version..............................................................................................................................................................2.7
2.8.2. 500 model – ARM board......................................................................................................................2.8
2.8.2.1. Powered version..............................................................................................................................................................2.8
2.8.2.2. Cordless version..............................................................................................................................................................2.9
2.8.3. 700 model...........................................................................................................................................2.10
2.8.3.1. Powered version............................................................................................................................................................2.10
2.8.3.2. Cordless version............................................................................................................................................................2.11
2.8.4. 700 model – ARM board....................................................................................................................2.12
2.8.4.1. Powered version............................................................................................................................................................2.12
2.8.4.2. Cordless version............................................................................................................................................................2.13
2.8.5. Wellness TV version...........................................................................................................................2.14
2.8.5.1. NCB Touch screen version...........................................................................................................................................2.14
2.8.5.2. UB Touch screen version..............................................................................................................................................2.15
2.9. CABLES ..........................................................................................................................................................2.16
3. PRINCIPLES OF OPERATION..........................................................................................................................3.1
3.1. BLOCK DIAGRAM..............................................................................................................................................3.1
3.1.1. Display boards.....................................................................................................................................3.2
3.1.1.1. 500i and 500i SP models ................................................................................................................................................3.2
3.1.1.2. 500i ARM and 500i SP ARM models............................................................................................................................3.3
3.1.1.3. 700i and 700i SP models ................................................................................................................................................3.3
3.1.1.4. 700i ARM and 700i SP ARM models............................................................................................................................3.4
3.1.1.5. 700iE Version (Wellness TV) ........................................................................................................................................3.5
3.1.1.6. 700iE UB Version (Wellness TV)..................................................................................................................................3.6
3.1.2. CSafe Board.........................................................................................................................................3.8
3.1.3. TGS reader...........................................................................................................................................3.8
3.1.4. Hand sensor board...............................................................................................................................3.8
3.1.5. Cardio receiver ....................................................................................................................................3.8
3.1.6. Connectors panel .................................................................................................................................3.8
3.1.7. Brake board..........................................................................................................................................3.8
3.1.8. Brake....................................................................................................................................................3.9
3.1.9. Speed sensor.........................................................................................................................................3.9
3.1.10.Power entry module .............................................................................................................................3.9
3.1.11.Alternator...........................................................................................................................................3.10
3.1.12.Battery................................................................................................................................................3.10
3.1.13.External power supply input ..............................................................................................................3.10
3.2. BRAKE CONTROL............................................................................................................................................3.11
3.2.1. Mechanics ..........................................................................................................................................3.11
3.2.2. Control ...............................................................................................................................................3.11
3.2.3. The signals involved...........................................................................................................................3.13
Page i

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page ii
4. ACCESSORIES .....................................................................................................................................................4.1
4.1. CARDIO THEATER CONNECTION........................................................................................................................4.1
4.2. PC LINK FOR PROGRAMMING............................................................................................................................4.1
4.3. CABLE FOR EXCHANGING TV CHANNEL TUNING DATA BETWEEN TWO MACHINES ...........................................4.2
4.4. MONITOR PLUG FOR CSAFE PORT.....................................................................................................................4.3
4.5. WELLNESS TV UPGRADE KIT............................................................................................................................4.4
4.5.1. Installation procedure..........................................................................................................................4.5
5. INSTALLATION INSTRUCTIONS....................................................................................................................5.1
5.1. SPECIFICATIONS AND REQUIREMENTS ..............................................................................................................5.1
5.2. SPECIFICATIONS AND REQUIREMENTS TO INSTALL A WELLNESS TV MACHINE.................................................5.1
5.3. INSTALLATION..................................................................................................................................................5.2
5.4. FIRST POWER-ON ..............................................................................................................................................5.2
6. TROUBLESHOOTING ........................................................................................................................................6.1
6.1. SERVICE TROUBLESHOOTING MENU..................................................................................................................6.2
6.1.1. Automatic Test......................................................................................................................................6.3
6.1.1.1. I2C Devices Test.............................................................................................................................................................6.3
6.1.1.2. LED Test (not on 700iE models)....................................................................................................................................6.3
6.1.1.3. Serial Ports Test..............................................................................................................................................................6.4
6.1.2. Manual Test..........................................................................................................................................6.4
6.1.2.1. Man. Keyboard Test........................................................................................................................................................6.4
6.2. THE DISPLAY FAILS TO ILLUMINATE .................................................................................................................6.5
6.2.1. 500i and 700i models...........................................................................................................................6.5
6.2.2. 500i SP and 700i SP models ................................................................................................................6.7
6.2.3. 700iE Wellness TV models...................................................................................................................6.9
6.3. NO AUDIO SOUND ...........................................................................................................................................6.13
6.4. NO TV PICTURE .............................................................................................................................................6.14
6.5. THE RADIO DOES NOT PLAY ............................................................................................................................6.16
6.6. “THE EQUIPMENT IS BLOCKED” MESSAGE ON THE DISPLAY .................................................................6.18
6.7. ERROR DETECTED BY BRAKE BOARD ..............................................................................................................6.19
6.7.1. Error 1 on brake board......................................................................................................................6.19
6.7.2. Error 2 on brake board......................................................................................................................6.19
6.7.3. Error 4 on brake board......................................................................................................................6.19
6.7.4. Error 8 on the brake board................................................................................................................6.20
6.7.5. Error 16 or 32 on the brake board.....................................................................................................6.20
6.7.6. Error 128 on brake board..................................................................................................................6.20
6.8. THERE IS NO RESISTANCE ...............................................................................................................................6.21
6.9. THE RESISTANCE IS INCORRECT......................................................................................................................6.22
6.10.THE SPEED SIGNAL IS INCORRECT ...................................................................................................................6.24
6.11.THE MACHINE DOES NOT READ THE TGS .........................................................................................................6.26
6.12.THERE IS NO HEART RATE SIGNAL...................................................................................................................6.28
6.12.1.Ricevitore telemetrico HFU ...............................................................................................................6.28
6.12.2.Hand sensor .......................................................................................................................................6.29
6.13.THE TELEMETRIC HR SIGNAL IS INCORRECT....................................................................................................6.31
7. DISASSEMBLY OF COMPONENTS.................................................................................................................7.1
7.1. DISASSEMBLING THE DISPLAY..........................................................................................................................7.1
7.1.1. 700i and 700i SP LED versions...........................................................................................................7.1
7.1.2. 700iE Wellness TV version...................................................................................................................7.2
7.1.3. 500i and 500i SP LED versions...........................................................................................................7.3
7.2. DISASSEMBLING THE CIRCUIT BOARDS ON THE DISPLAY...................................................................................7.4
7.2.1. 700i and 700i SP LED versions...........................................................................................................7.4
7.2.2. 700iE Touch screen Wellness TV version ............................................................................................7.5
7.2.2.1. NCB models....................................................................................................................................................................7.5
7.2.2.2. UB models.......................................................................................................................................................................7.8
7.2.3. 500i and 500i SP versions..................................................................................................................7.12
7.3. DISASSEMBLING THE KEYBOARD / TOUCH SCREEN.........................................................................................7.13
7.3.1. 700i and 700i SP LED versions.........................................................................................................7.13

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
7.3.2. 700iE Touch screen Wellness TV version ..........................................................................................7.14
7.3.3. 500i and 500i SP versions..................................................................................................................7.15
7.4. DISASSEMBLING THE CARDIO RECEIVER.........................................................................................................7.16
7.5. DISASSEMBLING THE HANDLEBAR..................................................................................................................7.19
7.6. DISASSEMBLING THE SENSORS / TOUCH SENSOR.............................................................................................7.20
7.7. DISASSEMBLING THE PEDALS AND THE PEDAL CRANKS ..................................................................................7.21
7.8. DISASSEMBLING THE GUARDS ........................................................................................................................7.22
7.9. DISASSEMBLING THE ELECTRICAL BOX...........................................................................................................7.23
7.10.DISASSEMBLING THE BELT .............................................................................................................................7.24
7.11.DISASSEMBLING THE PULLEY .........................................................................................................................7.25
7.12.DISASSEMBLING THE BRAKE WINDING............................................................................................................7.26
7.13.DISASSEMBLING THE BRAKE GROUP...............................................................................................................7.27
7.14.DISASSEMBLING THE SPEED SENSOR...............................................................................................................7.29
7.15.DISASSEMBLING THE PLATFORMS WITH CSAFE BOARD CONNECTORS AND POWER ENTRY MODULE...............7.30
7.16.DISASSEMBLING THE ALTERNATOR ................................................................................................................7.32
7.17.DISASSEMBLING THE BATTERY.......................................................................................................................7.33
7.18.DISASSEMBLING THE SADDLE.........................................................................................................................7.34
7.19.DISASSEMBLING THE HAND SENSOR BOARD ...................................................................................................7.37
7.20.DISASSEMBLING THE SADDLE HANDLEBARS...................................................................................................7.39
8. ADJUSTMENTS....................................................................................................................................................8.1
8.1. BELT TENSION ..................................................................................................................................................8.1
8.2. BELT TENSION ..................................................................................................................................................8.2
8.3. SPEED SENSOR POSITION...................................................................................................................................8.3
8.4. BRAKE ASSEMBLY............................................................................................................................................8.4
8.5. SADDLE SLIDING...............................................................................................................................................8.5
9. MACHINE CONFIGURATION..........................................................................................................................9.1
9.1. USER MENU CONFIGURATION FOR 700 MODELS................................................................................................9.1
9.1.1. Language..............................................................................................................................................9.1
9.1.2. Distance................................................................................................................................................9.2
9.1.3. Priority setting......................................................................................................................................9.2
9.1.4. Maximum excercise time......................................................................................................................9.2
9.1.5. Pause time............................................................................................................................................9.3
9.1.6. Enable TGS ..........................................................................................................................................9.3
9.1.7. Enable keyboard...................................................................................................................................9.3
9.1.8. Modifiable target heart rate.................................................................................................................9.3
9.1.9. Enable custom messages......................................................................................................................9.4
9.1.10.Edit custom messages...........................................................................................................................9.4
9.1.11.Change messagges languages..............................................................................................................9.4
9.1.12.Enable multi-language mode ...............................................................................................................9.5
9.1.13.Resetting parameters to default values ................................................................................................9.5
9.1.14.Format P&P.........................................................................................................................................9.5
9.1.15.SN.........................................................................................................................................................9.5
9.1.16.Standby.................................................................................................................................................9.6
9.2. USER MENU CONFIGURATION FOR 500 MODEL .................................................................................................9.7
9.2.1. Language..............................................................................................................................................9.7
9.2.2. Change messagges languages..............................................................................................................9.8
9.2.3. Distance................................................................................................................................................9.8
9.2.4. Maximum excercise time......................................................................................................................9.8
9.2.5. Pause time............................................................................................................................................9.8
9.2.6. Default age...........................................................................................................................................9.9
9.2.7. Default weight ......................................................................................................................................9.9
9.2.8. Default time..........................................................................................................................................9.9
9.2.9. Default calories..................................................................................................................................9.10
9.2.10.Default distance..................................................................................................................................9.10
9.2.11.Modifiable target heart rate...............................................................................................................9.10
9.2.12.Enable TGS ........................................................................................................................................9.11
9.2.13.Enable keyboard.................................................................................................................................9.11
Page iii

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page iv
9.2.14.Enable custom messages....................................................................................................................9.11
9.2.15.Resetting parameters to default values ..............................................................................................9.12
9.2.16.Format P&P.......................................................................................................................................9.12
9.2.17.SN.......................................................................................................................................................9.12
9.3. SERVICE MENU CONFIGURATION ....................................................................................................................9.13
9.3.1. Time and date.....................................................................................................................................9.14
9.3.1.1. Hour ..............................................................................................................................................................................9.15
9.3.1.2. Minutes..........................................................................................................................................................................9.15
9.3.1.3. Day................................................................................................................................................................................9.15
9.3.1.4. Month............................................................................................................................................................................9.15
9.3.1.5. Year...............................................................................................................................................................................9.15
9.3.1.6. Set Clock.......................................................................................................................................................................9.15
9.3.2. Low kit parameter ..............................................................................................................................9.15
9.3.2.1. Read from low kit .........................................................................................................................................................9.16
9.3.2.2. Write to low kit.............................................................................................................................................................9.16
9.3.2.3. Default Setting..............................................................................................................................................................9.16
9.3.2.4. Configuration parameters table.....................................................................................................................................9.17
9.3.3. Operating data...................................................................................................................................9.17
9.3.3.1. Read from low kit .........................................................................................................................................................9.18
9.3.3.2. Write to low kit.............................................................................................................................................................9.18
9.3.3.3. Machine usage data.......................................................................................................................................................9.18
9.3.4. Errors log...........................................................................................................................................9.18
9.3.4.1. Read from low kit .........................................................................................................................................................9.19
9.3.4.2. Reset Errors...................................................................................................................................................................9.19
9.3.4.3. COM.Fault ....................................................................................................................................................................9.19
9.3.4.4. View Errors...................................................................................................................................................................9.20
9.3.5. Standard settings................................................................................................................................9.20
9.3.6. Low kit menu ......................................................................................................................................9.21
9.3.6.1. Low kit version.............................................................................................................................................................9.21
9.3.6.2. Low Kit fault code........................................................................................................................................................9.21
9.3.7. High kit version..................................................................................................................................9.21
9.3.8. BOOT version.....................................................................................................................................9.21
9.3.9. Screen saver .......................................................................................................................................9.22
9.3.10.Waiting time .......................................................................................................................................9.22
9.3.11.TV Standard (700iE version only)......................................................................................................9.22
9.4. TV MENU CONFIGURATION FOR 700IE MODEL...............................................................................................9.24
9.4.1. TV channel tuning ..............................................................................................................................9.24
9.4.2. Wellness TV adjustments....................................................................................................................9.26
9.5. RADIO MENU CONFIGURATION FOR 700IE MODEL..........................................................................................9.27
9.5.1. Radio channel tuning .........................................................................................................................9.27
9.5.1.1. Procedure for manually entering radio channel frequencies........................................................................................9.28
9.5.1.2. Automatic radio channel tuning procedure ..................................................................................................................9.29
9.6. TRANSFERRING THE TUNING DATA .................................................................................................................9.30
9.6.1. Using the TGS....................................................................................................................................9.30
9.6.2. Using the connecting cable................................................................................................................9.30
9.7. TOUCH SCREEN CALIBRATION ........................................................................................................................9.31
10.SCHEDULED MAINTENANCE.......................................................................................................................10.1
10.1.DAILY MAINTENANCE OPERATIONS................................................................................................................10.1
10.1.1.Setting up the operation .....................................................................................................................10.1
10.1.2.External cleaning operations .............................................................................................................10.1
10.2.MONTHLY MAINTENANCE OPERATIONS..........................................................................................................10.2
10.2.1.Saddle cleaninig operation.................................................................................................................10.2
10.2.2.Check wear of foot straps...................................................................................................................10.2
10.2.3.Checking the operation of the cardiotester receiver..........................................................................10.2
10.2.4.Checking the operation of the hand sensor receiver..........................................................................10.2
10.3.TWICE-YEARLY MAINTENANCE OPERATIONS..................................................................................................10.3
10.3.1.Carrying out the monthly maintenance procedure.............................................................................10.3
10.3.2.Setting up the operation .....................................................................................................................10.3
10.3.3.Cleaning operations...........................................................................................................................10.3
10.3.4.Checking the working conditions .......................................................................................................10.3
10.3.5.Checking the wear of rubber parts.....................................................................................................10.3
10.3.6.Checking the belt................................................................................................................................10.3

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
10.3.7.Checking the display ..........................................................................................................................10.3
10.3.8.Checking the wiring and connections ................................................................................................10.4
11.APPENDIX...........................................................................................................................................................11.1
11.1.UPDATING THE SW ........................................................................................................................................11.1
11.2.HARDWARE – SOFTWARE COMPATIBILITY......................................................................................................11.2
11.2.1.500i and 500i SP models....................................................................................................................11.2
11.2.2.700i e 700i SP models........................................................................................................................11.2
11.2.2.1. New Touch Sensor........................................................................................................................................................11.2
11.2.3.700i E model ......................................................................................................................................11.2
11.2.3.1. Connectors board..........................................................................................................................................................11.3
11.2.3.2. New Touch Sensor........................................................................................................................................................11.3
11.3.REQUIRED TOOLS ...........................................................................................................................................11.4
Page v

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page vi
Page intentionally left blank

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
1. GENERAL NOTICES
1.1. INTRODUCTION
This document is reserved for Technogym Service technicians, and is intended to provide
authorized personnel with the necessary information to correctly carry out repairs and maintenance.
A thorough knowledge of the technical information contained in this manual is essential for
completing the professional training of the operator.
In order to facilitate consultation, the paragraphs are accompanied by schematic drawings which
illustrate the procedure being described.
This manual contains notices and symbols which have a specific meanings:
WARNING: non observance may result in accident or injury.
ATTENTION: non observance may cause damage to the machine.
Information about the operation in progress.
OBSERVE: observation about the operation in progress.
c
hine malfunction and ask all the
•
rsonal experience and attendance at the training
dure so as to minimize the downtime necessary for procuring
• ns. In this regard it will
be useful to refer to the disassembly sequence described in this manual.
1.2. RECOMMENDATIONS
Te hnogym recommends the following steps for planning repair procedures:
Carefully evaluate the customer’s description of the mac•
necessary questions to clarify the symptoms of the problem.
Clearly diagnose the causes of the problem. This manual provides the fundamental theoretical
basis, which must then be integrated by pe
courses periodically offered by Technogym.
Rationally plan the repair proce•
spare parts, preparing tools, etc.
Access the component to be repaired, avoiding any unnecessary operatio
Page 1.1

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page 1.2
1.3. GENERAL RULES FOR REPAIR PROCEDURES
. Always mark any parts or positions which may be confused with each other at the time of
. Use special tools where specified.
4. hnical Newsletters, which may contain more up-to-date information on
adjustments and maintenance than those contained in this manual.
. Before starting the repair procedure, make sure that the recommended tools are available and in
g
6. For the procedures described in this manual, use only the specified tools.
1reassembly.
2. Use original Technogym spare parts and lubricants of the recommended brands.
3
Consult the Tec
5ood condition.
OBSERVE: The tool sizes quoted in this manual are expressed in mm.

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
2. TECHNICAL CHARACTERISTICS
2.1. PRODUCT CODES
The machine codes take into account all the possible variants and options available for the products.
The machine code, which does not include the Serial Number, consists of 16 alphanumeric
characters arranged as follows:
Characters description key to values
1,2,3 Machine type: Recline Excite D46 = Recline
D4B = Recline small
4 Product version
5= Recline 500
6= Recline 500i
7= Recline 700
8= Recline 700i
5 Type of power supply 3= multi-voltage (110-220)
4= self-powered
6 Type of display L = LED display
T = Wellness TV
E= Wellness TV Touch screen
7 Device for downloading data used by the Wellness
System N = not available
T = TGS
8, 9 Color of the frame AL = aluminum
10, 11 Color of paddings AG = gray
M0 = bordeaux
12 Guard color G= gray
13 Type of TV model
0= none
1= Pal B/G
2= Pal I
3= Pal N
4= NTSC M
5= Secam E/L
6= Secam D/K
7= NTSC M44
8= Pal D/K
9= Secam B/G
A= Secam K1
B= Pal M
Page 2.1

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page 2.2
Characters description key to values
14,15 Language
IT = Italian
DE = German
FR = French
US = American English
NL = Dutch
BR = Portuguese
JP = Japanese
UK = British English
ES = Spanish
16 Type of packaging
I = Italy
E = standard international
S = overseas international
0= none
For example, a possible product code would be:
D4683LTALM0G0UKE
which is interpreted as follows:
D46 8 3 L T AL M0 G 0 UK E
standard international packing
British English language
no TV model
gray guards
burgundy paddings
aluminum frame color
interfaced to TGS key reader
LED display
ma upply with multi-voltage inletins powered s
700i model
Re
cline Excite

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
2.2. AVAILABLE VERSIONS
There machine is available in 2 versions:
• Recline 500: mains operated machine;
• Recline 500SP: self-powered machine;
• Recline 700: mains operated machine;
• Recline 700SP: self-powered machine;
• Recline 700iE: mains operated machine with Wellness TV display;
• Recline 500i: mains operated machine, new model;
• Recline 500i SP: self-powered machine, new model;
• Recline 700i: mains operated machine, new model;
• Recline 700i SP: self-powered machine, new model;
• Recline 700iE Touch screen: mains operated machine with Wellness TV Touch screen display.
all of which have the same structure but are differentiated by certain characteristics.
CHARACTERISTIC
Display Handlebar SW version Wellness TV Effort
Level
500 – 500 SP Oval Rounded 3.XX.X NO 12
500i – 500i SP Rectangula
r Squared 4.XX.X NO 25
700 – 700 SP Oval Rounded
(Hand sensor) 4.YY.Y NO 12
700i – 700i SP Rectangula
r
Squared
(Hand sensor;
touch sensor) 5.YY.Y NO 25
700iE Rectangula
r Rounded (Hand sensor) 5.WW.W YES 12
VERSIONS
700iE Touch screen Rectangula
r
Squared
(Hand sensor;
touch sensor) 6.WW.W Touch Screen 25
This manual only the models 500i, 500i SP, 700i, 700i SP e 700iE touch screen will be
taken into consideration.
As regards the previous models, please refer to the Service and Maintenance Manual
version 1.x.
Page 2.3

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page 2.4
2.3. PRODUCT CHARACTERISTICS
VERSION
500I500I SP 700I – 700IE 700I SP
Power 30-500 Watt 40-500 Watt 30-500 Watt 40-500 Watt
Hand sensor NO YES
Touch sensor NO YES
CSafe YES YES
Cardio receiver HFU HFU
Training programs Quick start
Goal
CPR
Quick start
Goal
6 profiles
CPR
Training Zone
Weight Loss
Custom program
CHARACTERISTIC
Test functions Fitness test Fitness test
2.4. MECHANICAL CHARACTERISTICS
VERSION
500i SP – 700i SP 500i – 700i – 700iE
Width 57 cm - 22.4 in
Length 143 cm - 56.3 in
Height 138.5 cm - 54.5 in
Weight 88 Kg - 194 lbs 88 Kg - 194 lbs

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
2.5. ELECTRICAL CHARACTERISTICS
VERSION
500I700I - 700IE
Mains voltage 90 - 260 VAC
Frequency 50 - 60 Hz
Consumption 50 VA
Fuses F 3.15 A
2.6. AMBIENT SPECIFICATIONS
Operating from 5° to 35° C
Temperature Storage from -10° to 70° C
Operating from 30% to 80% non-
condensing
Humidity Storage from 5% to 85% non-condensing
2.7. CONFORMITY TO REGULATIONS
The machine conforms to the following standards:
Europe USA
EMI
EN 55014-1
EN 55014-2
EN 61000-3-2
EN 61000-3-3
Safety EN 60335-1
EN 957-1
EN 957-5 class SA
Directives 73/23/CEE
89/366/CEE
89/392/CEE
UL 1647
In addition:
• Electrical isolation class: Class I;
• Protection rating: IP21.
Page 2.5

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page 2.6
2.8. WIRING DIAGRAM
2.8.1. 500 MODEL
2.8.1.1. Powered version
DISPLAY
DISPLAY BOARD
CBQ-13
CBQ-32
KEYBOARD
CSAFE
BOARD
386 BOARD
HFU
RECEIVER
CN7
CN8
CN1
TGS
BOARD
CN1
CN9CN1
CN3
CN2
CBQ-28
BRAKE
POWER
ENTRY
MODULE
VAC BRAKE
BOARD
CN3
CN4CN1
CN2
SPEED
SENSOR
CB-0
Patch
conn.
CB-51
CB-4 CB-3

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
2.8.1.2. Cordless version
DISPLAY
DISPLAY BOARD
CBQ-13
CBQ-32
KEYBOARD
CSAFE
BOARD
386 BOARD
HFU
RECEIVER
CN7
CN8
CN1
TGS
BOARD
CN1
CN9CN1
CN3
CN2
BRAKE
BRAKE
BOARD
CN3
CN4CN1
CN2
SPEED
SENSOR
Patch
conn.
CB-51
CB-4 CB-3
BATTERY
ALTERNATOR
Patch
conn.
CB-52
BATTERY CHARGER
INPUT
CBQ-28
Page 2.7

RECLINE EXCITE: Service & Maintenance Manual - rev. 2.4
Page 2.8
2.8.2. 500 MODEL – ARM BOARD
2.8.2.1. Powered version
DISPLAY
DISPLAY BOARD ARM
CBQ-13
CBQ-32
KEYBOARD
CSAFE
BOARD
HFU
RECEIVER
CN7
CN8
CN1
TGS
READER
CN1
CN9CN1
CN3
CN2
CU83
BRAKE
POWER
ENTRY
MODULE
VAC BRAKE
BOARD
CN3
CN4CN1
CN2
SPEED
SENSOR
CB-0
Patch
conn.
CB-51
CB-4 CB-3