Volvo IL-VOL Instruction Manual

Courtesy of: DiscountCarStereo.com
Serving the internet community since 1995
IL-VOL
QUICK START INSTALLATION GUIDE FOR 1990-01 VOLVO CHANGER CONTROLLING RADIOS
Created March1, 2017
Revised: June 4, 2021

PRODUCT SAFETY & DISCLAIMER
READ ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING, FAILURE TO DO SO MAY CAUSE
PERSONAL INJURY OR DAMAGE TO PRODUCT AND/OR PROPERTY
•This installation guide is provided as a GENERAL installation guide, some vehicles vary and
may require additional steps. We do not accept responsibility for third party labor charges
or modifications. Exercise due-diligence when installing this product.
•We do not accept any responsibility for vehicle damage or personal injury resulting from
the installation of this product.
•Careless installation and operation can result in equipment damage.
Introduction:
Many Volvo Owners with older “SC”and “CT”radios are having a difficult time
finding an easy an effective way of connecting and listening to their Apple
Lightning device. Many are turned away, offered an FM Modulator recommend
replacing the radio, but if none of those options pique your interest we offer the
IL-VOL. The IL-VOL Adapter works in 1990-01 Volvo SC and CT Changer controlling
Radios and the only requirement is to disconnect the factory external CD
Changer* (if present), but with the storage capacity of most portable devices,
sacrificing the CD Changer should be an easy decision.
Installation:
Radio must be pulled from the dash to connect the adapter.
Although not critical, we recommend disconnecting car
battery. Keep in mind that most Volvo “SC” radios are
coded and will not operate without code. Radio code
must be available for radio to operate upon
reconnection.
1. To remove you must first push in on the release tabs at the bottom
Left/Right of Radio as seen in Fig. 1
Fig. 1
2. Once tabs come out, place index fingers inside release tab ring and pull
outward as seen in Fig. 2
Fig. 2
3. Connect 8-pin plug (See Fig. 3) from adapter harness to “CD” port on
radio (See. Fig. 4).
Factory CD changer (if present) must be disconnected.

Fig. 3
Fig. 4
Radio’s 8-pin CD port
4. Tap yellow wire from adapter to either GREEN/BROWN wire on radio
harness indicated by yellow arrows in Fig. 5
Fig. 5
Radio 14-pin plug
5. Run Lightning plug (See Fig. 6) to desired mounting location on
dashboard, glove box, console etc. (within 5 ft. of radio). Use caution
to not cut, pinch or crimp cable during this step.
Fig. 6
6. Securely install plug and cable in a location away from heat, humidity,
moving parts, or sharp metal objects. Damage to lightning plug may
occur if subject to abuse.
Test Operation:
1. Reconnect battery and enter radio code
2. Turn radio “ON”
3. Press “CHGR”button
4. Connect Apple device to lightning plug
5. Apple device should begin charging
6. Play test track. Track will play on car speakers.
7. Use radio volume control button to set the playback level.
Warning! Playlist and Track selection is *NOT* possible
from the Volvo radio. You must use the audio devices
built-in controls to access audio files.
8. If correct operation is confirmed go ahead and reinstall radio

Optional Smart Remote:
This wireless remote would let you pause, play, adjust volume, or otherwise
control your media from farther away than arm’s reach. Use at home to
control Bluetooth device from up to 30 ft.
1. Keep audio device in pocket, glovebox, purse or elsewhere
2. To track up/down within playlist etc.
3. To adjust audio device volume (up/down)
Pairing:
Operation:
Use smart remote to perform the following functions on any iOS7.0 and higher
or Android 4.4 and higher.
Package Contents:

Frequent asked questions
1. Does the IL-VOL work all Volvo radios?
NO;The IL-VOL works only on Volvo”SC”and” CT” radios with CD changer
controls such as the “SC-816”pictured below.
(Model number is printed on radio faces)
2. Can I use radio buttons to control Apple device?
NO; the IL-VOL is not able to control Apple Lightning device functions. You
must use the Apple device built-in controls to navigate its menus or optional
remote control
3. My vehicle has a factory CD changer in trunk/hatch. Will that continue
to play?
NO; the IL-VOL takes the place of the CD changer (changer must be
disconnected)
4. I’ve installed everything but my Phone does not charge and audio
plays on Phone speaker. Is the unit defective?
For Apple lighting devices to play or charge, power must be applied to
module. Please ensure you did not skip step 4 on page 3. Lastly, if your
adapter has a fuse holder, ensure fuse is not blown.
* External or remote CD changer refers to the optional changer installed under seat, hatch,
trunk etc. CD changer built-into the head unit (e.g., SC-901) is not affected
Email [e-mail]
1995-2021 Discount Car Stereo, Inc. All rights reserved. Information in this document is subject
to change without notice. Other products and companies referred to herein are trademarks or
registered trademarks of their respective companies or mark holders.