Volvo 31285564 User manual

Instruction No Version Part. No.
31285543 1.1 31285564
Mobility Connection Package
Instruction No Version Part. No.
31285543 1.1 31285564
Mobility Connection Package
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 1 / 84

Equipment
IMG-242205 A0000162 IMG-282403 IMG-240673 IMG-240675 IMG-239660
IMG-317443 IMG-317444 IMG-264163 IMG-239446 M0000232
IMG-317463
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 2 / 84

IMG-317464
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 3 / 84

IMG-317465
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 4 / 84

IMG-319004
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 5 / 84

IMG-213320
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 6 / 84

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
These installation instructions show installation on a left hand
drive car. For installation on a right hand drive car, perform the
steps on the opposite side and/or mirrored. Where the
operations differ, the right hand version is also shown with text
and image. When installing Velcro strips/tape, the surface
must be at a temperature of at least +20ºC (68º F).
Note!
Navigation system, portable: For information regarding the
GARMIN device, see www.garmin.com.
Note!
The disc marked A in the kit image is used on cars with
central loudspeaker grilles.
Note!
Bluetooth handsfree: This accessory requires software unique
to the car. There may be parts in the accessories kit that do
not need to be used for this installation. Keep the manual for
this accessory in a convenient place in the car.
Note!
USB/iPod Interface: This accessory requires software unique
to the car.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 7 / 84

1
IMG-296185
Note!
Take care when handling the components, they are fragile and
are easily damaged.
Take the three screws M5x25 part no. 986957 and nuts from the
kit.
To prevent excessive resistance when the nut for the holder is
tightened, hold the screw and screw the nut on and off the
threaded part of the screw. Carry this out on all screws and nuts.
2
IMG-282404
Take special tool 9814104 (torx driver, torx 6), and unscrew the
two screws holding the connector in the holder.
Carefully push the connector to one side with the cable to
expose the bottom of the holder.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 8 / 84

3
IMG-282405
Take the kit with the four spacers from the installation kit.
Applies to left and right hand drive cars without centre
loudspeaker grille
Carefully pry off the spacer using P/N 31212788. The part
number (1) is on the bottom of the spacer.
Applies to left hand drive cars with centre loudspeaker grille
Carefully pry off the spacer using P/N 31212534. The part
number (1) is on the bottom of the spacer.
Applies to right-hand drive cars with centre loudspeaker grille
Carefully pry off the spacer using P/N 31212787. The part
number (1) is on the bottom of the spacer.
4
IMG-282407
Take the three screws and insert them in the spacer fully.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 9 / 84

5
IMG-282408
Apply pieces of butyl tape to the screws so that the screw heads
do not protrude outside the spacer when installing it.
6
IMG-282406
Install the spacer in the bottom of the holder.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 10 / 84

7
IMG-282409
Ensure that the holder's two screw turrets align between the
small pins in the oblong holes in the spacer. A click should be
heard when the spacer is securely in position.
8
IMG-282410
Place the connector in the bottom of the hole. The guide hole (1)
in the connector's circuit board must align in the corresponding
pin at the bottom of the holder and the holes (2) in the circuit
board must be over the holder's screw turret.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 11 / 84

9
IMG-282411
Take the small torx screws and carefully tighten the connector to
the holder. Ensure that the connector's circuit board is properly
against the screw turret and that there is no play.
Remove the butyl tape from the screws.
10
IMG-245980
Turn the ignition key to position 0.
Note!
Wait at least three minutes before unplugging the connectors
or removing other electrical equipment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 12 / 84

11
IMG-279845
Sections 11-15 apply to cars without centre loudspeaker grilles
Take the template from the kit and cut along the outer lines
LHD/RHD
12
IMG-279846
Note!
It is important to carefully measure for the location of the
template. Incorrect positioning of the hole group can cause
problems in tightening the holder.
Apply a piece of tape on the dashboard between the LED and
button for the hazard warning lights, centered in the middle of
these.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 13 / 84

13
IMG-279848
Mark out the middle of the piece of tape in two places as
illustrated, and draw a line between these marks.
14
IMG-279854
Measure a distance of 82 mm (3¼") from the joint between the
dashboard and grille and rearwards on the dashboard.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 14 / 84

15
IMG-279857
Take the template and position the arrow point by the marking
for 82 mm (3¼"). Position the template so that the central line
follows the line on the piece of tape.
Tape the template to the dashboard.
16
IMG-239420
Applies to all models
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 15 / 84

17
IMG-237462
18
IMG-237463
Prize away the holder for the switch at the lower edge.
Then prize at the upper edge while coaxing and pulling it out.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 16 / 84

19
IMG-237478
Unplug the connector.
20
IMG-237479
Remove the screw.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 17 / 84

21A
IMG-237481
21B
IMG-296551
Illustrations A and B
Locate the holes. Pull the panel with air vents straight out.
Use special tool 9512943.
22
IMG-222268
Remove the bolts of the panel underneath the glovebox and
remove it.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 18 / 84

23
IMG-225205
Remove the two screws.
24
IMG-225201
Remove the six screws.
Pull out the glove box in one piece.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 19 / 84

25
IMG-279924
Disconnect the connector at the rear edge.
26
IMG-279925
Remove the connectors on top and disconnect them.
Remove the glovebox.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Mobility Connection Package- 31285543 - V1.1
Page 20 / 84