Volvo 31316789 User manual

Instruction No Version Part. No.
31316791 1.0 31316789
Satellite radio, Sirius
IMG-337360
Instruction No Version Part. No.
31316791 1.0 31316789
Satellite radio, Sirius
IMG-337360
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 1 / 34

Equipment
IMG-242205 A0000162 IMG-239664 IMG-337357 IMG-337356 IMG-337358
IMG-333288 IMG-332314 IMG-336909
IMG-337606
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 2 / 34

IMG-337605
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 3 / 34

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
Do not do the work at a temperature below 20°C (68° F).
Leave the vehicle indoors for 2 hours after finishing the work.
Do not wash the car for 72 hours.
There may be components in the accessories kit that are not
used for this installation.
1
IMG-245980
Installation, antenna
Set the ignition key to position 0.
Note!
Wait at least three minutes before unplugging the connectors
or removing other electrical equipment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 4 / 34

2
J8504579
Remove the rear roof panel by pulling it downwards. It is
secured by nine clips on the inside.
Unplug the interior lighting connector and move the panel aside.
3
J8504575
Remove the cargo compartment carpet.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 5 / 34

4
IMG-240926
Use a weatherstrip tool and pry up one corner of the sill trim
panel so that the two clips on the short side release.
Pull up the sill trim panel so the remaining six clips release.
Remove the panel.
Detach the rubber strip where it covers the left and right-hand
side panel in the tailgate opening.
5
IMG-275653
Remove the rubber strip at the left and right-hand D-post panel.
Disconnect the right side panel at the rear edge to expose the D-
post panel's lower end.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 6 / 34

6
IMG-275654
Remove the right-hand D-post panel by first disconnecting it
from the body, it is secured by four clips. Unhook it at the upper
edge from the headlining.
7
J8504586
Fold both rear seat backrests forward.
Remove the side cushion on both sides by pulling it forwards at
the upper edge until the clip on the rear releases, and then by
pulling it straight up.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 7 / 34

8
IMG-240927
Remove the screw.
Pull the panel upwards so that the four clips on the inside
release. Remove the panel.
Repeat the operation on the other side.
9
J8704087
Pry off the cover that holds the C-post panel at the upper edge
and remove the screw underneath.
Remove the rubber strip at the rear edge on the rear door.
Repeat the operation on the other side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 8 / 34

10
IMG-275655
Pull off both C-post panels.
Remove the upper C-post panel from the side panel's cover and
the lower C-post panel, it is secured by two clips.
Note!
Do not damage the roof panel.
Repeat the operation on the other side.
11
J8504624
Fold out the load securing eyelets on the left-hand side panel.
Insert a scriber with an angled tip into the holes in the top of the
covers (1). Turn the scriber so that the tip engages the reverse
of the cover. Pull the covers off.
Remove the screws in the load securing eyelets.
Remove the screw (2).
Pull off the side panels at the top so that the two clips at the
rear/bottom of the side window and the clip at the bottom of the
D-post release.
Lift out the side panel.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 9 / 34

12
J8504786
Remove the D-post panel on the left-hand side by first
disconnecting it from the body, it is secured by four clips.
Unhook it at the upper edge from the headlining.
13
J8504990
Fold down the grab handle above the rear doors on both sides,
pry up the covers and remove the screws underneath. Remove
the handle.
Repeat the operation on the other side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Satellite radio, Sirius- 31316791 - V1.0
Page 10 / 34