Advantech TREK-510 User manual

TREK‐510Usermanual1








UserManual

TREK‐510
 
In‐VehicleComputingBox
SmartDisplay
Usermanual




TREK‐510Usermanual2
Copyright

Thedocumentationandthesoftware  includedwiththis  product  are  copyrighted  2010by
AdvantechCo.,Ltd.Allrights
 arereserved.AdvantechCo.,  Ltd.reservesthe  righttomake
improvements
 intheproductsdescribed  inthis  manualat  anytimewithoutnotice.No  part 
ofthismanualmay  be  reproduced,copied,translated  or  transmittedinanyform  orby  any
meanswithoutthe
 priorwrittenpermissionofAdvantechCo.,Ltd.Informationprovided  in
this
 manualisintendedtobeaccurateand  reliable.How‐ever,AdvantechCo.,Ltd.assumesno
responsibilityforitsuse,norforanyinfringementsoftherightsofthirdparties,whichmay
resultfromitsuse.



Acknowledgements
IntelandAtomaretrademarksofIntelCorporation.MicrosoftWindows  andMS‐DOSare
registeredtrademarksofMicrosoftCorp.Allotherproductnamesortrademarksare

propertiesoftheirrespectiveowners. 


ProductWarranty(2years)

Advantechwarrantstoyou,theoriginalpurchaser,thateachofits  productswillbefreefrom
defectsinmaterialsandworkmanshipfortwoyearsfromthedateofpurchase.

This  warrantydoesnotapplyto  any  products  which  havebeenrepaired  oralteredbypersons
otherthanrepair
 personnelauthorizedbyAdvantech,orwhich  havebeensubject  tomisuse, 
abuse,  accidentor  improperinstallation.Advantechassumesnoliabilityunderthetermsof
thiswarrantyasaconsequenceofsuchevents.

Becauseof  Advantech’s  highquality‐controlstandardsandrigoroustesting,mostofour
customersneverneedtouse
 ourrepairservice.If  anAdvantech  productisdefective,itwillbe
repairedorreplacedatnochargeduringthewarrantyperiod.Forout‐ of‐warranty
 repairs,
youwill
 bebilledaccording  tothecost  ofreplacementmaterials,servicetime  andfreight. 
Pleaseconsultyourdealerformoredetails. 
Ifyouthinkyouhaveadefectiveproduct,followthesesteps: 
1.  Collectallthe  informationabouttheproblemencountered.(Forexample,CPUspeed,
Advantechproductsused,otherhardwareandsoftwareused,
 etc.)Noteanything
abnormalandlistanyonscreenmessagesyougetwhentheproblemoccurs.

2.  Callyourdealeranddescribethe  problem.Please  have  yourmanual,product,andany
helpfulinformationreadily
 available. 
3.  Ifyourproductisdiagnosedasdefective,obtainanRMA(returnmerchandise
authorization)numberfrom
 yourdealer.Thisallowsusto  process  your  returnmore
quickly.

4.  Carefullypack  thedefectiveproduct,afully‐completedRepairand  ReplacementOrder
Card
 and  a  photocopyproofof  purchasedate(such  as  yoursalesreceipt)inashippable
container.Aproductreturned
 without  proofofthepurchasedateisnoteligiblefor
warrantyservice.

5.  Write  theRMA  number  visiblyontheoutsideofthe  package  andshipitprepaidtoyour
dealer.






PartNo.2010051001  Edition1 

Printedin  Ta i w a n  Jan2011 



TREK‐510Usermanual3
DeclarationofConformity

Thisproduct  has  passedtheCEtestfor  environmentalspecifications.Te s t conditionsfor
passingincluded
 the  equipmentbeing  operatedwithinanindustrialenclosure.  Inorderto
protecttheproductfrombeingdamagedbyESD
 (ElectrostaticDischarge)andEMIleakage, 
westrongly  recommend  theuseofCE‐compliantindustrialenclosureproducts. 


FCCClassB 

Note:This  equipmenthasbeentestedandfoundtocomplywiththelimitsforaClassB  digital
device,pursuanttopart15of
 theFCCRules.Theselimitsaredesignedtoprovidereasonable
protectionagainstharmfulinterferenceinaresidentialinstallation.Thisequipment
generatesuses
 andcanradiateradiofrequencyenergyand,ifnotinstalled  andused  in 
accordancewiththeinstructions,may  causeharmfulinterferencetoradio  communications.
However,thereisnoguaranteethatinterferencewillnotoccurina
 particular  installation.If 
thisequipment  doescauseharmfulinterferencetoradioortelevisionreception,whichcanbe
determinedbyturningtheequipmentoff
 andon,theuserisencouragedtotrytocorrect
theinterferencebyoneormoreofthe
 followingmeasures: 
z
Reorientorrelocatethereceivingantenna. 
z
Increasetheseparationbetweenthe  equipmentandreceiver. 
z
Connect  the  equipmentintoan  outletona  circuitdifferentfromthattowhichthe
receiverisconnected.

z
Consultthedealeroranexperienced  radio/TVtechnicianforhelp. 


TechnicalSupportandAssistance

1.  VisittheAdvantechwebsiteat www.advantech.com/support  forthelatest
informationabouttheproduct.

2.  Contactthedistributor,  salesrepresentative,orAdvantech'scustomerservicecenter
for
 technicalsupport  ifyouneed  additionalassistance.Pleasehavethefollowing
informationreadybeforeyoucall:

–  Productnameandserialnumber 
–  Descriptionofyour  peripheral  attachments 
–  Descriptionofyoursoftware(operating  system,version,applicationsoftware,etc.) 
–  Acompletedescriptionoftheproblem 
–  Theexactwordingofanyerrormessages 
























TREK‐510Usermanual4

Warnings,CautionsandNotes


Warning!  Warningsindicateconditions,which  if  not  observed,cancausepersonal

Caution!  Cautionsareincludedtohelpyouavoiddamaginghardwareorlosingdata.
e.g.


Note!  Notesprovideoptionaladditional  information. 



DocumentFeedback

To  assistusinmaking  improvements  tothis  manual,  wewouldwelcomecommentsand
constructivecriticism.Sendall
 suchinwritingto:[e-mail] 


PackingList

Beforesettingup,checkthattheitems  listed  belowareincluded,in  goodcondition.Ifanyitem
doesnotaccord
 withthetable,pleasecontactyourdealer  immediately. 

z TREK‐510series  In‐VehicleComputingBox 
z
USB/AudioCableclip 
z
Warrantycard 
z Powercord:DCpowerinletcable  (180cm‐forTREK‐510only)
z“ Drivers,UtilitiesandUserManual"CD‐ROM 
z
EndUserLicenseAgreement(WinCEmodel),pleasedownloaddriverandrelated
documentfromwww.advantech.com/support 


Orderinginformation

P/NDescription
TREK‐510‐GCEA0EST2062333Mhz,GPS,GPRSmodulebuiltin,WinCE5.0
TREK‐303R‐LA0E7"vehicledisplaysystem,480x234resolution,with4wireresistivetouch
screen,2‐wattsspeaker.
17000183422‐metercable(pairedwithTREK‐510)

Packinglist
Item
Powercablex1Screwx4
GPSantennax1CableclipforMICin,lineout,USBhost,USBclientx4
WWANantennax1StartupmanualCDx1





TREK‐510Usermanual5
SafetyInstructions
1. Readthesesafetyinstructionscarefully.
2. Keepthisusermanualforlaterreference.
3. DisconnectthisequipmentfromACoutletbeforecleaning.Donotuseliquidorspraydetergents
forcleaning.
4. Forpluggableequipment,thepoweroutletshallbeinstalledneartheequipmentandshallbe
easilyaccessible.
5. Keepthisequipmentawayfromhumidity.
6. Putthisequipmentonareliablesurfaceduringinstallation.Droppingitorlettingitfallcould
causedamage.
7. Donotleavethisequipmentinanenvironmentunconditionedwherethestoragetemperature
under‐30°C(‐22°F)orabove70°C(158°F),itmaydamagetheequipment.
Operatingtemperature:50°C.SafetyCertificateTemperature:50°C
8. Theopeningsontheenclosureareforairconvectionhenceprotectstheequipmentfrom
overheating.DONOTCOVERTHEOPENINGS.
9. Makesurethevoltageofthepowersourceiscorrectbeforeconnectingtheequipmenttothe
poweroutlet.
10. Placethepowercordsuchawaythatpeoplecannotsteponit.Donotplaceanythingoverthe
powercord.Thevoltageandcurrentratingofthecordshouldbegreaterthanthevoltageand
currentratingmarkedontheproduct.
11. Allcautionsandwarningsontheequipmentshouldbenoted.
12. Iftheequipmentisnotusedforlongtime,disconnectitfromthepowersourcetoavoidbeing
damagedbytransientover‐voltage.
13. Neverpouranyliquidintoventilationopenings.Thiscouldcausefireorelectricalshock.
14. Neveropentheequipment.Forsafetyreasons,theequipmentshouldbeopenedonlyby
qualifiedservicepersonnel.
15. Ifanyofthefollowingsituationsarises,gettheequipmentcheckedbyservicepersonnel:
a. Thepowercordorplugisdamaged.
b. Liquidhaspenetratedintotheequipment.
c. Theequipmenthasbeenexposedtomoisture.
d. Theequipmentdoesnotworkwelloryoucannotgetittoworkaccordingtousermanual.
e. Theequipmenthasbeendroppedanddamaged.
f. Theequipmenthasobvioussignsofbreakage.

16. CAUTION:Thecomputerisprovidedwithabattery‐poweredreal‐timeclockcircuit.Thereisa
dangerofexplosionifbatteryisincorrectlyreplaced.Replaceonlywithsameorequivalenttype
recommendedbythemanufacture.Discardusedbatteriesaccordingtothemanufacturer’s
instructions.

17. THECOMPUTERISPROVIDEDWITHCDDRIVESCOMPLYWITHAPPROPRIATESAFETYSTANDARDS
INCLUDINGIEC60825.








CLASS 1 LASER PRODUCT
KLASSE 1 LASER PRODUKT

TREK‐510Usermanual6

18.ThisdevicecomplieswithPart15oftheFCCrules.Operationissubjecttothefollowingtwo
conditions:
(1)thisdevicemaynotcauseharmfulinterference,and
(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethatmaycause
undesiredoperation.
19.CAUTION:Alwayscompletelydisconnectthepowercordfromyourchassiswheneveryouwork
withthehardware.Donotmakeconnectionswhilethepowerison.Sensitiveelectronic
componentscanbedamagedbysuddenpowersurges.
20.CAUTION:Alwaysgroundyourselftoremoveanystaticchargebeforetouchingthemotherboard,
backplane,oradd‐oncards.Modernelectronicdevicesareverysensitivetostaticelectric
charges.Asasafetyprecaution,useagroundingwriststrapatalltimes.Placeallelectronic
componentsonastatic‐dissipativesurfaceorinastatic‐shieldedbagwhentheyarenotinthe
chassis.
21.CAUTION:Anyunverifiedcomponentcouldcauseunexpecteddamage.Toensurethecorrect
installation,pleasealwaysusethecomponents(ex.screws)providedwiththeaccessorybox.
22.Cautiontextconcerninglithiumbatteries:








23"RackMountInstructions‐Thefollowingorsimilarrack‐mountinstructionsareincludedwiththe
installationinstructions:

A) ElevatedOperatingAmbient‐Ifinstalledinaclosedormulti‐unitrackassembly,theoperating
ambienttemperatureoftherackenvironmentmaybegreaterthanroomambient.Therefore,
considerationshouldbegiventoinstallingtheequipmentinanenvironmentcompatiblewiththe
maximumambienttemperature(Tma)specifiedbythemanufacturer.
B) ReducedAirFlow‐Installationoftheequipmentinarackshouldbesuchthattheamountofair
flowrequiredforsafeoperationoftheequipmentisnotcompromised.
C) MechanicalLoading‐Mountingoftheequipmentintherackshouldbesuchthatahazardous
conditionisnotachievedduetounevenmechanicalloading.
D) CircuitOverloading‐Considerationshouldbegiventotheconnectionoftheequipmenttothe
supplycircuitandtheeffectthatoverloadingofthecircuitsmighthaveonovercurrentprotection
andsupplywiring.Appropriateconsiderationofequipmentnameplateratingsshouldbeused
whenaddressingthisconcern.
E) ReliableEarthing‐Reliableearthingofrack‐mountedequipmentshouldbemaintained.Particular
attentionshouldbegiventosupplyconnectionsotherthandirectconnectionstothebranch
circuit(e.g.useofpowerstrips)."
24.CAUTION:
1.Thisproductisconnectedtoafuseboxinthepassengercompartmentbeforeitconnectedto
thevehiclebattery,andthefuseinafuseboxisULlistedandautomotivefuse.
2.UsetheappropriateflexibleandSAEwiringtoconnecttoafusebox.
*Thisproductisinstalledinthepassengercompartment.
3.Thisproductmustbeinstalledandmaintainedbyqualifiedservicepersonnel.
4.ThisdevicecomplieswithPart15oftheFCCrules.Operationissubjecttothefollowingtwo
conditions:(1)Thisdevicemaynotcauseharmfulinterference,and
(2)Thisdevicemustacceptanyinterferencereceived,including
interferencethatmaycauseundesiredoperation.
ADVARSEL!
Lithiumbatteri - Eksplosionsfare ved fejlagtig
håndtering.
Udskiftning må kun ske med batteri af samme

TREK‐510Usermanual7
















WichtigeSicherheishinweise

1.  BittelesensieSichdieseHinweise  sorgfältigdurch. 
2.  HebenSiedieseAnleitungfürdenspäterenGebrauch  auf. 
3.  VorjedemReinigenistdasGerätvomStromnetzzutrennen.Ver w e nd e n SieKeine
Flüssig‐oderAerosolreiniger.AmbestendienteinangefeuchtetesTuc hzurReinigung.

4.  DieNetzanschluBsteckdosesollnahedemGerätangebrachtundleicht
zugänglichsein.

5.  DasGerätistvorFeuchtigkeitzu  schützen. 
6.  BeiderAufstellungdesGerätesistaufsicherenStandzuachten.EinKippenoder
FallenkönnteVe rletzu nge n hervorrufen.

7.  DieBelüftungsöffnungendienen  zurLuftzirkulationdiedasGerätvorüberhit‐zung
schützt.SorgenSiedafür,daBdieseÖffnungennichtabgedecktwerden.

8.  BeachtenSiebeim.AnschluBan  dasStromnetzdieAnschluBwerte. 
9.  VerlegenSiedieNetzanschluBleitungso,daBniemanddarüberfallenkann.Essollteauch
nichtsaufderLeitungabgestelltwerden.

10.  AlleHinweiseundWarnungendie  sichamGerätenbefindensindzubeachten. 
11.  WirddasGerätübereinenlängerenZeitraum  nichtbenutzt,solltenSieesvom
Stromnetztrennen.SomitwirdimFalleeinerÜberspannungeineBeschädigung
vermieden.

12.  Durchdie  Lüftungsöffnungendürfenniemals  GegenständeoderFlüssigkeiten  indasGerät 
gelangen.DieskönnteeinenBrandbzw.elektrischenSchlagaus‐lösen. 
13.  ÖffnenSieniemalsdasGerät.DasGerätdarfausGründenderelektrischen 
SicherheitnurvonauthorisiertemServicepersonalgeöffnetwerden. 
14.  WennfolgendeSituationenauftretenistdasGerätvomStromnetzzu  trennenundvon
einerqualifiziertenServicestellezuüberprüfen:

15.  NetzkabeloderNetzsteckersindbeschädigt. 
16.  FlüssigkeitistindasGeräteingedrungen. 
17.  DasGerätwarFeuchtigkeitausgesetzt. 
18.  Wenndas  Gerätnichtder  Bedienungsanleitung  entsprechendfunktioniertoder 
SiemitHilfedieserAnleitungkeine  Verbesserungerzielen. 
19.  DasGerätistgefallenund/oderdasGehäuseistbeschädigt. 
20.  Wenndas  GerätdeutlicheAnzeicheneines  Defektesaufweist. 
21.  VOSICHT:Explisionsgefahrbei  unsachgemaben  AustauschderBatterie.Ersatznurdurch
densellbenordereinemvom
 Herstellerempfohlene‐mahnlichenTyp. Entsorgung
gebrauchterBatteriennavhAngabendesHerstellers.

22.  ACHTUNG:EsbestehtdieExplosionsgefahr,fallsdieBatterieaufnichtfach‐männische 
Weisegewechseltwird.  Ve r f a n ge n SiedieBatterie  nurgleicher  oderentsprechender
Typ e, wie
 vomHerstellerempfohlen.EntsorgenSieBatteriennachAnweisungdes

TREK‐510Usermanual8
Herstellers. 
23.  DerarbeitsplatzbezogeneSchalldruckpegelnachDIN  45635Te i l 1000beträgt 
70dB(A)oderweiger. 
Haftungsausschluss:  DieBedienungsanleitungen  wurdenentsprechend  der  IEC‐704‐1 
erstellt.  Advantech  lehnt  jegliche  Veran two r tun g  für  die  Richtigkeit  der  in
diesemZusammenhanggetätigtenAussagenab. 





SafetyPrecaution‐StaticElectricity

Followthesesimpleprecautionstoprotect  yourself  fromharmandtheproductsfrom
damage.

z
To avoidelectricalshock,alwaysdisconnectthepowerfrom  yourPCchassisbefore
youworkonit.Don'ttouchany
 componentsontheCPUcardorothercardswhilethe
PCison.

z
Disconnectpowerbeforemakinganyconfigurationchanges.Thesuddenrushofpower
asyouconnectajumperorinstall
 acardmaydamagesensitiveelectroniccomponents. 


Warning!  1.  Inputvoltagerated:6‐36Vdc . 
2.  Tra n s p o r t : carry  theunitwith  bothhandsandhandlewithcare . 
3.  Maintenance:  to  properlymaintainandclean  the  surfaces,useonly
approvedproductsor
 cleanwith  adryapplicator . 
4.  CompactFlash:  Tu r n offthepowerbeforeinsertingorremoving 
CompactFlashstoragecards . 




EuropeanContactinformation:
AdvantechEuropeGmbHKolberger
Straße7


D‐40599Düsseldorf,Germany 

Te l : 49‐211‐97477350 
Fax:49‐211‐97477300 























TREK‐510Usermanual9












Contents 

Chapter1GeneralInformation............................12

1.1  Introduction  ...............................................................................................  12 
1.2  GeneralSpecifications  ...............................................................................  13 
1.3  Dimensions  ................................................................................................  14 
Figure1.1  TREK‐510dimensions............................................ 1 4 


Chapter2SystemSetup.......................................15

2.1  AQuickTouroftheVehicle  Mounted  ............................................................ 1 6 
Figure2.1  Frontview  ofthe  TREK‐510  ....................................... 1 6 
Figure2.2  RearsideoftheTREK‐510  .......................................... 1 6 
Figure2.3  SideviewoftheTREK‐510  .......................................... 1 6 
Figure2.4  Bottom viewoftheTREK‐510  ................................... 1 7
Figure2.5
 Top viewoftheTREK‐510  .......................................... 1 7 
2.2  InstallationProcedures.................................................................................... 1 7 
2.2.1  Connecting  thePowerCord  .............................................................. 1 7 
Table  2.2.1:  PinDefinition  ofPowerCord  ................................... 1 7 
2.2.2 Powerc onnector…………………..  ...........................................................18
Figure2.6
 Powerconnectoroutlook ................................... 1 8 
Table  2.2.2:  PinDefinition  ofPowerconnector.......................... 1 8 
Figure2.7  Powerconnectorphoto ...................................... 1 9
2.3
 RunningtheBIOS  SetupProgram  ............................................................... …….. 19 
2.4  InstallingSystemSoftware  ...............................................................................  19 
2.5  InstallingtheDrivers.....................................................................................  19 
2.6  ProgrammingFunction  Keys  andGPIO/CANBUS  .......................................  19 


Chapter3Hardware&PeripheralInstallation……20

3.1  OverviewofHardware  Installation  &Upgrading  .....................................  21 
3.2  InstallingtheStorageDeviceandMemory  .............................................  21 
3.3  InstallingOptionalAccessories  ..................................................................  21 
3.3.1  InstallingTREK‐510peripheralmodules.......................................  21 
Figure3.1  Installperipheralinthesystem............................... … 21 
3.3.2  InstallingtheMiniPCI  typeWWAN,SIMcard&coinbattery......  22 
Figure3.2  MiniPCI  typeWWAN,SIMcard&coinbatteryfrombottom
view…………………………………………………………....
………………………………22
3.3.4  InstallingCFcard……………..........................................................  22 
Figure3.4  InstallingCFcard…..  .................................................  23 
Figure  3.5  Installingcablelock…..  .............................................  23 
3.3.5  GPSmoduleisunabletobeinstalledbycustomer.......................  23 
3.4  PairedwithTREK‐303specification…......................................................  23 




TREK‐510Usermanual10


TREK‐510Usermanual11
Chapter4JumperSettingsandConnectors.....24

4.1  SettingJumpersandSwitches................................................................ …. 25 
4.1.1LocationsoftheJumpersandconnector.................................. …. 26 
Figure4.1Locationsofjumpersandconnectorsontopsidethe
motherboard………………………………………………………………………….…26
Figure4.2Locationsofjumpersandconnectorsonbottomsideofthe
motherboard……………………………………………………...……………………26

Figure4.3Locationsofjumpersandconnectorsonbottomsideofthe
daughterboard……………………………………………………27 
4.1.2  Jumpers………………………………………………………………27
Ta b l e 4.1.2.1:Jumpersonmotherboard ................................... … 27 
Ta b l e 4.1.2.2:Jumpersondaughterboard
................................ .. 27 
4.1.3  Connectors....................................................................................  28 
Ta b l e 4.1.3.1:Connectorsonmotherboard
.................................  28 
Ta b l e 4.1.3.2:Connectorsondaughterboard ..............................  28 

 4.2JumperSettings……………………………………………………………….29
4.2.1  CMOSClearforExternalRTC(JP2)………………………………29 
Ta b l e 4.2.1:ClearCMOS/ExternalRTC(JP1)…………………..29
4.2.2  PowerInputVoltageSetting(JP1)…………………………………29 
Ta b l e 4.2.2:PowerInputVoltageSelection(JP1)………………..29
4.2.3Pin9ofCOM3FunctionSelection(JP3)…………………………29
Table4.2.3:Pin9ofCOM3FunctionSelection(JP3)……………29
4.2.4
 Pin9ofCOM8FunctionSelection(J3)……………………………29 
 Table4.2.4:Pin9ofCOM8FunctionSelection(J3)……………..29

  4.2.5
 DI/GPSFunctionSelection(SW2)………………………………..30 
Table4.2.5:Pin9o22fCOM8FunctionSelection(J3)…………30
4.3 COMPortInterface………………………………………………………………30
Table4.7:SerialPortFunction…………………………………….30
Ta b l e 4.7:SerialPortSettings…………………………………….30

Chapter5PinAssignments...............................31

5.1 FrontSideconnectors…………………………………………………………..32
5.2 RearSideConnectors………………………………………………………….32
5.3 PowerConnector(12/24V;6~36V)…………………………………………..32
Ta b l e 5.3:Powerconnector………………………………………..32
5.4 SmartDisplayConnector…………………………………………………………33
Ta b l e 5.4:Smartdisplayconnector………………………………..33
5.5 RS‐232Connector(COM3,COM8)……………………………………………..34
Ta b l e 5.5:RS232/485/J1708connector……………………………34
5.6  RS‐232(COM9)/RS‐485(COM5)/J1708(COM6)Connector………34
Ta b l e 5.6:RS232/485/J1708connector……………………….…..34
5.7 DI/DOConnector…………………………………………………………………35
Ta b l e 5.7:DI/DOconnector………………………………………….35
5.8 CAN/VideoinConnector…………………………………………………………35
Ta b l e 5.8:CAN/Videoinconnector………………………………...35
5.9LEDConnector………………………………………………………
…………… 36
Ta b l e 5.9:LEDconnector…………………………………………….36


Chapter6SWfunctionality...............37

6.1 Introduction …………………………………………………………………………38 

TREK‐510Usermanual12
6.1.1  ExecuteJ1939demoutility……………………………………………………………………….….38 
Figure6.1IMCdemoutility
……………………………………………..………38 
Figure6.2J1939trucksimulator
………………………………38 
Figure6.3J1939test
………………………………………………………….…39 
Figure6.4J1939test
……………………………………………………..……39 
6.1.2  CANTest…………………………………………………………………………..…………………………39 
Figure6.9CANtest‐2
………………………………………………………………39 
6.2   RTCtest………………………………………………………………….……………………………………40 
Figure6.10RTCtest‐1
………………………………………………………………40 
Figure6.11RTCtest‐2
…………………………………………………..……………40 
Figure6.12RTCtest‐3
………………………………………………………………40 
Figure6.13RTCtest‐4
…………………………………………………….…………40 
Figure6.14RTCtest‐5
…………………………………………………………….…41 
  6.3  PowerManagement………………………………………………………………………………….…..41
6.3.1PowermanagementMechanism………………………………….……………..42

6.3.2 PowerManagementutilityprogram…………………………………………….43 
6.3.3  PowerManagementParametersettings………………………..…………….43
Figure6.15Powermanagementtestutility …………………………………43 
6.3.4TREK‐510powerconsumption……………………………………………………….43 
6.4  GPIOTest…………………………………………………………………………………….…44
Figure6.16DI/Otest …………………………………………………………………….44 
Figure6.17Digitalin
……………………………………………………………………..…44 
Figure6.18Digitalout
……………………………………………………………………45 
6.7  G‐sensor………………………………………………….………………………………………..46

Chapter7SWdemoutilitysetUp...............37

6.1 Introduction …………………………………………………………………………38 
6.1.1  ExecuteJ1939demoutility……………………………………………………………………….….38 
Figure6.1IMCdemoutility
……………………………………………..………38 
Figure6.2J1939trucksimulator
………………………………38 
Figure6.3J1939test
………………………………………………………….…39 
Figure6.4J1939test
……………………………………………………..……39 
6.1.2  CANTest…………………………………………………………………………..…………………………39 
Figure6.9CANtest‐2
………………………………………………………………39 
6.2   RTCtest………………………………………………………………….……………………………………40 
Figure6.10RTCtest‐1
………………………………………………………………40 
Figure6.11RTCtest‐2
…………………………………………………..……………40 
Figure6.12RTCtest‐3
………………………………………………………………40 
Figure6.13RTCtest‐4
…………………………………………………….…………40 
Figure6.14RTCtest‐5
…………………………………………………………….…41 
  6.3  PowerManagement………………………………………………………………………………….…..41
6.3.1PowermanagementMechanism………………………………….……………..42

6.3.2 PowerManagementutilityprogram…………………………………………….43 
6.3.3  PowerManagementParametersettings………………………..…………….43
Figure6.15Powermanagementtestutility …………………………………43 
6.3.4TREK‐510powerconsumption……………………………………………………….43 
6.4  GPIOTest…………………………………………………………………………………….…44
Figure6.16DI/Otest …………………………………………………………………….44 
Figure6.17Digitalin
……………………………………………………………………..…44 
Figure6.18Digitalout
……………………………………………………………………45 
6.7  G‐sensor………………………………………………….………………………………………..46






TREK‐510Usermanual13
AppendixAPairedwithTREK‐303............................47

A.1  TableA.1:TREK‐303spec  .............................................................................. 48
A.2 Ta b l e A.2SmartDisplayconnectorpinout ....................................................  49 
FigureA.1Hotkeyutility………………………………………………………….…..51




AppendixBWinCE5.0compatiblelist......................47

A.1  TableA.1:WinCE5.0compatiblelist............................................................. 48






















TREK‐510Usermanual14

























Chapter 1




1  GeneralInformation
Thischaptergivesbackground
informationontheTREK‐510
In‐VehicleComputingBox.


Sectionsinclude:

zIntroduction
zGeneralSpecifications
zDimensions

TREK‐510Usermanual12

1.1Introduction

TheTREK‐510TheTREK‐510isadedicatedboxcomputerforindustrialvehiclefleets,transporttrucks,
busesandtaxis.TREK‐510combinedwithavarietyofI/Oconnectorscanbeconnectedtodeviceslike
OBD‐IIorTPMS(TirePressureMonitoringSystem).Built‐inwirelesscommunications‐WWANenables
TREK‐510tosendimportantdriver/vehicle/location/carinformationbacktothecontrolcenter.
TREK‐510canalsooperateinextremeenvironmentswithfeatureslikeawideworkingtemperature
range(‐30to70degrees)andanti‐shock/vibrationdesign.TREK‐510alsousesaspecialdesignto
handlethecriticalissueofin‐vehiclepower.Specialpowerprotection(ISO7637‐2/SAEJ1455ClassA/
SAEJ1113)andcarpowermanagementsoftware(Ignitionon/off,delayon/off,lowbatterymonitor)
preventelectricalnoiseandsurgesfromimpactingthesystem,guardingagainstdamagefrom
transientcarpower.

I/OConnectors






1.2GeneralSpecifications

Keyfeatures
zSTARMbasedSTA2062333MHzCPUwithWinCE5.0
zAutomotivegradeworkingtemperaturerange(‐30°Cto70°C)
zRichI/OincludingCAN,multi‐COMs,isolation4DI/4DO,Lineout,Micin,USBandSD.
zBuilt‐inRFcommunicationmodules,includingGSM/GPRS/HSDPA/CDMA
zGPSwithAGPS
zCertifications:CE/FCC/e‐mark,MIL‐SD810F,ISO7637‐2,SAEJ1455,SAEJ1113regulations
zIgnitionon/offdelay;SWcontrollableforcarpowermanagement
zBuiltinGsensorforactivesecuritysystem
ƒ


Specifications 

z Dimensions :(WxHxD): 261x125x59.1mm
z
Weight :1.5kg. 
z
Vehiclepowerfeature: 
–  Inputvoltage :6  ~36Vdc,supportignitioncoldcrank 
–  SupportIgnitionon/off 
–  Supportlowbatteryshut‐downprotectionthreshold  (optional) 
–  Supportpoweroffeventdelay

TREK‐510Usermanual13
–  Supportpowerondelay
–  Supportpowerlowdelay 
–  Supportpowerlowharddelay 
–
 Supporthardoff  delay

Note!  Formoredetailoffunctionplease  referto  Chapter7,Section6.3ofthismanual. 


z Enclosure :Ruggedizedaluminumwithoutventilation  holes.

z CPU : STA2062333MHz
z
Systemmemory : 2GBonboardflashforbootloader,image&Customer'sAP
z
Storage : SD : 1x(externalaccessible)
z
Serialports : 
COM1&2:2xFullFunctionRS‐232,5V/12V@0.5A,ping9,byjumperselected
COM3:1x4‐wireRS‐232/485(controlbySW,5V/12V@0.5A,ping9,byjumper
selected
 
z
USBHostport :SupportsuptotwoUSB1.1xbyTypeA.Onefromsmartdisplayport. 
z
USBClientport: 1xbyminiTypeAB 
z Watchdogtimer :Supports0‐255secstimeintervals,SWprogrammableandSW
enable/disabled. 
z RTCBattery :3.0V@  200mAHlithiumbattery. 
z
Powermanagement :Supportspowersaving  modesincludingNormalmode. 
z
DigitalI/O : 4xIsolateddrycontactdigitalinputsfromDB9connector(2500Vrms
protection),4xrelaydriverfromDB9connector
z
CANbus :SupportCANV2.0Bupto500kb/s. 
z Audio: 2audiocodecs,oneisforsmartdisplay,oneisforTREK‐510lineoutandmicin
phonejack.
z Optionalmodules :  
 GPS 
z LEA‐5S:50  channelsGPS
 RF :
z Quad‐band  GSM/GPRS,HSDPA,CDMA
z Operatingtemperature :‐30~70°C 
z
Relativehumidity :  10~95%@40°C(non‐condensing) 
z
Shock :30Gpeakacceleration(11msecduration) 
z
Certifications :CE,FCC,CCC,Emark 
z
Vibration :5~500HzSAEJ14554.9.4.2,MIL‐STD‐810F514.5 











TREK‐510Usermanual14
1.3Dimensions





Figure1.1  TREK‐510dimensions









TREK‐510Usermanual15



Chapter
2ShThis
Thischapterdetailssystemsetup
Sectionsinclude:
zAQuickTourofthecomputerbox
zInstallationProcedures
zRunningtheSetupProgram



















TREK‐510Usermanual16

2.1AQuickTo u r oftheTREK‐510Computingbox.

Before  startingtosetuptheIn‐VehicleComputingBox,  take  a  moment  tobecomefamiliarwiththe
locationsand
 purposesofthecontrols,  drives,connectorsandports,whichareillustrated  in  thefigures
below.Whenthe
 Computer box isplacedinsidetruckglovecabinetorunderthepassenger’sseatnextto
thedriver,itsfrontappearsasshown
 in  Figure2.1.


Figure2.1.FrontviewofTREK‐510



Figure2.2.RearviewofTREK‐510 
Unit:mm





TREK‐510Usermanual17
Figure2.3.SideviewofTREK‐510 


Unit:mm

Figure2.4.BottomviewofTREK‐510 
Unit:mm

Figure2.5.TopviewofTREK‐510 

