ATD Tools 7430A User manual

ATD7430A_ATD7431A_rev_0622Made in China to ATD Tools, Inc. Specifications
Visit us at www.atdtools.com
ATD-7430A / ATD-7431A
1/2 Ton Telescopic Transmisison Jack
Owner’s Manual
ATD-7430A Features:
([WUDZLGHEDVHORZHUVFHQWHURIJUDYLW\DQGSURPRWHVVWDELOLW\
5XJJHGSRO\XUHWKDQHZKHHOVIRUVPRRWKDQGHDV\PRYHPHQW
)RRWUHOHDVHSHGDOSURYLGHVFRQWUROOHGORZHULQJRIORDG
6DGGOHDGMXVWVWRILWPRVWSDQFRQILJXUDWLRQV
&KURPHSODWHGWZRVWDJHUDPVPD[LPL]HWKHKLJKUHDFK
1\ORQVWUDSVHFXUHVWUDQVPLVVLRQWRMDFN
0HHWVRUH[FHHGV$60(3$6(VWDQGDUGV
ATD-7431A Features:
([WUDZLGHEDVHORZHUVFHQWHURIJUDYLW\DQGSURPRWHVVWDELOLW\
5XJJHGSRO\XUHWKDQHZKHHOVIRUVPRRWKDQGHDV\PRYHPHQW
$XQLTXHIRRWUHOHDVHSHGDOSURYLGHVFRQWUROOHGORZHULQJRIORDG
$GMXVWDEOHVDGGOHIRUTXLFNDGMXVWPHQWIRUPRVWSDQFRQILJXUDWLRQV
&KURPHSODWHGWZRVWDJHUDPVPD[LPL]HLWVKLJKUHDFK
$FRPSDFW\HWSRZHUIXODLUPRWRULVHTXLSSHGWRUDLVHWKHORDG
WRWKHGHVLUHGKHLJKWHIILFLHQWO\HIIRUWOHVVO\DQGVDIHO\
1\ORQVWUDSVHFXUHVWUDQVPLVVLRQWRMDFN
0HHWVRUH[FHHGV$60(3$6(VWDQGDUGV
$7'$ $7'$
ATD-7430A Specifications:
&DSDFLW\7RQ
0LQLPXP+HLJKW´
0D[LPXP+HLJKW
6DGGOH%DVH´[´
6DGGOH$UHD0LQ´[´
([SDQGHG6DGGOH$UHD0D[´[´
6KLSSLQJ:HLJKWOEV
ATD-7431A Specifications:
&DSDFLW\7RQ
0LQLPXP+HLJKW´
0D[LPXP+HLJKW´
6DGGOH$UHD0LQ´[´
([SDQGHG6DGGOH$UHD0D[´[´
$LU3UHVVXUHSVL
6KLSSLQJ:HLJKWOEV

2
SAFETY AND GENERAL INFORMATION
Save these instructions. )RU \RXU safet\, read, understand, and follow the information provided with and on this
device EHfore usLQJ. The owner andor operator should have an understDQGLQJ of the device, its operatLQJ characteristics
and VDIHW\ RSHUDWLQJ instructions EHIRUH RSHUDWLQJ the HTXLSPHQW The owner DQGRU operator should EH aware that use
and repair of this product PD\ UHTXLUH special VNLOOV and NQRZOHGJH Instructions and VDIHW\ information should EH read
to and discussed with the operator in the RSHUDWRUV native ODQJXDJH PDNLQJ sure that the operator comprehends
their contents, EHIRUH use of this HTXLSPHQW is DXWKRUL]HG If DQ\ GRXEW H[LVWV as to the safe and proper use of this
device, remove from service immediatel\.
Inspect before each use. Do not use if DEQRUPDO conditions such as FUDFNHG welds, GDPDJHG loose or PLVVLQJ
parts are noted. $Q\ HTXLSPHQW that appears GDPDJHG in DQ\ wa\, is found to EH worn, or operates DEQRUPDOO\ should
EH removed from service until repaired. If the HTXLSPHQW has EHHQ or is suspected to have EHHQ VXEMHFWHG to an
DEQRUPDO load or VKRFN LPPHGLDWHO\ discontinue use until inspected E\ a IDFWRU\ DXWKRUL]HG repair IDFLOLW\ FRQWDFW
GLVWULEXWRU or manufacturer for list of DXWKRUL]HG repair IDFLOLWLHV It is recommended that an annual inspection EH
PDGHE\DQDXWKRUL]HGUHSDLUIDFLOLW\/DEHOVDQGRSHUDWRUVPDQXDOVDUHDYDLODEOHIURPWKHPDQXIDFWXUHr.
PRODUCT DESCRIPTION
The +\GUDXOLF Transmission -DFN is GHVLJQHG to EH used as an aid in the removal and installation of automotive and
OLJKW WUXFN transmissions, transfer cases and WUDQVD[OHV This telescopic VW\OH transmission MDFN is for use under an
overhead lift or in a JDUDJH pit. )RU air option model A7'$ ensure that \RXU air source can dedicate  &)0
@ 1SVLWRHDFKMDFNRSHUDWHG
!WARNING
Study, understand, and follow all instructions before operating this device.
Do not exceed rated capacity.
Use only on hard, level surfaces.
Adequately support the vehicle before starting repairs.
The use of this product is limited to removal, installation, and transportation in the
lowered position, of transmissions, transfer cases and transaxles.
No alterations should be made to this product.
Only attachments and/or adapters supplied by the manufacturer shall be used.
Failure to heed these markings may result in personal injury and/or property
damage.
SPECIFICATIONS
Model &DSDFLW\
OEV.´ ´  ´[´ ´[´
:HLJKW6DGGOH%DVH
Min.
+HLJKW
0D[
+HLJKW
([SDQGHG
Saddle Area
$7'$
$7'$
OEV
OEV
OEV. ´   ´[´´[´
6DGGOH5DQJHRI0RWLRQ
)URQW5HDU
/HIW5LJKW
´
)URQW5HDU
/HIW5LJKW

3
PREPARATION
Assembly - Please refer to the exploded view drawing in this manual in order to identify parts
1.0DMRUFRPSRQHQWVLQFOXGHGZLWKWKLVMDFN
a. +\GUDXOLFSRZHUXQLW DVVHPEO\
E. Saddle DVVHPEO\
c. TZREDVHKDOISLHFHVZLWKKDUGZDUH
2.3XWWKHK\GUDXOLFSRZHUXQLWLQDQXSULJKWSRVLWLRQDVVHPEOHWKHOHJVSDUWWRWKHF\OLQGHUSDUWZLWKWKH
EROWVSDUWDQGZDVKHUVSDUW$SSO\ the same procedure to the other EDVH half. 'RQRWWLJKWHQ\HW
$VVHPEOHVZLYHOFDVWHUVSDUWDQG3DUWWROHJFDVWHUEUDFNHWV
4. 7LJKWHQWKHEROWVWKDWDVVHPEOHVLQWKHOHJVSDUWWRWKHF\OLQGHUSDUWLQVWHS
.7KHK\GUDXOLFSRZHUXQLWLVHTXLSSHGZLWKWZRUHVHUYRLUILOOVFUHZVSDUWDQG7KHFORVHGVKLSSLQJVFUHZLV
LQVWDOOHGLQWKHUHVHUYRLUDWWKHIDFWRU\VRWKHMDFNZLOOQRWOHDNGXULQJVKLSPHQW5HPRYHVKLSSLQJVFUHZDQGUHSODFH
ZLWKWKHSURYLGHGYHQWVFUHZLQWKHIROORZLQJ³%HIRUH8VH´VWHSV
Before Use
1. %HIRUH XVLQJ this product, read the RSHUDWRUV manual FRPSOHWHO\ and IDPLOLDUL]H \RXUVHOI WKRURXJKO\ with the
SURGXFWLW¶VFRPSRQHQWVDQGUHFRJQL]HWKHKD]DUGVDVVRFLDWHGZLWKLWVXVH
2. VHULI\WKDWWKHSURGXFWDQGDSSOLFDWLRQDUHFRPSDWLEOH
3. 3UHVV the release valve pedal to ensure that saddle is IXOO\ lowered. 5HPRYH VKLSSLQJ screw and replace with
provided vent screw
.
4. )RU air option model A7'$ pour a teaspoon of JRRG TXDOLW\, air tool OXEULFDQW into the air VXSSO\ inlet of the lift
FRQWUROYDOYH&RQQHFWWRDLUVXSSO\DQGRSHUDWHIRUVHFRQGVWRHYHQO\GLVWULEXWHOXEULFDQW
NOTICE: The ModelATD-7431A is equipped with a 1/4” NPT air coupler. If installing a different air coupler, use thread
tape or compound on all air connections. To ensure dependable operation, install an inline air dryer and oiler.
.(QVXUH that MDFN rolls freel\. 5DLVH and lower the unloaded MDFN WKURXJKRXW the OLIWLQJ UDQJH EHIRUH SXWWLQJ into
service to ensure the pump operates smoothl\. 5HSODFH worn or GDPDJHG parts and DVVHPEOLHV with IDFWRU\
DXWKRUL]HGUHSODFHPHQWSDUWVRQO\.
)LJXUH T\SLFDO TUDQVPLVVLRQ-DFNFRPSRQHQWVA7'$VKRZQ
6DGGOH3ODWH
/LIW3HGDO 5HOHDVHVDOYH3HGDO
3RVLWLRQ+DQGOH
Caster
$LU3XPS3HGDO
2LO)LOOHU6FUHZ(reference
parts drawing for location)
Air Motor*
6KLSSLQJ6FUHZ
(replace w/ Vent Screw
before initial use)
%DVH+DOI
+\GUDXOLF8QLW
5DWFKHW%UDFNHW
*Air Option Model A7'$RQO\
Tilt $GMXVWPHQW.QREV
$LU6XSSO\,QOHW
6DGGOH6RFNHW

4
PREPARATION (cont.)
Venting trapped air procedure
$LUFDQDFFXPXODWHZLWKLQDK\GUDXOLFV\VWHPGXULQJVKLSPHQWRUDIWHUSURORQJHGXVH7KLVHQWUDSSHGDLUFDXVHVWKH
MDFNWRUHVSRQGVORZO\RUIHHOVSRQJ\8VHWKHVWHSVEHORZWREOHHGWKHV\VWHP
3XPSWKHMDFNWRWKHKLJKHVWSRLQWZKHUHWKHILUVWDQGWKHVHFRQGSLVWRQUDPVDUHERWKDWPD[LPXPKHLJKW
*HWWKHKHOSRIDQRWKHUSHUVRQWRNHHSWKHUHOHDVHSHGDOGHSUHVVHGDQGDFWLYDWHWKHIRRWSHGDODERXWWLPHV
/HWJRRIWKHUHOHDVHSHGDOWKHDLULQWKHRLOV\VWHPVKRXOGEHEOHGVXFFHVVIXOO\
)ROORZWKHVHVWHSVWREOHHGWKHDLULQWKHVHFRQGF\OLQGHU
/RFDWHWKHDLUEOHHGHUVFUHZDWWKHWRSQXWZKLFKLVRQWKHWRSRIWKHILUVWSLVWRQURG
3XPSWKHMDFNWRLWVPD[LPXPKHLJKW8VHDQ$OOHQVRFNHWZUHQFKWRORRVHQWKHDLUEOHHGHUVFUHZIRUQRPRUHWKDQ
WZRWXUQV3XVKWKHVDGGOHDVVHPEO\GRZQZDUGWRSXVKWKHDLULQWKHF\OLQGHURXWXQWLOQRWKLQJEXWRLOGUDLQVRXW
RIWKHEOHHGLQJKROH
7LJKWHQWKHEOHHGHUVFUHZDQGGRXEOHFKHFN,WPD\EHQHFHVVDU\WRUHSHDWWKHDERYHVWHSVVHYHUDOWLPHV
OPERATION
)ROORZ the instruction for removal and installation of transmission, transfer case or WUDQVD[OHLQDFFRUGDQFHZLWKWKHYHKLFOH
PDQXIDFWXUHUVVHUYLFHPDQXDO,QVSHFWWKHMDFNEHIRUHHDFKXVH'RQRWXVHMDFNLIGDPDJHGDOWHUHGPRGLILHGOHDNLQJ
K\GUDXOLFIOXLGRULILWKDVPLVVLQJRUORRVHFRPSRQHQWV
NOTICE:
WARNING:
WARNING:
Lowering saddle:
WARNING: Clear all tools and personnel before lowering load. Engage release valve pedal slowly. Maintain
control of load at all times.
$SSO\GRZQZDUGSUHVVXUHWRWKHUHOHDVHYDOYHSHGDOVORZO\DQGFDUHIXOO\.
!
!
!
3RVLWLRQWKHWUDQVPLVVLRQMDFNXQGHUWKHWUDQVPLVVLRQ'HSUHVVWKHIRRWSHGDOWRUDLVHWKHVDGGOHWRDKHLJKWFORVHWRWKH
FHQWHURIEDODQFHSRLQWRIWKHWUDQVPLVVLRQRLOSDQEXWGRQRWWRXFKWKHWUDQVPLVVLRQ
$GMXVWWKHUDWFKHWDUPVRQWKHVDGGOHVRWKDWWKHEHQWXSVHFWLRQRIWKHDUPVZLOOILWLQWKHPRXQWLQJIODQJHDURXQGWKH
SHULPHWHURIWKHWUDQVPLVVLRQRLOSDQ6ORZO\SXPSWKHMDFNWRPDNHWKHVDGGOHIXOO\FRQQHFWWKHWUDQVPLVVLRQ6HFXUHWKH
WUDQVPLVVLRQWRWKHMDFNVVDGGOHZLWKWKHWLHGRZQVWUDSSURYLGHG,IQHFHVVDU\WXUQWKHIRUHDQGDIWDQGVLGHWRVLGHWLOW
NQREVVRWKHVDGGOHLVLQWKHSURSHUDOLJQPHQWZLWKWKHWUDQVPLVVLRQSDQEHIRUHVHFXULQJWKHORDGWRWKHVDGGOH
IMPORTANT:0DNHVXUHWKHWLHGRZQVWUDSLVYHU\WLJKWZKHQVHFXULQJWKHWUDQVPLVVLRQWRWKHVDGGOHDQGEHIRUH
UDLVLQJRUORZHULQJWKHWUDQVPLVVLRQ
5HPRYHWKHWUDQVPLVVLRQIURPWKHHQJLQHDFFRUGLQJWRLQVWUXFWLRQVLQWKHYHKLFOHVHUYLFHPDQXDO
2QFHWKHWUDQVPLVVLRQKDVEHHQGLVVHPEOHGIURPWKHHQJLQHYHU\VORZO\GHSUHVVWKHUHOHDVHSHGDOWRORZHUWKH
WUDQVPLVVLRQDOOWKHZD\GRZQ
IMPORTANT:%HVXUHDOOWRROVDQGSHUVRQQHODUHFOHDUEHIRUHORZHULQJORDG6ORZO\GHSUHVVUHOHDVHYDOYHSHGDO
:KHQLQVWDOOLQJDWUDQVPLVVLRQUHIHUWRWKHDERYHLQVWUXFWLRQVDQGWKHYHKLFOHPDQXIDFWXUHUVLQVWDOODWLRQPDQXDO

Symptom Possible Causes CorrecƟve AcƟon
1. 5elease valve is open. 1. Close release valve.
2. Lowno oil in reservoir. 2. )ill with Oil and Eleed s\stem.
3. AirlocNed s\stem. 3. %leed s\stem.
4. Load is aEove capacit\ of MacN.4. 8se correct eTuipment
6. 3acNinJ worn out or defective. 6. Install seal Nit
JacN advances slowl\1. 3ump not worNinJ correctl\. 1. Install seal Nit, or replace power 8nit.
1. C\linder pacNinJ is leaNinJ. 1. Install seal Nit
2. Valve not worNinJ correctl\
suction, deliver\, release, or
E\pass.
2. Inspect valves. Clean and repair seat
surfaces.
3. AirlocNed s\stem. 3. %leed s\stem.
JacN leaNs oil 1. :orn or damaJed seals. 1. Install seal Nit.
JacN will not retract 1. 5elease valve is closed. 1. Open or clean release valve.
JacN does not lift
JacN lifts load, Eut doesnt hold

MAINTENANCE
NOTICE:
Changing oil
NOTICE:
NOTICE:
3. 6HWMDFNLQLWVOHYHOSRVLWLRQ .
4. 3HUIRUPventing trapped air procedure SDJH
Lubrication
1. A periodic FRDWLQJ of OLJKW OXEULFDWLQJ oil to pivot points, D[OHV and KLQJHV will help to prevent rust and assure that
FDVWHUVDQGSXPSDVVHPEOLHVPRYHIUHHO\.
2. )RU air operated models A7'$ :KHQ used on a GDLO\ EDVLV air pump model should EH LQWHUQDOO\ OXEULFDWHG
EHIRUH each use. 8VH RQO\ JRRG TXDOLW\ air tool OXEULFDQW If no LQOLQH oiler is used, pour a teaspoon of air tool oil
LQWRWKHDLUVXSSO\LQOHW2SHUDWHWKHMDFNXVLQJWKHDLUIHDWXUHWRIXOO\GLVWULEXWHWKHRLO
Cleaning
'LUWLVWKHJUHDWHVWVLQJOHFDXVHRIIDLOXUHLQK\GUDXOLFXQLWV.HHSWKHMDFNFOHDQDQGZHOOOXEULFDWHG
WRSUHYHQWIRUHLJQPDWWHUIURPHQWHULQJWKHV\VWHP,IWKHMDFNKDVEHHQH[SRVHGWRUDLQVQRZVDQGRUJULWLWPXVW
EHFOHDQHGEHIRUHLWLVXVHG3HULRGLFDOO\ FKHFN the pump piston and ram for VLJQV of rust or corrosion. Clean as needed
and wipe with an RLO\FORWK
NOTICE: Do not use sandpaper or abrasive material on pump piston or ram surfaces.
Storage
:KHQQRWLQXVHVWRUHWKHMDFNZLWKVDGGOHIXOO\ORZHUHG6WRUHWKHMDFNLQDZHOOSURWHFWHGDUHDZKHUHLWZLOOQRWEH
H[SRVHGWRFRUURVLYHYDSRUVDEUDVLYHGXVWRUDQ\RWKHUKDUPIXOHOHPHQWV

6
REPLACEMENT PARTS
1RW all components of this MDFN are replacement items, EXW are illustrated as a convenient reference for location
and position in the DVVHPEO\ VHTXHQFH :KHQ RUGHULQJ parts, please JLYH the model QXPEHU and parts description.
Call \RXUGLVWULEXWRU for current SULFLQJ
ATD-7430A Replacement Parts:

7
ITEM# ORDERING PART# PART DESCRIPTION QTY ITEM# ORDERING PART# PART DESCRIPTION QTY
11%AS( :(LDM(1T1
13* D8ST 35OO) 5I1G1
12ST((L %ALL 1 14S1A3 5I1G1
13%ALL S(AT VALV(11 3ISTO11
14S35I1G1
16G8IDI1G 5I1G1
1 SC5(: 117* O5I1G1
16* S(AL 1 1 CA31
17SC5(: 119* OIL 3L8G1
1 ST((L %ALL 3 160* D8ST 35OO) 5I1G1
19S35I1G1 161 %OLT 1
110* CO33(5 :AS+(5 2162 ST((L %ALL 1
111 %OLT 2 163 +A1DL( ASS(M%LY 1
112 S35I1G1 2135T7430A2126 CAST(5 :%OLT A1D :AS+(5 2
113 S833O5T 5OD 1 2235T7430A2226 LOC.I1G CAST(5 :%OLT A1D :AS+(5 2
114 %ALL S(AT VALV(123%OLT 
1118T2
24:AS+(5 12
116 S35I1G1
2 L(G2
117* CO33(5 :AS+(5 126%OLT 4
11OIL 5(L(AS( VALV(131SADDL( 3LAT(1
119* O5I1G1
323LAT( 2
120 )IX 5I1G1
333LAT( 1
121 S1A3 5I1G1
343LAT( 1
122 OIL 5(L(AS( VALV( 5OD 1 3 LOCATI1G %LOC.4
123 3(DAL 1 3ALOCATI1G %LOC. ASS(M%LY 4
124 3I123% L(A) S35I1G4
123(DAL 3I123C5IV(T 4
126 S35I1G1
363I14
127* Y5I1G1
37LOCATI1G %LOC.1
12*O5I1G1
3 ADJ8STI1G %LOC. :(LDM(1T1
129 38M3 CO5( 139ADJ8STI1G %LOC. 1
130 S35I1G COV(5 1310 SC5(: 1
131 S1A3 5I1G1 311 SC5(: 1
132 %8S+I1G1 312 +A1DL( :+((L1
133 AXIS 1 313 +A1DL( :+((L1
134 3(DAL 1 314 AXIS 2
13S1A3 5I1G2 31AXIS 2
136 AXIS 1 316 %8S+I1G4
137 %OLT 1 317 %8S+I1G 3I14
13%OLT 1 313I12
139* S(AL 1 319 %OLT 1
140 18T1
320 %OLT 1
141 %OLT 1 321 18T2
142* :AS+(5 1322 TI(1
143* O5I1G1
323 %OLT 1
144* O5I1G1 324 :AS+(5 1
143ISTO1 5I1G1
32:AS+(5 1
146 S1A3 5I1G2
326 %OLT 1
147 3ISTO1 5I1G1
327 18T1
14MIDDL( CYLI1D(5 132+A1DL(1
149 LIMIT(D COLLA51329 :AS+(5 2
10G8IDI1G COLLA51330 %OLT 2
11* OIL 3L8G1
332 S1A3 5I1G4
12CA31
35T7430A31332
SADDL( ASS(M%LY
35T7430A11163
+YD5A8LIC CYLI1D(5
35T7430A11163
+YD5A8LIC CYLI1D(5
*  35T7430AS.  S(AL .IT CO1TAI1S 16, 110, 117, 119, 127, 12, 139, 142, 143, 144, 11, 13, 17, 19, 160


ATD-7431A Replacement Parts:

ITEM# ORDERING PART# PART DESCRIPTION QTY ITEM# ORDERING PART# PART DESCRIPTION QTY
11A AI5 :(LDM(1T1166 3I11
1213T 14 CO83L(5 1167 +A1DL( :+((L1
133I1316A VALV( %LOC.1
143(DAL A 1 169 :AS+(5 3
1 3I12170 %OLT 2
16:AS+(5 1171 CO11(CTI1G 5OD S(AT 1
17%OLT 1 172 38M3 %ODY 1
1 S35I1G1173 O5I1G2
193(DAL %1174 S1A3 5I1G2
110 3I121738M3 CO5( 1
111 CO11(CTI1G 5OD 2 176 3I11
112 CO11(CTI1G 5OD JOI1T1 177 3I11
113 VALV( 117+A1DL( SOC.(T1
114 O5I1G2179 +A1DL(1
11VALV( 5OD 2 10+A1LD G5I31
116 S(AL 2 11)8(L 3I3( 11
117 COV(5 212:AS+(5 1
11:AS+(5 213:AS+(5 1
119 %OLT 2 14%OLT 1
120 S35I1G21 %OLT 4
121 CO33(5 :AS+(5 216%OLT 1
122 CO83L(5 117T+5OTTL( VALV(1
123 CO83L(5 11 STO3 COLLA51
124 S1A3 5I1G1193I12
12CO83L(5 12135T7430A2126 CAST(5 :%OLT A1D :AS+(5 2
126 COV(5 122:AS+(5 4
127 %OLT 1 23%OLT 4
12CA3124L(G ASS(M%LY 4
129 %OLT 2 %OLT 4
130 3I1126:AS+(5 4
131 AI5 +O8SI1G12735T7430A2226 LOC.I1G CAST(5 :%OLT A1D :AS+(5 2
132 Y5I1G131 SADDL( :(LDM(1T1
133 S833O5TI1G 5I1G132%5AC.(T C 2
134 3ISTO1133%5AC.(T %1
13%IG CYLI1D(5 134%5AC.(T A 1
136 CA313 5(TAI1(5 3LAT( ASS(M%LY 4
137 G8IDI1G 5I1G13A5(TAI1(5 3LAT(4
131YLO1 GAS.(T23% S35I1G4
139 O5I1G23C5IV(T4
140 %OLT 1 363I14
141 MIDDL( CYLI1D(5 CA31375(TAI1(5 3LAT( A 1
142 O5I1G23 ADJ8STI1G %5AC.(T1
143 1YLO1 GAS.(T239ADJ8STI1G %5AC.(T A 1
144 O5I1G2310 SC5(: %1
14%IG CYLI1D(5 CA31311 SC5(: A 1
146 G8IDI1G 5I1G1312 +A1DL( %1
147 MIDDL( CYLI1D(5 1313 +A1DL( A 1
143ISTO1 5OD 1 314 S+A)T2
149 SMALL CYLI1D(5 131S+A)T2
10CO33(5 :AS+(5 2316 %8S+I1G4
11ST((L2317 3I14
12S35I1G2313I12
13ST((L %ALL 2 319 %OLT 1
14%OLT 2 320 %OLT 1
1 CO33(5 :AS+(5 2321 LOC. 18T2
16%OLT 2 322 TI(1
17ST((L %ALL 1 323 %OLT 1
1 ST((L %ALL VALV( S(AT 1 324 :AS+(5 1
19S35I1G132:AS+(5 1
160 %OLT 1 326 %OLT 1
161 S(AL 1 327 18T1
162 %OLT 1 32G5I31
163 ST((L %ALL 1 329 :AS+(5 2
164 O5I1G1330 %OLT 2
16OIL 5(L(AS( VALV(1331 S1A3 5I1G4
35T7430A31332
SADDL( ASS(M%LY
35T7431A11A19
+YD5A8LIC
CYLI1D(5 :AI5
MOTO5
35T7431A11A19
+YD5A8LIC
CYLI1D(5 :AI5
MOTO5
* PRT7431A-SK - SEAL KIT CONTAINS: 1-32, 1-38, 1-39, 1-42, 1-43, 1-44, 1-50, 1-55, 1-61, 1-64, 1-73, 1-74
9

10
1RWHs

11
1RWHs

12
WARRANTY
1 YEAR LIMITED WARRANTY
THIS WARRANTY AND CONFIRMED RECEIPT(S) SHOULD BE RETAINED BY THE CUSTOMER AT ALL TIMES
385&+$6(')520 _______________________________________
'$7(385&+$6(' ________________________________________
,192,&(5(&(,37180%(5BBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBBB
<RXU$7'$RU$7'$LVZDUUDQWHGIRUDSHULRGRIPRQWKVIURPWKHRULJLQDOSXUFKDVHGDWH
)RUDSHULRGRIRQH\HDUIURP\RXUSXUFKDVHGDWH$7'7RROV,QFZLOOUHSDLURUUHSODFHDWLWVRSWLRQZLWKRXWFKDUJH\RXU
$7'SURGXFWLILWZDVSXUFKDVHGQHZDQGWKHSURGXFWKDVIDLOHGGXHWRDGHIHFWLQPDWHULDORUZRUNPDQVKLSZKLFK\RXH[SHULHQFHG
GXULQJQRUPDOXVHRIWKHSURGXFW7KLVOLPLWHGZDUUDQW\LV\RXUH[FOXVLYHUHPHG\
7RDFFHVVWKHEHQHILWVRIWKLVZDUUDQW\FRQWDFW\RXUVXSSOLHURUSRLQWRIVDOHGLUHFWO\<RXPD\EHDGYLVHGWRUHWXUQWKHSURGXFW
XQGHUZDUUDQW\IUHLJKWSUHSDLGWR\RXUVXSSOLHUIRUZDUUDQW\GHWHUPLQDWLRQ
,IWKLV$7'SURGXFWLVDOWHUHGDEXVHGPLVXVHGPRGLILHGRUXQGHUJRHVVHUYLFHE\DQXQDXWKRUL]HGWHFKQLFLDQ\RXUZDUUDQW\ZLOO
EHYRLG:HDUHQRWUHVSRQVLEOHIRUGDPDJHWRRUQDPHQWDOGHVLJQV\RXSODFHRQWKLV$7'SURGXFWDQGVXFKRUQDPHQWDWLRQVKRXOG
QRWFRYHUDQ\ZDUQLQJVRULQVWUXFWLRQVRUWKH\PD\YRLGWKHZDUUDQW\7KLVZDUUDQW\GRHVQRWFRYHUVFUDWFKHVVXSHUILFLDOGHQWVDQG
RWKHUDEUDVLRQVWRWKHSDLQWILQLVKWKDWRFFXUXQGHUQRUPDOXVH,WDOVRGRHVQRWFRYHUQRUPDOZHDULWHPVVXFKDVEXWQRWOLPLWHGWR
EUXVKHVEDWWHULHVGULOOELWVGULOOFKXFNVSDGVRUEODGHV
6XEMHFWWRWKHODZLQ\RXUVWDWH
<RXUVROHDQGH[FOXVLYHUHPHG\LVUHSDLURUUHSODFHPHQWRIWKHGHIHFWLYHSURGXFWDVGHVFULEHGDERYH
$7'LVQRWOLDEOHIRUDQ\LQFLGHQWDOGDPDJHVLQFOXGLQJEXWQRWOLPLWHGWRORVWSURILWVDQGXQIRUHVHHDEOHFRQVHTXHQFHV
7KHUHSDLUDQGUHSODFHPHQWRIWKLVSURGXFWXQGHUWKHH[SUHVVOLPLWHGZDUUDQW\GHVFULEHGDERYHLV\RXUH[FOXVLYHUHPHG\DQGLV
SURYLGHGLQOLHXRIDOORWKHUZDUUDQWLHVH[SUHVVRULPSOLHG$OORWKHUZDUUDQWLHVLQFOXGLQJLPSOLHGZDUUDQWLHVDQGZDUUDQWLHVRI
PHUFKDQWDELOLW\RUILWQHVVIRUDSDUWLFXODUSXUSRVHDUHGLVFODLPHGDQGLIGLVFODLPHULVSURKLELWHGWKHVHZDUUDQWLHVDUHOLPLWHGWR
RQH\HDUIURP\RXUGDWHRISXUFKDVHRIWKLVSURGXFW
Some states’ laws do not allow limited durations on certain implied warranties and some states’ laws do not allow limitations on
LQFLGHQWDORUFRQVHTXHQWLDOGDPDJHV<RXVKRXOGFRQVXOWWKHODZLQ\RXUVWDWHWRGHWHUPLQHKRZ\RXUULJKWVPD\YDU\
>$IIL[UHFHLSWRULQYRLFHKHUHIRUVDIHNHHSLQJ@