Cleveland SteamCub 1SCEMCS User manual

Cleveland
™
Project ________________________________
Item __________________________________
Quantity_______________________________
FCSI Section ____________________________
Approval _______________________________
Date __________________________________
1333 East 179 St.,
Cleveland, Ohio,U.S.A. 44110
Tel: [phone]
Fax: [phone]
Web Site:www.ClevelandRange.com
Email: [e-mail]
STEAMCUB™ BOILERLESS
CONNECTIONLESS STEAMER
SECT. IPAGE 1
0707
SteamCub TM
PRESSURELESS STEAM COOKER,
RETHERMALIZER & HOLDING CABINET
Cleveland Standard Features
nBoilerless Pressureless Steam Cooker and Rethermalizer.
nCapacity: Full Size Steam Table Pans:
•Five: 2 1/2" x 12" x 20" (1/1 GN, 65mm)
•Ten: 1" x 12" x 20" (1/1GN, 40mm)
nEasy installation, no drain line, water connections or hood is
needed.*
n60 Mechanical Timer with ON/OFF Main Power Switch with
aHeat On, Low Water Indicator Lights and High
Temperature Safety Light and Shut-off (Reset Light).
n6" (152mm) Skid Resistant Stainless Steel Adjustable Legs
with Flanged Feet.
n8gauge stainless steel inner cooking compartment, 14
gauge stainless steel outer compartment with two piece
compartment door for an airtight, leak-proof seal.
nReversible Door Gasket.
n9kW total output, with easy to remove 1 kW heating
elements (9 each) cast into aluminum bocks.
nElectronic Low-Water Shut-OffSafety Indicator with audible
alarm, High Temperature Safety Shut-Off and LED "Heat
On" Indicator Light.
nSeparate Power ON/OFF Control includes an Automatic
Pre-Heat when power is turned "ON".
nEasy-Access Manual Drain Valve located in front, Pan Slide
Guides located under unit to fit 12" x 20" (1/1GN) Pans.
Includes one 4" x 12" x 20" stainless steel pan
(1/1GN-102mm).
nApprovals: cUL, NSF #4.
Options & Accessories
pEquipment Stand Model UniStand34.
pPOSK Pull-Out Shelf Kit for UniStands (P/N 111724)
pURK Pan Rack Kit UniStands (P/N 111726)
pOptional Voltages, 480 Volt (VOS2).
p6kW total Output Six - 1 kW heating elements.
pSingle Phase Operation.
*Consult local authorities for venting requirements
Shall be a Cleveland SteamCub™, Model 1SCEMCS,one compartment
steamer.60-minute mechanical timer with a low water indicator and alarm. a
heat-on indicator light. 9 kW power rating. Capacity for five 2 1/2" deep full
size steam table pans. 8 gauge stainless steel inner cooking compartment,
14 gauge stainless steel outer compartment with two piece compartment
door.
Short Form Specifications
MODEL:c1SCEMCS

(NOT TOSCALE)
SECT.IPAGE 2
0707
Litho in U.S.A.
17.434"
443mm
21.625"
549mm
23.100"
587mm
25.361"
644mm
2.100"
53mm
24.858"
631mm
1.574"
40mm
30.890"
785mm
1.500"
38mm
RIGHT
SIDE VIEW
FRONT
VIEW
REAR
VIEW
Note:Consult local authorities for venting and installation requirements.
∗For supply connection use only copper wire suitable for at least 75°C(167°F).
•Compartment has capacity for:
Five, 12˝ x 20˝ x 21⁄2˝deep Cafeteria Pans.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards whether
untreated or pre-treated, based upon 10 hours of use per day,
and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million
Consult a local water treatment specialist for an on site water
analysis for recommendations concerning steam generator
feed water treatment (if required), in order to remove or
reduce harmful concentrations of minerals. The use of high-
ly mineralized water will mean that more frequent servicing of
the steam generator will be necessary. The fact that a water
supply is potable is not proof that it will be suitable for the
generator.
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are U.L/NSF#4 and CSA (AGA, CGA).
H
D
C C1 C2
ELECTRICAL
WATTS VOLTS PHASE WIRES CYCLE AMPS SUPPLYCONNECTION
HERTZ WIRE SIZE (COPPER)*
Standard Wattage
Three Phase - 9 kW Standard
9400 208 3 3 60 26.1 10
9400 240 3360 22.6 10
9400 480 3 3 60 11.4 14
Optional Low Wattage
Three Phase - 6 kW option
6400 208 3 3 60 17.8 12
6400 240 3 3 60 15.4 12
6400 480 3 3 60 7.7 14
*For supply connection use only copper wire suitable for at least 75˚C. (167˚F).
WATTS VOLTS PHASE WIRES CYCLE AMPS SUPPLYCONNECTION
HERTZ WIRE SIZE (COPPER)*
Standard Wattage
Single Phase - 9 kW Standard
9400 208 1 2 60 45.2 6
9400 240 1260 39.2 8
Optional Low Wattage
Single Phase - 6 kW option
6400 208 1 2 60 30.8 8
6400 240 1 2 60 26.7 10