Cleveland 24CSM Series User manual

Cleveland
™
Project ________________________________
Item __________________________________
Quantity_______________________________
FCSI Section ____________________________
Approval _______________________________
Date __________________________________
1333 East 179 St.,
Cleveland, Ohio,U.S.A. 44110
Tel: [phone]
Fax: [phone]
Web Site:www.ClevelandRange.com
Email: [e-mail]
CLASSIC CONVECTION STEAMERS
15 PSI BOILER BASE STYLE
MODEL:c24-CSM
Cleveland Standard Features
n Cooking Capacity for up to six 12˝ x 20˝ x 2
1
⁄ 2 ˝deep Cafeteria Pans.
nPressureless cooking with forced convection steam, permitting
doors to be opened while cooking continues.
n Solid State Controls operate water level and safety functions.
n Each compartment is equipped with a 60 minute mechanica l
timer, separate bypass switch for constant steaming and a
cold water condenser for superior cooking results.
n Instant Steam Standby Mode: Holds generator at steaming
temperature. Allows unit to start cooking instantly.
nDurable 14 GaugeStainless Steel Construction:
For Compartment Door and Steam Cooking Cavity.
nSeparate Main Power Switch for “On/Off”
nExclusive Steam Cooking Distribution System: The exclu-
sive Convection Jets produce a high velocity convection
steam without fans. Coved Corner design in cooking compart-
ment distributes heat evenly and is easy to keep clean.
Creased top & bottom enhance drainage. Cold Water
Condenser for each compartment maintains a dry steam. Fully
insulated cooking compartment for thermal efficiency.
Removable Stainless Steel Slide Racks for easy cleaning.
nExclusive “Cool to the Touch” Compartment Door Design:
Free floating inner door with reversible door gasket provides
an air tight seal. Stainless Steel Slam/Latch mechanism pro-
vides greater reliability.
nLeft Hand Door Hinging: Compartment Doors hinged left,
controls on the right.
nModular Cabinet Base with Hinged Door.
nSteam Coil Generator: Automatic Water Fill on start up.
Minimum 35 psi incoming steam pressure required with a
3⁄4˝steam line.
nAutomatic Generator Drain at shutdown: Contains a “Water
Jet” Spray Rinse Cleaning Cycle to keep drain clear.
nAutomatic Water Level Control System with Low Water
Power Cut-off Circuit.
nSteam generator equipped with High Limit Pressure Safety
Switch, 15 psi Safety Valve, and Steam Generator Pressure
Gauge.
nSecondary Low Water Cut-Off, factory installed (CALS)
(Required for AZ. AR. CA. CO. CT.DE. FL. GA. HI. IL. IA. KS. MD. MA. MI. MN.
MT. NE. NV. NM. NC. OK. OR. PR. RI. TN. UT. VA. WA. WV., Buffalo, NY,
Wash. DC)
nNSF Certified 6˝ Stainless Steel Legs with adjustable
flanged feet for a one inch level adjustment.
nStandard Voltage for Controls: 115 volts, 60 Hz, single phase.
nAll Controls are serviceable from the front.
Options & Accessories
pRight Hand Door Hinging, Controls on the Left (DHR)
pElectronic Timer with Compensating Load Feature (ETC)
pON/OFF Steam Switch only for compartment controls (MC)
pCafeteria pans in depths of 1˝, 21⁄2˝, 4˝ and 6˝
pAdditional Power Reducing Valve (PRV)
pMoisture Separator Trap (MS)
pStainless Steel Base Frame (FSS)
pCompartment Door Steam Shut Off Switch (SCS)
pCorrectional Packages
pBoiler Descaling Pump Kit (107142)
pWater Filters
Shall be Two Compartments, CLEVELAND Convection Steamer, Model 24-
CSM, Steam Coil Steam Generator,115 volts, single phase. Solid State
Controls operate timing, water level and safety functions. Steam Generator
with Automatic Water Fill on start-up and Automatic Blowdown with addi-
tional Manual Drain Valve. For each cooking compartment: 60 minute
Mechanical Timer, Manual Operation Mode and Cold Water Condenser.
Type 304 Stainless Steel cooking compartment.
Short Form Specifications
Cleveland Classic Series
TWO COMPARTMENT, PRESSURELESS
STEAM COIL GENERATOR
24” WIDE CABINET BASE DESIGN
CONVECTION
STEAMERS
SECT. III PAGE 5
0707

(NOT TOSCALE)
SECT.III PAGE 6
0707
Litho in U.S.A.
Right - 3”, Left - 3”, Rear - 3”
(12” on control side if adjoin-
ing wall or equipment is over
30” high for service acess)
Contact factory for
variances to clearances.
11/2” IPS common drain.
Do not connect other units to
this drain.
Do not use PVC pipe for drain.
Condensate Return Drain Line
•Each compartment has capacity for:
Three, 12˝ x 20˝ x 21⁄2˝or six, 12˝ x 20˝ x 1˝ deep
Cafeteria Pans.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours
of use per day, and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million
Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
remove or reduce harmful concentrations of minerals.
The use of highly mineralized water will mean that more
frequent servicing of the steam generator will be
necessary. The fact that a water supply is potable is not
proof that it will be suitable for the generator.
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are ASME/N. Bd, UL, NSF and CSA.