Ferno EZ Glide 59-T User manual

October 2005
Users’ Manual
Pub. No. 234-3298-01
Model 59-T and Model 59
EZ Glide™Evacuation Chair
MODEL 59-T
MODEL 59

2© Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
Disclaimer
This manual contains general instructions for the use, operation and
care of this chair. The instructions are not all-inclusive. Safe and proper
use of this chair is solely at the discretion of the user. Safety information
is included as a service to the user. All other safety measures taken by
the user should be within and under consideration of applicable
regulations. It is recommended that training on the proper use of this
chair be provided before using this chair in an actual situation.
Retain this manual for future reference. Include it with the chair in the
event of transfer to new users. Additional free copies are available
upon request from Customer Relations.
Proprietary Notice
The information disclosed in this manual is the property of Ferno-
Washington, Inc., Wilmington, Ohio, USA. Ferno-Washington, Inc.
reserves all patent rights, proprietary design rights, manufacturing
rights, reproduction use rights, and sales use rights thereto, and to any
article disclosed therein except to the extent those rights are expressly
granted to others or where not applicable to vendor proprietary parts.
Ferno-Washington, Inc.
70 Weil Way
Wilmington, OH 45177-9371 U.S.A.
© Copyright Ferno-Washington, Inc. All Rights Reserved.
Telephone (Toll Free) ......................... 1.877.733.0911
Telephone ........................................... 1.937.382.1451
Fax (Toll Free) .................................... 1.888.388.1349
Fax ..................................................... 1.937.382.6569
Internet ............................................... www.ferno.com
Additional Instructional Material Available for the
EZ Glide Evacuation Chair
EZ Glide Training CD 283-1214

© Ferno-Washington, Inc. 234-3298-01 October 2005 3
Models 59 and 59-T Evacuation Chair
TABLE OF CONTENTS
Section page
1 - Safety Information.................................................. 5-7
1.1 Warnings .............................................................. 5
1.2 Important .............................................................. 5
1.3 Bloodborne Disease Notice ................................. 5
1.4 Safety and Instruction Labels ........................... 5-7
2 - Operator Skills and Training.................................... 7
2.1 Skills .................................................................... 7
2.2 Training ................................................................ 7
3 - About the Chair...................................................... 8, 9
3.1 Chair Description ................................................. 8
3.2 General Specifications ......................................... 8
3.3 Components ......................................................... 9
4 - Chair Setup......................................................... 10, 11
4.1 Restraint Configurations for
Chair with ABS Panels ...................................... 10
4.2 Using One-Piece Restraints ............................... 10
4.3 Ankle Restraint ................................................... 11
4.4 Attaching Restraints to Chair With Soft
Vinyl Seating ....................................................... 11
5 - Using the Features............................................... 12-15
5.1 Chair Lock Bar .................................................. 12
5.2 Track System - Model 59-T Only ...................... 13
5.3 Extending Lift Bar ............................................. 14
5.4 Telescoping Lift Handles ................................... 14
5.5 Footrest .............................................................. 15
5.6 Wheel Locks ...................................................... 15
6 - Using the Chair ................................................... 16-22
6.1 Before Placing the Chair in Service .................. 16
6.2 General Guidelines for Use ............................... 16
6.3 Transferring the Patient ..................................... 17
6.4 Rolling the Chair................................................ 17
Section page
6.5 Gliding the Chair Down Stairs -
Model 59-T Only ......................................... 18, 19
6.6 Transporting the Patient Down Stairs -
Model 59 Only ................................................... 20
6.7 Transporting the Patient Up Stairs -
Models 59-T and 59 .......................................... 21
6.8 Using Additional Help ....................................... 22
7 - Maintenance ........................................................ 23-30
7.1 Maintenance Schedule ....................................... 23
7.2 Disinfecting/Cleaning Restraints ....................... 23
7.3 Disinfecting/Cleaning the Chair ........................ 23
7.4 Cleaning Track and Belts................................... 23
7.5 Inspecting the Chair ........................................... 24
7.6 Lubricating the Chair ......................................... 25
7.7 Do Not Lubricate Track System
on Model 59-T ................................................... 25
7.8 Adjusting Track-Belt Tension ...................... 26, 27
7.9 Reconditioning the Track Belts ......................... 28
7.10 Removing and Attaching ABS Panels .............. 29
7.11 Removing and Attaching Soft Vinyl Seating ... 30
8 - Accessories and Related Products .......................... 31
8.1 Accessories ........................................................ 31
8.2 Restraints ........................................................... 31
9 - Parts and Service ............................................... 32, 33
9.1 Parts and Service - U.S.A. and Canada ............. 32
9.2 Parts and Service - Worldwide .......................... 32
9.3 Parts List ............................................................ 32
9.4 Parts Diagrams .................................................. 33
10 - Limited Warranty .................................................. 34
11 - Ferno Customer Relations..................................... 34
Training Record............................................................. 35
Maintenance Record ..................................................... 36

4© Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
Safety Labels ................................................................. 6, 7
Components - Model 59-T and Model 59......................... 9
Figure 1- Horizontal Restraint Configuration ................. 10
Figure 2 - Criss-Cross Restraint Configuration .............. 10
Figure 3 - Top: Correctly Wrapped One-Piece Restraint
Inset: Restraint Buckled .................................... 10
Figure 4 - Threading Buckle Through Loop .................... 11
Figure 5 - Tightening Strap .............................................. 11
Figure 6 - Ankle Restraint Attached ................................. 11
Figure 7 - Torso Restraints on Chair with Soft
Vinyl Seating ....................................................... 11
Figure 8 - Aligning the Wheels ....................................... 12
Figure 9 - Disengaging the Lock ..................................... 12
Figure 10 - Folding the Chair .......................................... 12
Figure 11 - Engaging the Lock ........................................ 12
Figure 12 - Opening the Track ........................................ 13
Figure 13 - Closing the Track.......................................... 13
Figure 14 - Left: Lift-Bar Positions
Inset: Adjusting Lift Bar Height ........................ 14
Figure 15 - Right: Lift Handle Positions
Inset: Extending/Retracting a Lift Handle ......... 14
Figure 16 - Footrest Folded for Storage .......................... 15
Figure 17 - Footrest Unfolded for Use ............................ 15
Figure 18 - Wheel Lock Engaged ................................... 15
Figure 19 - Wheel Lock Disengaged............................... 15
Figure 20 - Patient Secured in Chair with Restraints ...... 17
Figure 21 - Rolling the Chair .......................................... 17
Figure 22 - Gliding the Chair Down a Curb ................... 17
Figure 23 - Preparing Model 59-T for Descent .............. 18
Figure 24 - Track Belts Engaging Top Step .................... 18
Figure 25 - Establishing the Glide Angle ........................ 19
Figure 26 - Preparing to Roll the Chair .......................... 19
Illustrations
Figure 27 - Pausing on the Stairs .................................... 19
Figure 28 - Carrying the Model 59 Chair
Down Stairs ........................................................ 20
Figure 29 - Pausing on the Stairs - Model 59 Chair ....... 20
Figure 30 - Preparing to Carry Model 59-T (Tracked) ........
Chair Up Stairs .................................................. 21
Figure 31 - Carrying Model 59 (Untracked)
Chair Up Stairs .................................................. 21
Using Additional Help ..................................................... 22
Minimum Intervals for Maintenance ............................... 23
Figure 32 - Top: Lubrication Point Locations
Bottom: Lubrication Point Close-up ................. 25
Figure 33 - Label on Chair Track .................................... 25
Figure 34 - Chair Ready for Tensioning Procedure ........ 26
Figure 35 - Belt Ready for Tensioning ........................... 26
Figure 36 - Tensioning the Belt ....................................... 26
Figure 37 - Checking Tension with Chair Laying on Its ......
Tracks on a Work Bench .................................... 27
Figure 38 - Checking Tension with Chair Standing on Its ...
Wheels ............................................................... 27
Figure 39 - Marking Starting Point for Sanding Belt ...... 28
Figure 40 - Sand in Direction of Arrows ......................... 28
Figure 41 - Releasing a Bottom Corner of Backrest ....... 29
Figure 42 - Lifting the Backrest Panel
Over the Keepers ............................................... 29
Figure 43 - Releasing a Corner of the Seat Panel ........... 29
Figure 44 - Unfasten Snaps ............................................. 30
Figure 45 - Unbuckle Straps ............................................ 30
Figure 46 - Unfasten Seat Snaps ..................................... 30
Figure 47 - Tighten Straps ............................................... 30
Parts Diagrams ................................................................ 33
Serial Number Location .................................................. 34

© Ferno-Washington, Inc. 234-3298-01 October 2005 5
Models 59 and 59-T Evacuation Chair
1 - SAFETY INFORMATION
Safety Information
1.1 Warnings
Warning notices indicate a potentially hazardous
situation which, if not avoided, could result in injury.
Untrained operators can cause injury or be
injured. Permit only trained personnel to
operate the chair.
Improper use of the chair can cause injury.
Use the chair only for the purpose described
in this manual.
Attaching one-piece restraints improperly
can allow seat and back panels to dislodge,
resulting in injury. Restraints must capture
panels AND chair frame.
Using the chair with the track unlocked can
cause injury. Verify that the track is locked
before transporting the patient.
Lubricating the track system can result in
injury to the patient and/or operators. Never
lubricate the track or belts.
Improper operation can cause injury. Operate
the chair only as described in this manual.
An unattended patient can be injured. Stay
with the patient at all times.
An unrestrained patient can fall off the chair
and be injured. Use restraints to secure the
patient on the chair.
Helpers can cause injury or be injured.
Maintain control of the chair, operate the
controls, and direct all helpers.
Improper maintenance can cause injury.
Maintain the chair only as described in this
manual.
Attaching improper items to the chair can
cause injury. Use only Ferno-approved items
on the chair.
Modifying the chair can cause injury and
damage. Use the chair only as designed by
Ferno.
Attaching improper items to the chair can
cause injury. Use only Ferno-approved items
on the chair.
WARNING!
WARNING!
1.2 Important
Important notices emphasize important usage or
maintenance information.
1.3 Bloodborne Disease Notice
To reduce the risk of exposure to bloodborne diseases
such as HIV-1 and hepatitis when using the chair, follow
the disinfecting and cleaning instructions in this manual.
1.4 Safety and Instruction Labels
Safety and instruction labels place important
information from the users’ manual on the chair.
Read and follow label instructions. Replace worn or
damaged labels immediately. New labels are available
from EMSAR (page 32) or from Ferno Customer
Relations (page 34).
The labels illustrated on pages 6 and 7 are affixed to
the chairs.
Important
The chair lock must be disengaged before
beginning to fold or unfold the chair. Pull the
lock bar forward, then begin to fold or unfold
the chair.

6© Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation ChairSafety Information
Safety and Instruction Labels (continued)
MODEL 59-T EVACUATION CHAIR LABELS
Label A
Basic Safety Guidelines and Load Limit
Label C - Instruction for Folding and Unfolding Chair
Label E - Instruction for Opening Track
Label 234-1440-00
Safety Instruction:
How to Attach
One- and Two-Piece Restraints
Label D
Safety Instruction:
Do NOT Lubricate
Track System
Label F
Instruction for
Closing Track
Label B
Instruction for Adjusting Lift Bar Height

© Ferno-Washington, Inc. 234-3298-01 October 2005 7
Models 59 and 59-T Evacuation Chair
2 - OPERATOR SKILLS ANDTRAINING
2.1 Skills
Operators using the chair need:
a working knowledge of emergency patient-
handling procedures.
the ability to assist the patient.
a complete understanding of the procedures
described in this manual.
2.2 Training
Trainees need to:
follow a training program designed by their
training officer.
read this manual. For additional free users’ manuals,
contact Ferno Customer Relations (page 34).
practice with the chair before using it in regular
service.
be tested on their understanding of the chair.
record their training information. A sample
training record sheet is provided on page 35.
Operator Skills and Training
Safety and Instruction Labels (continued)
MODEL 59 EVACUATION CHAIR LABELS
Label C - Instruction for Folding and
Unfolding Chair
Label B
Instruction for Adjusting Lift Bar Height
Label J
Basic Safety Guidelines and Load Limit
Label 234-1440-00
Safety Instruction:
How to Attach
One- and Two-Piece Restraints
Untrained operators can cause injury or be
injured. Permit only trained personnel to
operate the chair.
WARNING
!

8© Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
3 - ABOUTTHE CHAIR
3.1 Chair Description
The Model 59-T and Model 59 EZ Glide™ Evacuation
Chairs (referred to as the "chair" in this manual) are
emergency patient-handling devices designed to
transport a seated patient up and down stairs and over
flat surfaces.
The chair is for professional use by a minimum of two
trained operators. A third person to "spot" may be
required by local protocols, and additional help may
be required when working with heavy patients.
The Model 59-T is designed with belted tracks that
enable operators to "glide" the chair down stairs instead
of carrying it. The Model 59 is untracked and is carried
down stairs.
Chair features include:
• Belted track system for "gliding" chair down stairs
(Model 59-T only)
• Choice of molded ABS seat and back panels or
soft vinyl seating
• 5-position extending lift bar at rear of chair
• 5-position telescoping front lift handles
• 6" rear locking wheels
• 4" front swivel wheels
• Folding footrest
• Ankle restraint
• Multiple patient restraint options
About the Chair
Improper use of the chair can cause injury.
Use the chair only for the purpose described
in this manual.
WARNING
!
Optional Accessories:
• Rear lift handles, locking or non-locking
• IV bag holder
•O
2 bottle holder
• Headrest (head pad with strap)
• Kwik Klip™Restraint System
• Secure Mount (with spring release) for storing chair
in ambulance or station
• Bracket (with hooks) for storing chair in station
LOAD LIMIT
Inspect the chair if the load
limit has been exceeded
(see Inspecting the
Chair, page 24 ).
500 lb
227 kg
* without restraints or accessories
Some specifications are rounded to the nearest whole number.
Metric conversions are calculated before rounding the
Imperial measurements. For more information, contact Ferno
Customer Relations (page 34).
Ferno reserves the right to change specifications without
notice.
3.2 General Specifications
Height
Maximum ......................................... 63.5 in/161 cm
Minimum ............................................ 37.5 in/95 cm
Width
Overall .........................................20.313 in/51.6 cm
Seat .....................................................16.5 in /42cm
Depth (front to back, Model 59-T)
Tracks Closed, Handles Retracted ........ 28 in/73 cm
Tracks Open, Handles Extended ......... 51 in/130 cm
Depth (front to back, Model 59)
Handles Retracted ................................. 27 in/69 cm
Handles Extended ............................... 40 in/102 cm
Folded (Model 59-T)
......................................... 37.5 in x 20.313 in x 8 in
......................................... 95 cm x 51.6 cm x 20 cm
Folded (Model 59)
......................................... 37.5 in x 20.313 in x 7 in
......................................... 95 cm x 51.6 cm x 18 cm
Weight*
Model 59-T ............................................33 lb/15 kg
Model 59 ................................................ 26 lb/12 kg
Load Limit............................................500 lb/227 kg

© Ferno-Washington, Inc. 234-3298-01 October 2005 9
Models 59 and 59-T Evacuation Chair
3.3 Components - Model 59-T and Model 59
About the Chair
Components of both chair models are the same except
for those parts marked "59-T Only."
Track Belt
(2)
59-T Only
Lift Bar
Release
Track
59-T Only
Track-Closing
Handle
59-T Only
Track-Release
Bar
59-T Only
MODEL 59-T
Removable
ABS Seat Panel
with Restraint
Slots
Extending
Lift Bar
Removable
ABS Back Panel
with Restraint
Slots
Folding
Footrest
Telescoping
Lift Handle
(2)
4" Swivel
Wheel (2)
6" Wheel
with Lock
(2)
Chair
Lock Bar
Patient
Restraint
MODEL 59
Ankle
Restraint
Soft Vinyl Seating
59-T and 59
To request additional
free users' manuals,
contact Ferno Cust-
omer Relations (page
34).
USERS’MANUAL
FERNO
RESTRAINT
OPTIONS
Model 430-P
Model 430
Coated Restraint
Model 416

10 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
4 - CHAIR SETUP
Chair Setup
Figure 1 -Horizontal
Restraint
Configuration
CRISS-CROSS CONFIGURATION
Use two restraints for the torso. Ferno recommends
using a third restraint for the lap (Figure 2).
1. Attach one strap of a restraint through a vertical
slot on the backrest panel of the chair.
2. Attach the other strap of the restraint through the
seat panel slot on the opposite side of the chair.
3. Repeat with the second restraint, attaching its
straps to opposite sides of the chair.
4. Attach the lap restraint through the seat-panel
slots.
Figure 2 - Criss-
Cross Restraint
Configuration with
Lap Belt
HORIZONTAL CONFIGURATION
Use one restraint for the chest and one restraint for the
lap (Figure 1).
1. Attach the chest straps through matching
horizontal or vertical slots in the backrest panel.
2. Attach the lap straps through the seat panel slots.
4.1 Restraint Configurations for
Chair with ABS Panels
Follow local protocols when choosing a configuration.
Two possible configurations are described below.
4.2 Using One-Piece Restraints
Ferno recommends using two-piece restraints with the
backrest and seat panels, but if you choose to use one-
piece restraints, they must capture the panel and frame,
as follows:
1. Work from the patient side of the panel and feed
the ends of the restraint through the slots on
opposite sides of the panel.
2. Wrap the restraint around the chair frame,
capturing the panel and the frame (Figure 3 Top).
3. Buckle the restraint (Figure 3 Inset) and adjust
the length.
Attaching one-piece restraints improperly
can allow seat and back panels to dislodge,
resulting in injury. Restraints must capture
panels AND chair frame.
WARNING!
Figure 3 - Top: Correctly Wrapped Restraint
Inset: Restraint Fastened

© Ferno-Washington, Inc. 234-3298-01 October 2005 11
Models 59 and 59-T Evacuation Chair
4.3 Ankle Restraint
Attach the two-piece ankle restraint to the front legs of
the chair.
To attach the restraint:
1. Unbuckle the restraint to separate the straps.
2. Wrap a strap around one front leg of the chair
and thread the buckle through the loop (Figure 4).
3. Pull the strap until the looped end is tight around
the chair leg (Figure 5).
4. Attach the remaining strap to the other front leg
of the chair.
5. Buckle the restraint and adjust the length (Figure 6).
Figure 4 - Threading Buckle Through Loop
Figure 6 - Ankle Restraint Attached
Figure 7 - Torso Restraints on
Chair with Soft Vinyl Seating
Figure 5 - Tightening Strap
Chair Setup
4.4 Attaching Restraints to Chair
With Soft Vinyl Seating
With soft vinyl seating, use the criss-cross restraint
configuration plus a lap restraint (Figure 2, page 10).
Attach restraints as follows:
1. Unbuckle a restraint to separate the straps.
2. Attach the strap with the female buckle piece to
the left or right side of the backrest frame (Figure
7). Follow instructions in the restraint users'
manual for attaching a two-piece restraint.
3. Attach the strap with the male buckle piece to the
exposed area of the seat frame on the opposite
side of the chair.
4. Repeat steps 1-3 to attach the second torso
restraint.
5. Attach a lap restraint alongside the restraints already
attached to the seat frame.
6. Fasten and adjust the restraints.

12 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
5 - USINGTHE FEATURES
Using the Features
UNFOLDINGTHE CHAIR
1. Stand beside the chair and grasp the backrest with
one hand and the lock bar with the other hand.
2. Pull the lock bar forward, then pull the seat away
from the backrest until it is fully unfolded and
the lock engages.
3. Verify that the lock has engaged by holding the
backrest in place while pulling up on the chair
frame at the front of the seat without pulling the
lock bar. The chair will not fold if the lock is
engaged.
FOLDINGTHE CHAIR
1. Buckle the restraints and adjust them to prevent
interference when folding the chair.
2. Roll the chair backward a foot or two to reverse
the swivel wheels (Figure 8)
3. Stand at the side of the chair and grasp the chair
backrest with one hand and the lock bar with the
other hand (Figure 9).
4. Pull the lock bar forward, then begin folding the
seat toward the backrest.
As you fold the seat, tilt the chair forward a little
(Figure 10) to keep the front wheels turned
outward so they will not hold the frame away from
the seat and prevent the lock from engaging.
5. Press the seat against the backrest until the lock
engages (Figure 11).
6. Verify the lock is engaged by pulling the seat away
from the backrest without pulling the lock bar.
The seat will not move if the lock is engaged.
5.1 Chair Lock Bar
The red lock bar below the front edge of the seat
disengages the lock for folding and unfolding the chair.
Before seating a patient, verify that the chair is
completely unfolded and the lock is engaged.
Figure 11 -
Engaging the Lock
Figure 8 - Aligning
the Wheels
Important
The chair lock must be disengaged before
beginning to fold or unfold the chair. Pull the
lock bar forward, then begin to fold or unfold
the chair.
Figure 9 -
Disengaging the
Lock
Figure 10 -
Folding the Chair
Lock Bar

© Ferno-Washington, Inc. 234-3298-01 October 2005 13
Models 59 and 59-T Evacuation Chair
5.2 Track System - Model 59-T Only
The EZ Glide track system enables operators to glide
the chair down stairs instead of lifting and carrying it.
OPENINGTHETRACK
1. Grasp the track-release bar located near the
top of the track (Figure 12) and firmly pull it
back until the track locks into the fully extended
position.
2. Verify that the lock is engaged by trying to push
the track closed. If the lock is fully engaged the
track will not move.
CLOSINGTHETRACK
With your hand, push down on the red track-closing
handle (Figure 13) until the track closes completely.
Figure 12 - Opening the Track
Lubricating the track system can result in
injury to patient and/or operators. Never
lubricate the track or belts.
WARNING
!
Figure 13 - Closing the Track
• Using the chair on stairs requires a minimum of
two trained operators. Ferno recommends using a
third person as a "spotter" (see Gliding the Chair
Down Stairs, page 18).
• Verify that the track system is fully opened and
locked into place before using it.
• Never lubricate track belts. Lubricated track belts
can perform unpredictably, resulting in injury to
the patient and/or operators.
• Moisture, water, snow, ice, or debris on or
between the track and belts can cause irregular
track-belt performance that results in sudden
changes in the weight operators must support.
Make sure the track and track belts are clean and
dry before using the chair on stairs.
• Water, snow, ice, or debris on the stairs can cause
poor footing for operators. To avoid possible
injury, clear the stairs or select an alternate route.
GUIDELINES FOR USINGTHETRACK SYSTEM
Using the chair with the track unlocked can
cause injury. Verify that the track is locked
before transporting the patient.
WARNING
!
Using the Features

14 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
5.3 Extending Lift Bar
Grasp the lift bar to move and guide the chair as you
glide it down stairs, carry it up stairs or over obstacles,
and roll it.
The lift bar adjusts to five locked positions (Figure 14,
Left). Adjust the height according to operator preference
and the task or situation at hand.
EXTENDING AND RETRACTINGTHE LIFT BAR
1. With one hand, squeeze the lift-bar release tabs
together and with the other hand grasp the lift bar
and raise or lower it (Figure 14, Inset).
2. Verify that the lift bar is locked by trying to raise
or lower it without squeezing the release tabs.
When the lock is engaged the lift bar will not
move.
Figure 15 - Right: Lift-Handle Positions
Inset: Extending/Retracting a Lift Handle
5.4 Telescoping Lift Handles
The telescoping lift handles can be adjusted to five
locked lifting positions (Figure 15, Right). Adjust the
handles according to operator preference and the task
at hand.
EXTENDING AND RETRACTINGTHE LIFT
HANDLES
1. Press the release button (Figure 15, Inset) and
push or pull the handle until it is near the stop
point desired.
2. Release the button and slide the handle a little
forward or backward until it locks into the stop
point.
3. Verify that both handles are locked by trying to
push or pull them without pressing the release
buttons. When the locks are engaged, the handles
will not move.
Figure 14 - Left: Lift-Bar Positions
Inset: Adjusting Lift- Bar Height
Using the Features
2
1
2
1

© Ferno-Washington, Inc. 234-3298-01 October 2005 15
Models 59 and 59-T Evacuation Chair
5.5 Footrest
The footrest has two positions: raised, for storage,
(Figure 16) and lowered for use (Figure 17).
To lower the footrest, swing it down until it stops.
To raise the footrest, swing it up until it stops.
Figure 16 - Footrest
Raised for Storage
5.6 Wheel Locks
The rear wheels of the chair are fitted with wheel locks
to help keep the chair from rolling during patient
transfer.
Stay with the chair and maintain control of it at all times.
Do not use the wheel locks as a substitute for operator
control.
To engage a wheel lock, press down on the rear end of
the lock pedal (Figure 18).
To disengage a wheellock, press down on the forward
end of the lock pedal (Figure 19).
Using the Features
GUIDELINES FOR USINGTHE FOOTREST
Use the footrest properly to ensure that is does not
interfere with patient's or operators' feet.
• Before transferring the patient onto the chair,
make sure the footrest is raised in the storage
position.
• When preparing to transfer the patient off the
chair, unfasten the ankle restraint and raise the
footrest into the storage position before
unfastening the patient's torso and lap restraints.
This will prevent the patient from attempting to
stand before the footrest has been stored out of the
way of his/her feet.
• Keep the footrest raised when it is not in use.
Figure 19 - Wheel
Lock Disengaged
Figure 18 - Wheel
Lock Engaged
Important
Raise the footrest into the storage position
before transferring the patient onto or off from
the chair.
Figure 17 - Footrest
Lowered for Use

16 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
6 - USINGTHE CHAIR
6.1 Before Placing the Chair
in Service
Personnel who will work with the chair need to
read this manual.
Set up the chair, following instructions in Chair
Setup (see Pages 10, 11).
Confirm that the chair operates properly. Follow
instructions in Inspecting the Chair, page 24.
6.2 General Guidelines for Use
• Using the chair requires a minimum of two trained
operators.
• Ferno recommends that a third trained person
serve as a "spotter" while the chair is being moved
up or down stairs.
• Operators may need help when working with
heavy loads (patient and equipment). See Using
Additional Help,page 22, for recommended
placement of operators and helpers.
• Operators work together at all times.
Communicate with one another and coordinate
your actions to operate the chair.
• Follow standard emergency patient-handling
procedures when operating the chair.
• Stay with the patient at all times.
• Always use patient restraints.
An unrestrained patient can fall off the chair
and be injured. Use restraints to secure the
patient on the chair.
WARNING
!
An unattended patient can be injured. Stay
with the patient at all times.
WARNING
!
Improper operation can cause injury. Operate
the chair only as described in this manual.
WARNING!
Using the Chair

© Ferno-Washington, Inc. 234-3298-01 October 2005 17
Models 59 and 59-T Evacuation Chair Using the Chair
6.3 Transferring the Patient
Always assist the patient onto and off from the chair.
6.4 Rolling the Chair
Figure 20 -
Patient Secured
in Chair with
Restraints
Figure 21 -
Rolling the Chair
Figure 22 - Gliding the Chair Down a
Curb
TO ROLLTHE CHAIR
1. Head-End Operator: Release the wheel locks.
2. Head-end Operator: Adjust the lift bar to a
comfortable height and grasp it to push and guide
the chair on all four wheels (Figure 21), or tilt
the chair back and roll it on its rear wheels.
2. Foot-end Operator:Assist the head-end operator
as needed and attend the patient.
GENERAL GUIDELINES
• Roll the chair on smooth, flat surfaces whenever
possible (Figure 21).
• For patient comfort, pull the chair backward over
low obstacles such as door sills.
• Use the extending lift bar and telescoping foot-end
handles to lift and carry the Model 59 chair over
curbs, obstacles, rough surfaces and rough terrain.
• Use the tracks on the Model 59-T chair to "glide"
the chair down over curbs or single steps (Figure 22).
ASSISTINGTHE PATIENT OFF FROMTHE CHAIR
1. Unfasten the ankle restraint.
2. Raise the footrest to the storage position.
3. Unfasten the torso and lap restraints.
4. Assist the patient off from the chair using accepted
practices and following local protocols.
1. Unfold the chair and verify that it is locked.
2. Engage the locks on the rear wheels.
3. Make sure the footrest is in the storage position.
4. Assist the patient onto the chair using accepted
practices and following local protocols.
5. Fasten and adjust the torso and lap restraints.
6. Lower the footrest and place the patient's feet on
it.
7. Fasten and adjust the ankle restraint.
ASSISTINGTHE PATIENT ONTOTHE CHAIR

18 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation Chair
Using the Chair
6.5 Gliding the Chair Down Stairs -
Model 59-T Only
GENERAL GUIDELINES
• Using the chair on stairs requires a minimum of two
operators. Use additional help as needed to control
the chair (see Using Additional Help, page 22).
• Ferno recommends that the two operators face
each other when transporting a patient down stairs
and that a third trained person “spot” for the foot-
end operator. However, the foot-end operator may
face forward (with back to patient) if desired.
Follow your local protocols for carrying chairs.
• Remove any water, ice, snow, or debris from the
stairs before using the chair on them.
• Remove any water, ice, snow, or debris from the
track and tread belts before using the chair on stairs.
• Verify that the track is locked in the open position
before starting down the stairs with the chair.
GLIDINGTHE CHAIR DOWN STAIRS
1. Head-End Operator: Roll the chair to the stairs
and engage the wheel locks.
2. Foot-End Operator: Extend the foot-end lift
handles to the desired stop point. Verify that both
handles are locked.
3. Spotter: Stand below the foot-end operator with
a hand on the operator's back to help steady and
guide him/her throughout the descent.
4. Head-End Operator: Pull the track system toward
yourself until the track locks open. Verify that
the track is locked.
5. Head-End Operator: Raise the lift bar to the desired
position and verify that it is locked (Figure 23).
6.Head-End Operator: Disengage the wheel locks
(Figure 23) and tilt the chair back.
7. Both Operators: Working together, guide the
chair over the edge of the top step, allowing the
track belts to engage the step (Figure 24).
Lubricating the track system can result in
injury to patient and/or operators. Never
lubricate the track or belts.
WARNING!
Using the chair with the track unlocked can
cause injury. Verify that the track is locked
before transporting the patient.
WARNING
!
Figure 23 - Preparing Model 59-T
for the Descent
Figure 24 - Track Belts Engaging Top Step

© Ferno-Washington, Inc. 234-3298-01 October 2005 19
Models 59 and 59-T Evacuation Chair Using the Chair
8. Move the chair slowly downward until the tracks
are resting on the top two or three steps. This
establishes the glide angle (Figure 25).
9. To maintain the glide angle as you descend, work
together as follows:
• The head-end operator applies slight
downward pressure on the extended lift bar.
•The foot-end operator applies slight upward
pressure on the foot-end lift handles.
10. Both Operators:When the chair reaches the
bottom of the steps and the rear wheels are on the
floor, the head-end operator tips the chair forward
until all four wheels are on the floor and the foot-
end operator retracts the lift handles (Figure 26).
11. Head-End Operator: Close the tracks and adjust
the lift bar to a comfortable height, then roll the
chair.
Figure 25 - Establishing the Glide Angle
To pause during the descent, tilt the chair forward
just enough to allow the rear wheels to rest on the
step while both operators hold the chair in place
(Figure 27).
To continue down the stairs, tilt the chair back to
the glide angle and engage the belts on the steps.
TO PAUSE DURINGTHE DESCENT
Figure 26 - Preparing to Roll the Chair
Figure 27 - Pausing on the Stairs

20 © Ferno-Washington, Inc. 234-3298-01 October 2005
Models 59 and 59-T Evacuation ChairUsing the Chair
GENERAL GUIDELINES
• Carrying the chair down stairs requires a
minimum of two operators. Use additional help
as needed (see Using Additional Help, page 22).
• Ferno recommends that the two operators face
each other when transporting a patient down stairs
and that a third person “spot” for the foot-end
operator. However, the foot-end operator may face
forward (with back to patient) if desired. Follow
your local protocols for carrying chairs.
6.6 Transporting the Patient
Down Stairs - Model 59 Only
CARRYINGTHE CHAIR DOWN STAIRS
1. Head-End Operator: Roll the chair to the stairs
and engage the wheel locks.
2. Foot-End Operator: Extend the foot-end lift
handles to the desired stop point. Verify that both
handles are locked and maintain your grasp.
3. Spotter: Stand below the foot-end operator with
a hand on the operator's back to help steady and
guide him/her throughout the descent.
4. Head-End Operator: Raise the lift bar to the desired
position and verify that it is locked.
5.Head-End Operator: Disengage the wheel locks
and tilt the chair back.
6. Operators and Spotter: Operators work together
to lift the chair and carry it down the stairs. The
spotter keeps a hand on the foot-end operator's
back and provides verbal guidance (Figure 28).
Note:To pause during the descent, allow the rear
wheels of the chair to rest on a step while both
operators hold the chair in place (Figure 29). To
continue down the stairs, tilt the chair back and lift
and carry it.
8. Operators: At the bottom of the stairs, the
operators set the chair on the floor and retract the
lift handles.
9. Head-End Operator: Adjust the lift bar to a
comfortable height before rolling the chair.
Figure 28 -Carrying the
Model 59 Chair Down Stairs
Figure 29 -Pausing on the Stairs - Model 59
Chair