Goldmedal Dogeroo User manual

Part No. 87793EX
Instruction Manual
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
Dogeroo, Super Dogeroo,
and Mini Dogeroo
Model No. 8102EX, 8103EX, 8108EX

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 2
gmpopcorn.com
SAFETY PRECAUTIONS

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 3
gmpopcorn.com
INSTALLATION INSTRUCTIONS
Inspection of Shipment
After unpacking, check thoroughly for any damage which may have occurred in transit. Claims
should be filed immediately with the transportation company. The warranty does not cover
damage that occurs in transit, or damage caused by abuse, or consequential damage due to the
operation of this machine, since it is beyond our control.
Setup
1. Your machine is fully assembled and tested at the factory. Carefully remove the
machine from the shipping cartons. emove all packing material and tape.
2. If the optional sneeze guard has been purchased, place it over the corner posts.
3. Be sure to place your Dogeroo where the revolving hot dogs will attract the most
attention.
Accessories Included With Your Machine
1 inch Dial Thermometer
9 inch Plastic Tongs

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 4
gmpopcorn.com
Electrical Requirements
The following power supply must be provided:
8102EX: 230Volts, 1495 Watts, 50Hz.
8103EX: 230Volts, 1748 Watts, 50Hz.
8108EX: 230Volts, 1035 Watts, 50Hz.
DANGER
Machine must be properly grounded to prevent electrical
shock to personnel. Failure to do so could result in serious
injury, or death.
Do NOT immerse any part of this equipment in water.
Do NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from
moisture.
Always unplug the equipment before cleaning or servicing.
Your electrician must furnish sufficient power for proper machine operation. We recommend
this equipment be on a dedicated and protected circuit. Failure to wire properly will void the
warranty and may result in damage to the machine. It is Gold Medal Products Company’s
recommendation that this machine be plugged directly into a wall outlet. The use of extension
cords is not recommended due to safety concerns, and may cause sacrificed and/or reduced
performance.
Before You Plug In Machine
1. Make sure all machine switches are in the OFF position before plugging the equipment
into the receptacle.
2. Make sure the wall outlet can accept the grounded plugs (where applicable) on the
power supply cord.
3. The wall outlet must have the proper polarity. If in doubt, have a competent
electrician inspect the outlet and correct if necessary.
4. DO NOT use a grounded to un-grounded receptacle adapter.
5. Install the unit in a level position.

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 5
gmpopcorn.com
OPERATING INSTRUCTIONS
Controls and Their Functions
ON/OFF S ITCH
Flipping the lever of this switch to the "ON" position will energize the drive motor which
rotates the rotisserie. It also lights the bulb behind the front glass and completes the
circuit to the heat control.
HEAT CONTROL
The infinite heat control allows you to vary the operating temperature of the heating
element. When this control is in any position other that "OFF", the red pilot light will be
on. When the control is set at the "HI" position, the heating element is energized
continually.
On/Off switch
Heat Control

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 6
gmpopcorn.com
Specifications for Each Machine
Dogeroo
Model 8102
Super Dogeroo
Model 8103
Mini Dogeroo
Model 8108
Hot Dogs 56 84 14
Buns 28 42 14
Operating Procedure
1. Pour 1 ½ quarts of water into the water pan (about 5/8" deep). This will keep the
buns moist and warm. Use hot water to speed the process. Do NOT overfill! Overfilling
will result in too much steam.
2. Place buns in the bun warmer basket.
3. Note: Some buns collect more moisture than others due to their texture.
4. Place the hot dogs on the rotisserie.
5. When ready to start cooking, move the toggle switch to the "ON" position. This will
rotate the rotisserie clockwise and light the bulb behind the silk screened sign.
6. The time required to broil the hot dogs will vary, depending upon size and
temperature (35-37° F refrigerated) of the hot dogs when placed in the Dogeroo.
With the heat control set on "HI" and using average size hot dogs, it will take from 10-15 minutes
to have the hot dogs ready for 145° F cook temperature. Watch the dogs carefully the first
several times you cook to avoid blistering or burning the hot dogs.
After the hot dogs are cooked, reduce the heat control setting to one which will keep the hot dogs
at the 140° F minimum serving temperature. Hot dogs can be kept on the rotisserie for several
hours without shriveling or loss of flavor, if the heat control is properly set.

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 7
gmpopcorn.com
CARE AND CLEANING
DANGER
Machine must be properly grounded to prevent electrical
shock to personnel.
DO NOT immerse in water.
Always unplug the equipment before cleaning or servicing.
Good sanitation practice demands that all food preparation equipment be cleaned regularly. A
clean looking, well-kept machine is one of the best ways of advertising your product.
The Dogeroo, Super Dogeroo, and Mini Dogeroo have been designed to disassemble quickly,
without the use of special tools, for easy cleaning.
1. Disconnect power supply cord. Be sure unit has cooled sufficiently to permit safe
handling.
2. emove the condensate pan and basket from the bun warmer.
3. emove the door from the bun warmer by sliding the pivot pin to the left or the right
to disengage.
4. Lift the bun warmer from the top of the top frame assembly. Lift out the water pan
from the top frame assembly.
5. Lift the power assembly from frame. This assembly must be cleaned by wiping with a
damp cloth.
6. Lift the left end of the rotisserie from the end support. Slide rotisserie to left and
disengage from motor coupling.
7. Lift out the drip pan. Slide the front and side glass upward in the slots designed in the
corner posts for glass removal.
8. All parts (except power assembly) may be immersed or flooded with water for
cleaning. Use a cleanser/sanitizer recommended or approved by your local Board of
Health. Wipe all parts dry.
9. eassemble in reverse order.

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 8
gmpopcorn.com
Care and Cleaning – Pan and Rotisserie Removal/Reassembly
Lift the left end of
the rotisserie from
the end support.
Slide rotisserie
to left
and disengage from
motor coupling.
Condensate
Pan and
Basket
ater Pan
Lift Power Assembly
from frame.
Bun armer
Removing/Reassembly of Pans
Removing
/Reassembly of
Power Assembly
Removing
/Reassembly of
Rotisserie

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 9
gmpopcorn.com
TROUBLESHOOTING
Hot Dogs are Dropping from the Cradle
The rotisserie cradle is bent. Be careful removing and reinstalling the cradles. Bent cradles will
not pivot freely in the rotisserie and can allow hot dogs to drop out as the unit rotates.
REPLACING BROKEN GLASS
If you accidentally break a panel of glass, it can be replaced very easily.
Note: Gold Medal Products Co. does NOT ship glass. Obtain replacement glass from
your local hardware store and always purchase double strength type glass.
1. emove all loose pieces of glass.
2. emove all rigid glass channels from around the glass to be replaced. Set it aside as it
must be reused.
3. Carefully remove the rest of the broken glass.
4. Apply decals (if desired) to the new glass panel.
5. Slide rigid glass channels over the exposed sides and bottom. Front and side glass slide
under top and is then lowered into bottom channel.
Glass Dimensions
Side Glass: 1/8" x 11 29/32" x 16 3/16 (All Models)
Front Glass: 1/8" x 13 29/32" x 16 3/16 (Model 8102 Dogeroo)
1/8" x 19 29/32" x 16 3/16 (Model 8103 Super Dogeroo)
1/8" x 8 29/32" x 16 3/16 (Model 8108 Mini Dogeroo)
Slide Glass Under Top
Lower Glass into Bottom channel

Dogeroo, Super Dogeroo
and Mini Dogeroo Model No. 8102EX, 8103EX, 8108EX
Page 10
gmpopcorn.com
MAINTENANCE INSTRUCTIONS
DANGER
Improper installation, adjustment, alteration, service, or
maintenance can cause property damage, injury or death.
Read the installation, Operating, and Maintenance
Instructions thoroughly before installing or servicing this
equipment.
DANGER
Do Not immerse the equipment in water. Unplug your
machine before servicing.
WARNING
Adequate eye protection must be used when servicing this
equipment to prevent eye injury.
CAUTION
THE FOLLOWING SECTIONS OF THIS MANUAL ARE
INTENDED ONLY FOR QUALIFIED SERVICE
PERSONNEL WHO ARE FAMILIAR WITH ELECTRICAL
EQUIPMENT. THESE ARE NOT INTENDED FOR THE
OPERATOR.