Goldmedal 5554 User manual

Part No. 39792
Pizza Oven
Models 5554 & 5554EX
Instruction Manual

Model 5554 & 5554EX
2
SAFETY PRECAUTIONS
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle. Keep cord and plug off the ground and away
from moisture. Always unplug the equipment before cleaning or servicing.
DO NOT immerse any part of this equipment in water.
DO NOT use a water jet or excessive water when cleaning. 008_012221
DANGER
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
014_020416
WARNING
ALWAYS wear safety glasses when servicing this equipment.
010_010914
WARNING
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514
WARNING
Read and understand operator’s manual and all other safety instructions
before using this equipment. To order copies of the operator’s manual go to
gmpopcorn.com or write to Gold Medal Products Co., 10700 Medallion Drive,
Cincinnati, OH 45241 USA 1-(800)-543-0862
022_060215
WARNING
DO NOT allow direct contact of this equipment by the public when used in
food service locations. Only personnel trained and experienced in the
equipment operation may operate this equipment.
Carefully read all instructions before operation.
012_010914

Model 5554 & 5554EX
3
WARNING
This machine is NOT to be operated by minors.
007_010914
CAUTION
If the supply cord is damaged, it must be replaced by Gold Medal Products Co.,
its service agent or similarly qualified persons in order to avoid a hazard.
039_080614
This appliance is not intended for use by persons (including children) with reduced physical,
sensory or mental capabilities, or lack of experience and knowledge, unless they have been
given supervision or instruction concerning use of the appliance by a person responsible for
their safety.
DO NOT install equipment in an area where a water jet is used.
Unit to be installed in locations where ambient temperatures are between a minimum of 5°C
(41°F) and a maximum of 55°C (131°F).
Unit to be installed in locations where it can be overseen by trained personnel.
Install unit on a level surface.
Unit is a pizza oven.
Note: Improvements are always being made to Gold Medal’s equipment. This information
may not be the latest available for your purposes. It is critical that you call Gold
Medal’s Technical Service Department at 1-800-543-0862 for any questions about
your machine operations, replacement parts, or any service questions. (Gold Medal
Products Co. does not assume any liability for injury due to careless handling and/or
reckless operation of this equipment.) General images may be used in manual for
reference only.

Model 5554 & 5554EX
4
Installation Instructions
Inspection of Shipment:
After unpacking, check thoroughly for any damage which may have occurred in transit. Claims should
be filed immediately with the transportation company. The warranty does not cover damage that
occurs in transit, or damage caused by abuse, or consequential damage due to the operation of this
machine, since it is beyond our control (reference warranty in back of manual).
Setup:
Your Pizza Oven was assembled and tested at the factory. Remove all packing material
and tape before starting operation.
Electrical Requirements:
The following power supply must be provided (reference unit Data Plate for Wattage requirement):
120 V~, 60 Hz
220-230 V~, 50/60 Hz
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle. Keep cord and plug off the ground and away
from moisture. Always unplug the equipment before cleaning or servicing.
DO NOT immerse any part of this equipment in water.
DO NOT use a water jet or excessive water when cleaning. 008_012221
A certified electrician must furnish sufficient power for proper machine operation and install any
supplied receptacle (reference unit Data Plate for model specific Volts AC, Hertz, and Wattage
requirements). We recommend this equipment be on a dedicated and protected circuit. Failure to
wire properly will void the warranty and may result in damage to the machine. It is Gold Medal
Products Co.’s recommendation that this machine be plugged directly into a wall outlet. The use of
extension cords is not recommended due to safety concerns, and may cause sacrificed and/or
reduced performance. Make sure cord is located to prevent a trip hazard or unit upset.
Before You Plug In Machine
1. Make sure all machine switches are OFF before plugging equipment into receptacle.
2. Make sure wall outlet can accept the grounded plugs (where applicable) on the power
supply cord.
3. The wall outlet must have the proper polarity. If in doubt, have a competent electrician
inspect the outlet and correct if necessary.
4. DO NOT use a grounded to un-grounded receptacle adapter (where applicable).
5. Install unit in a level position.
CAUTION
If the supply cord is damaged, it must be replaced by Gold Medal Products Co.,
its service agent or similarly qualified persons in order to avoid a hazard.
039_080614

Model 5554 & 5554EX
5
Operating Instructions
Controls And Their Functions
On/Off Switch
Flipping this switch to the "ON" position energizes the machine turning on the fan motor
and the heat elements.
Malfunction Light
If the malfunction light goes on, the appliance is malfunctioning.
TURN OFF OR DISCONNECT THE MACHINE FROM THE POWER SUPPLY AND
HAVE IT SERVICED BY A QUALIFIED TECHNICIAN.
Start Button
This button starts the count-down sequence on the digital control.
Mode Button
Changes the mode from time setting, to temperature setting, to viewing the current
temperature.
Up Button
Depressing the button increases the time or temperature accordingly.
Down Button
Depressing the button decreases the time or temperature accordingly
Start
Button
On/Off
Switch
Mode
Button
Malfunction
Light
Up and Down
Buttons

Model 5554 & 5554EX
6
EASY STEPS FOR USING UNIT
1. Prepare the oven for operation
a. Place the stone at the desired level. IF BEING USED FOR THE FIRST TIME, THE STONE
MUST BE PRE-DRIED. THIS IS A ONE TIME ONLY PROCEDURE WHEN A STONE IS NEW
OUT OF THE BOX. PLEASE FOLLOW THE INSTRUCTIONS BELOW FOR THE
PROCEDURE:
1. Place the stone on the baking pan in the center position of the oven.
2. Set the oven at 200°. Leave at 200 for 2 hours.
3. Set the oven at 300°. Leave at 300 for 2 hours.
4. Set the oven at 400°. Leave at 400 for 1 hour.
5. Set the oven at 450°. Leave at 450 for 1 hour.
CAUTION: a slight odor & outgassing may occur during the initial heat up. This is normal
as the decks are adjusting to their environment.
b. Turn on the power switch
c. Depress the mode button to time setting and enter the time using the up and down buttons.
d. Depress the mode button to temperature setting and enter the setting with the up and down
buttons.
e. When the oven reaches 200°F the L.E.D. will show the temperature.
f. Using oven mitts, load the food product into the oven when it reaches the desired temperature.
g. Depress the start button to display the count-down sequence.
h. When the control beeps the cook cycle is complete. Carefully remove the food product using
oven mitts.
i. Repeat steps F thru H for additional cycles.
DO NOT BAKE FROZEN PRODUCTS ON THE PIZZA STONE.
DOING SO MAY CAUSE THE STONE TO SHATTER!
FOR FROZEN PRODUCTS, PLEASE REMOVE THE STONE AND USE
THE ALUMINUM BAKING PAN ONLY.

Model 5554 & 5554EX
7
CARE AND CLEANING
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
DO NOT immerse in water. DO NOT clean appliance with a water jet or steam
cleaner. Always unplug the equipment before cleaning or servicing. 025_051321
WARNING
To avoid burns, DO NOT touch heated surfaces.
DO NOT place or leave objects in contact with heated surfaces.
009_092414
Good sanitation practice demands that all food preparation equipment be cleaned regularly (only use
non-toxic, food grade cleaners).
For any cleaning products used, follow the manufacturer’s instructions on the product. DO NOT use
oven cleaners or abrasive materials as they will damage parts of machine.
The stainless steel body of the Warmer can be kept clean with cleaner designed for stainless
steel and a clean cloth. We recommend Gold Medal Products Company’s Watchdog
Stainless Steel Polish (P/N 2088.)

Model 5554 & 5554EX
8
THE FOLLOWING SECTIONS ARE FOR QUALIFIED SERVICE PERSONNEL ONLY
MAINTENANCE INSTRUCTIONS
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle. Keep cord and plug off the ground and away
from moisture. Always unplug the equipment before cleaning or servicing.
DO NOT immerse any part of this equipment in water.
DO NOT use a water jet or excessive water when cleaning. 008_012221
DANGER
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
014_020416
WARNING
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514
CAUTION
THE FOLLOWING SECTIONS OF THIS MANUAL ARE INTENDED ONLY
FOR QUALIFIED SERVICE PERSONNEL WHO ARE FAMILIAR WITH
ELECTRICAL EQUIPMENT. THESE ARE NOT INTENDED FOR THE
OPERATOR.
027_010914

Model 5554 & 5554EX
9
ORDERING SPARE PARTS
1. Identify the needed part by checking it against the photos, illustrations, and/or
parts list. (General images may be used in manual for reference only.)
2. Use only approved replacement parts when servicing this unit.
3. When ordering, please include part number, part name, and quantity needed.
4. Please include your model number, serial number, and date of manufacture (located on
the machine nameplate/data plate) with your order.
5. Address all parts orders to Parts Department, Gold Medal Products Co., 10700 Medallion
Drive, Cincinnati, Ohio 45241-4807
or place orders by phone or online:
Phone: [phone]
[phone]
Fax: [phone]
[phone]
E-mail: [e-mail]
Web Page: gmpopcorn.com

Model 5554 & 5554EX
10
Item Part No. Description
139797 Oven Front Door Weldment
240807 Handle
342798 Switch, Lighted Rocker Green
441031 Switch, Oil Pump
541033 Pilot Light, 125V Red
647155 Rubber Feet 3/4" High
776540A Digital Baker Control
839794 Baking Pan
943288 Bottom Element (500 Watts)
10 50017 Top Element (900 Watts)
11 39790 Pizza Stone (Not Shown)
1
2
3
4
5
6
9
8
7