Goldmedal 2408 User manual

Part No. 59410
FUN POP
8 OZ. POPPER
Instruction Manual
Model #2408
Shown here on Model #2689CR Cart (Optional)
Cincinnati, OH 45241-4807 USA
www.food-service.com.ua
A-PDF Watermark DEMO: Purchase from www.A-PDF.com to remove the watermark

SAFETY PRECAUTIONS
www.food-service.com.ua

Popcorn Machine
3Model# 2408
Installation Instructions
Inspection of Shipment:
Unpack all cartons and check thoroughly for any damage that may have occurred during transit.
Damage claims should be filed immediately with the transportation company. Gold Medal Products
is not responsible for damage that occurs in transit.
Setup:
Your new Popper is completely assembled and tested at the factory.
Remove all packing material and tape before starting operation.
Electrical Requirements:
The following power supply must be provided:
120 Volt, 60 Cycle, single phase
Your electrician must furnish sufficient power for proper machine operation. We recommend this
popper be on a dedicated and protected circuit. Failure to wire properly will void the warranty and
may result in damage to the machine.
It is Gold Medal Products Company’s recommendation that this machine be plugged directly into a
wall outlet. The use of extension cords is not recommended due to safety concerns, and may cause
sacrificed and/or reduced performance.
Before You Plug In Machine:
1. Make sure the wall outlet can accept the grounded plugs (where applicable) on the power supply
cord.
2. The wall outlet must have the proper polarity. If in doubt, have a competent electrician inspect the
outlet and correct if necessary.
3. DO NOT use a grounded to un-grounded receptacle adapter.
www.food-service.com.ua

Popcorn Machine
4Model# 2408
Popping Instructions
Controls and their Functions
There are three switches on the popper.
Light and Warmer Switch
Turns on heat to bottom corn pan and light.
Kettle Motor switch
Turns on motor which drives kettle agitator shaft.
Kettle Heat Switch
Turns on heat element.
1. Turn kettle heat and kettle motor switch "ON."
2. Make test pop with 3 kernels of corn and 30ml of oil.
3. Load pre-measured popcorn and oil pouch into kettle.
4. When corn has finished popping, dump kettle.
5. Repeat cycle starting with #3; always pop 3 to 5 batches for best popcorn.
Amount of Popcorn and Oil
Your new popper is equipped with a 178ml corn measure cup. Popcorn popped in coconut oil
stays fresher longer. Coconut oil does not leave black deposits in your kettle like other oils.
Corn charge - 8 oz. (240 ml)
Oil charge – 2.6 oz. (60 ml)
Flavacol – 1 tablespoon (8 cc)
www.food-service.com.ua

Popcorn Machine
5Model# 2408
Care and Cleaning
Each time you finish a series of poppings, wipe the outside of the kettle with a soft cloth to remove
any oil drippage on the outside of the kettle. After you finish popping for the day, allow kettle to
cool until it is not too hot to handle, but still warm. Unplug kettle and remove it from the machine.
With a cloth, wipe out the inside of the kettle, kettle lid, crossbar, outside and underneath of the
kettle.
Cleaning the cabinet of your machine is easy. Take a clean cloth and wipe excess grease from
the glass. Wipe the outside of the machine also.
NOTE: Never use a glass or plastic cleaner that contains ammonia. It will crack the plastic on the
machine.
www.food-service.com.ua

MAINTENANCE INSTRUCTIONS
www.food-service.com.ua

ORDERING SPARE PARTS
* Always speak to a Gold Medal Products Technical Service Advisor before
ordering any parts to help ensure accuracy for your product. Included
diagrams may not be the latest information.
1. Identify the needed part by checking it against the photos, illustrations, and/or parts list.
2. When ordering, please include part number, part name, and quantity needed.
3. Please include your model name, serial number, and date of manufacture (located on
the machine nameplate) with your order.
4. Address all parts orders to:
Parts Department
Gold Medal Products Co.
10700 Medallion Drive
Cincinnati, Ohio 45241-4807
Or, place orders by phone or online:
[phone]
[phone]
Fax: [phone]
E-mail: [email protected]
Web Page: www.gmpopcorn.com
www.food-service.com.ua

Popcorn Machine
8Model# 2408
Cabinet Assembly
5
4
2
1
8
9
6
3
7
www.food-service.com.ua

Popcorn Machine
9Model# 2408
Cabinet - Interior Roof
14
12
13
11
10
www.food-service.com.ua

Popcorn Machine
10 Model# 2408
Interior Cabinet (Top)
20
19
16
15
18
14
21
17
13
www.food-service.com.ua