Goldmedal Fun Pop 8 Oz. Popper User manual

Part No.59410
Instruction Manual
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
Fun Pop 8 Oz. Popper
Model No. 2408, 2408EX
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 2
www.gmpopcorn.com
SAFETY PRECAUTIONS
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 3
www.gmpopcorn.com
INSTALLATION INSTRUCTIONS
Inspection of Shipment
Unpack all cartons and check thoroughly for any damage that may have occurred during transit.
Damage claims should be filed immediately with the transportation company.
Setup
Your new Popper is completely assembled and tested at the factory. Remove all packing material
and tape before starting operation.
Electrical Requirements
The following power supply must be provided:
2408:120Volts, 60 Cycle, 1053W
2408EX: 230V, 50 Cycle, 1053W
DANGER
Machine must be properly grounded to prevent electrical
shock to personnel. Failure to do so could result in serious
injury, or death.
Do NOT immerse any part of this equipment in water.
Do NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from
moisture.
Always unplug the equipment before cleaning or servicing.
Your electrician must furnish sufficient power for proper machine operation. We recommend
this steamer be on a dedicated and protected circuit. Failure to wire properly will void the
warranty and may result in damage to the machine. It is Gold Medal Products Company’s
recommendation that this machine be plugged directly into a wall outlet. The use of extension
cords is not recommended due to safety concerns, and may cause sacrificed and/or reduced
performance.
Before You Plug In Machine
1. Make sure the wall outlet can accept the grounded plugs (where applicable) on the power
supply cord.
2. The wall outlet must have the proper polarity. If in doubt, have a competent electrician
inspect the outlet and correct if necessary.
3. DO NOT use a grounded to un-grounded receptacle adapter.
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 4
www.gmpopcorn.com
OPERATING INSTRUCTIONS
Controls and Their Functions
LIGHT/WARMER SWITCH
This switch heats the bottom of the corn pan and turns on the light.
KETTLE MOTOR SWITCH
This switch turns on the motor which drives the kettle agitator shaft.
KETTLE HEAT SWITCH
This switch turns on the heat element.
Amount of Popcorn and Oil
Your new popper is equipped with a corn measure cup. Popcorn popped in coconut oil stays
fresher longer. Coconut oil does not leave black deposits in your kettle like other oils.
Corn charge: 8 oz.
Oil charge: 2.6 oz.
Flavacol: 1 tablespoon
8 Oz. Accessory Pack
Part No. 2071: Scoop
Part No. 47174: Measure Cup
Part No. 47150: Oil Measure Cup
Part No. 47678: Flavacol Measure
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 5
www.gmpopcorn.com
CARE AND CLEANING
1. Each time you finish a series of popping, wipe the outside of the kettle with a soft cloth to
remove any oil drippings on the outside of the kettle.
2. After you finish popping for the day, allow kettle to cool until it is not too hot to handle,
but still warm.
3. Unplug kettle and remove it from the machine.
4. With a cloth, wipe out the inside of the kettle, kettle lid, crossbar, outside and underneath
of the kettle.
DO NOT place the kettle in water. This will cause damage to the electrical components
and will void your warranty.
5. Cleaning the cabinet of your machine is easy. Take a clean cloth and wipe excess grease
from the glass. Wipe the outside of the machine also.
NOTE: Never use a glass or plastic cleaner that contains ammonia. It will crack the plastic on the
machine.
DANGER
Machine must be properly grounded to prevent electrical
shock to personnel.
DO NOT immerse in water.
Always unplug the equipment before cleaning or servicing.
Good sanitation practice demands that all food cooking equipment be cleaned regularly. A clean
looking, well-kept machine is one of the best ways of advertising your product.
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 6
www.gmpopcorn.com
MAINTENANCE INSTRUCTIONS
DANGER
Do NOT immerse the equipment in water.
Unplug your machine before servicing.
WARNING
Adequate eye protection must be used when servicing this
equipment to prevent eye injury.
CAUTION
THE FOLLOWING SECTIONS OF THIS MANUAL ARE
INTENDED ONLY FOR QUALIFIED SERVICE
PERSONNEL WHO ARE FAMILIAR WITH ELECTRICAL
EQUIPMENT. THESE ARE NOT INTENDED FOR THE
OPERATOR.
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 7
www.gmpopcorn.com
ORDERING SPARE PARTS
1. Identify the needed part by checking it against the photos, illustrations, and/or
parts list.
2. When ordering, please include part number, part name, and quantity needed.
3. Please include your model number, serial number, and date of manufacture (located
on the machine nameplate) with your order.
4. Address all parts orders to:
Parts Department
Gold Medal Products Co.
10700 Medallion Drive
Cincinnati, Ohio 45241-4807
Or, place orders by phone or online:
Phone: [phone]
[phone]
Fax: [phone]
[phone]
E-mail: [email protected]
Web Page: www.gmpopcorn.com
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 8
www.gmpopcorn.com
Cabinet Exterior
Item Part No. Model(s) Part Description Qty.
122038 ALL LEAD-IN CORD ASSEMBLY 1
255060 ALL TOP HINGE BRACKET 1
355061 ALL BOTTOM HINGE BRACKET 1
458104 ALL TOP DOME ASSEMBLY 1
558101 ALL DOME COVER 1
647120 ALL KNOB LID LEFT 2
755104 ALL LATCH CATCH 1
858065 ALL DOOR ASSEMBLY (includes item no. 2) 1
958113 ALL DROP PANEL 1
10 50013 ALL MAGNET 1
11 20066 ALL SCREW (for knob) 1
12 76026 ALL STRAIN RELIEF 1
13 87247 ALL RUBBER BUMPER FOOT (not shown) 4
1
6, 7
2
3
4
5
8
9
10, 11
12
13
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 9
www.gmpopcorn.com
Cabinet Interior
Item Part No. Model(s) Part Description Qty.
147060 ALL SPUR GEAR 1
267194A ALL GEAR BLOCK ASSEMBLY 1
355076 ALL SWITCH MOUNT BOX 1
42947 2408 50W COATED BULD
13122 2408EX 40W 240V COATED FLOOD
549010 ALL FRONT HANGER ARM 1
649009 ALL REAR HANGER ARM 1
742532 ALL DPST ROCKER SWITCH 3
4 1
1
2
3
4
5
6
7
www.food-service.com.ua

Fun Pop 8 Oz. Popper Model No. 2408, 2408EX
Page 10
www.gmpopcorn.com
Cabinet Bottom
1
4 3
2 5
Item Part No. Model(s) Part Description Qty.
158077 ALL WIRE ROUTE COVER 1
258110 ALL CORN PAN 1
349100 ALL OLD MAID PAN 1
58064 2408 BASE PAN
58064EX 2408EX EXPORT BASE PAN
40557 2408 120V 20W FOIL HEATER (bottom of corn pan)
40557EX 2408EX 230V 20W FOIL HEATER (bottm of corn pan)
655104 ALL LATCH CATCH 1
4 1
5 1
www.food-service.com.ua