Goldmedal 2404MD Series User manual



© 2016 Gold Medal Products Co. Part No. 59406

























Instruction Manual
10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA
Fun Pop 4 oz. Popper
Model No. 2404, 2404MD, 2404EX, 2404MDX
Model2404MD
Model2404

Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 2

gmpopcorn.com
SAFETY PRECAUTIONS
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
DO NOT immerse any part of this equipment in water.
DO NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from moisture.
Always unplug the equipment before cleaning or servicing.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle.
008_051514

DANGER
Improper installation, adjustment, alteration, service, or maintenance can
cause property damage, injury, or death. Any alterations to this equipment
will void the warranty and may cause a dangerous condition. This appliance
is not intended to be operated by means of an external timer or separate
remote-control system. NEVER make alterations to this equipment. Read the
Installation, Operating, and Maintenance Instructions thoroughly before
installing, servicing, or operating this equipment.
014_020416

WARNING
To avoid burns, DO NOT touch the kettle or any heated surface.
DO NOT place or leave objects in contact with heated surfaces.
013_092414

WARNING
ALWAYS wear safety glasses when servicing this equipment.
010_010914

WARNING
No user serviceable parts inside. Refer servicing to qualified service
personnel.
011_051514

WARNING
Read and understand operator’s manual and all other safety instructions
before using this equipment. To order copies of the operator’s manual go to
gmpopcorn.com or write to Gold Medal Products Co., 10700 Medallion Drive,
Cincinnati, OH 45241 USA 1-(800)-543-0862
022_060215



Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 3

gmpopcorn.com
SAFETY PRECAUTIONS (continued)
WARNING
DO NOT allow direct contact of this equipment by the public when used in
food service locations. Only personnel trained and experienced in the
equipment operation may operate this equipment.
Carefully read all instructions before operation.
012_010914

WARNING
This machine is NOT to be operated by minors.
007_010914

Thisapplianceisnotintendedforusebypersons(includingchildren)withreduced
physical,sensoryormentalcapabilities,orlackofexperienceandknowledge,unlessthey
havebeengivensupervisionorinstructionconcerninguseoftheappliancebyaperson
responsiblefortheirsafety.
Note: ImprovementsarealwaysbeingmadetoGoldMedal’sequipment.This
informationmaynotbethelatestavailableforyourpurposes.Itiscriticalthat
youcallGoldMedal’sTechnicalServiceDepartmentat1‐800‐543‐0862forany
questionsaboutyourmachineoperations,replacementparts,oranyservice
questions.(GoldMedalProductsCo.doesnotassumeanyliabilityforinjurydue
tocarelesshandlingand/orrecklessoperationofthisequipment.)



Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 4

gmpopcorn.com
INSTALLATION INSTRUCTIONS
Inspection of Shipment
Afterunpacking,checkthoroughlyforanydamagewhichmayhaveoccurredintransit.Claims
shouldbefiledimmediatelywiththetransportationcompany.Thewarrantydoesnotcover
damagethatoccursintransit,ordamagecausedbyabuse,orconsequentialdamageduetothe
operationofthismachine,sinceitisbeyondourcontrol(referencewarrantyinbackofmanual).
Manual
Readandunderstandtheoperator’smanualandallothersafetyinstructionsbeforeusingthis
equipment.Toordercopiesoftheoperator’smanualgotogmpopcorn.comorwritetoGold
MedalProductsCo.,10700MedallionDrive,Cincinnati,OH45241USA1‐(800)‐543‐0862.
Model Description
2404:FunPop4oz.Popperwithredandgoldcabinet.
2404MD:Midnight4oz.Popperwithblackandsilvercabinet.
2404EX:ExportFunPop4oz.Popperwithredandgoldcabinet.
2404MDX:ExportMidnight4oz.Popperwithblackandsilvercabinet.
Thisapplianceisintendedtobeusedinhouseholdandsimilarapplicationssuchasstaffkitchen
areasinshops,officesandotherworkingenvironments;farmhouses;byclientsinhotels,motels,
bedandbreakfastorotherresidentialtypeenvironments.
Items Included with this Unit

ScoopMeasure6.5cc
BulbforCabinet
Interior
4/6oz.Corn
Measure
38ccOilScoop
KnobandScrew
forOldMaidPan
Knob,Magnet,and
ScrewforDoor
IECPowerCord
(2404EXand2404MDGXonly)

Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 5

gmpopcorn.com
Setup
Thisunithasbeentestedatthefactory.
1. Removeallpackagingandtapepriortooperation.Removeaccessoriesandcarefully
removekettlepackedincabinetinterior.
2. Placetheunitonasturdy,levelbase.
3. Tiltkettleandinsertintohangerarms,thenallowkettletoreturnnaturallytoan
uprightposition(seeimagebelow).
4. Plugkettleleadintoreceptaclelocatedonceilingofcabinetinterior.Alignkeyedor
hookshapedprongwiththecorrectopening,thenpushplugallthewayinandtwist
orrotatetolockinplace.Tounplug,untwistkettleplugbeforeattemptingtopullfrom
receptacle.
5. Doorknobsareshippedinaccessoriespacklocatedinsidemachine.Installadoor
knobwithmagnetonpopperdoor;installknobwithscrewontheoldmaidpan.
6. Carefullyinstallthelightbulb(donotover‐tighten)intothelampholderlocatedinthe
cabinetinterior.EnsuretheunitisOFFandunpluggedbeforeinstallingorchanging
thebulb(referencetheElectricalRequirementssection).
7. ExportModels2404EXand2404MDX,aresuppliedwithanIECPowerCord.Securely
plugIECPowerCordintounit(referencetheElectricalRequirementssectionofthis
manual).
8. Aftersetup,unitshouldbecleanedpriortouse(seeCareandCleaningsection).



Kettleshown
mountedin
hangerarms.
Kettleleadshown
pluggedintokettle
receptacle.

Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 6

gmpopcorn.com
Electrical Requirements
Thefollowingpowersupplymustbeprovided:
2404and2404MD:120V~,608W,60Hz
2404EXand2404MDX:230V~,608W,50Hz
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
Failure to do so could result in serious injury, or death.
DO NOT immerse any part of this equipment in water.
DO NOT use excessive water when cleaning.
Keep cord and plug off the ground and away from moisture.
Always unplug the equipment before cleaning or servicing.
Make sure all machine switches are in the OFF position before plugging the
equipment into the receptacle.
008_051514

Acertifiedelectricianmustfurnishsufficientpowerforpropermachineoperationandinstallany
suppliedreceptacle.Werecommendthisequipmentbeonadedicatedandprotectedcircuit.
Failuretowireproperlywillvoidthewarrantyandmayresultindamagetothemachine.ItisGold
MedalProductsCo.’srecommendationthatthismachinebepluggeddirectlyintoawalloutlet.The
useofextensioncordsisnotrecommendedduetosafetyconcerns,andmaycausesacrificed
and/orreducedperformance.Makesurecordislocatedtopreventatriphazardorunitupset.
Before You Plug In Machine
1. MakesureallmachineswitchesareOFFbeforepluggingequipmentintoreceptacle.
2. Makesurewalloutletcanacceptthegroundedplugs(whereapplicable)onthepower
supplycord.
3. Thewalloutletmusthavetheproperpolarity.Ifindoubt,haveacompetent
electricianinspecttheoutletandcorrectifnecessary.
4. DONOTuseagroundedtoun‐groundedreceptacleadapter(whereapplicable).
5. Installunitinalevelposition.
Models2404and2404MD(unitswithahardwiredpowercord):
CAUTION
If the supply cord is damaged, it must be replaced by Gold Medal Products Co.,
its service agent or similarly qualified persons in order to avoid a hazard.
039_080614
Models2404EXand2404MDX(unitswitharemovable,IECpowercord):
CAUTION
If the supply cord is damaged, it must be replaced by a special cord or
assembly available from Gold Medal Products Co. or its service agent.
038_062714


Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 7

gmpopcorn.com
OPERATING INSTRUCTIONS
Controls and Their Functions
KETTLEHEATSWITCH
Twoposition,ON/OFFlightedrockerswitch‐suppliespowertotheheatingelementsinthe
poppingkettle.ThegreenswitchlightONindicatesthereispowertothekettleheating
element.
KETTLEMOTORSWITCH
Twoposition,ON/OFFlightedrockerswitch‐suppliespowertothekettleagitatormotor.
TheKettleMotorSwitchMUSTbeONatalltimeswhenthereispopcorn(poppedorun‐
popped)inthekettle.
LIGHTS/WARMERSWITCH
Twoposition,ON/OFFlightedrockerswitch‐suppliespowertotheinteriorcabinetlight,
andheatelementforthecornpan.


KettleHeatSwitch
KettleMotorSwitch
LightandWarmerSwitch

Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 8

gmpopcorn.com
Popping Corn Instructions
ThissectiondescribesinstructionsforpoppingStandard(salted)popcorn.
Amount of Popcorn and Oil
Thepopperisequippedwithacorn,salt,andoilmeasure.Werecommendflavoredandcolored
coconutoil.Popcornpoppedincoconutoilstaysfreshlongeranddoesnotleaveblackdepositsin
thekettlelikeotheroils.Useonlytopquality,freshpopcornfromreputablesuppliers.
KettleSizePopcornCharge OilCharge Flavacol(Salt)
4oz. 4oz.(118ml) 1to1.3oz.(30to38ml) 1Teaspoon(5cc)

ForbestresultsuseMega‐Pop®4oz.premeasuredpouches(Item#2834).
Popping Standard (Salted) Popcorn
1. TurnallswitchesON.
2. Todeterminewhenkettleisreadytopopcorn(about4minutes),testpopthree
kernelsofcorninoneounce(30ml)ofpoppingoil.Whenkernelspop,kettleisready.
3. LiftkettlelidandloadMega‐Pop®premeasuredpopcornandoilpouch,orpourin
popcornandFlavacol,thenaddoilinpremeasuredamount.Closelid.
4. Whencornhasfinishedpopping,gentlydumpthepopcorn.
5. Onfinalkettleofcorn,turnKettleHeatSwitchOFFjustaslidsareforcedopenbythe
poppingcorn.Thisproceduresaveselectricity,sincekettlehasplentyofheat,andhelps
eliminatesmoke/odorfromanyoilresiduethatremainsafterpoppinghasstopped.
6. Whenfinishedpopping,turnKETTLEHEATandKETTLEMOTORswitchesOFF.
NEVERLEAVETHEHEATONWHENYOUARENOTPOPPINGCORN!


Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 9

gmpopcorn.com
Care and Cleaning
DANGER
Machine must be properly grounded to prevent electrical shock to personnel.
DO NOT immerse in water.
Always unplug the equipment before cleaning or servicing.
025_020314

WARNING
To avoid serious burns, DO NOT touch the kettle while it is hot!
028_082715

Goodsanitationpracticedemandsthatallfoodpreparationequipmentbecleanedregularly(only
usenon‐toxic,foodgradecleaners).Acleanlooking,well‐keptmachineisoneofthebestwaysof
advertisingyourproduct.
Note: Itisextremelyimportanttofollowallofthecleaningprocedures,otherwiseparts
damageandequipmentfailurewillresult.Thewarrantydoesnotcoverpartsthat
aredamagedduetoimpropercleaning.
Daily Kettle Cleaning Instructions
CAUTION:Ahotkettlewillcauseburnsifyoutouchitwithyourhand.Allowkettletocool
atleast1hourbeforeattemptingtoclean.DONOTuseiceorwatertocool
downahotkettle!Severekettledamagewillresult!
1. Whencool,wipetheoutsideofthekettlewithaclean,softcloth.DONOTuseoven
cleanersorabrasivematerialsastheywilldamagethekettle.
2. Everynight,mixGoldMedal’sHeat’nKleensolution(ItemNo.2095),2tablespoons
pergallonofwater.Itisnotnecessarytousetheentiregallonatonce;onlyuse
enoughtofillthekettle1/2inchdeep.
3. TurnthekettleheatON.Whenthewaterstartstoboil,turnthekettleheatOFF.
4. Allowtocoolforatleast1hour,thendumpthesolutionintoabucketandwipethe
insideofthekettlewithacleancloth.Makesureallofthesolutiongoesintothe
bucket;donotspillanyintheinteriorofthemachine.
Foranextradirtykettle,theprocessmayberepeated;or,afterturningthekettleheat
OFF,allowsolutiontositinthekettleovernight.Thenextmorning,dumpthesolution
intoabucketandwipetheinsideofthekettlewithacleancloth.
5. WiththeunitOFFandunplugged,wipethekettleleadcordwithacleanSLIGHTLYdamp
cloth.DONOTgetmoistureintothekettlelead‐incord,severedamagewillresult.


Fun Pop 4 oz. Popper Model No. 2404, 2404MD, 2404EX, 2404MDX
Page 10

gmpopcorn.com
Daily Unit Cleaning Instructions
1. TurnmachineOFF,unplugunitandallowittocoolbeforeattemptingtoclean.
2. Cleanallpans/accessoriesinordertosanitizethembeforeeachuse.
3. Takeaclean,SLIGHTLYdampclothandwipeexcessgreasefromglassandcabinet.
4. Wipestainlesssteelpartswithacleanclothandcleanerdesignedforstainlesssteel,
suchasGoldMedalWatchdogStainlessCleaner(ItemNo.2088).
DONOTuseovencleanersorabrasivematerialsastheywilldamagepartsofmachine.
5. Cleanglasspanelswithglasscleaner.GoldMedalWatchdogGlassCleaner(ItemNo.
2588)isrecommended.
Ammoniacleanerswilldamageplasticdoors/panels.Useonlynon‐ammoniacleaners,
suchasGoldMedalWatchdogGlassCleaner(ItemNo.2588).
