Horizon Fitness T303 User manual

TREADMILL OWNER’S MANUAL
MANUEL DU PROPRIÉTAIRE DU TAPIS ROULANT
MANUAL DEL PROPIETARIO DE LA CAMINADORA
Read the TREADMILL GUIDE before using this OWNER’S MANUAL.
Lisez le GUIDE DU TAPIS ROULANT avant de vous référer au présent MANUEL DU PROPRIÉTAIRE.
Lea la GUÍA DE LA CAMINADORA antes de utilizar este MANUAL DEL PROPIETARIO.
T303
HZ_12_OM_T303_Rev1_4.indd 1 7/25/12 4:00 PM

23
2 ENGLISH
30 FRANÇAIS
58 ESPAÑOL IMPORTANT PRECAUTIONS
SAVE THESE INSTRUCTIONS
When using an electrical product, basic precautions should always be followed, including the following: Read all instructions
before using this treadmill. It is the responsibility of the owner to ensure that all users of this treadmill are adequately informed of
all warnings and precautions. If you have any questions after reading this guide, contact Customer Tech Support at the number
listed on the back panel of the OWNER’S MANUAL.
This treadmill is intended for in-home use only. Do not use this treadmill in any commercial, rental, school or institutional setting.
Failure to comply will void the warranty.
HZ_12_OM_T303_Rev1_4.indd 2-3 7/25/12 4:00 PM

4 5
TO REDUCE THE RISK OF BURNS, FIRE, ELECTRICAL SHOCK OR INJURY TO PERSONS:
• At NO time should children under the age of 13 or pets be within 10 feet of the machine.
• At NO time should children under the age of 13 use the treadmill.
• Children over the age of 13 or disabled persons should not use the treadmill without adult supervision.
• Use the treadmill only for its intended use as described in the treadmill guide and owner’s manual.
• Do not use other attachments that are not recommended by the manufacturer. Attachments may cause injury.
• Never operate the treadmill if it has a damaged cord or plug, if it is not working properly, if it has been dropped or damaged, or
immersed in water. Contact tech support at the number on the back panel to schedule service.
• Keep power cord away from heated surfaces. Do not carry this unit by its supply cord or use the cord as a handle.
• Never operate the treadmill with the air opening blocked. Keep the air opening clean, free of lint, hair, and the like.
• To prevent electrical shock, never drop or insert any object into any opening.
• Do not operate where aerosol (spray) products are being used or when oxygen is being administered.
• To disconnect, turn all controls to the off position, then remove plug from outlet.
• Do not use treadmill in any location that is not temperature controlled, such as but not limited to garages, porches, pool rooms,
bathrooms, car ports or outdoors. Failure to comply may void the warranty.
• This treadmill is intended for in-home use only. Do not use this treadmill in any commercial, rental, school or institutional setting.
Failure to comply will void the warranty.
• Do not remove the console covers unless instructed by Customer Tech Support. Service should only be done by an authorized
service technician
It is essential that your treadmill is used only indoors, in a climate controlled room. If your treadmill has been exposed to colder
temperatures or high moisture climates, it is strongly recommended that the treadmill is warmed up to room temperature before
first time use. Failure to do so may cause premature electronic failure.
TO REDUCE THE RISK OF BURNS, FIRE, ELECTRICAL SHOCK OR INJURY TO PERSONS:
• Never use the treadmill before securing the safety tether clip to your clothing.
• If you experience any kind of pain, including but not limited to chest pains, nausea, dizziness, or shortness of breath, stop
exercising immediately and consult your physician before continuing.
• When exercising, always maintain a comfortable pace.
• Do not wear clothes that might catch on any part of the treadmill.
• Always wear athletic shoes while using this equipment.
• Do not jump on the treadmill.
• At no time should more than one person be on treadmill while in operation.
• This treadmill should not be used by persons weighing more than specified in the OWNER’S MANUAL WARRANTY SECTION.
Failure to comply will void the warranty.
• When lowering the treadmill deck, wait until rear feet are firmly on the floor before stepping on the deck.
• Disconnect all power before servicing or moving the equipment. To clean, wipe surfaces down with soap and slightly damp cloth
only; never use solvents. (See MAINTENANCE)
• The treadmill should never be left unattended when plugged in. Unplug from outlet when not in use, and before putting on or
taking off parts.
• Do not operate under blanket or pillow. Excessive heating can occur and cause fire, electric shock, or injury to persons.
• Connect this exercise product to a properly grounded outlet only.
WARNING
TO REDUCE THE RISK OF ELECTRICAL SHOCK:
Always unplug the treadmill from the electrical outlet immediately after using, before cleaning, performing maintenance and putting on or
taking off parts.
DANGER WARNING
WARNING
This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.
HZ_12_OM_T303_Rev1_4.indd 4-5 7/25/12 4:00 PM

67
ASSEMBLY
There are several areas during the assembly process that special attention must be paid. It is very important to follow the assembly
instructions correctly and to make sure all parts are firmly tightened. If the assembly instructions are not followed correctly, the
treadmill could have parts that are not tightened and will seem loose and may cause irritating noises. To prevent damage to the
treadmill, the assembly instructions must be reviewed and corrective actions should be taken.
Before proceeding, find your treadmill’s serial number located on a white barcode sticker
on the base frame as shown in this image.
ENTER YOUR SERIAL NUMBER BELOW:
» Refer to the SERIAL NUMBER and MODEL NAME when calling for service.
SERIAL NUMBER:
TM
MODEL NAME: HORIZON T303 TREADMILL
WARNING
SERIAL NUMBER LOCATION
GROUNDING INSTRUCTIONS
This product must be grounded. If a treadmill should malfunction or breakdown, grounding provides a path of least resistance
for electrical current to reduce the risk of electrical shock. This product is equipped with a cord having an equipment-grounding
conductor and a grounding plug. The plug must be plugged into an appropriate outlet that is properly installed and grounded in
accordance with local codes and ordinances.
Connect this exercise product to a properly grounded outlet only.
Never operate product with a damaged cord or plug even if it is working
properly. Never operate any product if it appears damaged, or has been
immersed in water. Contact Customer Tech Support for replacement or repair.
3-POLE
GROUNDED
OUTLET
GROUNDED
POWER
CORD
WARNING
DANGER
Improper connection of the equipment-grounding conductor can result in a risk of electric shock. Check with a qualified
electrician or serviceman if you are in doubt as to whether the product is properly grounded. Do not modify the plug provided
with the product. If it will not fit the outlet, have a proper outlet installed by a qualified electrician.
This product is for use on a nominal 110-120 Volt circuit and has a grounding plug that looks like the plug in the illustration. Make
sure that the product is connected to an outlet having the same configuration as the plug. No adapter should be used with this
product.
This product must be used on a dedicated circuit. To determine if you are on a dedicated circuit, shut off the power to that circuit
and observe if any other devices lose power. If so, move devices to a different circuit. Note: There are usually multiple outlets on one
circuit. This treadmill should be used with a minimum 15-amp circuit.
HZ_12_OM_T303_Rev1_4.indd 6-7 7/25/12 4:00 PM

8 9
SPEAKERS
WATE R BOTTLE POCKET HE ART R ATE GRIP BARS
HANDLEBARS
ACCE S SORY TRAY
CONSOLE
ON/OFF SWITCH
CIRCUIT BREAKER
TRANSPORT WHEEL
POWER COR D
RE ADING RACK
CONSOLE FAN
CONSOLE DISPLAY AND CONTROLS
SAFE T Y KEY PLACEME NT
MOTOR COVER
SIDE R AIL
RE AR ROLLER
TENSION/ADJUSTMENT BOLTS
CONSOLE MAS T
FOOT LOCK L ATCH
RUNNING BELT / RUNNING D ECK
12
(UNDERNE ATH DECK)
MISE EN GARDE
GARDEZ VOS MAIN ET VOS PIEDS À
L'ÉCART DE CET ENDROIT.
DES COUPS À HAUTE PRESSION
PEUVENT CAUSER DES BLESSURES
CORPORELLES.
MISE EN GARDE
GARDEZ VOS MAIN ET VOS PIEDS À
L'ÉCART DE CET ENDROIT.
FIXEZ L'ATTACHE DE LA CLÉ DE SÉCURITÉ À VOS VÊTEMENTS AVANT DE
COMMENCER. POUR ÉVITER LES BLESSURES, TENEZ-VOUS SUR LES RAILS
LATÉRAUX DU TAPIS ROULANT. LIRE ET SUIVRE TOUTES LES INSTRUCTIONS AVANT
D'OPÉRER. GARDEZ LES ENFANTS LOIN DE CET ÉQUIPEMENT. ENLEVEZ LA CLÉ DE
SÉCURITÉ LORSQUE LA MACHINE N'EST PAS UTILISÉE ET ENTREPOSEZ-LA HORS DE
LA PORTÉE DES ENFANTS. CONSULTEZ UN MÉDECIN AVANT D'UTILISER CET
ÉQUIPEMENT. ARRÊTEZ VOS EXERCICES SI VOUS RESSENTEZ DE LA DOULEUR, DES
FAIBLESSES, DES VERTIGES OU DE L'ESSOUFFLEMENT. GARDEZ VOTRE CORPS ET
VOS VÊTEMENTS LIBRE ET LOIN DES PIÈCES AMOVIBLES. POUR USAGE PAR LES
CONSOMMATEURS SEULEMENT.
MISE EN GARDE RISQUE DE
ATTACH SAFETY KEY CLIP TO CLOTHING BEFORE STARTING. TO AVOID
INJURY, STAND ON THE SIDE RAILS BEFORE STARTING TREADMILL. READ
AND FOLLOW ALL INSTRUCTIONS BEFORE OPERATING. KEEP CHILDREN
AWAY FROM THIS EQUIPMENT. REMOVE SAFETY KEY WHEN NOT IN USE
AND STORE OUT OF REACH OF CHILDREN. CONSULT A PHYSICIAN
BEFORE USING THIS EQUIPMENT. STOP EXERCISING IF YOU FEEL PAIN,
FAINT, DIZZY OR SHORT OF BREATH. KEEP BODY AND CLOTHING FREE
AND CLEAR OF ALL MOVING PARTS. FOR CONSUMER USE ONLY.
CAUTION
RISK OF INJURIES TO PERSONS:
BLESSURES À LA PERSONNE : LESIONES PARA LAS PERSONAS:
ASEGURE EL BROCHE DE LA LLAVE DE SEGURIDAD A SU ROPA ANTES DE
COMENZAR. PARA EVITAR LESIONES, COLÓQUESE SOBRE LOS RIELES LATERALES
ANTES DE ACTIVAR LA CAMINADORA. LEA Y SIGA TODAS LAS INSTRUCCIONES
ANTES DE PONER EN FUNCIONAMIENTO LA UNIDAD. MANTENGA A LOS NIÑOS
ALEJADOS DE ESTE EQUIPO. QUITE LA LLAVE DE SEGURIDAD CUANDO NO UTILICE
EL EQUIPO Y GUÁRDELA FUERA DEL ALCANCE DE LOS NIÑOS. CONSULTE CON UN
MÉDICO ANTES DE UTILIZAR ESTE EQUIPO. DEJE DE HACER EJERCICIO SI SIENTE
DOLOR, SENSACIÓN DE DESMAYO, MAREOS O SI SIENTE FALTA DE AIRE.
MANTENGA EL CUERPO Y LA ROPA LIBRES Y ALEJADOS DE TODAS LAS PIEZAS
MÓVILES. PARA USO POR PARTE DEL CONSUMIDOR ÚNICAMENTE.
PRECAUCIÓN RIESGO DE
PRECAUCIÓN
MANTENGA LAS MANOS Y LOS
PIES ALEJADOS DE ESTA ÁREA.
DESCARGAS DE ALTA PRESIÓN
PODRÍAN OCASIONAR
LESIONES FÍSICAS.
PRECAUCIÓN
MANTENGA LAS MANOS Y LOS
PIES ALEJADOS DE ESTA ÁREA.
CAUTION
KEEP HANDS AND FEET
AWAY FROM THIS AREA.
HIGH-PRESSURE
SHOCKS COULD CAUSE
BODILY INJURY.
CAUTION
KEEP HANDS AND FEET
AWAY FROM THIS AREA.
TOOLS REQUIRED:
F6 mm T-Wrench
F5 mm L-Wrench
FScrewdriver (not included)
PARTS INCLUDED:
F2 Console Masts
F1 Console Assembly
F2 Sets Console Mast Covers
F1 Accessory Tray
F1 Hardware Kit
F1 Safety Key
F1 Power Cord
F1 Audio Adapter Cable
F 1 Bottle of Silicone Lubricant
(for 2 applications)
If you have questions or if
there are any missing parts,
contact Customer Tech
Support. Contact information
is located on the back panel
of this manual.
NEED HELP?
DO NOT ATTEMPT TO LIFT THE TREADMILL! Do not move or lift treadmill
from packaging until specified to do so in the assembly instructions. You may
remove the plastic wrap from console masts.
WARNING
UNPACKING
Place the treadmill carton on a level flat surface. It is recommended that you place a
protective covering on your floor. Take CAUTION when handling and transporting this
unit. Never open box when it is on its side. Once the banding straps have been removed,
do not lift or transport this unit unless it is fully assembled and in the upright folded
position, with the lock latch secure. Unpack and assemble the unit where it will be used.
The enclosed treadmill is equipped with high-pressure shocks and may spring open if
mishandled. Never grab hold of any portion of the incline frame and attempt to lift or
move the treadmill.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN INJURY!
WARNING
NOTE:
• During each assembly step, ensure that ALL nuts and bolts are in place and partially
threaded in before completely tightening any ONE bolt.
• A light application of grease may aid in the installation of hardware. Any grease, such
as lithium bike grease is recommended.
• It is recommended that two people work together for ease and efficiency while
assembling an treadmill.
PRE ASSEMBLY
HZ_12_OM_T303_Rev1_4.indd 8-9 7/25/12 4:00 PM

10 11
BOLT (A)
9 mm
Qty: 2
HARDWARE FOR STEP 1:
BOLTS (A)
MAIN FRAME BRACKET
ASSEMBLY STEP 1
A Cut the yellow banding straps and lift the running
deck upward to remove all contents from underneath
the running deck.
B Open HARDWARE FOR STEP 1.
C Insert 2 BOLTS (A) into MAIN FRAME BRACKETS.
ASSEMBLY STEP 2
A Open HARDWARE FOR STEP 2.
B Attach LEFT CONSOLE MAST so that BOLT (A)
sits on the NOTCHED HOLE in the bottom of the
CONSOLE MAST.
C Attach LEFT CONSOLE MAST to MAIN FRAME
BRACKET using 4 FLAT WASHERS (B), 4 SPRING
WASHERS (C) and 4 BOLTS (D).
SPRING
WASHER (C)
8 mm
Qty: 8
FLAT
WASHER (B)
8 mm
Qty: 8
BOLT (D)
70 mm
Qty: 8
HARDWARE FOR STEP 2:
CONSOLE MAST
MAIN FRAME
FLAT WASHERS (B)
SPRING WASHERS (C)
BOLTS (D)
HZ_12_OM_T303_Rev1_4.indd 10-11 7/25/12 4:00 PM

12 13
ASSEMBLY STEP 3
SCREW (E)
8 mm
Qty: 2
SPRING
WASHER (C)
8 mm
Qty: 4
FLAT
WASHER (B)
8 mm
Qty: 4
BOLT (F)
20 mm
Qty: 4
HARDWARE FOR STEP 3:
CONSOLE POCKET
SCREWS (E)
CONSOLE A Open HARDWARE FOR STEP 3.
B Attach CONSOLE POCKETS to CONSOLE using 2
SCREWS (E).
C Gently place CONSOLE on top of CONSOLE
MASTS.
D Connect the CONSOLE CABLES and tuck them
inside the right CONSOLE MAST.
E Connect the CONSOLE to the right CONSOLE
MAST using 2 BOLTS (F), 2 SPRING WASHERS
(C) and 2 FLAT WASHERS (B).
F Repeat STEP E on other side.
NOTE: Be careful not to pinch the console
cables while attaching the console.
CONSOLE CABLES
FLAT WASHERS (B)
CONSOLE
SPRING WASHERS (C)
BOLTS (F)
RIGHT CONSOLE MAST
ASSEMBLY STEP 2 (continued)
LEFT CONSOLE MAST
RIGHT CONSOLE MAST
BOLTS (A)
CONSOLE CABLE
LEAD WIRE
NOTCHED HOLE
D Pull the CONSOLE CABLE out of the treadmill base
frame using the LEAD WIRE. Attach CONSOLE
CABLE to the CONSOLE CABLE in the bottom of
the mast. The other end of the CONSOLE CABLE
should be located at the top of the mast. Detach and
discard LEAD WIRES.
E Align the RIGHT CONSOLE MAST so that BOLT
(A) sits in the NOTCHED HOLE in the bottom of the
CONSOLE MAST.
F Attach CONSOLE MAST to MAIN FRAME
BRACKET using 4 FLAT WASHERS (B), 4 SPRING
WASHERS (C) and 4 BOLTS (D).
NOTE: Be careful not to pinch the console
cable while attaching the right console mast.
HZ_12_OM_T303_Rev1_4.indd 12-13 7/25/12 4:00 PM

14 15
ASSEMBLY STEP 5
SPRING
WASHER (I)
6 mm
Qty: 4
FLAT
WASHER (H)
6.2 mm
Qty: 4
BOLT (J)
15 mm
Qty: 4
HARDWARE FOR STEP 5:
CONSOLE MAST
FLAT WASHERS (H)
SPRING WASHERS (I)
BOLTS (J)
ACCESSORY TRAY
A Open HARDWARE FOR STEP 5.
B Align the ACCESSORY TRAY between the
CONSOLE MASTS.
C Attach the CONSOLE POCKETS to the CONSOLE
MASTS using 4 FLAT WASHERS (H), 4 SPRING
WASHERS (I) and 4 BOLTS (J).
ASSEMBLY COMPLETE!
Before the first use, lubricate the treadmill deck by
following the instructions in the MAINTENANCE
section in the TREADMILL GUIDE.
A Open HARDWARE FOR STEP 4.
B Attach the the LEFT OUTER CONSOLE MAST
COVER with 2 SCREWS (G).
C Attach the LEFT INNER CONSOLE MAST COVER
with 2 SCREWS (G).
D Repeat steps 2 and 3 to attach the RIGHT-SIDE
CONSOLE MAST COVERS.
ASSEMBLY STEP 4
SCREW (G)
15 mm
Qty: 8
HARDWARE FOR STEP 4:
CONSOLE MAST COVERS
SCREWS (G)
CONSOLE MAST
HZ_12_OM_T303_Rev1_4.indd 14-15 7/25/12 4:00 PM

16 17
TREADMILL OPERATION
This section explains how to use your treadmill’s console and programming. The BASIC OPERATION section in the
TREADMILL GUIDE has instructions for the following:
• LOCATION OF THE TREADMILL
• USING THE SAFETY KEY
• FOLDING THE TREADMILL
• MOVING THE TREADMILL
• LEVELING THE TREADMILL
• TENSIONING THE RUNNING BELT
• CENTERING THE RUNNING BELT
• USING THE HEART RATE FUNCTION
HZ_12_OM_T303_Rev1_4.indd 16-17 7/25/12 4:00 PM

18 19
12%
10%
8%
6%
4%
3%
2%
incline q uick keys
1%
12
MPH
10
MPH
8
MPH
6
MPH
4
MPH
3
MPH
2
MPH
1
MPH
speed qui ck keys
cardio
burn
muscle
toner
strength
builder 5K10Kmoun tain
climb
endurance
interval s
speed
interval s
peak
interval s
weig ht l oss work out sinte rva l wo rkou ts per form anc e wor kout s
enter
custom
1
custom
2
T303
incline
sta rt
pause
goal
center
sto p
hold to reset fan
speed
ABG O FC H R
D E
T
S S
Q
UI J K L M N
P P
CONSOLE OPERATION
Note: There is a thin protective sheet of clear plastic on the overlay of the console that should be removed before use.
A) LCD DISPLAY WINDOW: time, distance, speed, calories, incline, and heart rate.
B) PROGRAM KEYS: press to select workout.
C) CUSTOM 1 & 2 KEYS: press to select custom 1 or custom 2 program.
D) KEYS: Used to cycle through programs and Goal Center workout statistics.
E) ENTER: used to confirm selection.
F) VOLUME: used to adjust volume up or down.
G) INCLINE QUICK KEYS: used to reach desired incline quickly.
H) SPEED QUICK KEYS: used to reach desired speed quickly.
I) INCLINE KEYS: used to adjust incline level.
J) GOAL CENTER: press to set or view your goal. See page 26 for more information.
K) START / PAUSE: used to start workout, pause workout, and restart after pause.
L) STOP / HOLD TO RESET: used to stop machine and also will reset machine when held down.
M) FAN KEY: press to turn fan on and off.
N) SPEED KEYS: used to adjust speed level.
O) AUDIO IN JACK: plug your CD / MP3 player into the console using the included audio adaptor cable.
P) SPEAKERS: play music through speakers when connected to your CD / MP3 device.
Q) STORAGE AREA: holds personal items, i.e. remote control, music player.
R) READING RACK: holds reading material.
S) WATER BOTTLE POCKETS: store your water bottle.
T) FAN: personal workout fan
U) SAFETY KEY: enables treadmill when safety key is inserted.
HZ_12_OM_T303_Rev1_4.indd 18-19 7/25/12 4:00 PM