kingsley-bate IP-90 User manual

KINGSLEY–BATE
Fine Garden Furniture
ASSEMBLY INSTRUCTIONS FOR THE IP–90
END FRAME BACK END FRAME
* NOTE
A TENON
B MORTISE HOLE
SEAT
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid marring the wood.
NOTE: During assembly of the furniture please match joints with the corresponding letters or
numbers stamped on the wood.
STEP-II
We recommend that two people assemble this
item. Place Styrofoam under the BACK. Fit the
SEAT tenons into the BACK mortise holes as
shown in the photographs. If necessary, gently
rock the parts while pushing down on them until
all the joints fit snugly together. One person
should balance the SEAT until STEP-III is done.
STEP-III
Carefully fit both END FRAMES mortise holes
over all exposed tenons and using a rubber mallet
or a regular hammer with the sanding block
between the hammer and the wood, gently drive
the mortise holes onto the tenons until all joints
fit snugly together.

STEP-IV
Hammer the long dowels into the pre-drilled holes under the BACK; details are shown in the
photographs. Insert knock bolts through the back legs and into END FRAMES, tightened
with the allen key provided. Do not over-tighten bolt as you may strip insert out of END
FRAME. Dowel the front leg of the END FRAME to the SEAT. NOTE: DO NOT FORCE
THE DOWELS; ANY EXCESS CAN EASILY BE SANDED AWAY. IF THE DOWELS
ARE NOT FLUSH DO NOT CONTINUE TO DRIVE THE DOWELS, YOU MIGHT
DAMAGE THE ITEM. Day bed needs to be up-righted carefully by two people; carefully lift
and place down, do not tilt day bed to the upright position.
STEP-V
Attach the BRACKETS to the BACK as shown in the
photographs. Washers go on the BRACKET side of the
assembly. Secure BRACKETS with the allen key provided
and be careful not to over-tighten.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE DEALER
NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU FOR
CHOOSING OUR FURNITURE.
* KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]