kingsley-bate Nantucket NT70 User manual

Kingsley-Bate
NT70 Nantucket Chaise Lounge
Assembly Instructions

KINGSLEY – BATE
0Fine Garden Furniture
ASSEMBLY INSTRUCTIONS FOR THE NT - 70
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid
marring the wood. Lay CHAISE FRAME on its back side with m ortise
holes facing up as shown on the assembly diagram.
CHAISE FRAME
STEP-II
Before inserting the brass bolts through the back leg,
slide one washer onto each bo lt. Insert the bolts through
the back leg and slide on the second washers. Then slide
wheel onto the bolt and conn ect the wheel assembly
with the short axle.
Screw in by hand and tighten with a standard adjustable wrench. Do not tighten too hard
or the wheels will not turn. Com plete the WHEEL ASSEMBLY as shown on the
assembly diagram
STEP-III
Before inserting the brass bolts to the front legs, slide one washer onto each bolt. Insert
the bolts through the front legs and then c onnect with long axle. Screw in by hand also
tighten with the standard adjustable wrench.

lace. Be sure to match the numbered tenons with the corresponding
ortise holes.
losen the bolts until you
an achieve a smooth but secure movement.
but drive them in with a proper screw
river.
e, please do not force them in. Any excess
an easily be sanded away.
INGSLEY - BATE DIRECTLY. WE THANK
MAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY
72 9
Phone : [phone], Fax : [phone]
STEP-IV
With a rubber m allet gently knock the front and back leg assem blies into their
corresponding p
m
1STEP-V
2If the wheels do not rotate after assembly,
c
3STEP-VI
Insert screws into all leg braces to secure the
legs to the lounge frame. Do not hammer in the
screws,
d
STEP-VII
With all legs tight against the side rails, insert the locking dowels and
drive them in gently with a ham mer. You should place the sanding
block between the ham mer and the dowel to prevent m arring of the
wood. If any dowels protrud
c
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE
DEALER NEAREST TO YOU OR K
FOR CHOOSING OUR FURNITURE.
*KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DA
4
00 Gateway Court, Manassas, Virginia 2010