Koplus Kolo Solo User manual

acoustic collection - kolo solo
[left hand open - outlet on left - without stool]
koplus b.v. | koplus.eu
[email protected]
version 20240104
Assembly
Instructions
KOLO
SOLO

Before we start, here are some things to be aware of:
This is the assembly instruction for left hand opening door Kolo
Solo without stool.
A packaged Kolo Solo unit weights 271 kg and will require
2-3 persons to install. It takes an average of 30 - 45 min to
install Kolo Solo.
Please assemble with caution and make sure that the installation
site is protected to prevent any injuries or risks of damaging the
product and surrounding.
Position and assemble Kolo Solo as close to its final placement
as possible. If needed, a fully assembled Kolo Solo can be
repositioned by retracting its four leveling feet and moved with
its bottom rollers. When moving the unit, DO NOT push the unit
against the rollers’ direction! You may risk tipping Kolo Solo or
damaging its rollers.
Make sure you have all the required tools listed (pg. 03).
We recommend leaving at least 30 cm of space between the
wall or between multiple units of Kolo Solo.
Make sure that the Kolo Solo power source can safely load
10amp. When the ventilation is on, LED light is at its full
lumination, and the power charging station is not in use, the
wattage usage is 22W. The power cord fuse is set at 7amp to
prevent overloading.
Kolo Solo comes with 2 AC power outlets and 2 USB charging
outlets. DO NOT plug in any electronic devices that uses over
5amp.
1.
2.
3.
4.
5.
6.
7.
8.

Required Tools
Drill 90 Degree Drill Adaptor
**Please confirm the adaptor specification
with a Koplus sale ahead of time**
Rubber Mallet
Ratchet Wrench - Metric Socket Phillips Screw Driver Allen Key Set
Aligning Rods
**Must be purchased seperately**
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 03

Part List
Tool Kit: Screw Pack Tool Kit: Power Cord
Bottom
Nº1-1 Nº1-2
Nº2
x1
x1
x1
Side Wall + Electric
Nº3
x1
Exterior Handle
Nº1-3
x1
Mounting Plate Rose
Nº1-4 Nº1-5
x2x2 Interior Handle
Nº1-6
x1
M4x40mmL Screw Cover Single
Nº1-7 Nº1-8
x2x2 Screw Cover Double
Nº1-9
x3
Bottom Socket Cover Tile
Nº1-10
x1
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 04

Bottom Finishing Panel
Nº11
x2
Top Finishing Panel
Nº10
x2
Glass Door Frame
Nº8
x1Table Top + Frame
Nº7-1
Table Bottom Cover
Nº7-2
x1 x1
Back Glass Frame
Nº6
x1Top
Nº5
x1
Floor Tile
Nº9
x1
Side Wall
Nº4
x1
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 05

Tool Kit: Screw Pack List
M8 x 50 M8 x 25 Spring Washer
1/4-20 UNC x 1-1/2 M4 x 12
A B C
D E
x36x16
x4 x4
x36
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 06

Step 1.
Side Wall +
Electric
Nº3
M8 x 50
Ax4
Bottom
Nº2
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 07

M8 x 50
Ax4
Side Wall
Nº4
Step 2.
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 08

Top
Nº5
M8 x 50
Ax8
Step 3.
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 09

Step 4.
Plug in the unit and check if all electronic devices
turn on normally. If not, check if all power cords are
properlly connected before proceeding.
Nº1-2
Tool Kit:
Power Cord
HEADS UP
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 10

Step 5.
Nº6
Back Glass Frame
Aligning Rod
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 11

Step 6.
LIGHTLY screw in the top and bottom 8 screws
HEADS UP
M8 x 25
Cx8
Spring
Washer
Dx8
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 12

LIGHTLY screw in the side 10 screws. Once all 18
screws are in position, go around and screw them
all in FIRMLY. Then REMOVE the aligning rods
HEADS UP
Step 7.
M8 x 25
Spring
Washer Cx10
Dx10
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 13
Aligning Rod

Step 8.
Floor Tile
Nº9
Bottom
Finishing Panel
Nº11
Top
Finishing Panel
Nº10
Bottom
Socket Cover Tile
Nº1-10
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 14

Step 9.
M4 x 12
Ex4
Table Bottom
Cover
Nº7-2
1/4-20 UNC x 1-1/2
Dx4
Table Top +
Frame
Nº7-1
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 15

Step 10.
Aligning Rod
Glass
Door Frame
Nº8
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 16

Step 11.
M8 x 25
Cx8
Spring
Washer
Dx8
LIGHTLY screw in the top and bottom 8 screws
HEADS UP
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 17

Step 12.
LIGHTLY screw in the side 10 screws. Once all 18
screws are in position, go around and screw them
all in FIRMLY. Then REMOVE the aligning rods
HEADS UP
M8 x 25
Spring
Washer Cx10
Dx10
Koplus B.V. | Kolo Solo | Left Hand Open Door | Outlet on Left | Without Stool | Assembly Instructions Page 18