National Cycle Quantum VStream N20121 User manual

National Cycle, Inc. PO Box 158 Maywood, IL 60153-0158 USA
708-343-0400 / Fax: [phone] / www.nationalcycle.com / [email protected]
©2018 National Cycle, Inc. Page 1 of 2 10-118615-000 04/18
Thank you for purchasing a National Cycle product. Read these instructions carefully and thoroughly before beginning work. Dealers, if installing this wind-
screen for a custo er, please give the this anual upon co pletion. It contains infor ation needed to properly aintain and use this product.
Note:
Tips for facilitation of operation, control and
adjustment, as well as maintenance work.
Attention:
Special notes and cautionary measures which can
prevent damage to the accessory or motorcycle.
Item Description Part No. Qty.
(1) VStream® Windscreen 1
CONTENTS OF KIT
Quantum® Hardcoated Polycarbonate
Stream® Windscreen for:
Kawasaki® Ninja Z1000SX
N20121, Low Dark Tint
N20122, Mid Light Tint
N20123, Tall Clear
TOOLS REQUIRED
5mm Allen Wrench
Figure 1
Figure 2
PREPARATION
1. Position motorcycle securely on its center stand.
emove the OEM windscreen, four screws, and four
washers. Hardware will be re-used. (5mm Allen
Wrench) Figure 1
INSTALLATION
2. Install the VStream Windshield using the OEM
screws and washers. Tighten the 4 screws firmly.
(5mm Allen Wrench) Figure 2

National Cycle, Inc. PO Box 158 Maywood, IL 60153-0158 USA
708-343-0400 / Fax: [phone] / www.nationalcycle.com / [email protected]
©2018 National Cycle, Inc. Page 2 of 2 10-118615-000 04/18
CLEANING AND MAINTENANCE
To clean the screen, wash with a clean soft cloth and plenty of warm water and, if
necessary, a non-abrasive soap such as dishwashing liquid. Flannel or soft chamois
make good cleaning cloths. Paint, glue residue or grease removal: Moisten cotton
wad with naphtha or turpentine followed by a wash as above.
National Cycle Shield Wash™ (N1401-01) makes a good daily cleaner and comes
with a handy travel-size bottle. Shield Wash is safe for all windshields and helmet
visors.
Do not clean polycarbonate in hot sun or high temperatures. Do not clean the screen
with household glass cleaners.
Do not allow brake fluid, alcohol, or strong solvents to contact the screen.
RAIN REPELLENT
Do not use rain protective products made for glass. We recommend National Cycle’s
RainZip® (N1410-01) to keep your windscreen clear in rainy weather.
Register Your Windshield Online at www.nationalcycle.com
National Cycle 3-Year Limited Warranty
National Cycle hereby warrants to the original registered owner of a National Cycle polycarbonate windshield for a period of
three years from the date of purchase against breakage. This limited warranty is expressly limited to the replacement of the
polycarbonate windscreen. This limited warranty does not include scratches, coating failure, cosmetic wear and tear, replace-
ment of hardware, or any consequential damages or expenses including labor cost of installation, removal and/or replace-
ment, inconvenience, inbound freight expenses or damage to any other component of the motorcycle or any other acces-
sories. Certain chemicals, generally known as acidic hydrocarbons, are known to cause polycarbonate damage and will not be
covered under this limited warranty. Please refer to the cleaning instructions supplied with all National Cycle windshields.
Visit www.nationalcycle.com for further details or call or write National Cycle
Never ride your motorcycle with loose accessory mounting hardware. Check the hardware for tightness regularly.
Today's motorcycles are built with enough frame rigidity to withstand the moderate loads imposed on them by the foreseeable addition of an
accessory(ies). If an accessory(ies) adversely affects your motorcycle's stability, immediately remove the accessory(ies). Do not ride a motorcycle
that exhibits unsafe handling traits.
Have experienced service personnel correct any problem before riding with the accessory(ies) installed. For further questions concerning handling
problems associated with an accessory(ies), contact your dealer, motorcycle manufacturer, or accessory manufacturer.
Sunlight reflected off the inside curvature of the windscreen can, at certain times of the day, cause extreme heat buildup on the motor-
cycle’s instruments and possibly even melt them. Exercise care in parking to avoid this. Park your motorcycle facing the sun, or place
an opaque object over the instruments and dash panel.
VStrea ® Windscreen Patent no. 7,387,328
Ask for Shield Wash™ and RainZip® at your local dealer
or visit www.nationalcycle.co .
WARNING