Rollplay 6V Mini Quad ACQUAD-P User manual

1
6V Fire/Police (Tahoe/Yukon)
(W510)
Customer Service Guide
MMXV © Copyright Aria Child Inc.

2
Customer Service Guide
Contents
I) Check Battery …………………………............................................. 3
II) Check Wiring Condition ……………………………..………………………. 6
III) Check Foot Pedal ………………………………………………………..….….. 8
IV) Gearbox Replacement …………………………………………..…………… 10
V) Door Replacement …………………………………………………………..... 15
VI) Dashboard Replacement ………………………………………………….…16
VII) Warning Stickers ………………………………………………….………… 20
VIII) Schematic diagram ……………...…………….…..….………..……………. 24
IX) Exploded View ……………………….......…....….……….……..…….…… 25
CAUTION :
Disconnect the battery before proceed the
checking and/or replacing processes

3
Customer Service Guide
I) Check Battery
Operation: Use a Flat head screwdriver, unlock and remove the seat. Locate the battery
harness, unplug the connector then use a volt-meter to check battery condition
at battery side.
Step (1)
Turn and unlock this plastic knob
Unlock position
Step (2)

4
Customer Service Guide
I) Check Battery
Unplug the battery connector (RED) underneath the seat
Step (3)
Step (4)

5
Customer Service Guide
I) Check Battery
Step
(5)
Reading Judgment: 6.0 V ~ 6.6 V –Good condition
5.6 V ~ 5.9 V –Proceed to Recharge
5.5 V –Battery to be recharged if after the stipulated
recharging time, voltage has not increased,
the Battery needs replacement
Below 5.5 V –Battery needs replacement

6
Customer Service Guide
II) Check Wiring Connection
Operation: There are totally two locations of connection should be checked.
A. Motor/Gearbox : Follow above (Point I) to remove the seat, locate the Gearbox
harness underneath.
Check the white connector of Gearbox underneath the seat

7
Customer Service Guide
II) Check Wiring Connection
B. Dashboard connections : Access the plugs underneath then check the wiring
connections.
Locate the connectors for dashboard
which near the right front wheel
Step (1)
Step (2)
There are three connectors (only two connectors if street car version)
for all the electronic functions, check any loose connection or not

8
Customer Service Guide
III) Check Foot Pedal
Operation: Follow below procedures to check the Foot Pedal connection.
Step (1)
Tip over the vehicle and pull out the Foot Pedal cover
by flat head screwdriver from its right side
Empty (front)
Step (2)
Pink

9
Customer Service Guide
III) Check Foot Pedal
Step
(3)
Slide in the Foot Pedal into Chassis from right side
2
Snap back in place
1

10
Customer Service Guide
IV) Gearbox Replacement
Operation: Follow below steps to take apart the gearbox completely for replacing.
Unplug the gearbox connector (white color) underneath the seat
Step (1)
Step (2)
Use flat head screwdriver to remove the rim by detaching the latches
Right rear wheel only