Volvo 30664381 User manual

Instruction No Version Part. No.
30664381 1.0
Bass speakers, cargo compartment
M3903045
Instruction No Version Part. No.
30664381 1.0
Bass speakers, cargo compartment
M3903045
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 1 / 20

Equipment
A0000162
M3903046
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 2 / 20

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
M8503119
Turn the ignition key to position 0
Wait at least five minutes before disassembling the connectors
or removing other electrical equipment
Remove the rear floor hatch. First open the hatch, then pull it
backwards.
2
M8503120
Secure the front floor hatch in the open position.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 3 / 20

3
M8503121
Remove the storage box from under the rear floor hatch. Turning
the clips on the left and right-hand sides 90°. Lift out the box.
4
M8503122
Cut out the insulation panel as illustrated.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 4 / 20

5
M3100087
Slacken off the screw (1) a few turns. Remove the two nuts (2)
from the holder (3) for the battery
Remove the holder
Remove the protective cover (4) from the battery
Disconnect the battery ground lead.
6
M7700278
Unscrew the holder for the spare wheel, jack and tool bag
Remove the jack and tool bag from the holder (it will not be used
again). There is a new holder and securing device for the jack,
too bag and spare wheel in the kit.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 5 / 20

7
M7700279
Tighten the spare wheel using the new securing device from the
kit.
8
M8901651
Remove the rubber washer (1) in the rear cross member behind
the spare wheel. The hole is used to secure the subwoofer at
the rear edge.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 6 / 20

9
M3702197
If the car has a pre-routed cable harness for the subwoofer,
disconnect the connector (1) from the cable harness at the rear
cross member and continue to point 31. If the car does not have
a pre-routed cable harness, carry out points 10 to 30 first.
10
M8503006
Remove the folding panels on the left and right-hand sides of the
cargo compartment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 7 / 20

11
M8503007
Remove the rear insulating panels on the right and left-hand
sides.
12
M8503008
Remove the left-hand side panel (first remove the cover and the
screw from the front edge)
Pull the top of the panel out until the clips release
Fold the panel inwards. Lift the panel out.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 8 / 20

13
M8502805
Fold the left-hand seat cushion (1) in the rear seat forwards
Fold the backrest (2) forwards.
14
A8500151
Remove the left-hand side cushion. First pull the upper edge of
the cushion backwards and then lift it upwards.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 9 / 20

15
M8502927
Remove the panel for the D-post loudspeaker. First carefully pry
off the bottom of the panel using a weatherstrip tool
Place the panel to one side
Repeat the operation on the other side.
16
M3902958
Remove the loudspeaker by pulling out the red catch (1). Press
in the interlock (2) and fold the loudspeaker forwards to lift it out
Disconnect the connector from the loudspeaker. Place it to one
side
Repeat the operation on the other side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Bass speakers, cargo compartment- 30664381 - V1.0
Side 10 / 20