WE-EF FLC220 LED User manual

Surge Protection
This product features built-in surge protection circuitry in compliance with
applicable standards.
For comprehensive protection of a luminaire installation against lightning and
electrical surges, it is essential to cover mains supply and data input lines at
the distribution board level, by using respective primary (Type 1) and secondary
(Type 2) surge arrestors in compliance with EN61643-11/IEC61643-1.
Warning
Ensure that all required surge protection measures are in place and activated
prior to luminaire installation. Also, disconnect luminaires before operating
high-power devices such as, for example, electrical arc welders.
Installation tools
Mounting hardware used on this product
includes fasteners with hexalobular socket
heads (ISO 10664). Installation requires the
use of matching tools.
WE-EF LEUCHTEN
Installation and Maintenance
Instructions
Projector
FLC220 LED
FLC230 LED
FLC240 LED
FLC260 LED
FLC220-CC LED
FLC230-CC LED
FLC240-CC LED
FLC260-CC LED

1
IP66, IK07, Class I, ta = 25°C
165
ø 340
70
190
ø 18
ø 14
44
175
ø 385
60
195
44
ø 18
ø 14
FLC240 FLC260
196
FLC240-CC
ø 385
60
214
175
FLC260-CC
ø 18
ø 14
44
FLC230
ø 260
65
185
145
FLC230-CC
138
61
ø 190
ø 18
ø 14
44
FLC220
138
61
ø 190
FLC220-CC
Projector
Weight kg
for FLC220/FLC220-CC 4.3/4.3
for FLC230/FLC230-CC 7.6/7.7
for FLC240/FLC240-CC 12.6/13.8
for FLC260/FLC260-CC 17.5/18.0
Windage area m²
for FLC220 0.030
for FLC230 0.054
for FLC240 0.090
for FLC260 0.116
ø 5,5 – 12 mm 0,14 – 2,5 mm2
DMX-Power
Tools required
– Screwdriver TX25 / TX27 / TX40 / TX70
– Screwdriver with blade 3x1
– Stepped Tommy Bar 8 mm

2
Light Source
LED
Maintenance
Apart from cleaning the product’s exterior surfaces, no special maintenance work is required.
Do not use high-pressure cleaners.
In case of component failure due to abnormal circumstances or at end of life, replacement must be carried out
E\DVXLWDEO\TXDOLƂHGDQGWUDLQHGSURIHVVLRQDO
Warning: Do not open luminaire while mains supply is switched on.

3
Installation
The product must be installed and maintained by a
VXLWDEO\TXDOLƂHGSURIHVVLRQDOLQFRPSOLDQFHZLWKODWHVW
building/construction and/or electrical regulations and
relevant legislation.
Warning: Switch off mains electrical supply prior to
installing and connecting the luminaire.
Notice:,IWKHOXPLQDLUHLVPRGLƂHGE\DQ\ERG\RWKHU
than the original manufacturer, then the warranty will
no longer be valid and shall become the full respon-
sibility of the modifying person/organisation. Claims
based on defects attributable to improper installation
and/or application, and the consequences thereof, are
excluded.

4
Installation Procedure
2) Switch off mains electrical supply.1) Prior to electrical connection, proceed with
mechanical installation by securing stirrup A
to optional mounting accessory or directly to a
suitable surface. Aim luminaire in the desired
direction.
Warning: Ensure not to damage any electric
cable, water pipe or other devices while
drilling holes.
4) Check that rating shown on luminaire label
conforms with mains electrical supply.
(example)
FLC230-LED 220-240V/50-60 Hz
139-XXXX SOE XXXXXXX
LED 3000K 12W item no. XXX
11/18 IP66
3) Remove gear box cover Bby releasing screws C.

5
5) Feed mains supply cable Dthrough cable gland E. See Fig I.
Fig I. Feed mains supply cable through cable gland
6) Connect mains supply leads to respective terminals in terminal block F:
a) ON/OFF (L = Phase, N = Neutral, = Earthing)
b) 1-10 V/DALI (L = Phase, N = Neutral, = Earthing, DA/DA = DALI control line,
D–/D+ = 1-10 V control line).
Tighten cable gland E
c) DMX (L = Phase, N = Neutral, = Earthing, –/+ = DMX control line, S=Shield).
S

6
8) Loosen two screws Gslightly. Aim luminaire
(see illustration), tighten screws Gfirmly
(100 Nm).
In addition, tighten screw H(max. 6 Nm) to
secure orientation of luminaire.
7) Reposition gear box cover Band retighten
screws C.
Torque
Screw Torque
M4 max. 2.0 Nm
M5 max. 4.0 Nm
M6 max. 6.0 Nm
M8 max. 15.0 Nm
M16 max. 100.0 Nm

www.we-ef.com
WE-EF LEUCHTEN
Germany
Tel [phone]
Fax [phone]
[e-mail]
WE-EF LUMIERE
France
Tel [phone]
Fax [phone]
[e-mail]
WE-EF HELVETICA
Switzerland
Tel [phone]
Fax [phone]
[e-mail]
WE-EF LIGHTING
United Kingdom
Tel [phone]
Fax [phone]
[e-mail]
WE-EF LIGHTING
Thailand
Tel [phone]
Fax [phone]
LQIRDVLDSDFLƂF#ZHHIFRP
WE-EF LIGHTING
Australia
Tel [phone]
Fax [phone]
[e-mail]
WE-EF LIGHTING
United States of America
Tel [phone]
Fax [phone]
[e-mail]
TO9255W0219 © WE-EF 2019
7HFKQLFDOVSHFLƂFDWLRQVDUH
subject to change.