Dometic PSB150 User manual

PSB150
Portable Solar Blanket Kit
Installation and Operating Manual
EN
ENERGY & LIGHTING
SUN POWER
PSB150W-IO-AUS.book Seite 1 Donnerstag, 2. August 2018 9:15 09

EN
Explanation of symbols PSB150
2
Please read this instruction manual carefully before installation and first
use, and store it in a safe place. If you pass on the product to another
person, hand over this instruction manual along with it.
Table of contents
1 Explanation of symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
2 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
6 Using the solar blanket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
7 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
8 Maintaining and cleaning the product. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
9 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
10 Disposal. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
11 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
1 Explanation of symbols
!
!
A
WARNING!
Safety instruction: Failure to observe this instruction can cause fatal or
serious injury.
CAUTION!
Safety instruction: Failure to observe this instruction can lead to injury.
NOTICE!
Failure to observe this instruction can cause material damage and impair
the function of the product.
PSB150W-IO-AUS.book Seite 2 Donnerstag, 2. August 2018 9:15 09

EN
PSB150 General safety instructions
3
2 General safety instructions
The manufacturer accepts no liability for damage in the following cases:
•Damage to the product resulting from mechanical influences and incorrect
connection voltage
•Alterations to the product without express permission from the manufacturer
•Use for purposes other than those described in the operating manual
The declaration of conformity can be requested from the manufacturer (contact
information on the back).
Note the following basic safety information when using electrical devices to protect
against:
•Electric shock
•Fire hazards
•Injury
2.1 General safety
!WARNING!
•Only use the device as intended. Any alternation to the product
without express permission from Dometic Australia head office avoids
warranty.
•Disconnect the device
– Before cleaning and maintenance
–Afteruse
– Before changing a fuse
•The device may not be used if the device itself or connection cables
are visibly damaged.
•This device may only be repaired by qualified personnel. Inadequate
repairs may cause serious hazards.
•This device can not be used by children as well as by persons with
diminished physical, sensory or mental capacities or a lack of experi-
ence and knowledge.
•Electrical devices are not toys.
Always keep and use the device out of the reach of children.
•Children must be supervised to ensure that they do not play with the
appliance.
PSB150W-IO-AUS.book Seite 3 Donnerstag, 2. August 2018 9:15 09

EN
General safety instructions PSB150
4
ANOTICE!
•Check the manufacturer‘s data for your battery and ensure that the
maximum voltage of the solar charge controller does not exceed the
manufacturer‘s recommended charging voltage.
•Do not use the device to charge non-rechargeable batteries.
•Be sure to connect the battery before exposing the solar blanket to the
sun.
•Store the device in a dry and cool place.
2.2 Safety when installing the device
!WARNING!
•The electrical installation may only be connected by qualified person-
nel and only in accordance with the national regulations. Incorrect
connection may cause severe hazards.
•Take the precautions necessary to ensure that children cannot inter-
fere with operation. Dangerous situations may occur which cannot be
recognised by children.
ANOTICE!
•Do not expose the device to a heat source (open fire, heating etc.).
Avoid additional heating of the device in this way.
Electrical cables
!CAUTION!
•Lay the cables so that they cannot be tripped over or damaged.
ANOTICE!
•If cables have to be fed through metal walls or other walls with sharp
edges, use ducts or bushings to prevent damage.
•Do not lay cables which are loose or bent next to electrically
conductive material (metal).
•Do not pull on the cables.
•Do not lay AC cables and DC cables in the same duct.
•Fasten the cables securely.
PSB150W-IO-AUS.book Seite 4 Donnerstag, 2. August 2018 9:15 09

EN
PSB150 General safety instructions
5
2.3 Operating the device safely
!CAUTION!
•Do not use the solar blanket in windy or gusty conditions until it is
safely secured through 6 eyelets.
•Do not operate the device
– In salty, wet or damp environments
– In the vicinity of corrosive fumes
– In the vicinity of combustible materials
– In areas where there is a danger of explosions
ANOTICE!
•Do not disconnect any cables when the device is still in use.
•Do not seat, drop, walk or place heavy items on the solar blanket.
•Do not place heavy items on top of the solar blanket when in storage.
PSB150W-IO-AUS.book Seite 5 Donnerstag, 2. August 2018 9:15 09

EN
Scope of delivery PSB150
6
3Scopeofdelivery
No. in
fig. 1Description
1 Portable solar blanket with junction box
2 15 A PWM solar charge controller
3 Cable with grey Anderson connector to ring terminals with fuse 15 A
4 Cable with black Anderson connector to ring terminals with fuse 15 A
5 5 m extension cable with grey Anderson sockets
6 Cable with grey Anderson connector to Alligator clips
7 Temperature sensor
8 Carry bag
AMP/
VOLT
BATTERY
TYPE
Holdfor set tings
Solar
charge
controller
12 Volt
15 Amp
Charging status Battery condition
1 2
8
3
4
5
6
7
1
PSB150W-IO-AUS.book Seite 6 Donnerstag, 2. August 2018 9:15 09

EN
PSB150 Intended use
7
4 Intended use
The portable solar blanket is a mobile power supply with a solar charge controller for
charging a 12 Vgbattery.
5 Technical description
The portable solar blanket consists of lightweight solar cells with anti-reflective,
scratch-resistant ETFE coating. The solar charge controller stored in a bag of the blan-
ket can be used to charge a 12 Vgbattery.
The solar charge controller ensures that the power supplied by the solar blanket is at
the right voltage to charge a home or auxiliary battery. The solar charge controller is
an intelligent 5 stage PWM solar controller.
Solar charge controller
The solar charge controller has the following functions:
•PWM controlled
•Five stage charging (Soft, Bulk, Absorption, Equalization, Float)
•Battery types selectable: LiFePO4, LTO, GEL, AGM, WET or CALCIUM
•LCD display dynamically displaying operating data and working condition
Additional protective functions of the solar charge controller:
•Incorrect polarity protections for battery
•Over voltage protection for battery
•Over heating protection for battery
•Battery over-discharge protection
•Under charge protection for battery
•Over charge protection for battery
•Short circuit protection
•Prevents discharge at night under low light or no light condition
Battery temperature sensor
The battery temperature sensor allows the solar charge controller to continuously
adjust charge voltage based on measured battery temperature. Temperature com-
pensation of charge voltage assures that the battery receives the proper charge volt-
age as battery temperature changes during normal operation.
PSB150W-IO-AUS.book Seite 7 Donnerstag, 2. August 2018 9:15 09

EN
Technical description PSB150
8
5.1 Connecting and operational elements
No. in
fig. 2Description
1 Display See chapter “Display elements” on page 9
2 AMP/VOLT button Select the parameter to be displayed
3 BATTERY TYPE button Select the battery type
4 BATTERY CONDITION LEDs Monitoring the battery condition according
to the LEDs lighting.
5 CHARGING STATUS LEDs Monitoring the charging status of the battery
according to the LEDs lighting.
No. in
fig. 3Description
1 Solar blanket terminals
2 Battery terminals
3 Temperature sensor
AMP/
VOLT
BATTERY
TYPE
Hold for settings
Solar
charge
controller
12 Volt
15 Amp
Charging status Battery condition
2
3
1
4
5
2
Solar Battery Temp.
Sensor
1 2 3
3
PSB150W-IO-AUS.book Seite 8 Donnerstag, 2. August 2018 9:15 09

EN
PSB150 Technical description
9
5.2 Display elements
No. in
fig. 4Description
1 Indicates that the solar blanket is connected.
2 Indicates the charging status of the battery.
3 Indicates the parameters.
By pressing the VOLT/AMP button in sequence, the display indicates the fol-
lowing parameters in turn:
At day:
Battery Voltage (V) – Charging Current (A) – Charged capacity (Ah) – Battery
Temperature (°C, if temperature sensor connected)
At full battery:
Battery Voltage (V) – FULL
At night:
Battery Voltage (V) – Battery Temperature (°C, if temperature sensor con-
nected)
4 Indicates the battery type:
LiFePO4, LTO, GEL, AGM, WET or CALCIUM battery
LiFeP04 LT0 GEL AGMWET CALCIUM
100%
V
2
3
4
1
4
PSB150W-IO-AUS.book Seite 9 Donnerstag, 2. August 2018 9:15 09

EN
Using the solar blanket PSB150
10
6 Using the solar blanket
A
6.1 Positioning the solar blanket
Eyelets on four corners and sides of the portable solar kit provide different mounting
options. This solar blanket can be mounted on a vehicle, caravan or tent to provide
shade and provide power generation as well. It is recommended to place the solar
blanket north at 20 to 40 degree, which can provide the maximum power no matter
at any season.
➤Locate a clear area free from over hanging branches or obstructions.
➤Remove the solar blanket from the carry bag.
➤Lay the solar blanket on the mounting location. Fix the solar blanket at the eyelets.
NOTICE!
Make sure that the solar blanket is always clean and dry (chapter “Main-
taining and cleaning the product” on page 17).
5
PSB150W-IO-AUS.book Seite 10 Donnerstag, 2. August 2018 9:15 09