Horizon Fitness T608 User manual

&-*5&4&3*&4
53&"%.*--64&34(6*%&
'03.0%&-4
5
T4_T6_Rev.1.8.indd 1 10/27/06 1:26:16 PM


/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500
)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
$0/(3"56-"5*0/4BOE5)"/,:06GPSZPVSQVSDIBTFPGUIJT&MJUF4FSJFTUSFBENJMM
8IFUIFSZPVSHPBMJTUPXJOSBDFTPSTJNQMZFOKPZBGVMMFSIFBMUIJFSMJGFTUZMFBO&MJUF4FSJFTUSFBENJMM
DBOIFMQZPVBUUBJOJUoBEEJOHDMVCRVBMJUZQFSGPSNBODFUPZPVSBUIPNFXPSLPVUTXJUIUIFFSHPOPNJDT
BOEJOOPWBUJWFGFBUVSFTZPVOFFEUPHFUTUSPOHFSBOEIFBMUIJFSGBTUFS#FDBVTFXFhSFDPNNJUUFEUP
EFTJHOJOHmUOFTTFRVJQNFOUGSPNUIFJOTJEFPVUXFVTFPOMZUIFIJHIFTURVBMJUZDPNQPOFOUT*UhTB
DPNNJUNFOUXFCBDLXJUIPOFPGUIFTUSPOHFTUGSBNFUPNPUPSXBSSBOUZQBDLBHFTJOUIFJOEVTUSZ
:PVXBOUFYFSDJTFFRVJQNFOUUIBUPGGFSTUIFNPTUDPNGPSUUIFCFTUSFMJBCJMJUZBOEUIFIJHIFTURVBMJUZ
JOJUTDMBTT
*/530%6$5*0/
*NQPSUBOU1SFDBVUJPOT
"TTFNCMZ
#FGPSF:PV#FHJO
5SFBENJMM0QFSBUJPO
$POEJUJPOJOH(VJEFMJOFT
5SPVCMFTIPPUJOH.BJOUFOBODF
-JNJUFE8BSSBOUZ
$0/5"$5*/'03."5*0/







#BDL1BOFM
5"#-&0'$0/5&/54
T4_T6_Rev.1.8.indd 2-3 10/27/06 1:26:17 PM


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#6035 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
5IJTQSPEVDUJTSBUFENPSFUIBOBNQFSFTBOEJTGPSVTFPOBDJSDVJUIBWJOHBOPNJOBMSBUJOHPG
WPMUTBOEJTGBDUPSZFRVJQQFEXJUIBTQFDJmDFMFDUSJDDPSEBOEQMVHUPQFSNJUDPOOFDUJPOUPBQSPQFSFMFDUSJD
DJSDVJU.BLFTVSFUIBUUIFQSPEVDUJTDPOOFDUFEUPBOPVUMFUIBWJOHUIFTBNFDPOmHVSBUJPOBTUIFQMVH
/PBEBQUFSTIPVMECFVTFEXJUIUIJTQSPEVDU*GUIFQSPEVDUNVTUCFSFDPOOFDUFEGPSVTFPOBEJGGFSFOU
UZQFPGFMFDUSJDDJSDVJUUIFSFDPOOFDUJPOTIPVMECFNBEFCZRVBMJmFETFSWJDFQFSTPOOFM
*.1035"/54"'&5:*/4536$5*0/4
01&3"5*0/
5PSFEVDFUIFSJTLPGEBNBHJOHJNQPSUBOUDPNQPOFOUTPOZPVSUSFBENJMMJUJT
TUSPOHMZSFDPNNFOEFEUIBUZPVSUSFBENJMMJTQMVHHFEJOUPBEFEJDBUFEBNQ
DJSDVJU XJUIPVU UIF VTF PG BO BEEJUJPOBM FYUFOTJPO DPSE BOEPS QPXFS TUSJQ
'BJMVSFUPDPNQMZNBZWPJEUIFXBSSBOUZ
*.1035"/5
*UJT FTTFOUJBMUIBU ZPVSUSFBENJMMJT VTFEPOMZJOEPPSTJOB DMJNBUFDPOUSPMMFESPPN*GZPVS USFBENJMM
IBTCFFOFYQPTFEUPDPMEFSUFNQFSBUVSFTPSIJHINPJTUVSFDMJNBUFTJUJTTUSPOHMZSFDPNNFOEFEUIBUUIF
USFBENJMMJTXBSNFEVQUPSPPNUFNQFSBUVSFCFGPSFmSTUUJNFVTF'BJMVSFUPEPTPNBZDBVTFQSFNBUVSF
FMFDUSPOJDGBJMVSF
4"7&5)&4&*/4536$5*0/4
3FBE BMM JOTUSVDUJPOT CFGPSF VTJOH UIJT USFBENJMM 8IFO VTJOH BO FMFDUSJDBM QSPEVDU CBTJD QSFDBVUJPOT
TIPVMEBMXBZTCFGPMMPXFEJODMVEJOHUIFGPMMPXJOH3FBEBMMJOTUSVDUJPOTCFGPSFVTJOHUIJTUSFBENJMM*UJTUIF
SFTQPOTJCJMJUZPGUIFPXOFSUPFOTVSFUIBUBMMVTFSTPGUIJTUSFBENJMMBSFBEFRVBUFMZJOGPSNFEPGBMMXBSOJOHT
BOEQSFDBVUJPOT*GZPVIBWFBOZRVFTUJPOTBGUFSSFBEJOHUIJTNBOVBMDPOUBDU4FBSTBUUIFOVNCFSMJTUFEPO
UIFCBDLDPWFSPGUIJTNBOVBM
WARNING $POOFDUUIJTFYFSDJTFQSPEVDUUPBQSPQFSMZHSPVOEFEPVUMFUPOMZ
4FFHSPVOEJOHJOTUSVDUJPOT
(306/%*/(*/4536$5*0/4
5IJTQSPEVDUNVTUCFHSPVOEFE*GBUSFBENJMMTIPVMENBMGVODUJPOPSCSFBLEPXOHSPVOEJOHQSPWJEFTBQBUI
PGMFBTUSFTJTUBODFGPSFMFDUSJDBMDVSSFOUUPSFEVDFUIFSJTLPGFMFDUSJDBMTIPDL5IJTQSPEVDUJTFRVJQQFEXJUI
BDPSEIBWJOHBOFRVJQNFOUHSPVOEJOHDPOEVDUPSBOEBHSPVOEJOHQMVH5IFQMVHNVTUCFQMVHHFEJOUPBO
BQQSPQSJBUFPVUMFUUIBUJTQSPQFSMZJOTUBMMFEBOEHSPVOEFEJOBDDPSEBODFXJUIMPDBMDPEFTBOEPSEJOBODFT
WARNING *NQSPQFSDPOOFDUJPOPGUIFFRVJQNFOUHSPVOEJOHDPOEVDUPSDBOSFTVMUJOBSJTLPG
FMFDUSJDTIPDL$IFDLXJUIBRVBMJmFEFMFDUSJDJBOPSTFSWJDFNBOJGZPVBSFJOEPVCU
BTUPXIFUIFSUIFQSPEVDUJTQSPQFSMZHSPVOEFE%POPUNPEJGZUIFQMVHQSPWJEFE
XJUIUIFQSPEVDU*GJUXJMMOPUmUUIFPVUMFUIBWFBQSPQFSPVUMFUJOTUBMMFECZB
RVBMJmFEFMFDUSJDJBO
WARNING
50 3&%6$& 5)& 3*4, 0' #63/4 '*3& &-&$53*$"- 4)0$, 03 */+63:
50 1&340/4
WARNING
/FWFSVTFUIFUSFBENJMMCFGPSFTFDVSJOHUIF
TBGFUZUFUIFSDMJQUPZPVSDMPUIJOH
*GZPVFYQFSJFODFBOZLJOEPGQBJOJODMVEJOH
CVU OPU MJNJUFE UP DIFTU QBJOT OBVTFB
EJ[[JOFTT PS TIPSUOFTT PG CSFBUI TUPQ
FYFSDJTJOH JNNFEJBUFMZ BOE DPOTVMU ZPVS
QIZTJDJBOCFGPSFDPOUJOVJOH
%POPUXFBSDMPUIFTUIBUNJHIUDBUDIPOBOZ
QBSUPGUIFUSFBENJMM
"MXBZTXFBSBUIMFUJDTIPFTXIJMFVTJOHUIJT
FRVJQNFOU
%POPUKVNQPOUIFUSFBENJMM
6OQMVHUSFBENJMMCFGPSFNPWJOHPSDMFBOJOH
JU5PDMFBOXJQFTVSGBDFTEPXOXJUITPBQ
BOE TMJHIUMZ EBNQ DMPUI POMZ OFWFS VTF
TPMWFOUT4FF."*/5&/"/$&
"UOPUJNFTIPVMENPSFUIBOPOFQFSTPOCF
POUSFBENJMMXIJMFJOPQFSBUJPO
5IFUSFBENJMMTIPVMEOPUCFVTFECZQFSTPOT
XFJHIJOH NPSF UIBO QPVOET'BJMVSF

UP DPNQMZ XJMM WPJE UIF XBSSBOUZ
5IFUSFBENJMMJTJOUFOEFEGPSJOIPNFVTFPOMZ
%POPUVTFUIJTUSFBENJMMJOBOZDPNNFSDJBM
SFOUBMTDIPPMPSJOTUJUVUJPOBMTFUUJOH'BJMVSF
UPDPNQMZXJMMWPJEUIFXBSSBOUZ
%POPUVTFUSFBENJMMJOBOZMPDBUJPOUIBUJT
OPUUFNQFSBUVSFDPOUSPMMFETVDIBTCVUOPU
MJNJUFE UP HBSBHFT QPSDIFT QPPM SPPNT
CBUISPPNTDBSQPSUTPSPVUEPPST'BJMVSFUP
DPNQMZNBZWPJEUIFXBSSBOUZ
t
t
t
t
t
t
t
t
t
t
"OBQQMJBODFTIPVMEOFWFSCFMFGUVOBUUFOEFEXIFOQMVHHFEJO
6OQMVHGSPNPVUMFUXIFOOPUJOVTFBOECFGPSFQVUUJOHPOPS
UBLJOHPGGQBSUT
$MPTFTVQFSWJTJPOJTOFDFTTBSZXIFOUIJTBQQMJBODFPSUSFBENJMM
JTVTFECZPOPSOFBSDIJMESFOJOWBMJETPSEJTBCMFEQFSTPOT
6TF UIJT BQQMJBODF PS USFBENJMM POMZ GPS JUT JOUFOEFE VTF
BT EFTDSJCFE JO UIJT NBOVBM %P OPU VTF BUUBDINFOUT OPU
SFDPNNFOEFECZUIFNBOVGBDUVSFS
/FWFSPQFSBUFUIJTBQQMJBODFPSUSFBENJMMJGJUIBTBEBNBHFE
DPSEPSQMVHJGJUJTOPUXPSLJOHQSPQFSMZJGJUIBTCFFOESPQQFE
PSEBNBHFE PSESPQQFEJOUP XBUFS 3FUVSOUIFBQQMJBODF PS
USFBENJMMUPBTFSWJDFDFOUFSGPSFYBNJOBUJPOBOESFQBJS
%POPUDBSSZUIJTBQQMJBODFPSUSFBENJMMCZTVQQMZDPSEPSVTF
DPSEBTBIBOEMF
,FFQUIFDPSEBXBZGSPNIFBUFETVSGBDFT
/FWFSPQFSBUFUIFBQQMJBODFPSUSFBENJMMXJUIUIFBJSPQFOJOHT
CMPDLFE,FFQUIFBJSPQFOJOHTGSFFPGMJOUIBJSBOEUIFMJLF
/FWFSESPQPSJOTFSUBOZPCKFDUJOUPBOZPQFOJOH
%POPUVTFPVUEPPST
%POPUPQFSBUFXIFSFBFSPTPMTQSBZQSPEVDUTBSFCFJOHVTFEPS
XIFSFPYZHFOJTCFJOHBENJOJTUFSFE
5PEJTDPOOFDUUVSOBMMDPOUSPMTUPUIFPGGQPTJUJPOUIFOSFNPWF
QMVHGSPNPVUMFU
%POPUPQFSBUFVOEFSCMBOLFUPSQJMMPX&YDFTTJWFIFBUJOHDBO
PDDVSBOEDBVTFmSFFMFDUSJDTIPDLPSJOKVSZUPQFSTPOT
t
t
t
t
t
t
t
t
t
t
t
t
8IFOVTJOHBOFMFDUSJDBMBQQMJBODFCBTJDQSFDBVUJPOTTIPVMEBMXBZTCFGPMMPXFEJODMVEJOHUIFGPMMPXJOH
3FBEBMMJOTUSVDUJPOTCFGPSFVTJOHUIJTBQQMJBODF
4"7&5)&4&*/4536$5*0/4
"U/0UJNFTIPVMEQFUTPSDIJMESFOVOEFSUIFBHFPGCFDMPTFSUPUIFUSFBENJMMUIBOGFFU
"U/0UJNFTIPVMEDIJMESFOVOEFSUIFBHFPGVTFUIFUSFBENJMM
$IJMESFOPWFSUIFBHFPGTIPVMEOPUVTFUIFUSFBENJMMXJUIPVUBEVMUTVQFSWJTJPO
50 3&%6$& 5)& 3*4, 0' &-&$53*$ 4)0$,
"MXBZTVOQMVHUIJTBQQMJBODFPSUSFBENJMMGSPNUIFFMFDUSJDBMPVUMFU
JNNFEJBUFMZBGUFSVTJOHBOECFGPSFDMFBOJOH
DANGER
50 3&%6$& 5)& 3*4, 0' */+63: 50 1&340/4
4UBOEPOUIFTJEFSBJMTCFGPSFTUBSUJOHUIFUSFBENJMM3FBE*OTUSVDUJPO
.BOVBMCFGPSFVTJOH3FNPWFTBGFUZLFZXIFOOPUJOVTFBOETUPSFPVUPG
SFBDIPGDIJESFO
WARNING
'03)064&)0-%64&0/-:
T4_T6_Rev.1.8.indd 4-5 10/27/06 1:26:20 PM


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#60
35 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500
)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
"44&.#-:
*.1035"/53&"%5)&4&4"'&5:*/4536$5*0/4#&'03&64&
%VSJOHUIFBTTFNCMZQSPDFTTPGUIFUSFBENJMMUIFSFBSFTFWFSBMBSFBTUIBUTQFDJBMBUUFOUJPONVTUCFQBJE
*UJT WFSZ JNQPSUBOU UPGPMMPXUIFBTTFNCMZ JOTUSVDUJPOT DPSSFDUMZBOEUPNBLF TVSF BMM QBSUTBSFmSNMZ
UJHIUFOFE*GUIFBTTFNCMZJOTUSVDUJPOTBSFOPUGPMMPXFEDPSSFDUMZUIFUSFBENJMMDPVMEIBWFGSBNFQBSUTUIBU
BSFOPUUJHIUFOFEBOEXJMMTFFNMPPTFBOENBZDBVTFJSSJUBUJOHOPJTFT5IFSFTIPVMECFOPTJEFUPTJEFQMBZ
JOUIFDPOTPMFNBTUTPSBOZGPSXBSEBOECBDLQMBZJOUIFDPOTPMFBTTFNCMZPSIBOEMFCBST*GUIFSFJTBOZ
QMBZJOUIFTFBSFBTUIFUSFBENJMMIBTOPUCFFOQSPQFSMZBTTFNCMFE5PQSFWFOUEBNBHFUPUIFUSFBENJMMUIF
BTTFNCMZJOTUSVDUJPOTNVTUCFSFWJFXFEBOEDPSSFDUJWFBDUJPOTTIPVMECFUBLFO
6/1"$,*/(
1MBDFUIFUSFBENJMMDBSUPOPOBMFWFMnBUTVSGBDF*UJTSFDPNNFOEFEUIBUZPVQMBDFBQSPUFDUJWFDPWFSJOH
POZPVSnPPS5BLF$"65*0/XIFOIBOEMJOHBOEUSBOTQPSUJOHUIJTVOJU/FWFSPQFOCPYXIFOJUJTPOJUT
TJEF6OQBDLUIFVOJUXIFSFJUXJMMCFVTFE'"*-63&50'0--085)&4&*/4536$5*0/4$06-%3&46-5*/
*/+63:
500-4*/$-6%&%
1"354*/$-6%&%
4BGFUZ,FZ
$POTPMF"TTFNCMZ
1PXFS$PSE
)BSEXBSF#BHT
)BOE3BJMT
)BOE3BJM#BTF$PWFST
$POTPMF.BTUT
$VQ)PMEFST
)BOE3BJM4MFFWFT
%*41-":
8"5&3#055-&)0-%&3
(3*116-4&)"/%3"*-4
0/0''48*5$)
$*3$6*5#3&",&3
53"/410358)&&-
108&3$03%
$0/40-&
4"'&5:,&:1-"$&.&/5
.0503$07&3
36//*/(#&-536//*/(%&$,
4*%&3"*-
30--&3&/%$"1
$0/40-&."45
3&"330--&3
"%+645.&/5#0-54
NN"MMFO8SFODI
NN5XSFODI
NN5XSFODI
4DSFXESJWFS
)"/%3"*-
)"/%3"*-4-&&7&
)"/%3"*-#"4&$07&3
WARNING
T4_T6_Rev.1.8.indd 6-7 10/27/06 1:26:23 PM


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#60
35 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500
)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
"0QFO #-6& )"3%8"3&#"(
#$POOFDUUIF$0/40-&8*3&4
GSPNUIF$0/40-&UPUIPTFGSPN
UIFUPQPGUIF."45
$"UUBDI $0/40-&UPUIF
$0/40-&."454VTJOH
#0-5%
%3FQFBUPOPUIFSTJEF
&5JHIUFOBMMDPOTPMFCPMUT
'4OBQFBDIPGUIF$61)0-%&34
mSNMZJOUPUIF$0/40-&
/05& %VSJOHFBDIBTTFNCMZTUFQFOTVSFUIBU"--OVUTBOECPMUTBSFJOQMBDFBOEQBSUJBMMZUISFBEFEJOCFGPSF
DPNQMFUFMZUJHIUFOJOHBOZ0/&CPMU/05&"MJHIUBQQMJDBUJPOPGHSFBTFNBZBJEJOUIFJOTUBMMBUJPOPGIBSEXBSF
"OZHSFBTFTVDIBTMJUIJVNCJLFHSFBTFJTSFDPNNFOEFE
13&"44&.#-:
"44&.#-:45&1
#0-5"
NN
2UZ
"3$8"4)&3$
NN%JBNFUFS
2UZ
413*/(8"4)&3#
NN%*".&5&3
2UZ
1*/,)"3%8"3&#"($0/5&/54
"44&.#-:45&1
#0-5%
NN
2UZ
#-6&)"3%8"3&#"($0/5&/54
#0-5"
413*/(8"4)&3#
8"4)&3$
$0/40-&."45
#"4&'3".&
$0/40-&8*3&4
#0-5%
$0/40-&
46((&45&%.&5)0%'0345"35*/(#0-5
$0/40-&8*3&4
"0QFO 1*/, )"3%8"3&#"(
#$POOFDUUIF$0/40-&8*3&4
GSPNUIF#"4&'3".&UPUIF
CPUUPNPGUIF$0/40-&."45
$"UUBDI -&'5$0/40-&."45
VTJOH#0-54"413*/(
8"4)&34#BOE"3$
8"4)&34$
%3FQFBUPOPUIFSTJEF
$61)0-%&3
/05&#FDBSFGVMOPUUPQJODIBOZ
XJSFTXIJMFBTTFNCMJOHUIFNBTUT
/05&#FDBSFGVMOPUUPQJODIBOZ
XJSFTXIJMFBTTFNCMJOHUIFDPOTPMF

10
INTRODUCTION IMPORTANT
PRECAUTIONS ASSEMBLY BEFORE
YOU BEGIN TREADMILL
OPERATION LIMITED
WARRANTY
TROUBLESHOOTING
& MAINTENANCE
CONDITIONING
GUIDELINES
11
INTRODUCTION
IMPORTANT
PRECAUTIONS
ASSEMBLY
BEFORE
YOU BEGIN
TREADMILL
OPERATION
CONDITIONING
GUIDELINES
TROUBLESHOOTING
& MAINTENANCE
LIMITED
WARRANTY
A Open WHITE HARDWARE BAG.
B Slide HAND RAIL SLEEVE over
the top of the hand rail.
C Attach top of HAND RAIL to
the console extension using 2
SCREWS (G).
D Attach bottom of HAND RAIL to
the base frame using 1 BOLT
(H), 1 SPRING WASHER (I) and
1 WASHER (J).
ESlide HAND RAIL SLEEVE firmly
against console.
FRepeat on other side.
ASSEMBLY STEP 3
SCREW (G)
15 mm
Qty: 4
BOLT (H)
30 mm
Qty: 2
WASHER (J)
8 mm DIAMETER
Qty: 2
SPRING WASHER (I)
8 mm DIAMETER
Qty: 2
WHITE HARDWARE BAG CONTENTS :
HAND RAIL
HAND RAIL SLEEVE
WASHER (J)
BOLT (H)
SPRING WASHER (I)
SCREW (G)
YOU’RE FINISHED!
A Open ORANGE HARDWARE BAG.
B Attach HAND RAIL BASE COVER to
the base frame using
2 SCREWS (K).
C Slide HAND RAIL TRANSITION
PIECE and HANDLEBAR into
CONSOLE.
CRepeat on other side.
DBe sure all bolts and screws are
tightened and secured on the
treadmill.
ASSEMBLY STEP 4
SCREW (K)
30 mm
Qty: 4
ORANGE HARDWARE BAG CONTENTS :
SCREW (K)
HAND RAIL BASE COVER
HAND RAIL TRANSITION PIECE
T4_T6_Rev.1.8.indd 10-11 10/27/06 1:26:31 PM

12
INTRODUCTION IMPORTANT
PRECAUTIONS ASSEMBLY BEFORE
YOU BEGIN TREADMILL
OPERATION LIMITED
WARRANTY
TROUBLESHOOTING
& MAINTENANCE
CONDITIONING
GUIDELINES
13
INTRODUCTION
IMPORTANT
PRECAUTIONS
ASSEMBLY
BEFORE
YOU BEGIN
TREADMILL
OPERATION
CONDITIONING
GUIDELINES
TROUBLESHOOTING
& MAINTENANCE
LIMITED
WARRANTY
BEFORE YOU BEGIN
CONGRATULATIONS! on choosing your treadmill. You’ve taken an important step in developing and
sustaining an exercise program! Your treadmill is a tremendously effective tool for achieving your personal
fitness goals. Regular use of your treadmill can improve the quality of your life in so many ways.
HERE ARE JUST A FEW OF THE HEALTH BENEFITS OF EXERCISE:
• Weight Loss
• A Healthier Heart
• Improved Muscle Tone
• Increased Daily Energy Levels
The key to reaping these benefits is to develop an exercise habit. Your new treadmill will help you eliminate
obstacles that prevent you from exercising. Inclement weather and darkness won't interfere with your
workout when you use your treadmill in the comfort of your home. This guide provides you with basic
information for using and enjoying your new machine.
LOCATION OF THE TREADMILL
Place the treadmill on a level surface. There should be 6 feet of clearance
behind the treadmill, 3 feet on each side and one foot in front for folding
and the power cord. Do not place the treadmill in any area that will block
any vent or air openings. The treadmill should not be located in a garage,
covered patio, near water or outdoors.
DO NOT STAND ON THE BELT
While you are preparing to use the treadmill, do not stand on the belt.
Place your feet on the side rails before starting the treadmill. Start
walking on the belt only after the belt has begun to move. Never start the
treadmill at a fast running speed and attempt to jump on!
SAFETY KEY
Your treadmill will not start unless the safety key is placed in position. Attach the clip end securely to your
clothing. This safety key is designed to cut the power to the treadmill if you should fall. Check the operation
of the safety key every 2 weeks.
NEVER USE THE TREADMILL WITHOUT SECURING THE SAFETY KEY CLIP TO YOUR
CLOTHING. PULL ON THE SAFETY KEY CLIP FIRST TO MAKE SURE IT WILL NOT
COME OFF YOUR CLOTHING.
WARNING
3 feet
6 feet
3 feet
1 foot
WARNING
PROPER USAGE
Your treadmill is capable of reaching high speeds. Always start off using a slower speed and adjust the speed in
small increments to reach a higher speed level. Never leave the treadmill unattended while it is running. When
not in use, remove the safety key, turn the on/off switch to off and unplug the power cord. Make sure to follow
the MAINTENANCE schedule in this manual. Keep your body and head facing forward. Do not attempt to turn
around or look backwards while the treadmill is running. Stop your workout immediately if you feel pain, faint,
dizzy or are short of breath.
Do not operate the treadmill if the power cord or plug is damaged.
If the treadmill appears to not be working properly, do not use the treadmill.
MOVING
Your treadmill has a pair of transport wheels built
into the frame. To move, firmly grasp the rear of the
frame and carefully lift.
Our Treadmills are heavy, use care and additional help if necessary when moving.
Failure to follow these instructions could result in injury.
WARNING
WARNING
T4_T6_Rev.1.8.indd 12-13 10/27/06 1:26:33 PM


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#60
35 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
-
-*
.%"
&3
5/0*5
"3
&10
(/*/0*5*%/0$ 4
&/
*-&%*6(
(/
*500
)4
&
-#6035 &$/"/
&
5/*
".

%&5
*
.*
-:5/"33"8
$&/5&3*/(5)&36//*/(#&-5
5IFSVOOJOHCFMUIBTCFFOQSPQFSMZBEKVTUFEBUUIF
GBDUPSZCFGPSFJUXBTTIJQQFE"UUJNFTUIFCFMUDBO
NPWFPGGDFOUFSEVSJOHTIJQNFOU#FGPSFPQFSBUJOHUIF
USFBENJMMNBLFTVSFUIFCFMUJTDFOUFSFEBOESFNBJOT
DFOUFSFEUPNBJOUBJOTNPPUIPQFSBUJPO
$"65*0/%POPUSVOCFMUGBTUFSUIBONQIXIJMF
DFOUFSJOH,FFQmOHFSTIBJSBOEDMPUIJOHBXBZGSPN
CFMUBUBMMUJNFT
*GUIFSVOOJOHCFMUJTUPPGBSUPUIFSJHIUTJEF
8JUIUIFUSFBENJMMSVOOJOHBUNQIUVSOUIFSJHIU
BEKVTUNFOUCPMUDMPDLXJTF 563/BU BUJNFVTJOH
UIFTVQQMJFE"MMFOXSFODI$IFDLUIFCFMUBMJHONFOU
"MMPXCFMUUPSVOBGVMMDZDMFUPHBVHFJGNPSFBEKVTUNFOU
JTOFFEFE3FQFBUJGOFDFTTBSZVOUJMUIFCFMUSFNBJOT
DFOUFSFEEVSJOHVTF
*GUIFSVOOJOHCFMUJTUPPGBSUPUIFMFGUTJEF
8JUIUIFUSFBENJMMSVOOJOHBUNQIUVSOUIFSJHIU
BEKVTUNFOUCPMUDPVOUFSDMPDLXJTF563/BUBUJNF
VTJOH UIF TVQQMJFE "MMFO XSFODI $IFDL UIF CFMU
BMJHONFOU"MMPXCFMUUPSVOBGVMMDZDMFUPHBVHFJGNPSF
BEKVTUNFOU JT OFFEFE 3FQFBU JG OFDFTTBSZ VOUJM UIF
CFMUSFNBJOTDFOUFSFEEVSJOHVTF
#FMUJTUPPGBSUPUIFSJHIUTJEF
#FMUJTUPPGBSUPUIFMFGUTJEF
5&/4*0/*/(5)&36//*/(#&-5
5IF SVOOJOH CFMU IBT CFFO QSPQFSMZ BEKVTUFE BU UIF
GBDUPSZ CFGPSF JU XBT TIJQQFE "U UJNFT UIF CFMU DBO
NPWFPGGDFOUFSEVSJOHTIJQNFOU
$"65*0/ 3VOOJOHCFMU TIPVME /05 CFNPWJOHEVSJOH
UFOTJPOJOH 0WFSUJHIUFOJOH UIF SVOOJOH CFMU DBO
DBVTF FYDFTTJWF XFBS PO UIF USFBENJMM BT XFMM BT JUT
DPNQPOFOUT/FWFSPWFSUJHIUFOUIFCFMU
*GZPVDBOGFFMBTMJQQJOHTFOTBUJPOXIFOSVOOJOHPOUIF
USFBENJMMUIFSVOOJOHCFMUNVTUCFUJHIUFOFE*ONPTU
DBTFT UIF CFMU IBT TUSFUDIFE GSPN VTF DBVTJOH UIF
CFMUUPTMJQ5IJTJTBOPSNBMBOEDPNNPOBEKVTUNFOU
5P FMJNJOBUF UIJT TMJQQJOH 563/ 5)& 53&"%.*-- 0''
BOEUFOTJPO#05) 5)& 3&"3 30--&3 #0-54VTJOHUIF
TVQQMJFE"MMFOXSFODI UVSOJOH UIFN  563/ UPUIF
SJHIU BT TIPXO 5VSO UIF USFBENJMM PO BOE DIFDL GPS
TMJQQJOH 3FQFBU JG OFDFTTBSZ CVU /&7&3 563/ UIF
SPMMFSCPMUTNPSFUIBOUVSOBUBUJNF#FMUJTQSPQFSMZ
UFOTJPOFEXIFOUIFTMJQQJOHTFOTBUJPOJTHPOF
T4_T6_Rev.1.8.indd 14-15 10/27/06 1:26:37 PM
/PUF5IFSFJTBUIJOQSPUFDUJWFTIFFUPGDMFBSQMBTUJDPOUIFPWFSMBZPGUIFDPOTPMFBOETIPVMECFSFNPWFE
"F53", #6550/6TFEUPTDSPMMUISPVHIF53",EJTQMBZNPEFT
# -&% %*41-": 8*/%084 %JTQMBZT )FBSU 3BUF $BMPSJFT 5JNF %JTUBODF *ODMJOF 4QFFE 1BDF $MPDL BOE
%BUF
$-"3(&-&%8*/%08%JTQMBZTQSPHSBNQSPmMFT
%"-1)"/6.&3*$8*/%08 *OEJDBUFTFYFSDJTFGFFECBDLBOEIFMQUFYU
&45"351SFTTUPCFHJOFYFSDJTJOHTUBSUTZPVSQSPHSBNPSSFTVNFFYFSDJTJOHBGUFSQBVTF
'45011SFTTUPQBVTFFOEZPVSXPSLPVU)PMEGPSTFDPOETUPSFTFUUIFUSFBENJMM
(64&3,&:41SFTTUPTFMFDUVTFS
)26*$, 130(3". ,&:41SFTTUPTFMFDUQSPHSBN1SFTT&/5&3 UPDPOmSNTFMFDUJPO
*130(3"..*/( #6550/6TFEUPTFMFDU1SPHSBN-FWFMBOE5JNFBOEPUIFSPQUJPOT1SFTTUPDIBOHFEJTQMBZ
GFFECBDLEVSJOHXPSLPVU
+*/$-*/&"3308,&:46TFEUPBEKVTUJODMJOFJOTNBMMJODSFNFOUTJODSFNFOUT
,41&&%"3308,&:46TFEUPBEKVTUTQFFEJOTNBMMJODSFNFOUTNQIJODSFNFOUT
-26*$,"%+645 */$-*/&,&:46TFEUPSFBDIEFTJSFEJODMJOFRVJDLMZ1SFTTCFGPSF*/$-*/&$0/'*3."5*0/
,&:
.*/$-*/& $0/'*3."5*0/ ,&:1SFTTUPDPOmSNRVJDLBEKVTUJODMJOFTFMFDUJPOOFDFTTBSZPOMZXIFO*/$3&"4*/(
JODMJOF
/26*$,"%+645 41&&%,&:46TFEUPSFBDIEFTJSFETQFFERVJDLMZ1SFTTCFGPSF41&&%$0/'*3."5*0/,&:
041&&% $0/'*3."5*0/ ,&:1SFTTUPDPOmSNRVJDLBEKVTUTQFFETFMFDUJPOOFDFTTBSZPOMZXIFO*/$3&"4*/(
TQFFE
53&"%.*--01&3"5*0/
%
$#"(
)- . /0*&+ ,'
#


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#60
35 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500
)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
16-4&(3*14
1MBDFUIFQBMNPGZPVSIBOETEJSFDUMZPOUIFHSJQQVMTFIBOEMFCBST#PUIIBOETNVTUHSJQUIFCBSTGPSZPVS
IFBSUSBUFUPSFHJTUFS*UUBLFTDPOTFDVUJWFIFBSUCFBUTTFDPOETGPSZPVSIFBSUSBUFUPSFHJTUFS8IFO
HSJQQJOHUIFQVMTFIBOEMFCBSTEPOPUHSJQUJHIUMZ)PMEJOHUIFHSJQTUJHIUMZNBZFMFWBUFZPVSCMPPEQSFTTVSF
,FFQ B MPPTF DVQQJOH IPME :PV NBZ FYQFSJFODF BO FSSBUJD SFBEPVU JG DPOTJTUFOUMZ IPMEJOH UIF HSJQ QVMTF
IBOEMFCBST.BLFTVSFUPDMFBOUIFQVMTFTFOTPSTUPFOTVSFQSPQFSDPOUBDUDBOCFNBJOUBJOFE
)&"353"5&
8*3&-&44$)&4553"/4.*55&3
1SJPS UP XFBSJOH UIF XJSFMFTT DIFTU USBOTNJUUFS PO ZPVS
DIFTUNPJTUFOUIFUXPSVCCFSFMFDUSPEFTXJUIXBUFS$FOUFS
UIFDIFTUTUSBQKVTUCFMPXUIFCSFBTUPSQFDUPSBMNVTDMFT
EJSFDUMZPWFSZPVSTUFSOVNXJUIUIFMPHPGBDJOHPVU/05&
5IFDIFTUTUSBQNVTUCFUJHIUBOEQSPQFSMZQMBDFEUPSFDFJWF
BOBDDVSBUFBOEDPOTJTUFOUSFBEPVU*GUIFDIFTUTUSBQJTUPP
MPPTFPSQPTJUJPOFEJNQSPQFSMZZPVNBZSFDFJWFBOFSSBUJD
PS JODPOTJTUFOU IFBSU SBUF SFBEPVU 8"3/*/( 5IF IFBSU
SBUFGVODUJPOJTOPUBNFEJDBMEFWJDF7BSJPVTGBDUPSTNBZ
BGGFDUUIFBDDVSBDZPGZPVSIFBSUSBUFSFBEJOH5IFIFBSUSBUF
SFBEJOHJTJOUFOEFEPOMZBTBOFYFSDJTFBJE
#"$,4*%&0'$)&4553"/4.*55&3
"11-:.0*4563&)&3&
.0/*503%*41-":4
$-0$,%"5&
*/$-*/& 41&&%1"$&
5*.& %*45"/$&
)&"353"5& $"-03*&4
)&"35 3"5&t4IPXOBT#1.*OEJDBUFTZPVSIFBSUSBUFXIJMFXBMLJOHPSSVOOJOH
$"-03*&4t5PUBM$BMPSJFTCVSOFEEVSJOHZPVSXPSLPVU
5*.&t4IPXOBT.JOVUFT4FDPOETBOE)PVST.JOVUFT7JFXUIFUJNFSFNBJOJOHPSUIFUJNFFMBQTFEJO
ZPVSXPSLPVU
%*45"/$&t4IPXOBT.JMFT*OEJDBUFTEJTUBODFUSBWFMFEEVSJOHZPVSXPSLPVU
*/$-*/&t4IPXOBT1FSDFOU*OEJDBUFTUIFJODMJOFPGZPVSXBMLJOHPSSVOOJOHTVSGBDF
41&&%t4IPXOBT.1)*OEJDBUFTIPXGBTUZPVSXBMLJOHPSSVOOJOHTVSGBDFJTNPWJOH
1"$&t4IPXOBT.JOVUFT5FOUITPGB.JOVUF*OEJDBUFTUIFUJNFUPSVOBNJMFBUUIFDVSSFOUTQFFE
$-0$,t5IFDMPDLEJTQMBZTUIFUJNFPGEBZ
%"5&t%BUFGPSNBUJTNPOUIBOEEBUF
130(3".130'*-&4t3FQSFTFOUTUIFQSPmMFPGUIFQSPHSBNCFJOHVTFETQFFEEVSJOHTQFFECBTFE
QSPHSBNTBOEJODMJOFEVSJOHJODMJOFCBTFEQSPHSBNT
T4_T6_Rev.1.8.indd 22-23 10/27/06 1:26:46 PM
(&55*/(45"35&%4&-&$5*/("130(3".
 $IFDLUPNBLFTVSFOPUIJOHJTPOPSXJMMIJOEFSUIFNPWFNFOUPGUIFUSFBENJMM
 1MVHJOUIFQPXFSDPSEBOEUVSOUIFUSFBENJMM0/
 4UBOEPOUIFTJEFSBJMTPGUIFUSFBENJMM
 "UUBDIUIFTBGFUZLFZDMJQUPQBSUPGZPVSDMPUIJOH
 *OTFSUUIFTBGFUZLFZJOUPUIFTBGFUZLFZIPMFJOUIFDPOTPMF
 :PVIBWFUXPPQUJPOTUPTUBSUZPVSXPSLPVU
26*$, 45"35 61
4JNQMZQSFTTUIF45"35 LFZUPCFHJOXPSLJOHPVU03
4&-&$5"130(3".
4FMFDUB130(3".VTJOHUIF26*$,130(3".,&:4LFZT
0ODFB130(3". IBTCFFODIPTFOQSFTT&/5&3
4&-&$5"-&7&-
4FMFDUB130(3". -&7&-VTJOHUIF"3308LFZTPOUIF130(3"..*/(CVUUPO
0ODFB130(3". -&7&-IBTCFFODIPTFOQSFTT&/5&3
4&-&$5"5*.&
4FMFDUB5JNFVTJOHUIF "3308LFZPOUIF130(3"..*/(CVUUPOPSVTFUIFEFGBVMUUJNF
0ODFB5*.&IBTCFFODIPTFOQSFTT45"35
'*/*4)*/(:063803,065
8IFOZPVSXPSLPVUJTDPNQMFUFZPVXJMMIFBSBTFSJFTPGCFFQT:PVSXPSLPVUJOGPSNBUJPOXJMMCFEJTQMBZFEGPS
TFDPOETBOEUIFOSFTFU
$-&"3$633&/54&-&$5*0/
5PDMFBSUIFDVSSFOUQSPHSBNTFMFDUJPOPSTDSFFOIPMEUIF4501CVUUPOGPSTFDPOET


/0*5$6%035/* 5/"5301.* 4/0*56"$&31 :-#.&44" &30'&# /*(&#60: --*.%"&35 /0*5"3&10 %&5*.*- :5/"33"8
(/*500)4&-#60
35 &$/"/&5/*".
(/*/0*5*%/0$ 4&/*-&%*6(

/0*5$6%035/*
5/"5301.* 4/0*56"$&31
:-#.&44"
&30'&# /*(&#60:
--*.%"&35 /0*5"3&10
(/*/0*5*%/0$ 4&/*-&%*6(
(/*500
)4&-#6035 &$/"/&5/*".
%&5*.*- :5/"33"8
130(3".*/5&37"-4
130(3"..06/5"*/$-*.#
4JNVMBUFTDMJNCJOHBOEEFTDFOEJOHBNPVOUBJOCZBVUPNBUJDBMMZWBSZJOH*/$-*/&  EJGmDVMUZMFWFMTUPDIPPTFGSPN
-FWFM 8"3. 61 $00-%08/
*ODMJOF
             
             
             
             
             
             
             
             
             
              
              
              
8"3.61 BOE $00-%08/MBTUNJOVUFTFBDIBOEBSFJODMVEFEJOQSPHSBNUJNFT
130(3".."/6"-
"MMPXTA0O5IF'MZNBOVBM41&&%BOE*/$-*/&DIBOHFT5JNFCBTFEHPBM
130(3".*/'03."5*0/
8BMLPSSVOBTFSJFTPGBMUFSOBUJOH41&&%MFWFMT5JNFCBTFEHPBMXJUIEJGmDVMUZMFWFMTUPDIPPTFGSPN
*/5&37"-4130(3".4&(.&/54
QFBLTFHNFOUTMBTUTFDPOETWBMMFZTFHNFOUTMBTUTFDPOET
   
8BSN6Q $PPM%PXO
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
-FWFM        
8"3.61BOE$00-%08/MBTUNJOVUFTFBDIBOEBSFJODMVEFEJOQSPHSBNUJNFT
T4_T6_Rev.1.8.indd 24-25 10/27/06 1:26:49 PM
130(3".8&*()5-044
$IBMMFOHFTXJUIWBSJPVTDPNCJOBUJPOTPGIJMMTBOEWBMMFZT*/$-*/&41&&%MFWFMT5JNFCBTFEHPBMXJUI
EJGmDVMUZMFWFMTUPDIPPTFGSPN
8&*()5 -044130(3".4&(.&/54 BMMTFHNFOUTMBTUTFDPOET
8"3.61 
%&)$"&34*&.*5%&5$&-&4-*5/6%&5"&1&3&3"45/&.(&4
$00-%08/
-FWFM &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
-FWFM  &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
-FWFM  &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
-FWFM  &MFWBUJPO            
4QFFE            
-FWFM  &MFWBUJPO            
4QFFE            
-FWFM  &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
-FWFM &MFWBUJPO            
4QFFE            
8"3.61 BOE $00-%08/MBTUNJOVUFTFBDIBOEBSFJODMVEFEJOQSPHSBNUJNFT