Keys Fitness Strength Trainer ST-MAB User manual

Owner’s Manual ST-MAB
215-000
09/06 Rev A
Model Name : ST-MAB
Manufactured Date :
PO # :
Model Name Decal Location
Questions?
Call Us Toll Free
Keys Fitness Helpline
1-888-340-0482

2
Table of Contents
Important Safety Information 3
Assembly 4-5
Parts List 6
Exploded View 7
Warranty Information 8

3
Important Safety Information
Please read all instructions carefully before using this product.
SAFETY TIPS
Consult with your physician before engaging in any vigorous exercise. Know your heart rate
and/or pulse as well as your physician-recommended heart rate training zone. Proper medical
clearance is recommended for anyone beginning an exercise program especially if you are 35
years of age or older or suffer from heart respiratory problems.
- Warm-up before any exercise program with 8 minutes of aerobic-like activity followed
by stretching from head to toe.
- Wear comfortable clothes that allow freedom of movement and are not tight or
restricting.
- Wear comfortable shoes made with good support and non-slip soles.
- Breath naturally, never holding your breath during an exercise.
- Perform exercises consistently with proper technique and pass through a full range of
motion.
- Increase resistance by adding heavier weights. Decrease resistance by using lighter
weights.
- Always use a spotter for safety.
- Avoid over-training. You should be able to carry on a conversation while exercising.
- After an exercise session. Cool down with slow stretching, cycling or walking.
EXERCISE DEFINITIONS:
Sets: A set is one complete routine of exercises. Complete 1-3 sets for each exercise.
Repetitions: (referred to as reps) Is the number of times you perform an exercise in a row.
We recommend beginning with 6 reps and increasing up to 12 reps as indicated below.
Novice: Start with one set of 8-12 reps. Once you can complete the entire set of 12 reps con-
secutively, progress to the intermediate level.
Intermediate: Complete 2 sets of 8-12 reps once you can complete two sets of 12 reps con-
secutively, progress to the advanced level.
Advanced: Complete 3 sets of 12 reps
DISCLAIMER:
Keys Fitness is not responsible for the misuse of any of its products or for any injury sustained
while using any Keys Fitness product. The consumer uses any or all of Keys Fitness Products at
their own risk.
BEFORE YOU BEGIN:
Before you begin assembly of your Keys Fitness product, please take a moment to review the
hardware and parts list on the following pages. Each part has been illustrated and numbered
for easy identification.
Check this list against the contents of your package to make sure you have all required parts.
If any parts are missing, please do not return this product to the store. Contact our service
department immediately at 1-888-340-0482 and we will rush you any parts you may require.

4
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
Attach the Main Frame (01) to the two Base Frames (02).
Using: four Hex Bolts M10x100 (05), eight Washers D10
(07), four Aircraft Nuts (09).
Attach Pad (04) to the Main Frame (01) Using: two Hex
Bolts M8X65 (06), two Washers (08).
STEP 1
Assembly

5
NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.
Insert two Foam Tubes (03) halfway through the holes on
the Main Frame (01). Push four Foams (12) onto the Tubes
from both sides.
STEP 2
Assembly

6
Ref # Part # Description Qty
1 223-00855 MAIN FRAME, ST-MAB 1
2 223-00853 BASE FRAME, ST-MAB 2
3 219-00298 FOAM TUBE#3 M-MAB 2
4 228-00196 BACK PAD, ST-MAB 1
5 202-00180 HEX BOLTS M10*100 4
6 202-00181 HEX BOLTS M8*65 2
7 202-00471 WASHER, 3/8” 8
8 202-00600 WASHER, 5/16” 2
9 202-00358 NYLON NUT, 3/8" 4
10 206-00063 1" ROUND PLUG 4
11 206-00168 PLUG 40*80#10 M-MAB/ST-MAB 4
12 206-00169 FOAM#11 M-MAB/ST-MAB 4
# 202-00065 BOLT PACK M-MAB/ST-MAB 1
ST-MAB Parts List Rev
A
Parts List

7
Exploded View

8
Warranty
KEYS FITNESS PRODUCTS, L.P.
STRENGTH TRAINER
WARRANTY
Keys Fitness Products L.P. warrants this product for a period of 90 days on parts and lifetime
on the frame from the original date of purchase. This warranty covers the product from defects
in materials and workmanship for the original purchaser. Using this product for commercial
purposes, products damaged by misuse, abuse, or from shipping, moving and storage will void
this warranty.
Replacement parts are available from Keys Fitness Products L.P.
To contact us for customer service or replacement parts, call 1-888-340-0482.
CUSTOMER SERVICE
If you have any questions regarding this or any Keys Fitness product, or if we may be of
assistance in any way, please do not hesitate to call our toll free number 1-888-340-0482.

Keys Fitness Products, L.P.
4009 Distribution Drive, Suite 250
Garland, Texas 75041
Customer Service: 1-888-340-0482