Kidzone 060-ROT-04 User manual

Ride On ATV Personalize License Plate (12V)
Item umber : 060-ROT-04

The following safety hazards may result in serious injury or death:
Never leave a child unattended.
Always sit in the seat when using this vehicle.
Keep your hands,hair, and clothes away from moving parts.
Always wear shoes when operating this vehicle,
Only one rider is allowed on the vehicle at a time.
Children under 3 years of age cannot use the vehicle.
Only drive on level ground.
Do not go near swimming pools or other bodies of water,drop-offs, or up and down steep inclines.
Do not drive the vehicle into loose dirt, mud,sand, fine gravel, or on wet surfaces.
Do not drive the vehicle on streets or near cars.
This vehicle must be assembled by an adult who has read and understood the instructions in this manual.
Keep the packaging and bags away, from children and dispose of all packaging before use, Always use
common sense and safe practices when operating this vehicle, This product contains or emits chemicals
known in the state of California to cause cancer or birth defects or other reproductive harm.
NOTE: For best performance, only use this vehicle on flat and hard surfaces.
Age Range: 3 to 7 years old
Weight Capacity: 77Ibs.
The following safety hazards may result in serious injury or death:
●This product contains small parts. eep children away during assembly. ake sure to remove all
packaging material and parts from underneath the vehicle body.
* Never open the battery. Batteries contain lead and lead compounds (acids) that are toxic and corrosive,
and known to the state of California to cause cancer and reproductive harrm.
●imbs, hair, and clothing can get caught in moving parts. lways wear shoes, keep limbs away from
moving parts, and do not wear loose clothing while operating this vehicle.
●This vehicle does not have brakes or braking capability. Do not leave a child unattended during
operation. Do not use this in a location that may require braking capability, as this could result in loss of
control, which may cause serious injury or death.
●se of this vehicle near streets, motor vehicles, steps, bodies of water, sloped surfaces, hills, wet areas,
flammable vapors, in alleys. at night. or in the dark could result in an unexpected accident.
●se of this vehicle in unsafe conditions such as snow, rain, loose dirt, mud, sand, or gravel may result in
an unexpected accident such as tipping over, and could damage the electrical system or battery
Do not operate this vehicle in an unsafe manner. Examples include but are not limited to:
- Pulling the vehicle with another vehicle or similar device
Allowing more than one rider
Pushing the user
Traveling at an unsafe speed
●For your chlid's safety, pls make sure fasten the seat belt when using this product.
Personal protective equipment such as helmet is needed when using this product.

The following safety hazards may result in serious injury or death:
se of a battery or charger other than the supplied rechargeable battery and charger may cause a fire
or explosion.Only use the supplied battery and charger.
se of the rechargeable battery and charger for any other product may result in overheating,fire,
or explosion.Never use the supplied rechargeable battery and charger 'with another product.
Explosive gases are created during charging.Charge the battery in a well-ventilated area.Do not
charge the battery near heat or flammable materials.
Contact between the positive and negative terminals may result in fire or explosion.Avoid direct
contact between the terminals. Picking up the battery by the wires or charger can cause damage to the
battery and may result in a fire.Always pick up the battery by its case or handles.
Liquids on the battery may cause fire or electric shock.Always keep all liquids away from the battery
and keep the battery dry. Contact or exposure to battery leakage (lead acid) may cause serious injury.
lf contact or exposure occurs immediately call your physician.if the chemical is on the skin or in the
eyes, flush with cool water for 15 minutes.If the chernical was swallowed,immediately give the person
water or milk.Do not give water or milk if the patient is vomiting or has a decreased level of alertness.
Do not induce vomiting.
Battery posts, terminals, and related accessories contain lead and lead compounds (acid) - chemicals
known to the State of California to cause cancer,reproductive harm, and are toxic and corrosive.
Never open the battery.
Tampering or modifying the electric circuit system may cause a shock, fire or explosion and permanently
damage the system.Exposed wiring and circuitry in the charger may cause electric shock.Always keep
the charger housing closed.
37 – 96 month
6V/12V
77IBS
42”(L)x25”(W)x29”(H)
3-7year old
2,0-001-,000
High speed:3.1mph Low-speed:1.4mph
Specification
Item
Battery
otor
Age
ax eighe
Dimension
Speed
Play Time
060-ROT-04
12V7A
110-20 12 1000
1-2hours/recharger time8-12hours
First Charging Time
Charging time after first charge
ax Charging Time
Average Battery Life
8-12hours
4-5hours
12Hous
Normal use 1year
Battery (Temperature Tolerance) -68 F to 140 F
O O
Charger

Anti-collision
beam
Headstock
Steering rod Steering bracket
Chair
710
1
1
1
Large gasket
77IBS
IBS
12mm
Charger Front wheel Rear wheel
Gear box L/R
Hub cap
Rear axle
10 nut
Washer
screw

J
The large gasket and steering rod are inserted into the body in turn.

2Turn gasket and steering bracket into square pipe
K
x2
K
x2

3Lock Steering Bracket Gasket Nut Fixation
x2
x2
x2
x2

4Lock nut fixed with wrench

Put the gasket, front wheel, gasket and nut into the front axle in turn.
Fix the nut with the plate hand, and then fix the wheel cover on the wheel.
Put the rear wheel, gasket and nut into the front axle in turn.
Fix the nut with a wrench, and then fix the wheel cover on the wheel.
L
R
5

X2
Head H is equipped with 2 AA batteries. Lock the battery cover screw and fix it.
The head H is clamped into the steering rod, the screw nut is fixed,
and the front and rear anti-collision beam G is clamped.
Hand up, up and down steering rods when assembling the headstock
6
Remove the motor wire from the pocket by hand.
Insert the motor wire and lock the seat N with the power cord.
7

N
x1
Step on the pedal. Back up. Loosen the pedal to slow down and stop.
usic. orns
Bluetooth function
Foot switch
High Speed. Low Speed Switch
Power switch
Open the tank cover. Insert the charging terminal for charging.
Forward. Stop. Back
O

OD

/V- /V+
Functional description
Digital Electricity Display
.ODE:
.V- : 1.Short press to play to the previous song,2.Long press to decrease volume
.
V+: 1.Short press to play to the next song,2.Long press to increase volume
.
.1.Short press to pause/playback,2.Radio mod e:ress 1 second to automatically search
for stations.
//:Switch between Bluetooth (Kidzone Ride-On) & Radio
 connector： nsert  to play the music.

●Charging socket is located on the back of the vehicle near the rear left wheel. Insert one end of the
part O charger into the charging socket and plug the other end into a wall outlet.
●Charge the battery at least 18 hours before initial use.
●On average, you will need to charge the battery between 8 and 12 hours. Do not charge the battery
for more than 20 hours. Failure to charge the battery as directed could cause permanent damage
to the battery and void the warranty.
●Damage to the battery may occur if it is allowed to drain completely. Do not allow the battery to
drain completely.
●Check the battery and charger (supply cord, connector) for wear and damage before charging.
Do not charge the battery if damage has occurred.
●Only an adult who has read and understood the safety warnings should handle, charge and
recharge the battery. .
Do not mix alkaline, standard (carbon zinc)and rechargeable (nickel hydride) batteries.
Do not mix old and new batteries.
Non-rechargeable batteries should not be charged.
Rechargeable batteries should be charged under adult supervision only.
Exhausted batteries should be removed.
The supply terminals should not be short-circuited.
Do not put batteries next to or in a heat source (fire,electronic heating device,etc.).
Do not hit batteries against hard objects.
Do not submerge batteries in water.
Batteries should be inserted with the correct polarity.
Park the vehicle indoors or cover it with a tarp to protect it from wet weather.
Do not leave the vehicle in the sun for long periods of time or fading may occur.Store in shade or
cover with tarp.
Do not wash the vehicle with a hose.
Do not wash the vehicle with soap.

Problem Reason solution
Vehicle does not move
Low battery Fully charge the battery
Electrical protection Stop use for several minutes and restart
Switch not in the correct position Completely press in switches
Battery connectors disconnected
Battery connectors disconnected
Plug in battery connectors
Plug in battery connectors
Battery does not recharge Charger not connected to socket
or outlet Completely plug in the charger
Battery does not last Battery docs not have a full charge Fully charge the battery
Battery is warm and
makes a slight noise while
charging Normal Normal
Slow speed
Low battery Fully charge the battery
Overloaded vehicle Reduce the weight on the vehicle
neven or sloped road Drive on flat pavement
vehicles shakes while
driving Loose connection to motor Ensure the motor is properly connected to
the battery
Forward and reverse
switch is flipped (forward
goes in reverse, reverse
goes forward)
Gear boxes are installed
incorrectly
ake sure the  gear box is on the left and
Rgear box is on the right