Kidzone 060-ROT-07 User manual

Ride On Bumper Car (2 Driving Modes) (12V)
item number: 060-ROT-07
Instruction Manual
*Product appearance and colors may vary from the photo.
This vehicle is packed with the battery disconnected. Connect
the battery before use.
This manual contains important safety, performance and
maintenance information. Read the manual thoroughly before
allowing your child to ride your new electric ride-on toy.
Failure to read the user manual can result in property damage
or bodily injuries.
Keep this user manual for future reference.

Safety Instruction
When using electrical product, basic safety precaution should always be followed including the following:
Read all Instruction before operating this product
WARNING
• To protect against electrical shock, do not immerse cord, charger, transformer, battery, or the product
in any liquids.
• Only use charging devices, transformer, and battery provided or recommended by the manufacturer.
• For your children’s safety, the product should be assembled by adults only.
• This toy is not intended for children under 18 months.
• Close and constant adult supervision is required when your child is operating this product.
• Disconnect the battery if not used for an extended period of time.
• To reduce the risk of injury, adult supervision is required. Never use in roadways, near motor vehicles,
on or near steep inclines or steps, swimming pools or other bodies of water; always wear shoes, and
never allow more than 1 rider.
• Do not use this product on slippery surfaces.
• Always keep hands, hair, and clothing away from moving parts.
• Maximum users’ weight for this product is 66 lb/30 kg.
• Do not change, modify or add any electrical wiring on this product.
• Avoid using this product in tight environments to prevent damage to the product or injury to the user.
• Do not use this product in the dark. Only operate this product during daytime or well-lit areas.
• For your child’s safety, please make sure the seat belt is securely fastened when operating this product.
• Personal protective equipment such as helmet is required when operating this product.
WARNING
Fire Hazard
•
permanently damage the electrical system.
•
The battery must be handled by adults only. The battery is heavy and contains sulfuric acid (electrolyte).
Dropping the battery could result in serious injury.
• Never allow children to charge the battery. Battery charging must be done by adults only.
• Never lift or carry the battery by the wires or connector. This can damage the battery and possibly cause
• Examine the battery, charger, and their connectors for excessive wear or damage each time before you
charge the battery. DO NOT use the charger or battery until worn or damaged parts are replaced.
1

• Avoid continuously hitting into obstacle to prevent overheating or damaging the motor. Drive away or
remove obstacle as soon as possible.
• Manufacturer and seller expressly disclaim any and all liability for personal injury, property damage or
losses, whether direct, indirect, or incidental, resulting from the incorrect attachment, improper use,
WARNING
--
FAILURE TO FOLLOW THE SAFETY INSTRUCTIONS LISTED BELOW MAY RESULT IN SERIOUS INJURY OR DEATH
.
Child Safety Warnings
•Adults supervising children must read and understand this entire manual before allowing any child
to use this product.
Adults must evaluate their own children as to maturity, strength, judgment and ability to follow
safety rules. Published age guidelines are not a substitute for careful evaluation of your own child.
has ever controlled a motorized ride-on toy. While you supervise, see through the child’s eyes, and
verbally teach them about steering and avoiding obstacles in the approved riding area.
Riding a motorized ride-on toy can be a dangerous activity, even under the best of circumstances.
Good choices regarding where and when to ride, constant adult supervision of riding, and practice
and careful riding by the child can all help to minimize risk. However this ride-on toy is intended to
situations that no amount of care, instruction or expertise can eliminate.
If this inherent risk is not acceptable, adults should not allow children to ride this ride-on toy.
•
•
•
•
The owner’s manual contains assembly, use and maintenance instructions.
WARNING
WARNING
WARNING:
WARNING:
WARNING:
WARNING:
Stop operating this product whenever it stuck under any circumstances.
Friction Hazards! Do not operate this product on carpets or rugs, it may cause burn or
or operated incorrectly, wait for 10-15 seconds to reactivate this product automatically.
This toy is to be assembled by an adult. Contains potentially hazardous sharp edges and
sharp points, or contains small parts before assembly.
Do not drive this vehicle into any puddle or contact with any liquids to avoid the electrical
shock to product or user.
2

WARNING
--
Safe Riding Warnings
•
Not to be used by children under 18 months or children over 72 months.
• Do not exceed the maximum weight capacity of 66 lbs(30 kg).
• Do not allow more than one (1) rider.
ADULTS AND SUPERVISORS, PLEASE NOTE:
1. Always instruct all children of common sense rules and safe practices.
3. Do not allow the child rider to operate the ride-on toy near streets, roads, sidewalks, walkways,
or any other place where they may encounter other moving vehicles.
4. Never leave children unattended with this ride-on toy. Continuous adult supervision is required.
5. If necessary, adults and supervisors are always responsible for setting up gates and barriers to
ensure a safe riding environment for the child rider.
6. Be aware that this ride-on toy does not have braking capabilities. Allowing use of this ride-on toy
in areas that require braking may cause rolls, crashes, serious injury, or death to the child rider.
7. Teach children not to allow other children to use this ride-on toy. Communicate this message to
other adults and supervisors of fellow children with which your child interacts.
8. Sternly alert children that hands, legs, hair, and clothing can potentially get caught in moving
parts. Ensure they never place a body part or piece of clothing near a moving part of the ride-on
toy. Avoid loose clothing.
9. Instruct children to always wear shoes when using the ride-on toy.
any part of the ride-on toy while it is charging.
11. Do not mix old and new batteries.
12. Do not mix alkaline, standard (carbon zinc), or rechargeable batteries.
13. Firmly instruct children to use the ride-on toy in a safe manner. Unsafe behaviors include, but
are not limited to:
• Traveling at unsafe speeds
• Not riding in the seated position
• Riding at night or in any conditions of low visibility
• Riding in any wet conditions including rain, snow, and ice
• Any kind of stunt riding: jumps, ramps, stairs, hills, sloped surfaces, or other actions involving
any notable risk
• Riding near any pool or open body of water
• Pushing, pulling, or shoving the driver in any way while operating the ride-on toy
• Using the ride-on toy without the battery cover or any other safety cover fully closed
• Pulling or hitching the ride-on toy with other similar moving ride-on toys or products
3

WARNING
•Battery posts, terminals and related accessories contain lead and lead compounds (acids)
chemicals and are toxic and corrosive. Never open the battery.
Contact or exposure to battery leakage (lead acid) may cause serious injury. If contact or
exposure occurs with the skin or in the eyes, or if the chemical is swallowed, immediately
call 911.
Use of a battery or charger other than the supplied rechargeable battery and charger may
ride-on toy.
Using the rechargeable battery and charger for any other product many result in overheating,
direct contact between the terminals. Lifting the battery by the wires or charger can cause
Plug wall charger directly into a wall outlet. Do not use an extension cord when charging as
Corrosive Material Warnings
•
•
•
•
•
•
The following safety hazards may result in serious injury or death to the user of the ride-on:
Battery and Charging Warnings
•
•
battery and keep the battery dry.
permanently damage the system. Exposed wiring, circuitry in the charger may cause electric
shock. Always keep the charger housing closed.
Regularly check charger, supply cord and connector for wear and damage. Look for frayed or
kinked wires, any exposed inner wires, any missing insulation. If any damage is observed do
not plug in the charger and do not charge the battery.
•
Electric Shock / Fire Warnings
•
• Do not mix alkaline, standard (carbon-zinc), or rechargeable (nickel-cadmium batteries.)
Do not mix old and new batteries.
Flammable and Explosive Materials Warnings
4

CAUTION
Re-Charge Interval and Time
Important!
•
•
•
•
•
•
•
Damage to the battery may occur if it is allowed to drain completely. Do not allow the
battery to drain completely.
Check the battery and charger (supply cord, connector) for wear and damage before
charging. Do not charge the battery if damage has occurred. Do not use an extension
cord when charging the ride-on toy.
On average you will need to charge the battery for 8 - 12 hours and no more than 20 hours.
Failure to charge the battery as directed could cause permanent damage to the battery and
void the warranty.
Only an adult who has read and understands the safety warnings should handle, charge and
recharge the battery.
WARNING
Product Warning
WARNING
This product can expose you to chemicals including lead, and lead components which is
known to the State of California to cause cancer and birth defects or other reproductive
harm. For more information go to www.
P65Warnings.ca.gov.
Assembly Warnings
The ride-on toy must be assembled by an adult who has read and understands the
instructions in this manual.
This ride-on toy contains small parts that are for adult assembly only. Keep small children
away when assembling.
Remove and dispose of all protective materials, plastic bags and packaging before assembly.
Motor: 12V 25W*2
Battery: 6V 4.5AH*2
Charger: 12V1000MA
Speed: 1.2~1.9mph(2~3km/h)
Suitable Age: 18 -72 months
Maximum User Weight: 66 lb / 30 kg
Dimension: 31.50” x 21.26” x 15.75”（800 x 540 x 400 mm）
Battery Charge Time: 8 - 12 hours
First charging time: 10~12 hours
Max charging time: 20 hours
Battery (Temperature Tolerance) : -15°C（-5°F) TO 60°C (140°F）
Operation Time: 1~2 hours
5

Parts and Feature
Vehicle Body Steering Wheel
Steerable Front Wheel Backrest
Seat Charger
Remote Control M5 x 39 Screw
M4 x 10 Tapping Screw M5 Nut
1 2
3
5
78
10
9
6
4
6

Assembly Instruction
•
•
Lift up the ①Vehicle Body and insert the ③Steerable Front Wheel through the opening.
Align and insert the ②Steering Wheel to the front wheel column. Using ⑧M5*38
Screw and ⑩
• Power supply is located under the seat location. Plug the connector to the terminal on the battery.
1
① ①
10
2
3
• Unscrew the ⑧M5*39 Screw and ⑩M5 Nut from ②Steering Wheel.
①
8
8
10 2
Connector
7

Assembly Instruction
•
•
Insert the ④Backrest to the ①Vehicle Body and secure by using two ⑨M4 x 10 Tapping Screws .
• Put on the Seat and secure by using two M4 x 10 Tapping Screws .
4
5 9
19
Unscrew the attached 4 pcs ⑨M4 x 10 Tapping Screws.
9
8

User Instruction
Control the vehicle
Start Switch
Light Switch
High-Low Speed Switch
Press to switch between high and low speed.
Charging Slot
Plug the charger in to charge battery.
Indoor / Outdoor Switch
Switch between indoor and outdoor mode.
Steering Wheel
Steer the vehicle left and right.
Only operate in outdoor mode.
Foot Pedal
Step on the pedal to move the vehicle.
Only operate in outdoor mode.
Forward / Reverse / Stop Switch
Press the switch to
Do not the speed or direction until the vehicle comes to a complete stop.
9. Control Stick
Move and turn the vehicle by pushing or pulling the control stick.
Only operate in indoor mode.
Bluetooth connection
To connect your mobile device to the vehicle, turn on the Bluetooth and select "KIDZONE BUMPER CAR”,
there is voice message after pairing successfully. Music can be played from the vehicle speaker according
to the user preferences.
9

• Lift up the vehicle body.
• Press the plastic buckle and fold up the steerable front wheel into the body.
• Press the switch to indoor mode.
• Control the vehicle using the control stick on the side on the vehicle.
NOTE: Control sticks can only be operated in indoor mode.
• Remote control can only be operated in indoor mode.
User Instruction
Indoor Mode:
When using the vehicle indoor, switch the setting to indoor mode.
10

Operating this vehicle by using control stick:
To move the vehicle forward, push both control sticks forward at the same time.
To move the vehicle backward, pull both control sticks backward at the same time.
To left turn the vehicle forward, push the right control stick forward.
To right turn the vehicle forward, push the left control stick forward.
To left turn the vehicle backward, pull the right control stick backward.
To right turn the vehicle backward, pull the left control stick backward.
To left spin the vehicle, pull the left control stick backward and push the right control stick forward at
the same time.
To right spin the vehicle, push the left control stick forward and pull the right control stick backward at
the same time.
To stop the vehicle, release both control sticks and returns them to the center position.
11

• Lift up the vehicle body.
• Press the plastic buckle and fold down the steerable front wheel.
• Press the switch to outdoor mode.
• Control the vehicle using the steering wheel and foot pedal.
NOTE: Remote control can only be operated in indoor mode.
• Do not use the remote control in outdoor mode to prevent
damaging the vehicle.
User Instruction
When using the vehicle outdoor, switch the setting to outdoor mode.
Outdoor Mode:
12

User Instruction (Remote Control)
Forward Stop
Right
Left
Speed Indicator
Reverse
Speed
Selection
Remote Control Buttons
1. Forward Button
Press to move the vehicle forward.
2. Reverse Button
Press to move the vehicle backward.
3. Speed Selection Button
Press to switch between low, medium, or high
speed.
4. Stop Button
Press to stop the vehicle.
5. Right Button
Press to turn the vehicle to the right.
6. Left Button
Press to turn the vehicle to the Left.
7. Speed Indicator
One light indicates in low speed.
Two lightsindicate in medium speed
Three lightsindicate in high speed.
13

User Instruction (Remote Control)
Using the remote control
The remote control should only be used by adult.
ATTENTION:
The remote control will override all control input from the vehicle control sticks.
The remote control should only be used when the vehicle is in indoor mode.
Insert / Changing Battery
1. Open the battery cover on the back side of the remote control.
2. Insert 2 AAA 1.5v cell batteries in the correct polarity
3. Put the cover back to the remote control.
NOTE: Do not mix old and new batteries. Do not mix alkaline, standard (carbon-zinc), or rechargeable
batteries.
Pairing the remote control to the vehicle
1. Press Forward and Reverse button simultaneously until the indicator light
2. Turn on the vehicle power.
3. The indicator light will stay on when the pairing is succeed.
The battery should only be changed by an adult.
WARNING!
14

User Instruction (Charging)
The battery should only be charged by an adult.The battery is not
replaceable.
WARNING!
Charging the battery
1. Insert the charging cable to the charging port located in front of the indoor / outdoor switch.
2. Insert the charger plug into a wall outlet, and the battery will start charging.
3. The charger indicator turns red whencharging, turns green after charging completed.
• The vehicle must be OFF when charging.
• Recharge the battery if the vehicle operates slowly.
• The vehicle has equipped with charging protection. All function of the vehicle will not be operated
when charging.
NOTE:
Damage to the battery may occur if it is completely drained.
Fully charge the batteryfor8 - 12 hours, do not charge the battery for more than 20 hours.
Charge the battery at least once a month even if not operating the vehicle to maximize the battery life.
15

Troubleshooting
Care and Maintenance
• Check the product regularly and make sure there is no missing or loose parts. Re-tighten any loose parts
if necessary.
• Make sure there is no cracked or broken plastic parts.
•Keep away the product from heat and humid area, cover it with trap when not in use.
Turn o the product and disconnect the battery if the product is not use for a long period of time.•
• Clean the vehicle with a cloth. Use a non-wax furniture polish to restore the shininess of the plastic
parts. Do not use abrasive cleaner.
• Do not wash the product with a hose or immerse any parts in water or other liquid.
• Occasionally use lightweight oil to lubricate moving parts
Problem Possible Reason Solution
Vehicle does not move
Low Battery Fully charge the battery
Fuse Protection Reset fuse
Disconnected / Badly connected
battery Reconnect the battery
Failed battery / engine Contact Customer Service
Vehicle does not run very long
Low Battery Fully charge the battery
Old Battery Replace battery if necessary
Vehicle runs very slow
Low Battery Fully charge the battery
Old Battery Replace battery if necessary
Vehicle is overloaded Make sure user’s weight is under
66 lb / 30 kg
Vehicle is being used in harsh
environment
Avoid using the vehicle in harsh
environment
16

Troubleshooting
Problem Possible Reason Solution
Vehicle needs a push to go
forward
Poor wire connection
Check if the battery connectors
Contact Customer service if
necessary
“Dead spot” on motor Contact customer service
Loud grinding sound or clicking
sound from the motor or gear box Damaged motor or gear box Contact customer service
Battery does not charge
Disconnected / Badly connected
battery Reconnect the battery
Disconnected / Badly connected
charger
plugged into the power source
and connected to the charging
port
Charger not working Contact customer service
Vehicle does not stop Damaged equipment Contact customer service
Charger becomes warm
during charging Normal N/A
17

Model: JR1602FCC
FCC ID: 2AWOBJR1602
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions:
(1) this device may not cause harmful interference, and
(2) this device must accept any interference received, including interference that may cause undesired
operation.
NOTE: This equipment has been tested and found to comply with the limits for Class B digital device,
pursuant to part 15 of the FCC rules. These limits are designed to provide reasonable protection against
harmful interference in a residential installation. This equipment generates, uses and can radiate
radiofrequency energy and if not installed and used in accordance with the instructions, may cause
harmful interference to radio or television reception, which can be determined by turning the equipment
o and on, the user is encouraged to try to correct the interference by one or more of the following
measures:
- Reorient or relocate the receiving antenna.
- Increase the separation between the equipment and the receiver.
- Connect the equipment into an outlet on a circuit dierent from that to which the receiver is connected.
- Consult the dealer or an experienced radio/TV technical for help.
Caution: Changes or modications not expressly approved by the party responsible for compliance could
void the user's authority to operate the equipment.
This product conforms to toy safety standards CPSIA and ASTM-F963.
Importer: ONE BIG OUTLET
Importer Address: 19301 E Walnut dr. N. City of industry CA91748 united states
Importer Tel.: 800 - 946 - 6151
18

Limited Term Warranty (One Year from Date of Purchase)
WARRANTY TERMS ADDITIONAL CONDITIONS
ADDITIONAL CONDITIONS
KIDZONE warrants that its merchandise are free
from manufacturing defects (workmanship and/
or material) and will either give credit or replace
defective parts for a period of up to one (1) year
from the date of purchase in accordance with the
conditions set forth below. If a manufacturing defect
the defect and supplied a copy of the invoice and
delivery ticket. Inspection by a KIDZONE employee
or representative may be necessary to verify that
a manufacturing defect exists, or you may be
required to submit samples to KIDZONE along
with a digital image of the defects. If replacement
is required in accordance with this warranty and
the defective material or merchandise has been
discontinued or unavailable, KIDZONE reserves
the right to select and supply similar merchandise
the same material or merchandise will be supplied
for replacement purposes. This warranty is made
solely to the retailer and is not transferable under
any circumstances. It is the retailer’s responsibility
to contact KIDZONE with a claim. We will not
handle claims from consumers directly; all
requests must go through the retailer who sold
the merchandise to the consumer. We advise all
retailers to retain invoices for a minimum of one
(1) year for warranty purposes. This warranty
supersedes and replaces all implied warranties
of merchantability and use for particular purpose.
No representative, employee, agent or any other
person is authorized to assume for KIDZONE any
additional liability or responsibility in connection
with KIDZONEs merchandise except as described
above. Implied warranties or merchantability
period of one (1) year from the date of purchase.
In no event shall KIDZONE be liable for indirect,
consequential or incidental damages of any kind.
THE FOLLOWING EXAMPLES ARE NOT
MANUFACTURER’S DEFECTS:
• Colors may vary slightly from the photo
because of photography and printing
tolerances.
• Sizes stated in U.S. standard measurements
may vary slightly due to product are
manufactured using the metric system.
• No returns for buyer’s remorse.
• No returns - other than stated above will be
accepted.
WARRANT IS VOID FOR ANY OF THE
FOLLOWING CONDITIONS:
1. Improper maintenance or improper use
resulting in damage.
2.
consumer, or other parties not authorized by
KIDZONE will void this warranty.
3. Floor samples sold or products designated
“AS IS” at the time of purchase are not
covered by the warranty
4. Warranty does not cover minor variations or
illustrations and your product.
5. Cost of packaging and shipping to and from
KIDZONE is not covered by the warranty
unless expressly arranged by KIDZONE.
6. This warranty covers only articles of
appliances intended for residential use only,
does not cover any industrial, commercial,
institutional or Rental use.
7. Dissatisfaction due to buyer’s remorse.
8. Normal wear and tear.
9. Damages incurred during transportation.
10.Damages incurred during assembling or
maintenance.
11. Damage incurred by accidents or abuse.
V1-2021-08-12
19