Leviton RENOIR II Series User manual

Service Switch
Load
Connected
Load
Disconnected
Service Switch
Load
Connected
Load
Disconnected
RENOIR II
FAN SPEED CONTROLS
Cat. Nos. AWRMG-QXX, AWSMG-QXX & AWSMT-QXX
INSTALLATION
WARNINGS AND CAUTIONS:
s TO AVOID FIRE, SHOCK OR DEATH; TURN OFF POWER AT CIRCUIT BREAKER OR FUSE AND TEST THAT POWER IS OFF BEFORE WIRING!
s TO BE INSTALLED AND/OR USED IN ACCORDANCE WITH ELECTRICAL CODES AND REGULATIONS.
s IF YOU ARE NOT SURE ABOUT ANY PART OF THESE INSTRUCTIONS, CONSULT AN ELECTRICIAN.
s DO NOT GANG VERTICALLY.
s ONLY INSTALL FOR THE ALLOWED LOAD TYPES. INSTALLATION FOR ANY OTHER LOAD TYPE WILL VOID WARRANTY AND POSSIBLY CAUSE DAMAGE TO
THIS DEVICE AND/OR CONNECTED EQUIPMENT.
s USE THIS DEVICE WITH COPPER OR COPPER CLAD WIRE ONLY.
s INSTALL THIS DEVICE IN A METAL OUTLET BOX ONLY.
Installation Requirements:
s 4HESEDEVICESAREDESIGNEDFORINSTALLATIONINTOAMETALXCMX
CMSINGLEGANGORMULTIGANGDEVICEBACKBOXCMORDEEPER
BACKBOXESAREREQUIRED4HESEDEVICESAREnotDESIGNEDFORAMULTIGANGlELD
CONlGUREDBOX)NSOMEINSTALLATIONSWHERECONDUITENTRYISFROMTHESIDEORIN
MULTIGANGINSTALLATIONSWHERENIPPLESBETWEENTWOADJACENTBOXESAREUSED
DEEPERBACKBOXESMAYBENECESSARY4ESTlTINSTALLATIONPRIORTOROUGHIN
s )NSTALLATIONOFMULTIPLEDEVICESINTOASINGLEBOXMAYREQUIREDERATINGAND
OTHERSPECIlCINSTALLATIONPROVISIONS2EFERENCEMulti-Gang InstallationsFOR
MOREDETAILS
s !SDEVICESVENTTOPBOTTOMDEVICESSHOULDNOTBEINSTALLEDVERTICALLYONEOVER
THEOTHER
s 4OAVOIDmICKERINGmASHINGORLIGHTSONONEDEVICEADJUSTINGWHENANOTHER
DEVICESLEVELISCHANGEDDONOTSHARENEUTRALS2UNSEPARATENEUTRALSFOR
EACHLOADCIRCUITBACKTOTHEDEVICE(See Figure 2).
Installation Instructions:
1.WARNING: TO AVOID FIRE, SHOCK OR DEATH; TURN OFF POWER AT
CIRCUIT BREAKER OR FUSE AND TEST THAT POWER IS OFF BEFORE
WIRING!
2.2EMOVEEXISTINGWALLPLATEANDSWITCHIFAPPLICABLE
3.#ONNECTWIRESPER7)2).'$)!'2!-)FTRAVELERWIREISNOTUSEDITMUSTBE
INSULATEDWIRENUTORELECTRICALTAPE
4.)NSTALLATIONMAYNOWBECOMPLETEDBYCAREFULLYPOSITIONINGALLWIRESTOPROVIDE
ROOMINOUTLETBOXFORDEVICE-OUNTDEVICEINTOBOXWITHMOUNTINGSCREWS
SUPPLIED
5.)NSTALLDEVICECONTROLPUSHBUTTONANDCONTROLASSEMBLY(see Figure 3).
3NAPFACEPLATEINTOPLACE
6.2ESTOREPOWERATCIRCUITBREAKERORFUSEInstallation is complete.
7.4EST$EVICEOPERATION
INPUT - 120 - 277
VAC 60 HZ
/540541!!!.9&!.
/540541"!!.9&!.
!0!$$,%&!.
Features and Operation:
s 4URN$EVICE/.OR/&&n0RESSINGTHESWITCHWILLTURNTHEDEVICE/.IFTHE
DEVICEIS/&&)FTHEDEVICEIS/.PRESSINGTHESWITCHWILLTURNTHEDEVICE/&&
s 3ET$EVICE,EVELn!DJUSTTHEKNOBORSLIDERTOSETTHEDESIREDOUTPUTLEVEL7HEN
THEDEVICETURNS/.THEDEVICEALWAYSTURNS/.TOTHELEVELSETBYTHESLIDEROR
KNOB
s 3ET#UTOFF,EVELn4HECUTOFFLEVELISTHELOWESTVOLTAGETHEDEVICEWILLOUTPUT
BEFORESHUTTING/&&4OSETTHECUTOFFLEVELADJUSTTHEKNOBORSLIDERTOTHE
MAXIMUMOUTPUT3LOWLYLOWERTHEOUTPUTTOTHEDESIREDCUTOFFLEVELTHENPUSH
ANDHOLDTHEPOWERBUTTONFORSECONDS4HEDEVICEWILLADJUSTTOTHENEWLEVEL
4ORESETTHECUTOFFLEVELTOADJUSTTHEKNOBORSLIDERTOTHEMINIMUMOUTPUTTHEN
PUSHANDHOLDTHEPOWERBUTTONFORSECONDS)FYOURLOADISNOTTURNING/.OR
SUFFERINGFROMANYOTHERERRATICBEHAVIORATTHEMINIMUMSETTINGRAISINGTHECUTOFF
LEVELMAYELIMINATETHEPROBLEM)FYOURFANSPEEDWILLNOTCHANGERESETTHECUTOFF
LEVELTOANDTHENRESETDESIREDMINIMUMSPEED
s 0RESET/PERATIONn7HILEDEVICEISOFFSETLEVELOFDEVICE4HENPRESSBUTTON4HE
DEVICEWILLTURNONATTHESETLEVEL
s 0OWER2ESTOREn5PONRESTORATIONOFPOWERTHEDEVICETURNS/.TOTHESTATEIT
WASINATTHETIMEOFPOWERLOSS
s 7AY/PERATIONn,INKTOGETHERORDEVICESFORMULTIWAYDIMMING
!LLCONNECTEDDEVICESMUSTBEPOWEREDBYTHESAMEELECTRICALCIRCUITTOENSURE
PROPERCOMMUNICATIONBETWEENTHEDEVICES
s ,%$,OCATORn!TTHEBOTTOMOFTHESWITCHISAN,%$LOCATOR4HISLOCATOR
ILLUMINATESWHENTHEDEVICEIS/&&SOYOUCANlNDTHEDEVICEINTHEDARK
s 2EMOTE#ONTROLn)FYOUAREUSINGAREMOTETHEOPERATIONATTHEREMOTEIS
IDENTICALTOTHEOPERATIONATTHEMASTER!SLIGHTREACTIONDELAYMAYBENOTICEDIF
OPERATINGLEVELCHANGESVERYQUICKLY
s 3ERVICE3WITCHn3OMEUNITSHAVEASERVICESWITCHWHICHMUSTBEUSEDTO
DISCONNECTTHELOADWHENREPLACINGFANS4HEBREAKERSHOULDBEDISCONNECTED
WHENPERFORMINGANYCIRCUITSERVICEOTHERTHANFANREPLACEMENT3EE Figure 1.
&OR4ECHNICAL!SSISTANCE#ALL53!/NLYWWWLEVITONCOM
LIMITED 5 YEAR WARRANTY AND EXCLUSIONS
,EVITONWARRANTSTOTHEORIGINALCONSUMERPURCHASERANDNOTFORTHEBENElTOFANYONEELSETHATTHISPRODUCTATTHETIMEOFITSSALEBY,EVITONISFREEOFDEFECTSINMATERIALSANDWORKMANSHIPUNDERNORMALANDPROPERUSEFORlVEYEARSFROMTHEPURCHASEDATE,EVITONSONLYOBLIGATION
ISTOCORRECTSUCHDEFECTSBYREPAIRORREPLACEMENTATITSOPTIONIFWITHINSUCHlVEYEARPERIODTHEPRODUCTISRETURNEDPREPAIDWITHPROOFOFPURCHASEDATEANDADESCRIPTIONOFTHEPROBLEMTO,EVITON-ANUFACTURING#O)NC!TT1UALITY!SSURANCE$EPARTMENT.ORTH
3ERVICE2OAD-ELVILLE.EW9ORK4HISWARRANTYEXCLUDESANDTHEREISDISCLAIMEDLIABILITYFORLABORFORREMOVALOFTHISPRODUCTORREINSTALLATION4HISWARRANTYISVOIDIFTHISPRODUCTISINSTALLEDIMPROPERLYORINANIMPROPERENVIRONMENTOVERLOADEDMISUSEDOPENED
ABUSEDORALTEREDINANYMANNERORISNOTUSEDUNDERNORMALOPERATINGCONDITIONSORNOTINACCORDANCEWITHANYLABELSORINSTRUCTIONS4HEREARENOOTHERORIMPLIEDWARRANTIESOFANYKINDINCLUDINGMERCHANTABILITYANDlTNESSFORAPARTICULARPURPOSEBUTIFANYIMPLIED
WARRANTYISREQUIREDBYTHEAPPLICABLEJURISDICTIONTHEDURATIONOFANYSUCHIMPLIEDWARRANTYINCLUDINGMERCHANTABILITYANDlTNESSFORAPARTICULARPURPOSEISLIMITEDTOlVEYEARS,EVITONISNOTLIABLEFORINCIDENTALINDIRECTSPECIALORCONSEQUENTIALDAMAGESINCLUDING
WITHOUTLIMITATIONDAMAGETOORLOSSOFUSEOFANYEQUIPMENTLOSTSALESORPROlTSORDELAYORFAILURETOPERFORMTHISWARRANTYOBLIGATION4HEREMEDIESPROVIDEDHEREINARETHEEXCLUSIVEREMEDIESUNDERTHISWARRANTYWHETHERBASEDONCONTRACTTORTOROTHERWISE
0+!
&IGURE3ERVICE3WITCH#ONTROL
2OTARY$EVICE 3LIDE$EVICE
Align flats when
installing knob
Center tab in opening
&IGURE#ONTROL!SSEMBLY
2OTARY$EVICE 3LIDE$EVICE
Wiring Diagram
Fan Speed Control
Fan
Black
Neutral (White)
Hot (Black) Blue
White
White Yellow
For use in multi-way
control (remote)
applications.
Cap wire if not used.
Ground (Green)
Line
120-277VAC
60 Hz
&IGURE$ONOTSHARENEUTRALWIRES
Blue
Hot (Black)
Neutral (White)
White
White
Load
Blue
Black
Black
White
Yellow
Yellow
Green
Ground
White
Hot (Black)
Neutral (White)
Load
–
Run a separate neutral wire
for each control circuit
–
Run a separate neutral wire
for each control circuit
Green
Ground
WEB VERSION

0+!
Ú,EVITON-FG#O)NC
-ULTI7AY#ONTROL
4HE2ENOIR))PRODUCTLINESUPPORTSUPTOWAYCONTROL!NYCOMBINATIONOF
$IMMERS &AN#ONTROLS3WITCHESOR2EMOTESARESUPPORTEDWITHAMAXIMUM OF
5 DEVICES4OTALRUNLENGTHFROMENDTOENDISMAXIMUM 250 FEET2EMOTES
REQUIRE5NCONTROLLED(OT.EUTRAL'ROUNDFORPROPEROPERATION/NETRAVELERWIREIS
TORUNINBETWEENALLMASTERSANDREMOTES2EMOTESDRAWM!POWEREAFROMTHE
#ONTROLTOWHICHTHEYARECONNECTED
NOTE:2EMOTE(OT.EUTRALSHOULDIDEALLYBEFEDFROMTHESAMECIRCUITASTHE-ASTER)F
THISISNOTPOSSIBLEENSURETHATTHEMASTERANDREMOTEAREBOTHFEDFROMTHESAMEPHASE.
Backbox - # Gangs
Wallplate Part #
Device Configuration
Backbox - # Gangs
Wallplate Part #
Device Configuration
Backbox - # Gangs
Wallplate Part #
Device Configuration
Backbox - # Gangs
Wallplate Part #
Device Configuration
Number & Type of NARROW
Number & Type of WIDE
0
1
2
3
0
4**
N+N+N
AWP0F-30x
2
N*+*N
AWP00-20x
1
N
AWP0F-10x
1
6**
W+N+N+N
AWP0F-31x
4
W+N*+*N
AWP00-21x
3
W+N
AWP0F-11x
1
W
AWP0F-01x
2
7
W+N*+*N*+*N+W
AWP00-32x
6
W+N*+*N+W
AWP00-22x
5
W+N+W
AWP0F-12x
4
W+W
AWP0F-02x
3
9
W*+*W+N*+*N*+*N+W
AWP00-33x
8
W*+*W+N*+*N+W
AWP00-23x
8**
W+W+N+W
AWP0F-13x
6**
W+W+W
AWP0F-03x
Basic Configurations
Multi-Gang Installations:
!MULTIGANGEDINSTALLATIONEXISTSWHENMULTIPLEDEVICESAREINSTALLEDINTHESAME
BACKBOX)NMULTIGANGINSTALLATIONSTHEFOLLOWINGMAYBEREQUIRED
- $EVICEDERATING    -&INREMOVAL
- 5SEOFJOINERBARSFORADJACENTDEVICES - "ACKBOXSIZE
NOTE: TEST FIT DEVICE INSTALLATION WITH THE WALL PLATE PRIOR TO
BREAKING FINS OR INSTALLING DEVICES TO ENSURE YOU UNDERSTAND ALL
REQUIREMENTS.
1. &INDTHECELLSTHATCORRESPONDTOYOURAPPLICATIONBYIDENTIFYINGTHEROWWITHTHE
NUMBEROFWIDEHEATSINKDEVICESYOUHAVEANDTHECOLUMNSTHATCORRESPOND
TOTHENUMBEROFNARROWHEATSINKDEVICESYOUHAVE)NTHECELLYOULLlNDTHE
FOLLOWING
2. 4HENUMBERINDICATESTHENUMBEROFh'ANGSvREQUIRED
3. 4HELETTERSUNDERTHENUMBERINDICATETHEORDERDEVICESSHOULDBEINSTALLED
.NARROW7WIDE
4.  7RIGHTlNBREAKOFFONWIDEDEVICE.RIGHTlNBREAKOFFONNARROWDEVICE
7LEFTlNBREAKOFFONWIDEDEVICE.LEFTlNBREAKOFFONNARROWDEVICE
7lNBREAKOFFONBOTHSIDESOFWIDEDEVICE.lNBREAKOFFONBOTHSIDESOF
NARROWDEVICE
5.INDICATESTHATUSEOFJUMPERBARSISREQUIRED*UMPERBARSCANBEFOUNDINTHEKIT
WITHTHEFACEPLATE
6.2EPLACEgXgINTHEFACEPLATEPARTNUMBERWITHTHEDESIREDCOLOR77HITE))VORY
4,IGHT!LMOND%"LACK''RAY++'OLD,3ATIN3TAINLESS2!NTIQUE
"RONZE""RUSHED"RASS
NOTE:-ETALlNISHESARENOTAVAILABLEONCUSTOMFACEPLATES
"ASIC7)$%.!22/7CONlGURATIONSFORADDITIONALCONlGURATIONS3EE
WWWLEVITONCOM2%./)2))
"ACK"OX3IZE*OINER"ARS
4ODETERMINETHEREQUIREDBACKBOXSIZEINMULTIGANGINSTALLATIONSREFERENCE
TABLEBELOW)NAPPLICATIONSWHERETHEDEVICESDONOTLINEUPWITHBACKBOXDEVICE
MOUNTINGHOLESUSEJOINERBARSTOJOINTHECONTROLSTOGETHER2EFERENCEFigure 5.
De-ratings:
7HENlNSAREBROKENSOMEDEVICESMUSTBEDERATED2EFERENCETABLEBELOWTO
DETERMINETHEDEVICERATINGSWHENORlNSAREREMOVED
&AN3PEED#ONTROLS&ULL6ARIABLE&ULL1UIET6!#6#!(Z
&ORUSEWITHANYFANUPTO!&ORUSEWITHANYQUANTITYOFCEILINGPADDLEFANSUPTO
MAXIMUMCURRENTRATING
0 fins
removed
Fan Speed Controls
Full variable, full quiet
1 fin
removed
2 fins
removed
AWRMG-QA_
AWSMG-QA_
Amps
VA @ 120V
Amps
VA @ 120V
AWSMT-QA_
AWRMG-QB_
AWSMG-QB_
AWSMT-QB_
VA @ 230V
VA @ 277V
VA @ 230V
VA @ 277V
600
5.0
1385
1150
Amps
VA @ 120V
VA @ 230V
VA @ 277V
840
7.0
1939
1610
1000
8.3
2308
1917
1000
8.3
2308
1917
780
6.5
1801
1495
660
5.5
1524
1265
636
5.3
1468
1219
&IN2EMOVAL
7HENITISDESIREDTOINSTALLDEVICESINASSMALLASPACEASPOSSIBLEALLINSIDElNSOFLIKE
SIZEDADJACENTDEVICESCANBEBROKENOFFFigure 4SHOWSHOWTOBREAKOFFlNSANDTHE
SPECIlCORDERINWHICHMULTIPLEDEVICESMUSTBEINSTALLEDINMULTIGANGINSTALLATIONS
-5,4)'!.').34!,,!4)/.2%15)2%-%.43
!DDITIONAL3INGLE'ANG"OX
-ULTI7AY#ONTROL7IRING$IAGRAM
Maximum 5 Devices, Dimmers, Remotes or Fan Controls
Maximum 250 feet
Device/Switch
Maximum 5 Devices, Dimmers, Remotes or Fan Controls
Maximum 250 feet
Remote
Device/Switch Remote
Device/Switch Remote Device/Switch
Multiple Device/Switches and Remote Device/Switches
Master
Device/Switch Remote Device/Switch Remote Device/Switch Remote Device/Switch Remote Device/Switch
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Traveler
Dimmed Hot
Neutral
Ground
LOAD
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
Traveler
Dimmed Hot
Neutral
Ground
LOAD
Dimmed Hot
Neutral
Ground
LOAD
Multiple Remote Device/Switches
Load in between Master Device/Switch and Remote Device/Switch
Master Device/Switch Remote Device/Switch
Dimmed Hot
Neutral
Ground
Hot
Neutral
Ground
Traveler
Hot
Neutral
Ground
LOAD
Load after Remote Device/Switch and Master Device/Switch
Master Device/SwitchRemote Device/Switch
Hot
Neutral
Ground
Hot
Neutral
Ground
Dimmed Hot
Neutral
Ground
Traveler
LOAD
Master
Device/Switch
&IGURE&IN2EMOVAL
Back view of devices shown
Break off these fins
DO NOT Break off these fins
Break off these fins
Fin break off points
&IGURE*OINER"AR
Narrow/Narrow
Wide/Narrow Wide/Wide
Joiner Bar
Joiner Bar
3/4" space (use chase nipple)
3-1/2" deep
back box is
required
Four-gang wallbox Single-gang
wallbox
WEB VERSION