Panasonic TY-FB9BD User manual

1 Safety Precautions 2
1.1. General Guidelines 2
2 Prevention of Electro Static Discharge (ESD) to
Electrostatically Sensitive (ES) Devices 3
3 About lead free solder (PbF) 4
4 Replacement 5
5 Connection 6
6 Circuit Board Layout 7
6.1. HU-Board 7
7 Block and Schematic Diagram 9
© 2006 Matsushita Electric Industrial Co., Ltd. All
rights reserved. Unauthorized copying and
distribution is a violation of law.
TY-FB9BD
7.1. Schematic Diagram Notes 9
7.2. HU-Board Block Diagram 10
7.3. HU-Board (1 of 2) Schematic Diagram 11
7.4. HU-Board (2 of 2) Schematic Diagram 12
8 Replacement Parts List 13
8.1. Replacement Parts List Notes 13
8.2. Electrical Replacement Parts List 14
8.3. Mechanical Replacement Parts List 16
8.4. Parts Location (1) 17
8.5. Parts Location (2) 18
BNC Dual Video Terminal Board
CONTENTS
Page Page
ORDER NO. ITD0605021CE
D10 Canada: B07
All manuals and user guides at all-guides.com
all-guides.com

1 Safety Precautions
1.1. General Guidelines
1.When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or
damaged by the short circuit.
2.After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly
installed.
3.After servicing, make the following leakage current checks to prevent the customer from being exposed to shock hazards.
1.1.1. Leakage Current Cold Check
1.Unplug the AC cord and connect a jumper between the two prongs on the plug.
2.Measure the resistance value, with an ohmmeter, between the jumpered AC plug and each exposed metallic cabinet part on
the equipment such as screwheads, connectors, control shafts, etc. When the exposed metallic part has a return path to the
chassis, the reading should be between 1MWand 5.2MW.
When the exposed metal does not have a return path to the chassis, the reading must be .
Figure 1
1.1.2. Leakage Current Hot Check (See Figure 1.)
1.Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check.
2.Connect a 1.5kW, 10 watts resistor, in parallel with a 0.15µF capacitors, between each exposed metallic part on the set and a
good earth ground such as a water pipe, as shown in Figure 1.
3.Use an AC voltmeter, with 1000 ohms/volt or more sensitivity, to measure the potential across the resistor.
4.Check each exposed metallic part, and measure the voltage at each point.
5.Reverse the AC plug in the AC outlet and repeat each of the above measurements.
6.The potential at any point should not exceed 0.75 volts RMS. A leakage current tester (Simpson Model 229 or equivalent) may
be used to make the hot checks, leakage current must not exceed 1/2 milliamp. In case a measurement is outside of the limits
specified, there is a possibility of a shock hazard, and the equipment should be repaired and rechecked before it is returned to
the customer.
2
TY-FB9BD
All manuals and user guides at all-guides.com

2 Prevention of Electro Static Discharge (ESD) to
Electrostatically Sensitive (ES) Devices
Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called
Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and
semiconductor "chip" components. The following techniques should be used to help reduce the incidence of component damage
caused by electro static discharge (ESD).
1.Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any ESD on your
body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging ESD wrist strap,
which should be removed for potential shock reasons prior to applying power to the unit under test.
2.After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as alminum
foil, to prevent electrostatic charge buildup or exposure of the assembly.
3.Use only a grounded-tip soldering iron to solder or unsolder ES devices.
4.Use only an anti-static solder removal device. Some solder removal devices not classified as "anti-static (ESD protected)" can
generate electrical charge sufficient to damage ES devices.
5.Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES devices.
6.Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most
replacement ES devices are packaged with leads electrically shorted together by conductive foam, alminum foil or comparable
conductive material).
7.Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material
to the chassis or circuit assembly into which the device will be installed.
Caution
Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.
8.Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise hamless motion such as the brushing
together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity (ESD) sufficient to
damage an ES device).
3
TY-FB9BD
All manuals and user guides at all-guides.com

3 About lead free solder (PbF)
Note: Lead is listed as (Pb) in the periodic table of elements.
In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder.
The Lead Free Solder used in our manufacturing process and discussed below is (Sn+Ag+Cu).
That is Tin (Sn), Silver (Ag) and Copper (Cu) although other types are available.
This model uses Pb Free solder in it’s manufacture due to environmental conservation issues. For service and repair work, we’d
suggest the use of Pb free solder as well, although Pb solder may be used.
PCBs manufactured using lead free solder will have the PbF within a leaf Symbol stamped on the back of PCB.
Caution
·
· ·
· Pb free solder has a higher melting point than standard solder. Typically the melting point is 50 ~ 70 °F (30~40°C) higher.
Please use a high temperature soldering iron and set it to 700 ± 20 °F (370 ± 10 °C).
·
· ·
· Pb free solder will tend to splash when heated too high (about 1100 °F or 600 °C).
If you must use Pb solder, please completely remove all of the Pb free solder on the pins or solder area before applying Pb
solder. If this is not practical, be sure to heat the Pb free solder until it melts, before applying Pb solder.
·
· ·
· After applying PbF solder to double layered boards, please check the component side for excess solder which may flow onto
the opposite side. (see figure below)
Suggested Pb free solder
There are several kinds of Pb free solder available for purchase. This product uses Sn+Ag+Cu (tin, silver, copper) solder.
However, Sn+Cu (tin, copper), Sn+Zn+Bi (tin, zinc, bismuth) solder can also be used.
4
TY-FB9BD
All manuals and user guides at all-guides.com

4 Replacement
5
TY-FB9BD
All manuals and user guides at all-guides.com

5 Connection
6
TY-FB9BD
All manuals and user guides at all-guides.com
all-guides.com

6 Circuit Board Layout
6.1. HU-Board
ABCDEFGH I
1
2
3
4
5
6
C446
C448
L308
L309
L319
L320
JK301 JK302
JK303
JK304
Q301
C306
Q302
C307
Q303
Q304
C308
Q305
Q306
C310
C312
C314
H1
C317 C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
D307 D308
D309
C330
C331
C332
D310
IC305
C335
C336
IC307
R310
R312
R314
R315
R316
R318
C340
R319
C341
C342
C345
R320
C348
R321
C349
R322 R323
R324
R325
R326
R327
R328R329
C354
C356
R330
C358
R331
C359
R332
R333
R334
R335
R336
R337
R338
C360 R339
C361
C362
C364
C365 C367
C369
R345
R346
C370
C371C373
C374
C375
R351
C379
R352
R353 R354
C380 C381
R359
C382
C384
C385
C386 C387 C388
R360
R361
R362
R363
C390
C391
C392
C393
C394
C395 R370 C398
R377
R383
R391
R392
R394
R395
R396
C400
C401
C402
C403
C404
C405
C406
C407
C408
C410
C411
C412
C413
C414
C415
C420
C423
R402
R405 R406
R409
C432 C433 C434
C435
C436
C437 C438
R410
HU
1
CR NO.3
TNPA3885
PbF
LR
LR
CY
ORDER NO.
B2
A1
A2A40
A39
B39
B40 B1
1
25
26 50
1
28
29
56
C440
C441
C442
C443
C444
C445
L301
L302
C447
L303
L304
C449
L305
L306
L307
C450
C451
L310
L311
L312
L313
L314 L315
L316
L317
L318
TP301
TP302
TP303
TP304
TP305
JK301
JK302
JK303
JK304
C301
C302
C303
C304
C305
C309
Q307
Q308
C311
C313
H0
H1
C315
C316
D301 D302
D303
D304
D305
R301
D306
R302
R303
R304
R305
R306
R307
R308
IC301
R309
IC302
IC303
C333
IC304
C334
D311
IC306
C337
IC308
C338
C339
IC309
R311 R313
R317
C343 C344
C346
C347
C350
C351
C352
C353
C355
C357
C363
C366
C368
R340
R341
R342
R343
R344
R347
R348
R349
C372
C376 C377
C378
R350
R355
R356
R357
R358
C383
C389
R364
R365
R366
R367 R368 R369
C396
C397
C399
R371
R372
R373
R374
R375
R376
R378R379
R380 R381
R382 R384R385
R386
R389
R390
R397
R399
X301
C409
C416
C417
C418
C419
C421
C422
C424
C425
C426
C427
R400
C428
R401
C429
R403 R404
R407
R408
C430
C431
R411
C439
R412
R413 R414
R417
TNPA3885
1
HU
CR NO.3
L
R
GND
HD VD
R415 R416
PbF
LR
L
RC
Y
SEE REVERSE FOR ORDER NO.
1
8
A1A2B1B2
A39A40B39B40
1
12
13 24
25
36
37
48
1
3
4
5
1
34
5
1
44
45 88
89
132
133
176
1
4
58
18
9
16
14
58
+
TY-FB9BD
HU-BOARD TXNHU10YHT TY-FB9BD HU-BOARD TXNHU10YHT
HU-BOARD (FOIL SIDE)
TXNHU10YHT HU-BOARD (COMPONENT SIDE) TXNHU10YHT
Parts Location
HU-BOARD
IC
IC3301 F-2
IC3302 G-2
IC3303 G-4
IC3304 G-3
IC3305 B-3
IC3306 H-2
IC3307 B-2
IC3308 G-2
IC3309 G-2
Q3301 D-2
Q3302 D-2
Q3303 D-3
Q3304 D-3
Q3305 C-2
Q3306 C-3
Q3307 G-3
Q3308 G-3
TRANSISTOR
TP3301 I-3
TP3302 I-3
TP3303 H-2
TP3304 H-2
TP3305 H-4
TRANSISTORTP
TY-FB9BD
7
All manuals and user guides at all-guides.com

NOTE
TY-FB9BD
8
All manuals and user guides at all-guides.com

7 Block and Schematic Diagram
7.1. Schematic Diagram Notes
TY-FB9BD
9
All manuals and user guides at all-guides.com

7.2. HU-Board Block Diagram
CY
L
L-G
R
R-G
L
R
1.8V
1.8V
3.3V
3.3V
3.3V
5V
5V_STB
5V_STB
9V
5V
3.3V
3.3V
9V
1
2
4
12
10
14
9
11
HU DUAL VIDEO TERMINAL(BNC/S)
B1
B2
5A2
6
3
LEVEL CHANGE
A1
2
SDA
SCL 6
5
IC3309
CONFIG ROM
1
5VOUT VDD
IC3303
AVR 1.8V
43
45
40
36
Q3302,Q3306
29
V/Y
(+6db) IN
V/CVB
(+6db)
Q3301,Q3305
CC IN 68
6db
6db
6db
Y IN
1
1
VOUT
1
COUT
YOUT
1
V1
LV1
RV1
C2
Y2
S2
LV2
RV2
LOGIC
26
27
SCL
SDA
6db
0db
6db
0db
39
1
LOUT
41
1
ROUT
JK3301
VIDEO IN
JK3302
AUDIO IN
L
R
S-VIDEO IN
JK3304
JK3303
R
AUDIO IN
L
164
X3301
27MHz
HD VIDEO DECODER (10bit ADC)
IC3304
SDRAM
IC3305
16M bit
60 RESETX
VCCVOUT
45
RESET
IC3302
96
95
93
94
92
91
90
89
105
106
84
83
MPU
I/F
SCL
SDATX
SCL
SDA
IC3306
3,3V 5V
4
31
12
27
7
28
10
6
11
8
14
ANALOG FRONT END(MUX/CLAM/AGC)
DOUT(2)
SCL
B12
TXC+
TXC-
TO J13
SDA
H1
B25
B24
39
37
40
42
41
45
38
46
47
48
B11
B15
B9
B14
B6
B8
B3
B5
B2
TX3+
TX3-
TX2+
TX2-
TX1+
TX1-
TX0+
TX0-
B28
PLUG DETECT
B23
SRQ
H0
2
6
7
FACTORY
FOR
USE
SRQ
SCL
SDA
SCL(5V)
SDA(5V)
A26
L
R
A28
Q3304
Q3303
L(0dB)
R(0dB)
S2 DETECT
B36
A22
5V_STB
9V
A21
9V
B21
A19
5V
5V
3.3V
A17
B19
B17
3.3V
SDRAM
I/F
XIN
99
CLOCK GENE
DOUT(3)
DOUT(4)
DOUT(5)
DOUT(7)
DOUT(6)
DOUT(8)
DOUT(9)
G0
G1
G2
G5
G3
G4
G7
G6
TCLK+
TD+
TC+
TB+
TD-
TA+
TC-
TB-
TA-
TCLK-
IC3307
LVDS TX
TC4
CLK_IN
TC5
HD
VD VD
HD
RCLK0 27MHz
VIDEO
SIGNAL
PROCCESSOR
Synchroni-
zation
Y/C Sepa
Chroma Demo
Noise Reduce
PictureAdjust/
Enhancer
Flame TBC
OUTPUT I/F(FORMATTER/BUFFER)
AV SW
IC3301
ADC
ADC
SCL(3.3V)
SDA(3.3V)
TD2
TD3
TB0
TA6
TB2
TB1
TB4
TB3
TY-FB9BD
HU-Board Block Diagram TY-FB9BD HU-Board Block Diagram
TY-FB9BD
10
All manuals and user guides at all-guides.com

7.3. HU-Board (1 of 2) Schematic Diagram
CY
+
+
+
AE_R
AE_L
F_SDA
F_SCL
9V
D3302
MAZ81400ML
R3338
1k
R3304
22k
L3306
EXC3BB221H
R3324
100
C3312
10V 1u
D3309
MAZ81400ML
R3327
330
Q3301
2SD0601ARL
C3326
50V
47p
R3322
33k
S3302
GAP0.3
C3301
50V
560p
C3303
50V
560p
R3301
75
C3319
16V
0.1u
R3326
330
R3339
1k
S3303
GAP0.3
R3331
100
C3308
10V 1u
C3310
10V 1u
JK3304
K1CB106B0027
C3321
50V
10p
R3306
22k
C3446
16V
0.1u
L3309
G1C100K00020
C3331
10V
10u
S3305
GAP0.3
C3448
16V
0.1u
Q3305
2SB0709ARL
C3450
16V
1u
C3426
16V
47u
C3307
10V 10u
C3309
16V
47u
L3301
EXC3BB221H
C3311
16V
0.1u
R3413
22
R3334
430
D3310
MAZ81400ML
L3303
EXC3BB221H
Q3302
2SD0601ARL
L3308
G1C100K00020
C3316
10V
1u
D3306
MAZ81400ML
D3307
MAZ81400ML
R3336
100
R3307
22k
R3335
430
9V
C3329
1000p
50V
S3307
GAP0.3
JK3302
K2HA204B0097
L
L-G
R
R-G
R3305
22k
9V
C3328
16V
0.1u
L3307
EXC3BB221H
D3304
MAZ81400ML
R3337
100
R3411
1k
JK3301
K1QBB1AB0008
P2347
R3310 220
R3414
22
R3332
127
C3304
50V
560p
C3427
16V
0.1u
L3319
J0JHC0000078
R3329
1k
R3333
127
R3316 220
Q3304
2SD0601ARL
C3318
10u
10V
R3321
47k
R3328
1k
R3325
100
S3306
GAP0.3
C3306
10V 1u
JK3303
K2HA204B0097
L
L-G
R
R-G
L3302
EXC3BB221H
C1AB00000461
IC3301
1
V1
2
LV1 3
Y1 4
RV1 5
C1 6
S2-1 7
S-1 8
V2 9
LV2 10
Y2 11
RV2 12
C2
13
S2-2
14 S-2
15 V3
16 LV3
17 Y3
18 RV3
19 C3
20 S2-3
21 S-3
22 LV4
23 V4
24
RV4
25
ADR
26 SCL 27 SDA 28 DC OUT 29 COUT2 30 LOUT2 31 YOUT2 32 ROUT2 33 VOUT2 34 Vcc 35 MUTE 36
YIN1
37
BIAS
38
CIN1 39
LOUT1 40
VOUT1 41
ROUT1 42
TRAP1 43
YOUT1 44
GND 45
COUT1 46
LTV 47
TV 48
RTV
R3314 220
Q3303
2SD0601ARL
Q3306
2SB0709ARL
R3308
1k
C3320
16V
0.1u
C3325
50V
47p
R3315 220
R3317 220
C3451
16V
0.1u
C3315
16V
47u
GAP0.3
S3301
R3330
100
R3302
75
C3317
10u
10V
L3305
EXC3BB221H
C3327
16V
0.1u
R3319
100
C3302
50V
560p
R3318
100
R3309 220
C3314
10V
10u
R3303
75
L3304
EXC3BB221H
D3308
MAZ81400ML
C3305
10V 10u
S3304
GAP0.3
C3332
10V
10u
R3320
33k
R3312 220
C3330
1000p
50V
R3323
47k
C3322
50V
10p
C3313
10V 10u
R3416
0
R_IN
L_IN
R_IN
L_IN
VIDEO
S-VIDEO
IN
IN
V
L
YR
CLR
C(+6dB) 4.5V
V/Y(+6dB) 3.3V
R(0dB) 4.5V
L(0dB) 4.5V
C
Y
R
L
B
E
96873
D
4
C
12
F
5
A
HU-BOARD TXNHU10YHT (1/2)
4
1
5
3
2
VIDEO IN
AUDIO IN
S-VIDEO IN
AUDIO IN
AV SW
TY-FB9BD
HU-Board (1 of 2) Schematic Diagram TY-FB9BD
HU-Board (1 of 2) Schematic Diagram
TY-FB9BD
11
All manuals and user guides at all-guides.com
all-guides.com

7.4. HU-Board (2 of 2) Schematic Diagram
+
+
+
+
+
+
+
+
+
SD_D15 SD_D14 SD_D13 SD_D12 SD_D11 SD_D10
SD_D9 SD_D8
SD_DQM
SD_CLK
SD_A9 SD_A8 SD_A7 SD_A6 SD_A5 SD_A4SD_A3
SD_A2 SD_A1 SD_A0 SD_A10 SD_BA SD_RAS SD_CAS SD_WE SD_DQM SD_D7 SD_D6 SD_D5 SD_D4 SD_D3 SD_D2 SD_D1 SD_D0
G_SDA
A_G4
G_SCL
A_G6
5V
A_G1
9V
G_SRQ
A_G3
A_G0
A_G2
A_G7
AE_R
3.3V
AE_L
A_G5
SD_D0
SD_D15
SD_D1
SD_D14
SD_D2
SD_D13
SD_D3
SD_D12
SD_D4
SD_D11
SD_D5
SD_D10
SD_D6 SD_D9 SD_D7 SD_D8
SD_WE
SD_A3
A_G0
A_G1
A_G2
A_G3
A_G4
A_G5
A_G6
A_G7
A_CLK
G_SDA
G_SCL
G_SRQ
G_SCL
G_SDA
SD_RAS
SD_BA
SD_A10
SD_A0
SD_A1
SD_A2
A_CLK
A_HD
A_HD
A_VD
A_VD
SD_A9
SD_A6
SD_A5
SD_A8
SD_A4
SD_A7
SD_DQM
F_SDA F_SCL
5V
5V
1.8V
5V
G_SCL
G_SDA
SD_CAS
5V
SD_CLK
AN_TX0-
AN_TX0+
AO_TX1-
AO_TX1+
AP_TX2-
AP_TX2+
AR_TX3+
AR_TX3-
AQ_TXC+
AQ_TXC-
AN_TX0-
AN_TX0+
AO_TX1-
AO_TX1+
AP_TX2-
AP_TX2+
AR_TX3+
AR_TX3-
AQ_TXC+
AQ_TXC-
3.3V
C3355
16V 0.1u
D3311
MAZ30360HL
C3400
16V
0.1u
C3429
0.1u
16V
TP3304
H0
1
2
3
4
5
6
7
8
3.3V
IC3307
C0JBCZ000523
1RS
2TD1
3TA5
4TA6
5GND
6TB0
7TB1
8TD2
9VCC
10 TD3
11 TB2
12 TB3
13 GND
14 TB4
15 TB5
16 TD4
17 R/F
18 TD5
19 TB6
20 TC0
21 GND
22 TC1
23 TC2
24 TC3
25 TD6
26 VCC
27 TC4
28 TC5 29
GND
30
TC6
31
CLK_IN
32
/PDWN
33
PLL_GND
34
PLL_VCC
35
PLL_GND
36
LVDS_GND
37
TD+
38
TD-
39
TCLK+
40
TCLK-
41
TC+
42
TC-
43
LVDS_GND
44
LVDS_VCC
45
TB+
46
TB-
47
TA+
48
TA-
49
LVDS_GND
50
TD0
51
TA0
52
TA1
53
GND
54
TA2
55
TA3
56
TA4
C3386
16V 0.1u
C3381
16V 0.1u
R3374
22
C3366
16V 0.1u
C3359
16V 0.1u
C3419
16V
0.1u
C3EBGC000065
IC3309
1A0
2A1
3A2
4GND 5
SDA
6
SCL
7
WP
8
VCC
R3367
EXB38V220JV
C3333
47u
6.3V
C3351
16V
0.1u
R3352
47k
R3384
EXB38V220JV
C3396
16V 0.1u
C3385
16V
0.1u
TP3305
R3356
10
C3369
10V
1u
C3415
16V
0.1u
C3380
16V 0.1u
C3424
16V
47u
C3437
16V
0.1u
R3340
150
C3334
16V
0.1u
C3367
16V 0.1u
R3378
EXB38V220JV
C3345
10V
1u
C3378
16V 0.1u
R3355
10
R3354
1.1k
R3385
EXB38V220JV
L3312
G1C6R8MA0061
C3337
50V
0.01u
C3ABMG000227
IC3305
1VCC 2DQ1 3DQ2 4VSSQ 5DQ3 6DQ4 7VCCQ 8DQ5 9DQ6
10 VSSQ 11 DQ7 12 DQ8 13 VCCQ 14 LDQM 15 WE 16 CAS 17 RAS 18 CS 19 A11 20 A10 21 A0 22 A1 23 A2 24 A3 25 VCC 26
VSS
27
A4
28
A5
29
A6
30
A7
31
A8
32
A9
33
NC
34
CKE
35
CLK
36
UDQM
37
NC
38
VCCQ
39
DQ9
40
DQ10
41
VSSQ
42
DQ11
43
DQ12
44
VCCQ
45
DQ13
46
DQ14
47
VSSQ
48
DQ15
49
DQ16
50
VSS
5V
3.3V
R3370
10k
C3388
16V 0.1u
5V_STB
R3351
47k
R3389
22
C3399
16V
0.1u
C3356
16V 0.1u
L3318
J0JHC0000078
R3381
22
R3406
4.7k
C3347
16V
0.1u
R3380
EXB38V220JV
C3434
0.01u
50V
C3431
0.1u
16V
R3404 22
C3407
16V
0.1u
R3344
1k
3.3V
C3383
16V 0.1u
R3408
10k
C3384
16V
0.1u
C3376
16V
0.1u
R3368
EXB38V220JV
R3345
330
TP3303
C1AB00002487
IC3304
1
AOUT2
2
AVSDA2
3
AVDDA1
4VREF1
5VRO1
6AOUT1
7AVSDA1
8AVDPL1
9AVSPL1
10 VDDE
11 SININ1
12 ITHR
13 VDDI
14 RCLKI
15 SMCK
16 VSS
17 AVDAD0
18 VRH0
19 VRL0
20 AVSAD0
21 AVDPG0
22 SYNCIN
23 GIN
24 CO0
25 AVSPG0
26 ATST0
27 AVSPG1
28 CO1
29 CVBSIN
30 AVDPG1
31 AVSAD1
32 VRL1
33 VRH1
34 AVDAD1
35 VSS
36 VDDI
37 VDDE
38 CLK8
39 CLK4
40 GCLP
41 REQ
42
VSS
43
VDDI
44
VDDE
45
AS
46
SEL
47
DIN[9]
48 DIN[8] 49 DIN[7] 50 DIN[6] 51 DIN[5] 52 DIN[4] 53 DIN[3] 54 DIN[2] 55 DIN[1] 56 DIN[0] 57 VDDI 58 DVCK 59 VSS 60 RESETX 61 TEST0 62 TEST1 63 AVDAD2 64 VRH2 65 VRL2 66 AVSAD2 67 AVDBF2 68 CCRIN 69 CO3 70 CO2 71 AVSBF2 72 ATST1 73 AVSBF3 74 CBIN 75 AVDBF3 76 AVSAD3 77 VRL3 78 VRH3 79 AVDAD3 80 VSS 81 VDDE 82 RX 83 SDATX 84 SCL 85 XCS 86
VDDI
87
VDDE
88
VSS
89
DOUT[9]
90
DOUT[8]
91
DOUT[7]
92
DOUT[6]
93
DOUT[5]
94
DOUT[4]
95
DOUT[3]
96
DOUT[2]
97
DOUT[1]
98
DOUT[0]
99
RCLKO
100
VDDE
101
VSS
102
VDDI
103
TIN
104
VSS
105
HD
106
VD
107
FID
108
VSS
109
VDDI
110
VDDE
111
MA[9]
112
MA[8]
113
MA[7]
114
MA[6]
115
MA[5]
116
MA[4]
117
MA[3]
118
MDQM
119
MCAS
120
VSS
121
VDDI
122
VDDE
123
MRAS
124
MBA
125
MA[10]
126
MA[0]
127
MA[1]
128
MA[2]
129
MD[17]
130
MD[16]
131
VSS
132
VDDI
133
VDDE
134
MCLK
135
MWE
136
MD[8] 137 MD[7] 138 MD[9] 139 MD[6] 140
MD[10] 141
MD[5] 142
MD[11] 143
VDDE 144
VSS 145
VDDI 146
MD[4] 147
MD[12] 148
MD[3] 149
MD[13] 150
MD[2] 151
MD[14] 152
MD[1] 153
MD[15] 154
MD[0] 155
VDDE 156
VSS 157
VDDI 158
PDOUT 159
VSS 160
AVSPL0 161
AVDPL0 162
CPO 163
VGS 164
XIN 165
XTST 166
VDDE 167
AVD 168
AVS 169
MST 170
SM 171
SININ2 172
VDDI 173
VSS 174
AVDDA2
175
VREF2
176
VRO2
C3397
16V0.1u
C3368
16V 0.1u
R3382
22
R3369
EXB38V220JV
L3320
J0JHC0000078
R3343
10 C3354
16V 0.1u
C3408
16V 0.1u
R3349
22
L3314
J0JHC0000078
R3364
10
Q3307
2SB0709ARL
C3393
16V
0.1u C3413
16V 0.1u
C3433
0.01u
50V
R3350
100k
C0JBAZ002269
IC3306
1
2
3
45
6
7
8
C3339
50V
33p
R3363
10
C3410
50V 1000p
L3313
G1C6R8MA0061
R3347
220
R3405
4.7k
R3379
EXB38V220JV
R3372
22
C3373
16V
0.1u
C3423
16V
0.1u
C3447
6.3V
1u
R3359
2.7k
C3394
16V 0.1u
R3392
10k
R3399 10k
L3311
J0JHC0000078
C3341
50V
68p
C3374
16V
0.1u
R3417
10
C3403
16V
0.1u
C3365
16V
0.1u
C3382
16V 0.1u
H1
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
A21
A22
A23
A24
A25
A26
A27
A28
A29
A30
A31
A32
A33
A34
A35
A36
A37
A38
A39
A40
B1
B2
B3
B4
B5
B6
B7
B8
B9
B10
B11
B12
B13
B14
B15
B16
B17
B18
B19
B20
B21
B22
B23
B24
B25
B26
B27
B28
B29
B30
B31
B32
B33
B34
B35
B36
B37
B38
B39
B40
R3361
1.1k
IC3302
C0EBE0000066
1
NC
2
SUB
3
GND
5
Vcc
4
Vout
C3425
10V
1u
R3403 22
C3404
16V
0.1u
C3364
16V 0.1u
R3390
22
R3376
10k
C3411
50V
1000p
C3344
6.3V
1u
C3353
16V 0.1u
C3389
16V 0.1u
C3430
0.1u
16V
C3441
47u
6.3V
C0CBCAC00275
IC3303
1
VDD
2
GND
3
CE
5
VOUT
4
NC
C3358
16V 0.1u
C3370
16V
0.1u
R3371
EXB38V220JV
TP3302
R3375
10k
C3401
16V
0.1u
C3357
16V 0.1u
C3432
0.01u
50V
L3317
J0JHC0000078
C3363
16V 0.1u
C3342
50V
68p
C3428
0.1u
16V
C3336
16V
0.1u
C3346
16V
0.1u
C3387
16V 0.1u
C3375
10V 1u
C3416 50V 1000p
C3362
16V 0.1u
C3405
16V
0.1u
C3412
50V
1000p
C3361
50V 33p
C3406
16V 0.1u
3.3V
R3348
220
C3414
16V 0.1u
L3310
J0JHC0000078
R3383 22
C3350
16V 0.1u
R3377
10k
C3436
0.01u
50V
C3402
16V
0.1u
C3379
16V 0.1u
C3445
6.3V
47u
R3346
330
C3409
10V
1u
R3342
10
C3371
16V
0.1u
C3390
16V 0.1u
C3352
16V
0.1u
TP3301
C3377
16V
0.1u
C3417
50V 1000p
C3348
16V
0.1u
C3422
6.3V
47u
R3386
EXB38V220JV
L3316
J0JHC0000078
C3443
47u
6.3V
C3335
16V
0.1u
R3360
2.2k
C3392
16V
0.1u
R3373
22
C3395
16V 0.1u
R3353
2.2k
C3343
50V
0.01u
R3358
10k
C3340
50V
33p
C3418 16V 0.1u
C3444
47u
6.3V
L3315
J0JHC0000078
X3301
H1A2705B0032
1
OE
2GND
3OUT 4
VDD
C3372
16V
0.1u
C3420
50V
18p
C3349
16V
0.1u
R3362
2.7k
R3365
10
C3438
0.01u
50V
C3391
16V 0.1u
C3435
0.01u
50V
C3360
16V 0.1u
C3398
16V
0.1u
Q3308
2SB0709ARL
C3442
47u
6.3V
R3366
22
R3341
150
5V_STB
C3440
47u
6.3V
5V_STB
3.3V
9V
5V
A=3.3V,B=5V
GND
/OE1
B1
A2
Vcc
A1
B2
SDA(3.3V)
/OE2
SCL(3.3V)
CONFIG ROM
EEPROM
SDA
SRQ
WP
GND
SCL
D+1.8V
D+3.3V
A+3.3V P+1.8V
A+3.3V
A+3.3V
A+3.3V
D+3.3V
100mA max
50mA max
B2
B0
B1
B3
B4
B5
B6
B7
R7
R1
R6
R5
R4
R3
R2
R0
9V/0.5A 3slot
5V/0.4A 3slot
3.3V/1.2A 3slot
D3.3V
D1.8V
P1.8V
A3.3V
A3.3V
A3.3V
A3.3V
A3.3V
D1.8V
D3.3V
D1.8V D3.3V
D1.8V
A3.3V A3.3V
Y/CVB IN
C IN
A3.3V A3.3V
D3.3V
SDA
SCL
SDA
SCL
D3.3V 27MHz 1.65kHz
D1.8V
D1.8V
D3.3V
D1.8V
D3.3V
D1.8V
D3.3V
57MHz
D3.3V
D1.8V
D1.8V
D1.8V
P1.8V
D3.3V
P1.8V
A3.3V
Low=I2C
16kbit
14 181210 1611 1513 17
3
4
1
2
5
16M bit SDRAM
AVR 1.8V
LVDSTX
HD VIDEO DECODER(10bit ADC)
RESET
LEVEL CHANGE
3.3V 5V
HU-BOARD TXNHU10YHT (2/2)
TO
J-BOARD
(J12)
USE
FACTORY
TO
TY-FB9BD
HU-Board (2 of 2) Schematic Diagram TY-FB9BD
HU-Board (2 of 2) Schematic Diagram
TY-FB9BD
12
All manuals and user guides at all-guides.com

8 Replacement Parts List
8.1. Replacement Parts List Notes
13
TY-FB9BD
All manuals and user guides at all-guides.com

Ref.
No. Part No. Part Name & Description Pcs Remarks
C3301-
04 ECJ1XC1H561J C 560PF, J, 50V 4
C3305 ECJ3YB1A106M C 10UF, M,6.3V 1
C3306 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3307 ECJ3YB1A106M C 10UF, M,6.3V 1
C3308 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3309 EEEHB1C470P C 47PF, J, 16V 1
C3310 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3311 ECJ1XB1C104K C 0.1UF, Z, 16V 1
C3312 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3313,1
4ECJ3YB1A106M C 10UF, M,6.3V 2
C3315 EEEHB1C470P C 47PF, J, 16V 1
C3316 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3317,1
8ECJ3YB1A106M C 10UF, M,6.3V 2
C3319,2
0ECJ1XB1C104K C 0.1UF, Z, 16V 2
C3321,2
2ECJ1VC1H100C C 10PF, C, 50V 2
C3325,2
6ECJ1XC1H470J C 47PF, J, 50V 2
C3327,2
8ECJ1XB1C104K C 0.1UF, Z, 16V 2
C3329,3
0ECJ1XB1H102K C 1000UF, Z, 50V 2
C3331,3
2ECJ1VB1A105K C 0.01UF, Z, 50V 2
C3333 EEEHB0J470R C 47PF, J, 6.3V 1
C3334-
36 ECJ1XB1C104K C 0.1UF, Z, 16V 3
C3337 ECJ1VB1H103K C 0.001UF, K, 50V 1
C3339,4
0ECJ1XC1H330J C 33PF, J, 50V 2
C3341,4
2ECJ1XC1H680J C 68PF, J, 50V 2
C3343 ECJ1VB1H103K C 0.001UF, K, 50V 1
C3344 ECJ1XB0J105K C 1UF, K, 16V 1
C3345 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3346-
60 ECJ1XB1C104K C 0.1UF, Z, 16V 15
C3361 ECJ1XC1H330J C 33PF, J, 50V 1
C3362-
68 ECJ1XB1C104K C 0.1UF, Z, 16V 7
C3369 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3370-
74 ECJ1XB1C104K C 0.1UF, Z, 16V 5
C3375 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3376-
08 ECJ1XB1C104K C 0.1UF, Z, 16V 33
C3409 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3410-
12 ECJ1XB1H102K C 1000UF, Z, 50V 3
C3413-
15 ECJ1XB1C104K C 0.1UF, Z, 16V 3
C3416,1
7ECJ1XB1H102K C 1000UF, Z, 50V 2
C3418,1
9ECJ1XB1C104K C 0.1UF, Z, 16V 2
C3420 ECJ1XC1H180J C 18PF, J, 50V 1
C3422 EEEHB0J470R C 47PF, J, 6.3V 1
C3423 ECJ1XB1C104K C 0.1UF, Z, 16V 1
C3424 EEEHB1C470P C 47PF, J, 16V 1
C3425 ECJ1VB1A105K C 0.01UF, Z, 50V 1
C3426 EEEHB1C470P C 47PF, J, 16V 1
C3427-
31 ECJ1XB1C104K C 0.1UF, Z, 16V 5
C3432-
36 ECJ1VB1H103K C 0.001UF, K, 50V 5
C3437 ECJ1XB1C104K C 0.1UF, Z, 16V 1
C3438 ECJ1VB1H103K C 0.001UF, K, 50V 1
C3440-
42 EEEHB0J470R C 47PF, J, 6.3V 3
C3443 ECGRL0G680ER C 68PF, J, 4V 1
Ref.
No. Part No. Part Name & Description Pcs Remarks
C3444,4
5EEEHB0J470R C 47PF, J, 6.3V 2
C3446 ECJ1XB1C104K C0.1UF,Z,16V 1
C3447 ECJ1XB0J105K C1UF,K,16V 1
C3448 ECJ1XB1C104K C0.1UF,Z,16V 1
C3450 ECJ1VF1C105Z C1UF,Z,16V 1
C3451 ECJ1XB1C104K C0.1UF,Z,16V 1
D3302 MA8140M ZENER DIODE 1
D3304 MA8140M ZENER DIODE 1
D3306-
10 MA8140M ZENER DIODE 5
D3311 MA3036H ZENER DIODE 1
H0 K1KA08AA0150 8P CONNECTOR 1
H1 K1KA80B00037 80P CONNECTOR 1
IC3301 CXA2089Q LINEAR IC 1
IC3302 PST9128NR IC (LOGIC) 1
IC3303 C0CBCAC00275 IC 1
IC3304 C1AB00002487 IC 1
IC3305 C3ABMG000227 IC 1
IC3306 C0JBAZ002269 IC 1
IC3307 C0JBCZ000523 IC 1
IC3309 C3EBGC000065 IC 1
JK3301 K1QBB1AB0008 CONNECTOR 1
JK3302,
03 K2HA204B0097 JACK 2
JK3304 K1CB106B0027 CONNECTOR 1
L3301-
07 EXC3BB221H BEAD CHOKE 7
L3308,0
9G1C100K00020 INDUCTION COIL 2
L3310,1
1J0JHC0000078 CHIP INDUCTOR 2
L3312,1
3G1C6R8MA0061 INDUCTOR COIL 2
L3314-
20 J0JHC0000078 CHIP INDUCTOR 7
Q3301-
04 2SD601A TRANSISTOR 4
Q3305-
08 2SB0709A TRANSISTOR 4
R3301-
03 ERJ6ENF75R0 M 75 OHM, 1/10W 3
R3304-
07 ERJ6GEYJ223 M 22KOHM,J,1/10W 4
R3308 ERJ3GEYJ102 M 1KOHM,J,1/16W 1
R3309,1
0ERJ3GEYJ221 M 220 OHM,J,1/16W 2
R3312 ERJ3GEYJ221 M 220 OHM,J,1/16W 1
R3314-
17 ERJ3GEYJ221 M 220 OHM,J,1/16W 4
R3318,1
9ERJ3GEYJ101 M 100 OHM,J,1/16W 2
R3320 ERJ3GEYJ333 M 33KOHM,J,1/16W 1
R3321 ERJ3GEYJ473 M 47KOHM,J,1/16W 1
R3322 ERJ3GEYJ333 M 33KOHM,J,1/16W 1
R3323 ERJ3GEYJ473 M 47KOHM,J,1/16W 1
R3324,2
5ERJ3GEYJ101 M 100 OHM,J,1/16W 2
R3326,2
7ERJ3EKF3300 M 330 OHM, 1/16W 2
R3328,2
9ERJ6GEYJ102 M 1KOHM,J,1/10W 2
R3330,3
1ERJ3GEYJ101 M 100 OHM,J,1/16W 2
R3332,3
3ERJ3EKF1270 M 127 OHM, 1/16W 2
R3334,3
5ERJ3EKF4300 M 430 OHM, 1/16W 2
8.2. Electrical Replacement Parts List
14
TY-FB9BD
All manuals and user guides at all-guides.com

Ref.
No. Part No. Part Name & Description Pcs Remarks
R3336,3
7ERJ3GEYJ101 M 100 OHM,J,1/16W 2
R3338,3
9ERJ6GEYJ102 M 1KOHM,J,1/10W 2
R3340,4
1ERJ3GEYJ151 M 150 OHM,J,1/16W 2
R3342,4
3ERJ3GEYJ100 M 10 OHM,J,1/16W 2
R3344 ERJ3GEYJ102 M 1KOHM,J,1/16W 1
R3345,4
6ERJ3GEYJ331 M 330 OHM,J,1/16W 2
R3347,4
8ERJ3GEYJ221 M 220 OHM,J,1/16W 2
R3349 ERJ3GEYJ220 M 22 OHM,J,1/16W 1
R3350 ERJ3GEYJ104 M 100KOHM,J,1/16W 1
R3351,5
2ERJ3GEYJ473 M 47KOHM,J,1/16W 2
R3353 ERJ3GEYJ222 M 2.2KOHM,J,1/16W 1
R3354 ERJ3GEYJ112 M 1.1KOHM,J,1/16W 1
R3355,5
6ERJ3GEYJ100 M 10 OHM,J,1/16W 2
R3358 ERJ3GEYJ103 M 10KOHM,J,1/16W 1
R3359 ERJ3GEYJ272 M 2.7KOHM,J,1/16W 1
R3360 ERJ3GEYJ222 M 2.2KOHM,J,1/16W 1
R3361 ERJ3GEYJ112 M 1.1KOHM,J,1/16W 1
R3362 ERJ3GEYJ272 M 2.7KOHM,J,1/16W 1
R3363-
65 ERJ3GEYJ100 M 10 OHM,J,1/16W 3
R3366 ERJ3GEYJ220 M 22 OHM,J,1/16W 1
R3367-
69 EXB38V220J RESISTOR ARRAY 3
R3370 ERJ3GEYJ103 M 10KOHM,J,1/16W 1
R3371 EXB38V220J RESISTOR ARRAY 1
R3372-
74 ERJ3GEYJ220 M 22 OHM,J,1/16W 3
R3375-
77 ERJ3GEYJ103 M 10KOHM,J,1/16W 3
R3378-
80 EXB38V220J RESISTOR ARRAY 3
R3381-
83 ERJ3GEYJ220 M 22 OHM,J,1/16W 3
R3384-
86 EXB38V220J RESISTOR ARRAY 3
R3389,9
0ERJ3GEYJ220 M 22 OHM,J,1/16W 2
R3392 ERJ3GEYJ103 M 10KOHM,J,1/16W 1
R3399 ERJ3GEYJ103 M 10KOHM,J,1/16W 1
R3403,0
4ERJ3GEYJ220 M 22 OHM,J,1/16W 2
R3405,0
6ERJ3GEYJ472 M 4.7KOHM,J,1/16W 2
R3408 ERJ3GEYJ103 M 10KOHM,J,1/16W 1
R3411 ERJ3GEYJ102 M 1KOHM,J,1/16W 1
R3413,1
4ERJ3GEYJ220 M 22 OHM,J,1/16W 2
R3416 ERJ3GEY0R00 M 0 OHM, 1/16W 1
R3417 ERJ3GEYJ100 M 10 OHM,J,1/16W 1
RTL TXNHU10YHT CIRCUIT BOARD HU 1
X3301 H1A2705B0032 CRYSTAL 1
15
TY-FB9BD
All manuals and user guides at all-guides.com

Ref.
No. Part No. Part Name & Description Pcs Remarks
1TBMU627 TERMINAL SHEET 1
2THEL0239 SCREW FOR
INSTALLATION 4
3THEL027N SCREW FOR SHIELD
PLATE 4
4TPCB96201 CARTON BOX 1
5TPDF1103 CUSHION 1
6TPEH135 PROTECT COVER 1
7TQE6691 POLY BAG (SCREW) 1
8TQZH461-1 INSTRUCTION SHEET 1
9TQZH737 INSTRUCTION BOOK
(ENGLISH) 1
10 XTV3+10JFJ SCREW FOR AV
TERMINAL 3
11 XZBT6506 POLY BAG
(INSTRUCTION BOOK) 1
8.3. Mechanical Replacement Parts List
16
TY-FB9BD
All manuals and user guides at all-guides.com
all-guides.com

8.4. Parts Location (1)
17
TY-FB9BD
All manuals and user guides at all-guides.com

8.5. Parts Location (2)
18
TY-FB9BD
All manuals and user guides at all-guides.com