Shuttle BALANCE User manual

Page 1
If you discover damaged or missing parts, please contact Shuttle Systems
[email protected] | 1-800-334-5633 9am-5pm Pacific Time
Assembly Guide
for the

Page 2
Important Note:
PDF versions of these instructions are available at:
http://shuttlesystems.com/pages/faq
!!
Keep in mind that the following images pertain to just one of the four
available Shuttle Balance models, your parts may appear slightly different
than those in the included images but, the required steps remain the"
same.
If there is any shipping damage please take a photo of the damage and "
email to [email protected] or call [phone].
The Balance will come in one box
* Balance Sport will come in 2 boxes
!1. Shuttle Balance
- Two Handrail Tubes"
!!- Two Bottom Frame Tubes"
!!- Wobble Board"
!!- Four Knurled Knobs & Four Steel/Rubber Washers"
!!- Two Steps"
BALANCE ASSEMBLY

Page 3
STEP 1
ASSEMBLING THE HANDRAIL TUBES TO THE BOTTOM FRAME TUBES
ITEMS
REQUIRED"
HANDRAILS"
TUBES "
BOTTOM
FRAME TUBES
1. Remove all protective packaging from the Handrail Tubes. "
2. Connect both Handrail Tubes to one side of the Bottom Frame Tubes, aligning the holes.
Lift both Handrail Tubes and attach the last remaining Bottom Frame piece. (Pic 1.1 & 1.2)
1.1
1.2

Page 4
STEP 2
ATTACHING THE WOBBLE BOARD
ITEMS"
REQUIRED"
WOBBLE "
BOARD"
KNURLED
KNOBS BAG
1. Place the Wobble Board in the middle of the Frame. Remove the zip-tie and parts bag with
four knurled knobs and four steel/rubber washers from the Wobble Board. (Pic 2.1)"
2. Detach four chain carabiners (two on each side) from the eyebolts on the Wobble Board
and attach them to the eyebolts on the Handrails. (Pic 2.2)"
3. Remove each carabiner attached to the black control rope from the eyebolts on the Wobble
Board. Attach the top carabiner of the control ropes to the corresponding eyebolt located
on the side of the Handrail Frame. Insert the eyebolt into and through the middle of the
frame. Tighten down the eyebolt with a Steel/Rubber Washer and Knurled Knob. Attach the
last remaining carabiner on the black control ropes to the bottom eyebolt of the frame. (Pic
2.3 & 2.4)"
4. Detach the red elasticord carabiners from each other. Attach them to the bottom eyebolts
on the frame. The elasticords and control ropes should both be attached to the bottom
eyebolt of the frame. Remove the protective packaging from the Wobble Board. (Pic 2.5)"
Pictures are on the next page

Page 5
2.1"
2.2"
2.3"
2.4
2.5

Page 6
STEP 3
SECURING THE STEMPS TO THE FRAME
ITEMS "
REQUIRED"
STEPS
1. Align the velcro on the bottom frame with the velcro on the bottom of the steps. Press the
step down to secure to the frame. The Shuttle Logo should be facing out from the Wobble
Board. (Pic 3.1)
3.1"

Page 7
Finally, you have one of the greatest machines on earth....
Well, at least we'd like to think so - and many of our owners agree.
Therefore, enjoy it!
Leave us a review on our website!
Please visit us at:
www.ShuttleSystems.com
1-800-334-5633
Made in the
USA

Page 8
II
5YEARLIMITEDORIGINALEQUIPMENTWARRANTY
REPLACEMENTPARTS
RSHUTTLESSTEMS
.T,18003345633.P
:M,,,
.
REPLACEMENTPARTWARRANTY
SHUTTLESSTEMS/CDC

/()
.W
(,,,).
PROOFOFPURCHASE
P.

.
LIMITEDORIGINALEQUIPMENTWARRANTY

/

(/),.W
,,,
.
 LIMITEDLIFETIMEWARRANTY:B,,,
,.
 FaedFIVEYEARS:P,,.
 FaedTWOYEARS:U,,,,&.
 FaedONEYEAR:E,,,,
.
LIMIALLIMLIEDAANIEOHEEIODECIFIEDABO
DAEHEODCACHAEDAEAIL.ECEAAEDHEEIN,
ANIMLIEDAANIEOMECHANABILIANDFINEAEECLDED.OME
AEDONOALLOLIMIAIONONHOLONGHEIMLIEDAANLA,OHE
ABOELIMIAIONMANOALOO.
,
,,
.I,
,
,.I,
.N
SHUTTLESSTEMS

.,,
/.S
,
.T,
.