Sprout BMS User manual

Simple. Modern. American Made.
Birch
Montessori
Shelf
Adult assembly only
2 Adults required for assembly
Assemble completely before use

Has Slots
Toe (2)
A
Bottom (1)
Shelves, Multiple
(one will be used for
the top of the unit)
Sides (2)
B
C
D
GLUE
REQUIRED: For steps using glue,
apply a pea-sized amount to the
thin end of slots. With the tabs
orented vertically, apply a pea-sized
amount at the top of each tab
(inside its groove). The glue will run
down and coat the rest of the tab
during assembly.
Apply glue just before
connecting pieces.
2
BEFORE YOU START
Parts
*
Glue helps make this shelving unit
rigid and it’s drying also makes this
assembly time-sensitive. To help the
process go smoothly, read all
instructions before proceeding.
RECCOMENDED: A rubber
mallet can help push
pieces together.
A hammer can also be
used with a scrap piece of
wood or a cutting board
placed over the surface
being hammered for
protection.
When inserting tabs into slots make
sure the side with the wider lip on
the tab faces the same direction as
the notch in the slot.
REQUIRED: Wood glue
is used to permanently
attach the shelving
pieces together.
This adds additional
rigidity to the unit.
Using other glue types
may aect curing and
workablity time.
2 people required for assembly.
Assemble on a hard oor.
For additional help watch our
Assembly Video at:
sprout-kids.com/bmsa
Or talk to our Customer Service
agent at: [phone]
NOTCH
WIDE LIP
SLOT TAB
QUARK ENTERPRISES, LLC PO BOX 1123, PROVO, UT 84601 MODEL NO. BMSPAGE 2 OF 8

Frustrated?
Need Help?
STOP
ASSEMBLY INSTRUCTIONS
A
B
A
Push tabs on Toes a into slots on bottom b . Tabs
and slots must be lined up correctly or they will not
properly tighten. See * for tab orientation.
1
*
B
A
Turning the part upright, push down on Toes a until
the ends are ush with the ends of Bottom Shelf b .
Repeat with second toe.
A
B
2
A
A
B
DOCUMENT: AI-B.2-NoBack WWW.SPROUT-KIDS.COM COPYRIGHT QUARK ENTERPRISES 2018 PAGE 3 OF 8
Talk to our customer service agent at:
[phone]
Watch our assembly video at:
sprout-kids.com/bmsa

B
C
C
D
4Press or hammer down Shelves B and Bottom B
to tighten until they make contact with the ground.
They will be ush with the underside of Side D .
Parts will be snug.
Remove excess glue from joints with a damp cloth.
If unable to get parts to be ush with each other
dissassemble immediately. Remove glue with a
damp cloth and contact Customer Service.
C
D
BB
3A second adult is needed to hold shelves in place.
Refer to * for tab orientation. Apply glue to slots on
Side D and tabs on Shelves C and Bottom B . Refer
to !! . Pop tabs into corresponding slots.
B
C
D*
Flat end of Slot
facing up
C
C
D
B
QUARK ENTERPRISES, LLC PO BOX 1123, PROVO, UT 84601 MODEL NO. BMSPAGE 4 OF 8

7
Carefully set shelving unit upright. Remove excess
glue with damp cloth. Check that everything is fully
tightened.
6To tighten, press or hammer down the second Side D
until it makes contact with the oor. Parts will be snug.
Remove excess glue from joints with a damp cloth.
D
One adult holds steady Side D , Shelves C and
Bottom B . Apply glue to the tabs on C and B and
the slots of the other Side D . Pop tabs into
corresponding slots.
5BB
C
C
D
D
B
C
C
D
Thin end of
Slot facing up
B
C
C
D
D
DOCUMENT: AI-B.2-NoBack WWW.SPROUT-KIDS.COM COPYRIGHT QUARK ENTERPRISES 2018 PAGE 5 OF 8

BRACKET INSTALLATION
6
Bracket (4) Screw (24)
Adult assembly only
Drill/power screwdriver required for assembly
2
1Tilt the assembled shelf on its back.
Place one of the brackets into the corner on the
underside of the shelf like so. The triangular face of the
bracket should be against the toe piece.
QUARK ENTERPRISES, LLC PO BOX 1123, PROVO, UT 84601 MODEL NO. BMSPAGE 6 OF 8

7
5Repeat for the other 3 corners.
Allow glue to set for 1 hour before use.
3Using a drill or power screwdriver, install 2 screws into
the holes on the triangular face. There are no
pre-drilled holes in the wood, so try to make the
screws as straight as possible.
4Install 2 more screws into the holes on one of the
small sides of the bracket, then the other.
DOCUMENT: AI-B.2-NoBack WWW.SPROUT-KIDS.COM COPYRIGHT QUARK ENTERPRISES 2018 PAGE 7 OF 8

Simple. Modern. American Made.
QUARK ENTERPRISES, LLC PO BOX 1123, PROVO, UT 84601 MODEL NO. BMSPAGE 8 OF 8