Tyco DV-5 User manual

DV-5 Deluge Valve, Diaphragm Style,
1-1/2 thru 8 Inch (DN40 thru DN200),
Deluge System — Electric Actuation
Page 1 of 14 OCTOBER 2014 TFP1320
Worldwide
Contacts
www.tyco-fire.com
General
Description
The DV-5 Deluge Valve (described in
Technical Data Sheet TFP1305) is a
diaphragm style valve that depends
upon water pressure in the Diaphragm
Chamber to hold the Diaphragm closed
against the water supply pressure.
When the DV-5 Valve is set for service,
the Diaphragm Chamber is pressurized
through the trim connections from the
inlet side of the system’s main con-
trol valve, for example an O.S.&Y. gate
valve or buttery valve (Ref. Figures 1
and 4).
Operation of an electrical device such
as a heat sensitive thermostat, smoke
detector, or electrical manual control
station signals the Deluge Valve Re-
leasing Panel to energize the Solenoid
Valve. In turn, the energized Solenoid
Valve opens to release water from the
Diaphragm Chamber faster than it can
be replenished through the 1/8 inch
(3,2 mm) restriction provided by the
Model ASV-1 Automatic Shut-Off Valve
in the diaphragm supply connections
(Item 5 - Fig. 3A and 5, also described
in Technical Data Sheet TFP1384). This
results in a rapid pressure drop in the
Diaphragm Chamber and the force
differential applied through the Dia-
phragm that holds it in the set position
is reduced below the valve trip point.
The water supply pressure then forces
the Diaphragm open permitting water
to ow into the system piping, as well
as through the Alarm Port to actuate
the system alarms.
As water ows into the system, the pi-
lot chamber of the Model ASV-1 Auto-
matic Shut-Off Valve (Item 5 - Fig. 3A
and 5) becomes pressurized and the
ASV-1 automatically shuts off the di-
aphragm chamber supply ow to the
DV-5 Diaphragm Chamber. Shutting
off the diaphragm chamber supply ow
prevents the DV-5 Diaphragm Chamber
from becoming re-pressurized, there-
by preventing inadvertent closing of the
DV-5 during a re (as may be the case
should the Solenoid Valve become de-
energized after its initial operation).
NOTICE
The DV-5 Deluge Valve with Electric
Actuation Trim described herein must
be installed and maintained in compli-
ance with this document, as well as
with the applicable standards of the
National Fire Protection Association, in
addition to the standards of any other
authorities having jurisdiction. Failure
to do so may impair the performance
of these devices.
The owner is responsible for main-
taining their fire protection system
and devices in proper operating con-
dition. Contact the installing contrac-
tor or product manufacturer with any
questions.

TFP1320
Page 2 of 14
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
DV-5 Deluge Valve
Main Control Valve (N.O.)
Diaphragm Chamber Supply
Local Manual Control Station
Open Nozzles or Sprinklers
Heat Detectors, Smoke Detectors,
Water Supply Pressure Gauge
Diaphragm Chamber Pressure
Control Valve (N.O.)
Gauge
etc. (Fire Detection)
System Drain Valve (N.C.)
Main Drain Valve (N.C.)
Diaphragm Chamber Automatic
Waterow Pressure Alarm Switch
Water Motor Alarm (Optional)
Solenoid Valve
Deluge Valve Releasing Panel
Shut-Off Valve
(Shown at Rear of Valve)
(Shown at Rear of Valve)
7
3
1
11
2
14
8
9
4
15
13
65
FIGURE 1 (1 OF 2)
SYSTEM SCHEMATIC (FRONT VIEW)
ELECTRIC ACTUATION

TFP1320
Page 3 of 14
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
DV-5 Deluge Valve
Main Control Valve (N.O.)
Diaphragm Chamber Supply
Local Manual Control Station
Open Nozzles or Sprinklers
Heat Detectors, Smoke Detectors,
Water Supply Pressure Gauge
Diaphragm Chamber Pressure
Control Valve (N.O.) Gauge (Shown at Front of Valve)
etc. (Fire Detection)
System Drain Valve (N.C.)
Main Drain Valve (N.C.)
Diaphragm Chamber Automatic
Waterow Pressure Alarm Switch
Water Motor Alarm (Optional)
Solenoid Valve
Deluge Valve Releasing Panel
Shut-Off Valve
(Shown at Front of Valve)
(Shown at Front of Valve)
1
2
11
13
5
6
3
10
14
12
9
15
FIGURE 1 (2 OF 2)
SYSTEM SCHEMATIC (REAR VIEW)
ELECTRIC ACTUATION

TFP1320
Page 4 of 14
Technical
Data
Approvals
UL and C-UL Listed
FM Approved.
Valve Trim
The Vertical Electric Actuation Trim
(Fig. 3A/3B) and Horizontal Electric
Actuation Trim (Fig. 5) form a part of
the laboratory listings and approvals
for the DV-5 Valve and are necessary
for its proper operation.
Each package of trim includes the fol-
lowing items:
• Water Supply Pressure Gauge
• Diaphragm Chamber
Pressure Gauge
• Diaphragm Chamber Connections
• Manual Control Station
• Main Drain Valve
• System Drain Valve
• Alarm Test Valve
• Automatic Drain Valve
The following items are included in the
Pre-trimmed Valve Assembly and can
be ordered separately for the valve
trim:
• Model BFV-N Buttery Valve
• Waterow Pressure Alarm Switch
(PS10-2)
• Figure 577 Grooved Coupling
To ease eld assembly of the trim ar-
rangement, the vertical trim compo-
nents are provided partially assembled
as shown in Figure 3B.
The trim arrangement is provided with
galvanized, black, or brass nipples and
ttings. The galvanized and brass trim
are intended for non-corrosive or cor-
rosive conditions, whereas the black
trim is principally intended for use with
AFFF systems.
NOTE: When the system pressure is
greater than 175 psi (12,1 bar), provision
is to be made to replace the standard
order 300 psi (20,7 bar) Water Pressure
Gauges, shown in Figure 3A/3B and 5
with separately ordered 600 psi (41,4
bar) Water Pressure Gauges.
The Electric Actuation Trim is required
for electric operation of the DV-5 Valve
by a detection system consisting of
electrical devices such as heat sen-
sitive thermostats, smoke detectors,
and/or electric manual pull stations.
Information on the various types of
separately ordered Solenoid Valves
that may be used with this trim pack-
age is given in Technical Data Sheet
TFP2180. Nominal installation dimen-
sions for the Vertical Electric Actuation
Trim are shown in Figure 4.
NOTE: Approval by Factory Mutu-
al is contingent on the use of an FM
Approved 24VDC Solenoid Valve. FM
only approves solenoid valves for use
in non-hazardous locations.
Consult with the authority having ju-
risdiction regarding installation cri-
teria pertaining to electric actuation
circuitry.
The Electric Actuation Trim is provided
with a Model ASV-1 Automatic Shut-Off
Valve (Item 5 - Fig. 3A and 5); conse-
quently, the release circuit of the Re-
leasing Panel need only provide the
standard ten minutes of alarm condi-
tion intended to energize the Solenoid
Valve to open. After the ten minute du-
ration, at which point should the Sole-
noid Valve become de-energized and
close (especially while operating under
battery back-up), the Automatic Shut-
Off Valve will have already automatical-
ly closed, thereby preventing the DV-5
Diaphragm Chamber from becoming
re-pressurized, and preventing an in-
advertent closing of the DV-5 during a
re event.
Materials of
Construction
NOTES: The galvanized or brass nip-
ples and fittings for the Valve Trim
provide corrosion resistance and are
intended to extend the life of the instal-
lation of the DV-5 Valve when exposed
to internal and external corrosive con-
ditions. Although these selections are
intended to resist corrosion, it is rec-
ommended that the end user or oth-
er technical expert familiar with con-
ditions at the proposed installation be
consulted with respect to these selec-
tions for a given corrosive condition.
Systems using a seawater or brackish
water supply require special consid-
erations in order to extend the life of
the valve and trim. This type of system
ideally should be configured with a pri-
mary source of clean fresh water (e.g.,
a pressurized water tank) and that only
upon system operation is the second-
ary water supply (seawater or brack-
ish water) allowed to enter the system.
After the system operation, the sys-
tem should be thoroughly flushed with
clean fresh water. Following this rec-
ommendation will increase the service
life of the DV-5 Valve and Valve Trim.
Pressure Gauges. Bronze bourdon
tube with brass socket.
Gauge Test Valve. Bronze body per
ASTM B584.
Manual Control Station. Corrosion
resistant copper alloys and glass lled
PTFE seals. Thermoplastic enclosure.
Automatic Drain Valve. Brass body
per ASTM B584, Type 440 stainless
steel or brass per ASTM B134 Ball, and
galvanized steel inlet.
Automatic Shut-Off Valve. Brass
body, cover, and center seat per UNS
C36000, Type 316 stainless steel
spring, and Nylon fabric reinforced,
natural rubber diaphragm per ASTM
D2000.
Ball Valve. Corrosion resistant copper
alloys and glass lled PTFE seals.
Spring Loaded Check Valve. Brass
body and buna-n seal.
NOTES:
1. SEE FIGURE 3, PER VALVE SIZE
AS APPLICABLE, FOR TRIM
ARRANGEMENT WITH BILL OF
MATERIALS AND COMPONENT
PART NUMBERS.
TRIM SHOWN FULLY ASSEMBLED;
COMPONENTS SUCH AS GAUGES
AND SWITCHES MAY REQUIRE
ASSEMBLY IN TRIM AT VALVE
INSTALLATION.
2.
DV-5
DELUGE
VALVE
WATERFLOW
PRESSURE
ALARM
SWITCH
SYSTEM
SHUT-OFF
VALVE
DELUGE
ELECTRIC
ACTUATION
TRIM
GROOVED
COUPLING
FIGURE 2
DV-5 PRE-TRIMMED DELUGE VALVE
ELECTRIC ACTUATION

TFP1320
Page 5 of 14
Y-Strainer. Bronze body per ASTM
B584 and Type 304 stainless steel
screen.
Swing Check Valve. Bronze body per
ASTM B584 and buna-n seal.
Angle Valve. Bronze body per ASTM
B584 and nitrile disc (TEFLON disc for
2 inch size valve).
3/32” Vent Fitting. Brass per ASTM
B16.
Tubing Connector. Brass per ASTM
B16.
Tubing. Type L copper per ASTM B88.
Pipe Fittings. Galvanized mallea-
ble iron per ANSI B16.3 or cast iron
per ANSI B16.4; black malleable iron
per ANSI B16.3 or cast iron per ANSI
B16.4; or, bronze per ANSI B16.15.
Pipe Nipples. Schedule 40 galvanized
steel per ASTM A53 or A135; Sched-
ule 40 black steel per ASTM A53 or
A135; or, Schedule 40 red brass pipe
per ASTM B43.
1-1/2" (DN40)
1/2" x 1-1/2"
Number
38
Nipple
1/2" x 5"40
3/4" x 1-1/2"45
2" (DN50)
1/2" x 2"
1/2" x 5-1/2"
3/4" x 2-1/2"
per DV-5 Deluge Valve Size
Select Appropriate Nipple Sizes
1/2" x 2"39 1/2" x 1-1/2"
1
1
1
1
1
1
1
1
1
1
2
2
1 2
1
1
1
3
10
1
QTY.
2
4
1
8
1
3
1
5
2
8
1
QTY. QTY.
1
3
2
1
2
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
. . . . . . . . . . . . . . . . .
. . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
2
3
4
18
13
14
16
17
9
8
11
7
10 31
22
20
33
34
28
29
NO.
1
19
6
35
36
38
41
43
27
26
23
25
12
NO. NO.
5
21
40
30
32
37
39
44
15
24 45
E1
E3
E4
E2
42
A2
A3
A1
46-005-1-0021/4" Gauge Test Valve
Model MC-1 Manual Control Station 52-289-2-001
Model AD-1 Automatic Drain Valve 52-793-2-004
1/2" Tubing Connector CH
92-211-1-003
92-343-1-007
Drip Funnel Bracket
Drip Funnel
92-032-1-0023/32" Vent Fitting
1/4" x 18" Tubing CH
52-353-1-0051/2" Y-Strainer
92-322-1-0021/2" Spring Loaded Check Valve
46-048-1-0053/4" Angle Valve
46-050-1-0041/2" Ball Valve
46-049-1-0053/4" Swing Check Valve 1/4" x Close Nipple CH
3/4" Plug CH
1/4" Plug CH
1/2" x 12" Tubing CH
1/2" x Close Nipple CH
1/2" x 1-1/2" Nipple CH
3/4" x 1/2" x 3/4" Tee
3/4" x 3/4" x 1/2" Tee CH
DESCRIPTION P/N
92-343-1-005300 psi/ 2000 kPa Water Pressure Gauge
Item No. Not Used
1/2" x 2-1/2" Nipple
3/4" x 1-1/2" Nipple
CH
1/2" x 7" Nipple CH
CH
3/4" x 2" Nipple CH
1/2" Tee CH
1/4" 90° Elbow CH
1/2" Union CH
3/4" Union CH
1/2" 90° Elbow CH
92-211-1-005
Drip Funnel Connector
DESCRIPTION P/N DESCRIPTION P/N
92-343-1-021Model ASV-1 Automatic Shut-Off Valve
1/2" x 1/4" x 1/2" Tee CH
CH
3/4" 90° Elbow CH
3/4" Tee CH
3/4" x Close Nipple CH
3/4" x 4" Nipple CH
Select Nipple per Table CH
Select Nipple per Table CH
Select Nipple per Table CH
1/2" x 2" Nipple CH
1/2" x 5" Nipple CH
Refer to
Data Sheet
Solenoid Valve Ordered Separately
Per Data Sheet TFP2180
1/2" Tubing Connector CH
1/2" x 1-1/2" Nipple CH
1/2" x 24" Tubing CH
Select Nipple per Table CH
COMPONENTS INCLUDED ONLY IN
PRE-TRIMMED VALVE ASSEMBLIES:
Buttery Valve, Power Ball 300:
51024A1-1/2" (DN40)
Figure 577 Coupling:
57715ACP1-1/2" (DN40)
Waterow Pressure Alarm Switch,
Model PS10-2 25710
51021A2" (DN50)
57720ACP2" (DN50)
(GREEN
TINT)
FOR OPTIONAL
ELECTRICALLY
CONTROL
VALVE
LOCATION
N.O. ALARM
SUPERVISED
SEPARATELY)
(ORDERED
2" (DN50)
DV-5 DELUGE VALVE
SHOWN
GROOVE x GROOVE
All Fittings and Nipples are
galvanized (Standard Order).
CH: Common Hardware.
See Figure 2 of TFP1305 for
Valve Port identication.
Route all Tubing to Drip Funnel,
Item 14.
2.
3.
4.
5.
Electric Actuation Trim is
comprised of Items 1-45
1.
NOTES:
A1-A3 included only in
pre-trimmed valve assemblies
as applicable; otherwise
ordered separately.
plus Items E2-E4. Item E1
ordered separately. Items
27
29
20
29
1
23
19
38
7
31
27
39
36
15
33
33
21
33
37
27
1
33
3
24
32
18
17
32
26
33
24
40
24
24
21
12
26
32
31
35
43
33
21
24
221
36
42
16
34
30
41
42
14
13
42
10 26
24
28
42
42
22
35
22
45
11
25
35
33
24
4
35
42
42
28
11 44
42
5
A2
A3
7
33
21
33
24
8
9
33
A1
E2
E3
E1
E4
FIGURE 3A (1 OF 3)
1-1/2 AND 2 INCH (DN40 AND DN50) DV-5 DELUGE VALVES
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM

TFP1320
Page 6 of 14
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
2
1
1
1
2
13
1
QTY.
2
1
1
2
2
5
1
1
1
3
1
5
2
8
1
QTY. QTY.
1 1
3
2
1
1
1
1
3
1
1
1
1
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . .
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
E1
E3
E4
E2
2
3
4
18
14
15
16
17
9
8
11
7
10
12
31
22
20
33
34
28
29
NO.
1 19
6
35
36
38
41
42
44
45
47
48
27
26
24
23
25
46
13
NO. NO.
5
21
40
30
32
37
39
43
A2
A3
A1
Refer to
Data Sheet
Solenoid Valve Ordered Separately
Per Data Sheet TFP2180
1/2" Tubing Connector CH
1/2" x 1-1/2" Nipple CH
1/2" x 24" Tubing CH
46-005-1-0021/4" Gauge Test Valve
Model MC-1 Manual Control Station 52-289-2-001
Model AD-1 Automatic Drain Valve 52-793-2-004
1/2" Tubing Connector CH
92-211-1-003
92-343-1-007
Drip Funnel Bracket
Drip Funnel
92-032-1-0023/32" Vent Fitting
1/4" x 18" Tubing CH
52-353-1-0051/2" Y-Strainer
92-322-1-0021/2" Spring Loaded Check Valve
46-048-1-0053/4" Angle Valve
46-050-1-0041/2" Ball Valve
46-049-1-0053/4" Swing Check Valve
46-048-1-0071-1/4" Angle Valve
1-1/4" x 3/4" x 1-1/4" Tee CH
1/4" x Close Nipple CH
3/4" Plug CH
1/4" Plug CH
1/2" x 12" Tubing CH
1/2" x Close Nipple CH
1/2" x 1-1/2" Nipple CH
3/4" x 1/2" x 3/4" Tee
3/4" x 3/4" x 1/2" Tee CH
DESCRIPTION P/N
92-343-1-005300 psi/ 2000 kPa Water Pressure Gauge
Item No. Not Used
1/2" x 2-1/2" Nipple
1/2" x 4" Nipple CH
1/2" x 5" Nipple CH
3/4" x 1-1/2" Nipple
CH
1/2" x 7" Nipple CH
CH
3/4" x 2" Nipple CH
1-1/4" x 2" Nipple CH
CH
1/2" Tee CH
1/4" 90° Elbow CH
1/2" Union CH
3/4" Union CH
1/2" 90° Elbow CH
92-211-1-005
Drip Funnel Connector
DESCRIPTION P/N DESCRIPTION P/N
92-343-1-021Model ASV-1 Automatic Shut-Off Valve
1/2" x 1/4" x 1/2" Tee
1/2" x 5-1/2" Nipple CH
CH
CH
3/4" 90° Elbow CH
3/4" Tee CH
1/2" x 3-1/2" Nipple CH
1/2" x 4-1/2" Nipple CH
3/4" x Close Nipple CH
3/4" x 4-1/2" Nipple CH
1-1/4" x 4" Nipple
COMPONENTS INCLUDED ONLY IN
PRE-TRIMMED VALVE ASSEMBLIES:
Model BFV-N Buttery Valve, 3" (DN80) 59300F030N
Figure 577 Coupling, 3" (DN80) 57730ACP
Waterow Pressure Alarm Switch,
Model PS10-2 25710
(GREEN
TINT)
FOR OPTIONAL
ELECTRICALLY
CONTROL
VALVE
LOCATION
N.O. ALARM
SUPERVISED
SEPARATELY)
(ORDERED
3" (DN80)
DV-5 DELUGE VALVE
SHOWN
GROOVE x GROOVE
All Fittings and Nipples are
galvanized (Standard Order).
CH: Common Hardware.
See Figure 2 of TFP1305 for
Valve Port identication.
Route all Tubing to Drip Funnel,
Item 15.
2.
3.
4.
5.
Electric Actuation Trim is
comprised of Items 1-48
1.
NOTES:
A1-A3 included only in
pre-trimmed valve assemblies
as applicable; otherwise
ordered separately.
plus Items E2-E4. Item E1
ordered separately. Items
28
30
21
30
47
32
48
1
24
20
35
7
33
28
35
39
16
35
22
35
42
28
1
35
3
25
34
19
18
34
27
35
25
42
25
25
22
13
27
35
33
12
36
45 35
22
25
222
41
44
17
37
31
43
44
15
14
44
10
27
25
29
44
44
23
36
23
46
11
43
26
38
35
25
4
40
43
5
A2
A3
7
35
22
35
25
8
9
35
A1
35
E2
E3
E1
E4
FIGURE 3A (2 OF 3)
3 INCH (DN80) DV-5 DELUGE VALVE
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM

TFP1320
Page 7 of 14
(DN100)
1/4" x 24"
No.
17
Tube
(DN150)
1/4" x 24"
per DV-5 Deluge Valve Size
Select Appropriate Tube Size
4" 6"
(DN200)
1/4" x 32"
8"
(DN100)
1/2" x 2-1/2"
No.
41
Nipple
1/2" x 2"42
1/2" x 6-1/2"43
3/4" x 2-1/2"46
(DN150)
1/2" x 5-1/2"
1/2" x 3"
1/2" x 7-1/2"
3/4" x 3-1/2"
per DV-5 Deluge Valve Size
Select Appropriate Nipple Sizes
1" x 6"49 1" x 9"
4" 6"
(DN200)
1/2" x 8-1/2"
1/2" x 3-1/2"
1/2" x 9"
3/4" x 4-1/2"
1" x 12"
8"
1/2" x 3"37 1/2" x 3" 1/2" x 5"
1/2" x 7"52 1/2" x 7" 1/2" x 9"
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
2
1
1
1
2
10
1
QTY.
2
1
2
1
3
2
1
1
5
1
3
1
5
2
8
1
QTY.
QTY.
1
1
1
1
1
3
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
. . . . . . . . . . . . . . . . .
. . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .. .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
2
3
4
18
14
15
16
17
9
8
11
7
10
12
31
22
20
33
34
28
29
NO.
1
19
6 35
36
37
39
40
43
44
45
47
48
49
27
26
24
23
25
46
13
NO.
NO.
5
21
38
41
30
42
32
A2
A3
A1
50
51
E1
E3
E4
E2
52
46-005-1-0021/4" Gauge Test Valve
Model MC-1 Manual Control Station 52-289-2-001
Model AD-1 Automatic Drain Valve 52-793-2-004
1/2" Tubing Connector CH
92-211-1-003
92-343-1-007
Drip Funnel Bracket
Drip Funnel
92-032-1-0023/32" Vent Fitting
Select Tubing per Table CH
52-353-1-0051/2" Y-Strainer
92-322-1-0021/2" Spring Loaded Check Valve
46-048-1-0061" Angle Valve
46-050-1-0041/2" Ball Valve
46-049-1-0053/4" Swing Check Valve
46-048-1-0092" Angle Valve
2" x 1" x 2" Tee CH
1/4" x Close Nipple CH
3/4" Plug CH
1/4" Plug CH
1/2" x 24" Tubing CH
1/2" x Close Nipple CH
1/2" x 1-1/2" Nipple CH
3/4" x 1/2" x 3/4" Tee
1" x 1" x 1/2" Tee CH
1" x 3/4" x 1" Tee
DESCRIPTION P/N
92-343-1-005300 psi/ 2000 kPa Water Pressure Gauge
Item No. Not Used
1/2" x 2-1/2" Nipple
CH
1/2" x 5" Nipple CH
Select Nipple per Table CH
3/4" x 1-1/2" Nipple
CH
1/2" x 7" Nipple CH
CH
3/4" x 2" Nipple CH
1" x Close Nipple CH
1" x 3" Nipple CH
1/2" Tee CH
1/4" 90° Elbow CH
1/2" Union CH
1" Union CH
1/2" 90° Elbow CH
92-211-1-005
Drip Funnel Connector
DESCRIPTION P/N
DESCRIPTION P/N
92-343-1-021Model ASV-1 Automatic Shut-Off Valve
1/2" x 1/4" x 1/2" Tee
1/2" x 6" Nipple CH
Select Nipple per Table CH
Select Nipple per Table CH
Select Nipple per Table CH
CH
CH
CH
1" 90° Elbow CH
Select Nipple per Table CH
COMPONENTS INCLUDED ONLY IN
PRE-TRIMMED VALVE ASSEMBLIES:
Model BFV-N Buttery Valve:
59300F040N4" (DN100)
Figure 577 Coupling:
57740ACP4" (DN100)
Waterow Pressure Alarm Switch,
Model PS10-2 25710
59300F060N6" (DN150)
59300F080N8" (DN200)
57760ACP6" (DN150)
57780ACP8" (DN200)
2" x 3" Nipple CH
2" x 5" Nipple CH
Refer to
Data Sheet
Solenoid Valve Ordered Separately
Per Data Sheet TFP2180
1/2" Tubing Connector CH
1/2" x 1-1/2" Nipple CH
1/2" x 24" Tubing CH
Select Nipple per Table
Select Nipple per Table CH
(GREEN
TINT)
FOR OPTIONAL
ELECTRICALLY
CONTROL
VALVE
LOCATION
N.O. ALARM
SUPERVISED
SEPARATELY)
(ORDERED
4" (DN100)
DV-5 DELUGE VALVE
SHOWN
GROOVE x GROOVE
All Fittings and Nipples are
galvanized (Standard Order).
CH: Common Hardware.
See Figure 2 of TFP1305 for
Valve Port identication.
Route all Tubing to Drip Funnel,
Item 15.
2.
3.
4.
5.
Electric Actuation Trim
is comprised of Items 1-52
1.
NOTES:
A1-A3 included only in
pre-trimmed valve assemblies
as applicable; otherwise
ordered separately.
plus Items E2-E4. Item E1
ordered separately. Items
28
29
21
46
10
29
50
32
51
1
24
20
41
40
7
33
28
47
35
38
16
35
35
22
35
52
28
1
35
3
25
34
19
18
25
5
34
27
35
25
43
25
25
22
13
27
42
33
12
36
45
31
35
22
25
222
39
47
44 23
17
38
30
47
47
48
23
47
26
36
37
25
4
27
36
15
14
49
11
A2
A3
7
35
22
35
25
8
9
35
A1
E2
E3
E1
E4
FIGURE 3A (3 OF 3)
4, 6, AND 8 INCH (DN100, DN150 AND DN200) DV-5 DELUGE VALVES
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM

TFP1320
Page 8 of 14
1-1/2" (DN40)
1/2" x Close
Number
1
Nipple
1/2" x Close2
1/2" x 5"3
3/4" x 1-1/2"4
2" (DN50)
1/2" x 2"
1/2" x Close
1/2" x 5-1/2"
3/4" x 1-1/2"
Select Appropriate Nipple and Tube Sizes per DV-5 Deluge Valve Size
3/4" x 1-1/2"5 3/4" x 2-1/2"
4" (DN100)
1/2" x 2-1/2"
1/2" x 2"
1/2" x 6-1/2"
3/4" x 2-1/2"
6" (DN150)
1/2" x 5-1/2"
1/2" x 3"
1/2" x 7-1/2"
3/4" x 3-1/2"
1" x 6" 1" x 9"
3" (DN80)
1/2" x 1-1/2"
1/2" x 1-1/2"
1/2" x 7"
3/4" x 1-1/2"
3/4" x 4-1/2"
Size
Main Drain 3/4" NPT 3/4" NPT 2" NPT 2" NPT1-1/4" NPT
8" (DN200)
1/2" x 8-1/2"
1/2" x 3-1/2"
1/2" x 9"
3/4" x 4-1/2"
1" x 12"
2" NPT
1/4" x 18"Tube 1 1/4" x 18" 1/4" x 24" 1/4" x 24"1/4" x 18" 1/4" x 32"
1/2" x 1-1/2"6 1/2" x 1-1/2" 1/2" x 3" 1/2" x 3"1/2" x 1-1/2" 1/2" x 5"
1/2" x 7"7 1/2" x 7" 1/2" x 7" 1/2" x 7"1/2" x 7" 1/2" x 9"
FOR OPTIONAL
ELECTRICALLY
CONTROL
VALVE
LOCATION
N.O. ALARM
SUPERVISED
NOTES:
When DV-5 trips, Automatic Shut-Off Valve
shuts off diaphragm chamber supply.
Install subassemblies in alphabetical order.1.
2.
Route all Tubing to Drip Funnel.3.
See Figure 2 of TFP1305 for Valve Port
4.
identication.
5. Nipples 1-7 and Tube 1 vary in length relative
to DV-5 size. Select per table. All other nipples
and tubing packed unassembled shall be
installed per appropriate trim exploded view,
Figure 3A Part 1, 2, or 3.
B
A
C
D
AUTOMATIC
DRAIN VALVE
CLOSED)
(NORMALLY
DRAIN VALVE
SYSTEM
1-1/4 INCH NPT
CONNECTION
TO DRAIN
FUNNEL
DRIP
TEST VALVE
ALARM
(NORMALLY
CLOSED)
PRESSURE
GAUGE
SUPPLY
WATER
SYSTEM
CONTROL
STATION
MANUAL
CONNECTION FROM
WATER SUPPLY
CONTROL VALVE
CHAMBER SUPPLY
1/2 INCH NPT
(NORMALLY
AUTOMATIC
SHUT-OFF VALVE
MAIN DRAIN
CONNECTION
(SIZED PER
OPEN)
(NORMALLY
OPEN)
DIAPHRAGM
CLOSED)
(NORMALLY
DRAIN VALVE
MAIN
2
NIPPLE
3
NIPPLE
5
NIPPLE
TABLE)
PRESSURE
GAUGE
DIAPHRAGM
CHAMBER
1/2 INCH CONDUIT
"ELECTRIC DETECTION"
CONNECTION FOR
(NORMALLY CLOSED)
SOLENOID VALVE,
ORDERED SEPARATELY
4" (DN100)
DV-5 DELUGE
VALVE SHOWN
FLANGE x FLANGE
7
NIPPLE
PRESSURE ALARM
SWITCH, ORDERED
SEPARATELY
WATERFLOW
ALARM
WATER MOTOR
CONNECTION FOR
3/4 INCH NPT
VENT FITTING
(GREEN TINT)
1
NIPPLE
4
NIPPLE
TUBE 1
6
NIPPLE
FIGURE 3B
1-1/2 THRU 8 INCH (DN40 THRU DN200) DV-5 DELUGE VALVES
OPERATIONAL COMPONENTS OF VERTICAL ELECTRIC ACTUATION TRIM
EXPLODED ARRANGEMENT OF SEMI-PREASSEMBLED TRIM

TFP1320
Page 9 of 14
(116,0)
4.56
(98,0)
3.85
(134,0)
5.26
(149,0)
5.86
A
Nominal Installation Dimensions in Inches and (mm)
(254,0)
10.00
(289,0)
11.38
B
(298,5)
11.75
(363,5)
14.31
C
(363,5)
14.31
(388,9)
15.31
D
(266,7)
10.50
E
(562,0)
22.13
(592,1)
23.31
G
(217,5)
8.56
(252,4)
9.94
H
(112,7)
4.44
(147,6)
5.81
J
(158,8)
6.25
K
(181,0)
7.13
L
(15,9)
0.63
(46,0)
1.81
M
(400,0)
15.75
(460,4)
18.13
Size
Valve
DN100
4"
DN150
6"
F
(44,5)
1.75
(88,9)
3.50
(266,7)
10.50
(158,8)
6.25
(181,0)
7.13
(198,4)
7.81
(265,1)
10.44
(266,7)
10.50
(485,8)
19.13
(170,0)
6.69
(68,3)
2.69
(108,0)
4.25
(22,2)
0.88
(324,0)
12.75
DN80
3"
(231,8)
9.13
(266,7)
10.50
(395,3)
15.56
(152,4)
6.00
(50,8)
2.00
(220,0)
8.63
DN50
2"
(23,8)
0.94
(177,8)
7.00
(225,4)
8.88
(335,0)
13.19
(266,7)
10.50
(387,4)
15.25
(147,6)
5.81
(46,0)
1.81
(76,2)
3.00
(98,4)
3.88
(204,0)
8.00
DN40
1-1/2"
(31,8)
1.25
(177,8)
7.00
(181,0)
7.13
(335,0)
13.19
(76,2)
3.00
(177,8)
7.00
(76,2)
3.00
(335,0)
13.19
(41,3)
1.63
(177,8)
7.00
(304,8)
12.00
(406,4)
16.00
(412,8)
16.25
(647,7)
25.50
(273,1)
10.75
(165,1)
6.50
(187,3)
7.38
(570,0)
22.50
DN200
8"
(44,5)
1.75
(266,7)
10.50
(158,8)
6.25
(181,0)
7.13
N
(103,9)
4.09
(102,1)
4.02
* * *
*
*
LEFT VIEW FRONT VIEW
DCA
E
L
H K
B
F
MINIMUM CLEARANCE
M
GJ
N
FIGURE 4
1-1/2 THRU 8 INCH (DN40 THRU DN200) DV-5 DELUGE VALVES
VERTICAL ELECTRIC ACTUATION / NOMINAL INSTALLATION DIMENSIONS

TFP1320
Page 10 of 14
Installation
General Instructions
Proper operation of the DV-5 Deluge
Valves depends upon their trim being
installed in accordance with the in-
structions given in this Technical Data
Sheet. Failure to follow the appropri-
ate trim diagram may prevent the DV-5
Valve from functioning properly, as well
as void listings, approvals, and the
manufacturer’s warranties.
The DV-5 Valve must be installed in a
readily visible and accessible location.
The DV-5 Valve, associated trim, and
wet pilot lines must be maintained at
a minimum temperature of 40°F (4°C).
Heat tracing of the DV-5 Valve or its
associated trim is not permitted. Heat
tracing can result in the formation of
hardened mineral deposits that are ca-
pable of preventing proper operation.
The DV-5 Deluge Valve is to be in-
stalled in accordance with the follow-
ing criteria:
Step 1. All nipples, ttings, and de-
vices must be clean and free of scale
and burrs before installation. Use pipe
thread sealant sparingly on male pipe
threads only.
Step 2. The DV-5 Valve must be
trimmed in accordance with Figure
3A/3B or 5.
Step 3. Care must be taken to ensure
that check valves, strainers, globe
valves, etc. are installed with the ow
arrows in the proper direction.
Step 4. Drain tubing to the Drip Funnel
must be installed with smooth bends
that will not restrict ow.
Step 5. The main drain and Drip Funnel
drain may be interconnected provided
a check valve is located at least 12
inches (300 mm) below the Drip Funnel.
Step 6. Suitable provision must be
made for disposal of drain water. Drain-
age water must be directed such that
it will not cause accidental damage to
property or danger to persons.
Step 7. Connect the Diaphragm Cham -
ber Supply Control Valve to the inlet
side of the system’s Main Control Valve
in order to facilitate setting of the DV-5
Valve (Ref. Figure 4).
Step 8. Unused pressure alarm switch
connections must be plugged.
1-1/2" (DN40)
1/2" x 1-1/2"
Number
38
Nipple
1/2" x 5"40
3/4" x 1-1/2"45
2" (DN50)
1/2" x 2"
1/2" x 5-1/2"
3/4" x 2-1/2"
per DV-5 Deluge Valve Size
Select Appropriate Nipple Sizes
1/2" x 2"39 1/2" x 1-1/2"
1
1
1
1
1
1
1
1
1
1
2
2
1
2
1
1
1
3
10
1
QTY.
2
4
1
8
1
3
1
5
2
8
1
QTY. QTY.
1
3
2
1
2
1
1
1
1
1
1
2
1
1
1
1
1
1
. . . . . . . . . . . . . . . . .
. . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
2
3
4
18
13
14
16
17
9
8
11
7
10
31
22
20
33
34
28
29
NO.
1 19
6
35
36
38
41
43
27
26
23
25
12
NO. NO.
5
21
40
30
32
37
39
44
15 24
45
E1
E3
E4
E2
42
A1
46-005-1-0021/4" Gauge Test Valve
Model MC-1 Manual Control Station 52-289-2-001
Model AD-1 Automatic Drain Valve 52-793-2-004
1/2" Tubing Connector CH
92-211-1-003
92-343-1-007
Drip Funnel Bracket
Drip Funnel
92-032-1-0023/32" Vent Fitting
1/4" x 18" Tubing CH
52-353-1-0051/2" Y-Strainer
92-322-1-0021/2" Spring Loaded Check Valve
46-048-1-0053/4" Angle Valve
46-050-1-0041/2" Ball Valve
46-049-1-0053/4" Swing Check Valve
1/4" x Close Nipple CH
3/4" Plug CH
1/4" Plug CH
1/2" x 12" Tubing CH
1/2" x Close Nipple CH
1/2" x 1-1/2" Nipple CH
3/4" x 1/2" x 3/4" Tee
3/4" x 3/4" x 1/2" Tee CH
DESCRIPTION P/N
92-343-1-005300 psi/ 2000 kPa Water Pressure Gauge
Item No. Not Used
1/2" x 2-1/2" Nipple
3/4" x 1-1/2" Nipple
CH
1/2" x 7" Nipple CH
CH
3/4" x 2" Nipple CH
1/2" Tee CH
1/4" 90° Elbow CH
1/2" Union CH
3/4" Union CH
1/2" 90° Elbow CH
92-211-1-005
Drip Funnel Connector
DESCRIPTION P/N DESCRIPTION P/N
92-343-1-021Model ASV-1 Automatic Shut-Off Valve
1/2" x 1/4" x 1/2" Tee CH
CH
3/4" 90° Elbow CH
3/4" Tee CH
3/4" x Close Nipple CH
3/4" x 4" Nipple CH
Select Nipple per Table CH
Select Nipple per Table CH
Select Nipple per Table CH
1/2" x 2" Nipple CH
1/2" x 5" Nipple CH
Refer to
Data Sheet
Solenoid Valve Ordered Separately
Per Data Sheet TFP2180
1/2" Tubing Connector CH
1/2" x 1-1/2" Nipple CH
1/2" x 24" Tubing CH
Select Nipple per Table CH
COMPONENTS ORDERED SEPARATELY:
Waterow Pressure Alarm Switch,
Model PS10-2 25710
(GREEN
TINT)
SEPARATELY)
(ORDERED
FOR OPTIONAL
ELECTRICALLY
CONTROL
VALVE
LOCATION
N.O. ALARM
SUPERVISED
SEPARATELY)
(ORDERED
2" (DN50)
DV-5 DELUGE VALVE
SHOWN
GROOVE x GROOVE
All Fittings and Nipples are galvanized
(Standard Order).
CH: Common Hardware.
See Figure 2 of TFP1305 for Valve Port
identication.
Route all Tubing to Drip Funnel, Item 14.
2.
3.
4.
5.
Electric Actuation Trim is comprised of
Items 1-45 plus Items E2-E4. Items A1
1.
NOTES:
6. Horizontal Arrangement uses only 7 out of
8 of Item 24, and 9 out of 10 of Item 33.
Discard unused material.
and E1 ordered separately.
27
33
32
18
17
19
31
2
24
9
33
24
34
33
21
8
33
37
26
24
26
21
21
35
23
31
39
21
36
3
33
29
35
20
42
43 10
41
28
35
24
27
38
35
26
4
12
14
13
21
24
32
15
A1
33
29
42
22
42
42
30
16
33
11
44
27
42
25
45
22
42
28
11
33
1
42
36
24
42
1
33
740
32
24
5
7
E3
E4
E2
E1
FIGURE 5 (1 OF 3)
1-1/2 AND 2 INCH (DN40 AND DN50) DV-5 DELUGE VALVES
EXPLODED VIEW OF HORIZONTAL ELECTRIC ACTUATION TRIM