Zamel EXTA ASH-02 User manual

STAIRCASE LIGHTING TIMERY ASH-02 INSTRUCTION MANUAL
ZAMEL Sp. z o.o.
ul. Zielona 27, 43-200 Pszczyna, Poland
Tel. [phone], Fax [phone]
www.zamelcet.com, e-mail: [email protected]
VER. 004_23.03.2012
APPEARANCE
b
l
a
c
k
b
r
o
w
n
g
r
e
y
b
l
u
e
FEATURES
DESCRIPTION
ی Staircaselightingcontrol,
ی Continuous ON-time adjustment of
10 seconds to 14 minutes,
ی Applicable together with single pole
pushbuttons,illuminated,
ی Counter-interlockfunction,
ی Either three-conductor or four-con-
ductor wiring system possible,
ی 0.5mcableterminal,
ی HermeticIP65casing,
ی Relayvoltageoutput,16Aload.
The ASH-02 staircase timer is desi-
gned for corridor and staircase lighting
control.Aftercircuittriggerthetimerkeeps
the light ON for the preset time and then
switchesitOFF.IthasanadjustableON-
timesettingof10 secondsto14minutes.
On-time may be adjusted by means of a
potentiometer. The timer is fitted with a
counter-interlock circuit. The ASH-02
staircase timer may be applied as a time
relay unit for delayed switch-OFF. The ti-
mer is placed within a hermetic IP65 ca-
sing which assures safe operating under
hardweatherconditions.
Thedeviceisdesigned
for single-phase instal-
lation and must be in-
stalled in accordance
with standards valid in
aparticularcountry.The
device should be con-
nectedaccordingtothedetailsincluded
in this operating manual. Installation,
connectionandcontrol should be car-
riedoutbyaqualiedelectricianstaff,
who act in accordance with the servi-
ce manual and the device functions.
Disassembling of the device is equal
withalossofguaranteeandcancause
electricshock.Beforeinstallationmake
suretheconnectioncablesarenotun-
dervoltage.Thecruciformheadscrew-
driver3,5mmshouldbeusedtoinstal
the device. Improper transport, stora-
ge,anduseofthedeviceinuenceits
wrongfunctioning.Itisnotadvisableto
instalthedeviceinthefollowingcases:
ifanydevicepartismissingorthede-
viceisdamagedordeformed.Incase
of improper functioning of the device
contacttheproducer.
CAUTION
TECHNICAL PARAMETERS
ASH-02
Power supply cables: L (black), N (blue)
Inputratedvoltage: 230 V~
Inputvoltagetolerance: from-15to+10%
Nominalfrequency: 50 / 60 Hz
Rated power consumption: 33 mA
Release cable:
grey
Output cable: brown
Timeadjustmentrange: from10secto14min
Timeaccuracyadjustment: ±10%
Timerepeatabilityadjustment: ±5%
Timeadjustment: continuous (rotational potentiometer)
Output relay parameters:
1NO-16A/250VAC14000VA(voltagecontact)
Numberofswitchcables: 4
Sectionofconnectingcables: 4x 1,50 mm2
Connectingcablelength: 0,5 m
Ambient temperature range: from-20to+45oC
Operating position: vertical,pointeddown
Mounting: 2xstretcher5x(3x30)
Protection degree: IP65 (PN-EN 60529)
Protectiveclass: II
Overvoltagecategory: II
Pollution degree: 2
Dimensions: 69 x 56 x 27 mm
Weight: 0,120 kg
Referencestandards: PN-EN 60669-1
PN-EN 60669-2-1
PN-EN 61000-4-2,3,4,5,6,11
Timeadjustment
Power supply cable (L)
Power supply cable (N)
Output cable
Release cable

VER. 004_23.03.2012
CONNECTINGMOUNTING
FUNCTIONING
EXAMPLE OF INSTALLATION
Thetimerisreadytowork justright
afteritsappropriateconnecting.Thelight
will be ON for the preset ON-time after
thetimeristriggeredbymeansofasingle
polepushbutton.When thepresettime
isover,thelightwillbeOFFautomatical-
lyuntilthetimeristriggeredonceagain.
The staircase timer may be connected
toeitherthreeconductororfour-conduc-
tor wiring. Check carefully if the trigger
and load circuits have been connected
correctly. The timer may be damaged if
connectedinappropriately.Incaseofthe
triggerpushbuttonblockingthecounter-
interlockcircuitswitchesOFFthelight.
1.Disconnect the power supply from the
mainsbythephasefuse,thecircuitbre-
akerortheswitch-disconnectorthatare
joinedtothepropercircuit.
2.Checkifthereisnovoltageoncon-
nectioncablesbymeansofaspecial
measureequipment.
3.FastentheASH-02tothebasewiththe
screw.
NOTICE!Itisforbiddentoboretting
holesinthecover!Itmayresultinthe
lossofcontainmentofthecover and
bythis–thelossofguarantee!
4.Connect the cables ASH-02 with the
hermeticinstallationjunctionboxaccor-
ding to installing diagram.
5.Switch on the power supply from the
mains.
6.Takeouttherubberholeplugcovering
the adjustment of the switch on thre-
sholdpotentiometer.
7.Adjustthedemandedswitchontimeby
meansofapotentiometer.
8.Putbacktherubberholeplugcovering
thepotentiometer.
DIMENSIONS
INNER DIAGRAM
TIME COURSE PRODUCT FAMILY
Thestaircasetimercontrolsthestaircaselightingandoperatesinfour-conductor
wiringconguration.Itispossibletoconnectthesinglepolepushbuttons(e.g.illumi-
nated) in parallel.
RELAY CAPACITY
TheASH-02isamemberoftheASx
staircasetimerfamily.
t
t t t
t
black blue
grey
brown
3 wire system 4 wire system
b
r
o
w
n
b
l
a
c
k
b
l
u
e
g
r
e
y
b
r
o
w
n
b
r
o
w
n
b
l
a
c
k
b
l
a
c
k
b
l
u
e
b
l
u
e
g
r
e
y
g
r
e
y
Device version
Casingversion:
M - modular
N- surface
H- hermetic
P- ushjunctionboxØ60mm
Deviceversion:
01 - 3- or 4-wire installation
02- anti-blockingfunction
03- anti-blockingfunctionandON/
AUTO/OFFmodeswitch
10- uentlightingbrighteningand
dimming
Voltageversion:
24V - 24 V AC/DC available for
ASM-02
U - 12÷240 V AC/DC available for
ASH-01, ASM-01, ASN-01