DEFA SmartCharge 4A User manual

10A
8A
6A
SmartCharge
Technical Manual
4A

2
This appliance can be used by children aged from
8 years and above and persons with reduced
physical, sensory or mental capabilities or lack
of experience and knowledge if they have been
given supervision or instruction concerning use of
the appliance in a safe way and understand the
hazards involved.
Dette apparatet kan brukes av barn fra 8 år og
oppover og personer med reduserte fysiske,
sensoriske eller mentale evner eller manglende
erfaring og kunnskap om de ikke er gitt innføring
eller instruksjon om bruken av apparatet på en
sikker måte og forstår farene involvert.
Denna apparat kan användas av barn från 8
år och uppåt och personer med nedsatt fysisk
eller mental förmåga eller brist på erfarenhet
och kunskap om de inte övervakas eller får
instruktioner angående användning av apparaten
på ett säkert sätt och förstår riskerna inblandade.
Dette apparat kan bruges af børn i alderen fra 8
år og derover og personer med nedsatte fysiske,
sensoriske eller mentale evner eller manglende
erfaring og viden, hvis de har fået den nødvendige
instruktion i brug af apparatet på en sikker måde
og forstår farerne involveret.

3
Tätä laitetta voidaan käyttää vuotiaille lapsille
8 vuotta tai enemmän ja henkilöt, joilla on
alentunut fyysinen tai henkinen toimintakyky
tai joilta puuttuu kokemusta ja tietoa, jos ne
on annettu ohjeet ja neuvot käyttää laitetta
turvallisesti ja ymmärtää vaarat mukana.
Этот прибор может быть использован для
детей в возрасте от 8 лет и старше и лиц с
ограниченными физическими, сенсорными
или умственными способностями или
нехваткой опыта и знаний, если они
находятся под контролем или инструкции
относительно использования прибора
безопасным способом и понимать опасности
участвует.
To urządzenie może być używane przez dzieci w
wieku od 8 lat i powyżej oraz osób o ograniczonej
zdolności fizycznej, czuciowej lub psychicznej
lub braku doświadczenia i wiedzy, jeżeli zostały
one nadzorowane lub zostaną poinstruowane
na temat korzystania z urządzenia w sposób
bezpieczny i rozumie zagrożenia zaangażowany.
Šis prietaisas gali būti naudojamas vaikams
nuo 8 metų vaikams ir aukščiau ir riboto
fizinių, sensorinių ar psichinių gebėjimų ar
patirties ir žinių trūkumo, jei jie buvo prižiūrimi
ar nurodymo, kaip naudoti prietaisą saugiai ir
suprasti pavojų dalyvauti.

4
Dieses Gerät kann von Kindern ab einem Alter
von 8 Jahren und Personen mit eingeschränkter
körperlicher, sensorischer oder geistiger
Leistungsfähigkeit oder fehlender Erfahrung
und Kenntnis verwendet werden, wenn ihnen
die Überwachung oder Anweisung über die
Verwendung des Geräts auf sichere Art und Weise
bekannt ist und die Gefahren verstanden werden
beteiligt.
See seade võib kasutada lastel vanuses 8
aastat ja vanemad ja isikud, kellel on vähenenud
füüsilised, sensoorsed või vaimsed võimed või
kogemuste puudumine ja teadmisi, kui nad
on antud järelevalve või juhendamise seadme
ohutult ja mõista ohud kaasatud.
Šī ierīce var izmantot bērni vecumā no 8 gadiem
un virs un personām ar ierobežotām fiziskām,
sensorām vai garīgām spējām vai trūkst pieredzes
un zināšanu, ja tie ir dota uzraudzību vai
apmācījusi izmantot ierīces drošā veidā un izprast
apdraudējumus iesaistīti.
Dit apparaat kan worden gebruikt door kinderen
van 8 jaar en ouder en personen met beperkte
lichamelijke, zintuiglijke of verstandelijke
vermogens of gebrek aan ervaring en kennis als
zij toezicht of instructie over het gebruik van het
apparaat is gegeven op een veilige manier en
begrijpen van de gevaren betrokken.

5
Cet appareil peut être utilisé par des enfants
âgés de 8 ans et plus et les personnes ayant
des capacités ou le manque d'expérience et
de connaissances physiques, sensorielles ou
mentales réduites si elles ont été supervisées ou
instructions concernant l'utilisation de l'appareil
d'une manière sûre et comprendre les dangers
impliqué.
Tento přístroj může být použit u dětí ve věku od
8 let a starší a osoby se sníženými fyzickými,
smyslovými nebo duševními schopnostmi, nebo
bez patřičných zkušeností a znalostí, pokud jim
nebyl poskytnut dohled nebo instrukce týkající se
použití spotřebiče bezpečným způsobem a rozumí
nebezpečí zapojit.
Tento prístroj môže byť použitý u detí vo veku od
8 rokov a staršie a osoby so zníženými fyzickými,
zmyslovými alebo duševnými schopnosťami alebo
bez potrebných skúseností a znalostí, pokiaľ
im nebol poskytnutý dohľad alebo inštrukcie
týkajúce sa použitia spotrebiča bezpečným
spôsobom a rozumejú nebezpečenstvo zapojiť.
Este aparelho pode ser utilizado por crianças
com idade igual ou superior a 8 anos. Também
pode ser usado por pessoas com capacidades
físicas, sensoriais ou mentais reduzidas ou ainda
com falta de experiência e conhecimento, desde
que tenham recebido supervisão ou instruções
sobre a utilização do aparelho de forma segura e
compreendam os perigos envolvidos.

6
DEFA AS - Support
Blingsmoveien 30
3540 Nesbyen
Norway
(: [phone]
7: [phone]
:: defa.automotiv[email protected]
www.defa.com
DEFA AS
Blingsmoveien 30
3540 Nesbyen
(: [phone]
7: [phone]
:: defa.automotiv[email protected]
www.defa.com
DEFA AB
Finlandsgatan 10 nb
164 74 Kista
(: [phone]
:: teknisksuppor[email protected]
www.defa.com

7
DEFA Danmark A/S
Vodskovvej 136
9310 Vodskov
(: [phone]
:: [email protected]
www.defa.com
DEFA OY
Tähtäinkuja 2
01530 Vantaa
([phone]
:[email protected]
www.defa.com
Dometic WAECO
International GmbH
Hollefeldstraße 63 · D-48282 Emsdetten
(: [phone]
7: [phone]
www.dometic-waeco.de

8
DEFA OY
Tähtäinkuja 2
01530 Vantaa, Finland
(: [phone]
::[email protected]
www.defa.com
DEFA OY
Tähtäinkuja 2
01530 Vantaa, Finland
(: [phone]
::[email protected]
www.defa.com
DEFA OY
Tähtäinkuja 2
01530 Vantaa, Finland
(: [phone]
::[email protected]
www.defa.com

9
FH Amervox Sp Zoo
ul. Warszawska 312
25-414 Kielce
www.amervox.com.pl
Pommard sp. z o.o. sp.k.
ul. Ogrodowa 27/29, Kiełpin
05-092 Łomianki
(: [phone]
::offi[email protected]
www.pommard.pl
Inter Cars S.A.
ul.Gdańska 15 Cząstków
Mazowiecki, 05-152 Czosnów
(: [phone]
::[phone]
ogrzew[email protected]
Dometic Benelux BV
Ecustraat 3
4879 NP
Etten-Leur
(: 0031 76 50 29 000
::0031 76 50 29 090

10
MOLPIR GROUP CZ a.s.
Technologická 838/14
779 00 Olomouc, Holice
Czech Republic
(: [phone]
www.molpir.cz
AUTONOMIA (LLC)
143085 Moskovskaya obl.,
Odintsovskiy rayon,
Zarechye rp, Torgovaya st.1
(: [phone]
:: [email protected]
www.autonomia.ru
Neptune Spb
2nd Kotlyakovskiy pereulok1/1
115201 Moscow
(: [phone]
:: [e-mail]

11
HOELZLE AG
Rosengartenstrasse 11
CH-8608 Bubikon
(: [phone]
7: [phone]
:: [email protected]
www.hoelzle.ch
MOLPIR s.r.o
Hrachova 30
821 05 Bratislava
Slovac Republic
(: [phone]
(: [phone]
BBRD Comercio a Serviços LTDA
Rua Sgto. Francisco Rodrigues da Rosa, 485
18105-008, Sorocaba-SP

12

English 14
Norsk 20
Svenska 26
Dansk 32
Suomi 38
Русский 44
Polski 52
Deutsch 58
Lietuviškai 64
Eesti 70
Latviešu 76
Dutch 82
Français 88
Čeština 94
Slovensky 100
Português 106
Italian 112
IT

14 English
Product warnings
1. This product is not intended for use
by children or people with reduced
physical, sensory or mental capabilities,
unless under the supervision of a
person responsible for their safety.
2. Children shall not play with the
appliance.
3. Children shall not clean or maintenance
the appliance without adult supervision,
the appliance shall be repaired by the
professionals.
4. The mains’ power supply cord cannot
be replaced. If the cord is damaged,
discontinue usage.
5. This charger is designed for use only
with LEAD/ACID type (both open and
closed) batteries including AGM, GEL
and Calcuim types; and for battery sizes
12V/8–225Ah.
The charger should not be used for
other battery types. Recharging the
non-rechargable batteries is forbidden!
6. Batteries can emit explosive gases during
normal charging. Avoid sparks in the
immediate area and always provide
proper ventilation during charging.
7. Connect the chargers plus clamp to the
plus terminal on the battery. Connect
the minus clamp to the chassis of the
vehicle away from petrol pipes. Connect
then to the wall socket.

15English
Charging phase details
Provide chargers for a variance of vehicles and
equipment such as motorbikes, snowmobiles,
lawnmowers and boats etc.
Battery Type
Lead acid battery (open and closed types),
AGM and Gel batteries included.
Pre Analysis
The charger checks if the battery is correctly
connected. The battery’s charge level (V) and
total capacity (Ah) is measured to determine the
correct settings for charging.
Battery
voltage
>12.65V
12.55V–12.65V
12.45V–12.55V
12.35V–12.45V
2.0V–12.35V
Battery
status
95–100%
80%
60%
40%
0-20%
LED
indication
All segments on
4 segments on
3 segments on
2 segments on
1 segment on
8. After charging, power-off the charger
and disconnect from the mains’ power
supply. The minus and plus terminals
can then be disconnected.
9. This charger includes high-strength
magnets and should not be placed in
close proximity to magnetic storage
devices such as computer hard drives
and tape media.

16 English
Charging
The charger starts charging the battery with
constant current up to 14.4V (at 25°C). The
charge voltage is then held constant at 14.4V and
the charging current is reduced until it is below
a dened level. The charge voltage then drops to
13.8V, before the long-term charging phase starts.
During charging, battery charge is shown by the
number of LEDs illuminated. The blinking segment
above these LEDs indicates active charging. Once
full battery charge is reached, all 5 LED segments
remain illuminated.
If the measured battery voltage is below 2.0V,
the charger will enter Error Mode.
Post Analysis
The charger analyses the battery again after the
charging phase. If the charger detects an error in
the battery, the warning triangle will ash. Post
analysis can detect batteries with a short circuit in
individual cells. This cannot be detected in the pre
analysis. If the battery voltage drops below 12.5V
within 2min, the charger will go into error mode.
The charging sequence will be stopped.
Long-term charging
After the battery is fully charged, the charger will go
in to Sleep Mode. This is indicated by all battery
LEDs slowly pulsating. This mode has a very low
power consumption.
After a week in Sleep Mode, the charger will
wake up and begin a new charging cycle.
The charger will also wake up and start a
charging cycle if battery voltage drops below 12.6V.

17English
Additional charger functionality
Temperature based voltage compensation
The charger automatically adjusts the charging
voltage to the correct level according to the
ambient temperature. The default ambient
temperature is 25°C. Voltage is reduced for
higher ambient temperatures and increased for
lower ambient temperatures. The correct amount
is ±0.03V/°C. Max temperature compensate
charging voltage is 15.3 V.
14.7V button
Some batteries require a higher charging voltage
than other batteries. If the 14.7V button is
activated the initial charging voltage will be 0.3V
higher than the standard level.
Before activating this button, the 14.7V charge
voltage requirement should be conrmed. If a
battery requires this higher charge voltage, it will
be described on the battery.
Power Supply mode
Keep pressing the button until the LED shines one
by one in a regular buttom to the top cycle, the
charger will start power supply mode. In this mode,
the charger supply 13.6V.
If the output short circuit or connect with incorrect
polarity in this mode, the charger will go into error
mode. You should press the power button to turn
off the charger, then restart the charger (go to
charger or power supply mode).

18 English
Safety features
Incorrect polarity
Spark protection
Short circuit protection
Over-current protection
Over-temperature protection
Over-voltage protection
Low voltage protection
Approvals
Safety:
EN 60335-1: 2012
EN 60335-2-29: 2004+A2:2010
EN 62233:2008
EMC (emission):
EN 61204-3:2000
EN 61000-3-3:2008
EN 61000-3-2:2006+A1:2009+A2:2009
EMC (immunity):
EN 61204-3:2000
Automatic restart after power interruption
If the mains’ power supply is temporarily interrupted,
the charger will continue charging when the power
supply returns.

19English
Technical data
Type 701515 (4A) 706060 (6A)
Battery size
[V/Ah] 12/2–110 12/10–150
Input [VAC/Hz] 230/50–60
Power
consumption
[W] 60 115
Output voltage
[V] 14,4/14,7
Output current
[A] 4 (max.) 6 (max.)
Reverse current
[mA] I drain < 1
IP class [IP] 65
Type 701785 (8A) 706161 (10A)
Battery size
[V/Ah] 12/20–200 12/30–250
Input [VAC/Hz] 230/50–60
Power
consumption
[W] 132 175
Output voltage
[V] 14,4/14,7
Output current
[A] 8 (max.) 10 (max.)
Reverse current
[mA] I drain < 1
IP class [IP] 65

20 Norsk
Sikkerhetsadvarsler
1. Dette produktet skal ikke brukes av
barn eller personer med redusert
fysisk, sansemessig eller mental
funksjonsevne med mindre de veiledes
av en person som er ansvarlig for
sikkerheten deres.
2. Barn skal ikke leke med dette
produktet.
3. Barn skal ikke rengjøre eller
vedlikeholde produktet uten tilsyn fra
voksne, all reparasjon skal utføres av
profesjonelle.
4. Nettledningen kan ikke byttes. Ikke bruk
laderen hvis nettledningen er skadet.
5. Denne laderen er utformet for bruk ute-
lukkende på BLY/SYRE-batterier (både
åpne og lukkede), bl.a. variantene
med AGM, GEL og kalsium, og for 12 V
batterier på 8–225 Ah. Laderen må ikke
brukes på andre batterityper. Lade ikke-
oppladbare batterier er forbudt!
6. Batteriene kan avgi eksplosjonsfarlige
gasser under normal lading. Unngå
gnister i umiddelbar nærhet og sørg
alltid for god lufting under ladingen.
7. Koble til batteriterminalen på batteriets
+ pol. Koble til - pol eller chassis i god
avstand fra bensinledninger o.l. Koble
så til strømnettet.
8. Slå av laderen når ladingen er ferdig
og trekk ut støpselet fra vegguttaket.
Deretter kan - pol og + pol kobles fra.