Hendi HND299289 User manual

HIGH POWER BLENDER
HND299289
You should read this user manual carefully before using the appliance.

2
Keep these instructions with the appliance.
For indoor use only.

3
EN
Dear Customer,
Thank you for purchasing this Hendi appliance. Before using the appliance for the first time, please
read this manual carefully, paying particular attention to the safety regulations outlined below.
Safety regulations
• This appliance is intended for buffet and household use.
• The appliance must only be used for the purpose for which it was intended and
designed. The manufacturer is not liable for any damage caused by incorrect
operation and improper use.
• Keep the appliance and electrical plug away from water and any other liquids. In the
event that the appliance should fall into water, immediately remove plug from the
socket and do not use until the appliance has been checked by a certified technician.
Failure to follow these instructions could cause a risk to lives.
• Never attempt to open the casing of the appliance yourself.
• Do not insert any objects in the casing of the appliance.
• Do not touch the plug with wet or damp hands.
• DANGER OF ELECTRIC SHOCK! Do not attempt to repair the appliance yourself.
In case of malfunctions, repairs are to be conducted by qualified personnel only.
• Never use a damaged appliance! Disconnect the appliance from the electrical outlet
and contact the retailer if it is damaged.
• WARNING! Do not immerse the electrical parts of the appliance in water or other
liquids. Never hold the appliance under running water.
•Regularly check the power plug and cord for any damage. If the power plug or power
cord is damaged, it must be replaced by a service agent or similarly qualified persons
in order to avoid danger or injury.
•Make sure the cord does not come in contact with sharp or hot objects and keep it
away from open fire. To pull the plug out of the socket, always pull on the plug and
not on the cord.
•
Ensure that the cord (or extension cord) is positioned so that it will not cause a trip
hazard.
• Always keep an eye on the appliance when in use.
•WARNING!
As long as the plug is in the socket the appliance is connected to the power
source.
• Turn off the appliance before pulling the plug out of the socket.
• Never carry the appliance by the cord.
• Do not use any extra devices that are not supplied along with the appliance.
• Only connect the appliance to an electrical outlet with the voltage and frequency
mentioned on the appliance label.
• Connect the power plug to an easily accessible electrical outlet so that in case of
emergency the appliance can be unplugged immediately. To completely switch off
the appliance pull the power plug out of the electrical outlet.

4
EN
• Always turn the appliance off before disconnecting the plug.
• Never use accessories other than those recommended by the manufacturer. Failure
to do so could pose a safety risk to the user and could damage the appliance. Only
use original parts and accessories.
•This appliance is not intended for use by persons (including children) with reduced
physical, sensory or mental capabilities, or lack of experience and knowledge.
•This appliance must not be used by children under any circumstances.
•Keep the appliance and its cord out of reach of children.
•Always disconnect the appliance from the mains if it is left unattended or is not in
use, and before assembly, disassembly or cleaning.
•Never leave the appliance unattended during use.
Special safety regulations
• Use the machine only as described in this manual.
• This machine should be operated and installed by specialized trained personnel in
the kitchen of the food industry.
• All maintenance, installation and repair works should be performed by specialized
trained authorized technicians.
• Do not place the machine on a heating object (gasoline, electric, charcoal cooker,
etc.) Keep the appliance away from any hot surfaces and open flames. Always oper-
ate the machine on a level, stable, clean, heat-resistant and dry surface.
• Do not use the machine near explosive or flammable materials, credit cards, mag-
netic discs or radios.
• Wear protective clothing, mask, or protective glasses if necessary during operation.
• This machine is not intended to be operated by means of an external timer or sepa-
rate remote-control system.
• Never bypass any safety interlocks on the machine.
• WARNING: Keep all ventilation openings in the appliance clear of obstruction.
• WARNING: ALWAYS switch off the machine and unplug from electrical power supply
before cleaning, maintenance or storage.
• WARNING! ALWAYS keep hands, long hair and clothing away from the moving parts.
• Allow at least 20 cm spacing around the appliance for ventilation purpose during use.
• CAUTION! Securely route the power cord if necessary in order to prevent unintention-
al pulling or contact with the heating surface.
• Do not put hands into the jug set when the machine is in operation.
• Do not load too much ingredients in order to prevent overflow of the food products.
• WARNING! Do not fill above the MAX. mark of the jug.
• WARNING! Liquids to blend should be at or below room temperature. If you are going
to blend warm liquids, ensure that the jug lid is correctly in place and use low speed
for processing. Risk of burns and be careful.
• Do not wash the machine with water or a waterjet. Washing with water can cause
leakage and increase the risk of electric shock. No parts are dishwasher safe.

5
EN
• Do not clean or store the machine unless it is completely cooled down.
• Do not move the machine while it is under operation. Unplug the machine when
moving the machine and hold it at the bottom.
• Do not operate the machine without ingredients to avoid overheated.
• Ensure the machine is switched OFF (0) and the speed dial in the “Low” position
before removing the jug set.
• WARNING: Appliance may produce noice levels exceeding 85dB, wear proper pro-
tection.
• WARNING: Always hold the jar when starting the appliance.
• WARNING: Only place food in the blender, never leave utensils or transparant cap in
the jar when operationg the appliance.
• WARNING: Only use the appliance with the lid on the jar, never without.
• WARNING: Never use a leaking can, this will damage the moter unit.
• WARNING: Never use the appliance without food or liquid in the jar, this will damage
the motor.
• WARNING: Never use the appliance for a prolonged time of 5 minutes, after 5 min-
utes the appliance needs to cool down for 15 minutes.
Intended use
• This appliance is intended for buffet and
household use.
• The appliance is designed for blending and
mixing food. Any other use may lead to damage
to the appliance or personal injury.
• Operating the appliance for any other purpose
shall be deemed as a misuse of the device. The
user shall be solely liable for improper use of
the device.
Grounding installation
This appliance is classified as protection class
I and must be connected to a protective ground.
Grounding reduces the risk of electric shock by
providing an escape wire for the electric current.
This appliance is fitted with a power cord that
has a grounding wire and grounded plug. The
plug must be plugged into an outlet that is prop-
erly installed and grounded.
Preparations before using for the first time
• Check to make sure the appliance is undam-
aged. In case of any damage, contact your
supplier immediately and do NOT use the ap-
pliance.
• Remove all the packing material.
• Keep the packaging if you intend to store your
appliance in the future.
• Clean the appliance with lukewarm water
with a non foaming detergent and a soft cloth.
Rinse thourougly and dry.
• Place the appliance on a level and steady sur-
face.
• Keep a clear space of 20 cm around the appli-
ance for ventilation purposses.
• Position the appliance in a way that the plug is
accessible at all times.

6
EN
Appliance and parts
1) transparant cap
2) lid
3) pusher
4) jar handle
5) jar
6) cutting unit
7) control panel
8) motor unit
NOTE: Grey marked parts are food contact ap-
proved.
1
23
4
5
6
7
8
Operation
• Always stand in front of the appliance in such
a way that the control panel can be easily
reached.
• Check if the motor unit is switched off and un-
plug it.
• Place the ingredients in the jar.
• Close the lid firmly.
• Place the jar onto the motor unit.
• Plug the appliance into mains.
• Switch on the motor unit.
• NOTE: Always start at low speed.
• The ‘power’-button (left button) on the motor
unit lets the appliance run continuously at the
variable speed determined setting of the speed
dial (center knob).
• Turn the speed dial clockwise for increasing
the speed and counter clockwise for decreas-
ing the speed.
• The ‘Pulse’-button (right button) on the motor
unit lets the motor run at full speed. The motor
stops if the button is released.
• Switch off the motor and wait until the motor
comes to a complete stop before removing the
container.
• The motor will automatically shut down if the
jar is removed.
• Unplug the appliance from the outlet when not
in use.
WARNING: Never place the jar on a switched on motor unit. This will damage the clutch on the motor
unit and on the jar. Only place the container onto the motor unit if the motor is switched off.

7
EN
Cleaning and maintenance of the motot unit
• Always remove the plug from mains before
cleaning the appliance.
• Beware: Never immerse the appliance in water
or any other liquid!
• Clean the outside of the appliance with a damp
cloth (water and a mild detergent).
• Never use aggressive cleaning agents and/or
abrasives. Do not use any sharp and/or pointed
objects. Do not use petrol or solvents! Clean
with a damp cloth and mild detergent if neces-
sary. Do not use abrasive materials.
Cleaning and maintenance of the jar
• Pour luke warm water and a mild non foaming
detergent into the jar.
• Place the lid onto the jar.
• Place the jar on to the motor unit.
• Switch the motor unit on at full speed for 10-20
seconds.
• Switch off the motor unit.
• Remove the jar from the motor unit.
• Rinse the jar thoroughly with clean water.
• In case of residu stuck to the knife carefully
clean with a small knife or tweezers. Never
clean the knife with your bare hands.
• Dry the in- and outside of the jar.
• After cleaning disinfect the jar. Use the in-
structions of the disinfectant manufacturer.
• Store the jar upside down.
• The underside of the jar may never come into
contact with any fluid!
• WARNING: Never disassamble parts of the jar
and cutting unit.
• WARNING: Never clean any parts of the appli-
ance in the dishwasher.
Troubleshooting
If the appliance does not function properly, please check the below table for the solution. If you are still
unable to solve the problem, please contact the supplier/service provider.
Problem Cause Solution
Appliance doesn’t work No power Check if the plug is connected
to mains.
Knife has been jammed Push the reset button on the
underside of the motor unit.
Appliance overheated Remove the plug from mains
and let the appliance cool down
The jar is not placed on the
motor unit
Switch the appliance of and
place the jar on the motor unit
and try again
Appliance makes a strange
noise
Motor worn out or jar damaged Contact your supplier.
Appliance emits an odd smell Motor unit burnt Contact your supplier.
The jar leaks or is otherwise
damaged
Worn out cutting unit Contact your supplier.
Extreme vibrations Worn out motor unit or jar Contact your supplier.
Appliance doesn’t cut evenly The knife is damaged Contact your supplier.
The appliance only works when
puls switch is used
Power module is defective Contact your supplier.

8
EN
Electric diagram (mechanical control models)
Motor
Pulse switch
Sensitive switch
Over load protection
Earth
Variable switch
Speed knob
On/Off
AC 220-240V
Technical specification
Item no.: HND299289
Operating voltage and frequency: 240V~ 50/60Hz
Peak power ≈ 1680 W
Dimensions: 270x250x(H)550 mm
Nominal volume: 2,5 liter
Net weight: approx. 5,5 kg
Rotation speed without loading (rpm):
- Minimum: 16,000 +/- 10%
- Maximum : 24,800 +/- 10%
Noise level: >85dB
Protection class: Class I
Jar material: PC

9
EN
Exploded drawing and part list

10
EN
Part no. Part name Quantity Remark
1 Small Lid 1
2 Cover set 1 Contains also part no. 1
3 Pusher 1
4 2.5L jar set 1 Contains also part no. 1,2,4,5,6,7
5 Knife set 1
6 Seal Ring 1
7 Fixed Plate 1
8 M4*6 Screw 1
9 Rotor 1 Contains also part no. 8
10 Base of 2.5L Jar 1
11 Body 1
12 Pulse Switch 1
13 On/Off Switch 1
14 Control Panel 1
15 Knob 1
16 Potentiometer 1
17 Warning Label 1
18 Shock protection for the motor 4
19 95*40 Motor 1 Contains also part no. 18
20 PCB Board 1 including sound filter PCB
21 Bottom Cover 1
22 Plastic Feet 4 Sold per piece
23 Air Deflector 1
24 Plate of Air Deflector 1
25 Power Cord 1
26 Over-Load Protection 1
27 Microswitch 1
28 Base of Microswitch 1

11
EN
Important notice to UK users
This appliance is fitted with a UK approved mains
plug and a 13A fuse. Should the fuse need to be
replaced, an ASTA or BSI approved BS1362 fuse,
rated at 13A must be used. If the plug needs re-
placing, ensure that the fuse is removed before-
hand. Always dispose of defunct plugs and fuses
immediately.
Warranty
Any defect affecting the functionality of the ap-
pliance which becomes apparent within one year
after purchase will be repaired by free repair or
replacement provided the appliance has been
used and maintained in accordance with the in-
structions and has not been abused or misused
in any way. Your statutory rights are not affected.
If the appliance is claimed under warranty, state
where and when it was purchased and include
proof of purchase (e.g. receipt).
In line with our policy of continuous product de-
velopment we reserve the right to change the
product, packaging and documentation specifi-
cations without notice.
Discarding & Environment
When decommissioning the appliance, the prod-
uct must not be disposed of with other house-
hold waste. Instead, it is your responsibility to
dispose to your waste equipment by handing it
over to a designated collection point. Failure to
follow this rule may be penalized in accordance
with applicable regulations on waste disposal.
The separate collection and recycling of your
waste equipment at the time of disposal will help
conserve natural resources and ensure that it is
recycled in a manner that protects human health
and the environment.
For more information about where you can drop
off your waste for recycling, please contact your
local waste collection company. The manufac-
turers and importers do not take responsibility
for recycling, treatment and ecological disposal,
either directly or through a public system.

Manufacturer: Hendi B.V.
Innovatielaan 6
6745 XW De Klomp, The Netherlands
Tel: [phone]
Email: [email protected]
Importer: Neville UK PLC
Unit 6, Viking Way. Erith, Kent.
DA8 1EW, England
https://www.nevilleuk.com/
Hendi HK Ltd.
1208, 12/F, Exchange Tower
33 Wang Chiu Road, Kowloon Bay, Hong Kong
Tel: [phone]
Email: [email protected]
Find Hendi on internet:
www.hendi.eu
www.facebook.com/HendiToolsforChefs
www.linkedin.com/company/hendi-food-service-equipment-b.v.
www.youtube.com/HendiEquipment
- Changes, printing and typesetting errors reserved.
© 2022 Hendi B.V. De Klomp - The Netherlands Ver: 15-02-2022