ORiNG IES-1080A User manual

Version 1.1
Quick Installation Guide
ORing Industrial Networking Corp.
SWITCH
INDUSTRIAL
QIG www.oring-networking.com Quick Installation Guide
IES-1000 Series PRINTED ON RECYCLED PAPER
IES-1050R
Features
Dual redundant DC power inputs at terminal block
Support 100TX, 1000T, 100Base-FX and 1000BaseX ports
Very wide operating temperature range from -40 to 70 C
Rigid IP-30 housing design
DIN-Rail and panel mounting enabled
o
IES-1000 Series . IES-1000 series
IES-1000 Series
are unmanaged Ethernet switches support dual
redundant power inputs, relay output alarm, and rigid IP-30 housing. In addition, the
wide operating temperature range from -40 C to 70 C can satisfy most of operating
environment.
can be used in connecting several Ethernet devices like Ethernet
I/O, IP-Camera or other Ethernet switches. In addition, there are two different power
inputs at terminal block to avoid interruption caused by power down. When the
primary DC power input fails, the backup power input will take over immediately to
guarantee a non-stop operation.
oo
World's Fastest Recovery Time: < 10mS (O-Ring)
support the fastest 10mS redundant recovery time which make a non-stop
Ethernet connection. If your primary communication path is disconnected, the O-Ring
Technology switch the data to redundant path in the network. Its 10mS ultra fast
recovery time allows to provide a solid foundation of highly fault-tolerant
and easily-managed network.
IES-1050R
IES-1050R
Redundant Ring (<10mS): O-Ring
PLC
O-Ring
(<10mS)
IPC
Introduction
O-Ring Ethernet Redundant Technology
IES-1050R
IES-1050R
IES-1050R
Specifications
ORing Switch Model IES-1080 IES-1062GF-MM
IES-1062FX-MM IES-1062FX-SSIES-1062GT
10/100 Base-T(X) Ports in RJ45
Auto MDI/MDIX 8
Physical Ports
6666
100 Base-F(X) Multimode Port
(2KM,1310nm,SC connector)
-2---
100 Base-F(X) Singlemode Port
(30KM,13100nm,SC connector)
--2--
1000Base-SX Multimode Port
(550M,850nm,SC connector)
---2-
1000Base-LX Singlemode Port
(10KM,1310nm,SC connector)
----2
-----
Technology
Ethernet Standards
IEEE 802.3 for 10Base-T,
IEEE 802.3u for 100Base-T(X) and 100Base-FX,
IEEE 802.3ab for 1000Base-T
IEEE 802.3x for Flow control
LED indicators
Green: Power LED x3Power Indicator
Amber:IndicatePWR1orPWR2failure
10/100TX RJ45 Port Indicator
Fault Indicator
Fiber Port Indicator
Fault contact
Relay Relayoutputtocarrycapacityof1Aat24VDC
Power
Redundant Input power
Power consumption(Typ.)
Triple DC inputs. 12-48VDC on 7-pin terminal block, 12-45VDC on power jack
4Watts 6Watts
Overload current protection
Reverse polarity protection
Present
Present on terminal block
Physical Characteristic
Enclosure IP-30
Dimension(WxDxH) 52(W)x106(D)x144(H) mm (2.05x4.17x5.67 inch.)
Weigh t (g)
Environmental
-40to85C(-40to185F)
oo
Storage Temperature
-40to70C(-40to158F)
oo
Operating Temperature
5% to 95% Non-condensingOperating Humidity
Regulatory approvals
FCC Part 15, CISPR (EN55022) class AEMI
EN61000-4-2 (ESD),
EN61000-4-3 (RS),
EN61000-4-4 (EFT),
EN61000-4-5 (Surge),
EN61000-4-6 (CS),
EN61000-4-8,
EN61000-4-11
EMS
IEC60068-2-27Shock
IEC60068-2-32
IEC60068-2-6Vibration
EN60950 Safety
Free Fall
Warranty
5 years
IES-1062GF-MM
6
-
-
-
-
2
1000 Base-T Ports in RJ45
Auto MDI/MDIX
MAC Table 8192 MAC addresses
Processing Store-and-Forward
Green for port Link/Act. Amber for Duplex/Collision
GreenforportLink/Act.AmberforLink
7Watts 8Watts 8Watts 6Watts
666 g 685 g677 g 680 g 680 g 685 g
8-port /10-port Unmanaged Switches
IES-1082GP
8
-
-
-
-
-
7Watts
709 g
1000Base-X SFP Port ----- - 2
IES-1000 Series Industrial Unmanaged Switch
ORing Industrial Networking Corp.
Copyright© 2008 ORing
All rights reserved.
TEL: [phone]
FAX: [phone]
Website: www.oring-networking.com
E-mail: [email protected]
ORing Switch Model IES-1080A IES-1042FX-MM
IES-1041FX-MM IES-1041FX-SSIES-1050A
10/100 Base-T(X) Ports in RJ45
Auto MDI/MDIX 8
Physical Ports
5444
100 Base-F(X) Multimode Port
(2KM,1310nm,SC connector)
-----
100 Base-F(X) Singlemode Port
(30KM,1310nm,SC connector)
--1-2
---1-
Technology
Ethernet Standards
IEEE 802.3 for 10Base-T,
IEEE 802.3u for 100Base-T(X) and 100Base-FX,
IEEE 802.3x for Flow control
LED indicators
Green: Power LED x2Power Indicator
Amber:IndicatePWR1orPWR2failure
10/100TX RJ45 Port Indicator
Fault Indicator
Fault contact
Relay Relayoutputtocarrycapacityof1Aat24VDC
Power
Redundant Input power
Power consumption(Typ.)
Dual DC inputs. 12-48VDC on 6-pin terminal block.
4Watts 7Watts
Overload current protection
Reverse polarity protection
Present
Present
Physical Characteristic
Enclosure IP-30
Dimension(WxDxH) 26.1(W)x95(D) x 144.3(H) mm (1.30 x 3.74 x 5.68 inch.)
Weigh t (g)
Environmental
-40to85C(-40to185F)
oo
Storage Temperature
-40to70C(-40to158F)
oo
Operating Temperature
5% to 95% Non-condensingOperating Humidity
Regulatory approvals
FCC Part 15, CISPR (EN55022) class AEMI
EN61000-4-2 (ESD),
EN61000-4-3 (RS),
EN61000-4-4 (EFT),
EN61000-4-5 (Surge),
EN61000-4-6 (CS),
EN61000-4-8,
EN61000-4-11
EMS
IEC60068-2-27Shock
IEC60068-2-32
IEC60068-2-6Vibration
EN60950 Safety
Free Fall
Warranty
5 years
IES-1042FX-SS
4
-
-
2
1000 Base-T Ports in RJ45
Auto MDI/MDIX
MAC Table 2048 MAC addresses
Processing Store-and-Forward
Green for port Link/Act. for Duplex/CollisionAmber
3.5 Watts 5 Watts
391 g 395 g
5-port / 6-port /8-port Unmanaged Switches (Slim Type)
ORing Switch Model IES-1050 IES-1050R
10/100 Base-T(X) Ports in RJ45
Auto MDI/MDIX 5
Physical Ports
5
Technology
Ethernet Standards
IEEE 802.3 for 10Base-T,
IEEE 802.3u for 100Base-T(X) and 100Base-FX,
IEEE 802.3x for Flow control
LED indicators
Green: Power LED x1Power/Readyindicator
Amber:IndicatesystemoperatedinO-RingMastermode
10/100TX RJ45 Port Indicator
R.M. Indicator
Power
Input power
Power consumption(Typ.)
9~ 30 VDC voltage power input at 3-pin terminal block
3Watts
Overload current protection
Reversepolarityprotection
Present
Present on terminal block
Physical Characteristic
Enclosure IP-30
Dimension (W x D x H) 88(W) x 102(D) x 24(H)mm (3.46 x 4.0 x 0.94 inch.)
Weigh t (g)
Environmental
-40to85C(-40to185F)
oo
Storage Temperature
-10to60C(14to140F)
Extended temperature model
(-40to70 C,-40to158 F,-Tmodel)
oo
oo
Operating Temperature
5% to 95% Non-condensingOperating Humidity
Regulatory approvals
FCC Part 15, CISPR (EN55022) class AEMI
EN61000-4-2 (ESD),
EN61000-4-3 (RS),
EN61000-4-4 (EFT),
EN61000-4-5 (Surge),
EN61000-4-6 (CS),
EN61000-4-8,
EN61000-4-11
EMS
IEC60068-2-27Shock
IEC60068-2-32
IEC60068-2-6Vibration
EN60950 Safety
Free Fall
Warranty
5 years
MAC Table
Processing Store-and-Forward
Green for port Link/Act. for duplex indicatorAmber
305 g 308 g
5-port Unmanaged Switches
2048 MAC addresses
Network Redundancy O-Ringwithrecoverytimelessthan10msover250units
-
-
Amber:IndicateportoperatedinO-Ringmode
O-Ring indicator -
-40 to 70 C (-40 to 158 F)
oo
1000Base-SX Multimode Port
(550M,850nm,SC connector)
1000Base-LX Singlemode Port
(10KM,1310nm,SC connector)
1000Base-X SFP Port
-----
-----
-----
-
-
-
Fiber Port Indicator
100 Base-F(X) Multimode Port
(2KM,1310nm,SC connector)
100 Base-F(X) Singlemode Port
(30KM,1310nm,SC connector)
1000 Base-T Ports in RJ45
Auto MDI/MDIX
1000Base-SX Multimode Port
(550M,850nm,SC connector)
1000Base-LX Singlemode Port
(10KM,1310nm,SC connector)
1000Base-X SFP Port
- -
- -
- -
- -
- -
- -
Network Redundancy -
Fault Indicator -
Fiber Port Indicator -
Fault contact
Relay -
R.M. Indicator -
O-Ring indicator -
-
Network Redundancy -
R.M. Indicator -
O-Ring indicator -
7 Watts5Watts
390 g 395 g 406 g406 g
-
-Green for port Link/Act.
Green for port Link/Act.

IES-1000IES-1000
IES-1050
Power
P1
P2
P3
P4
P5
Duplex
Industrial 8-port Ethernet Switch
with 6x10/100TX 2x1000TX
Unmanaged
and
Industrial 8-port Unmanaged Ethernet Switch
2x100FX (Multi-mode)
with 6x10/100TX and
Industrial 8-port Unmanaged Ethernet Switch
2x1000SX (Multi-mode)
with 6x10/100TX and
Industrial 5-port Unmanaged Ethernet Switch
with 5x10/100TX
Industrial 8-port Unmanaged Ethernet Switch
2x100FX (Single-mode)
with 6x10/100TX and
Industrial 8-port Unmanaged Ethernet Switch
2x1000LX (Single-mode)
with 6x10/100TX and
Industrial Unmanaged Ethernet Switch8-port
with 8x10/100TX
Industrial 6-port slim type Unmanaged
Ethernet Switch with 4x10/100TX and
2x100FX (Multi-mode)
Industrial 6-port
Ethernet Switch with 4x10/100TX and
2x100FX (Single-mode)
slim type Unmanaged
IES-1042FX-MM
Model name Model Description Accessory
Industrial 8-port slim type Unmanaged
Ethernet Switch with 8x10/100TX
Duplex LED
PowerOnLED
LAN Port LNK/ACT LED
Front Panel
F
E
F
A
B
B
B
B
A
C
I
6X1, 7X8, 9X8, 10 X2,
11 X1, 12 X1
1X1, 2X1, 3X6,
X8, X1
4X1,
Front Panel
P1 P2
P3 P4
P5 P6
G1
G2
PowerOnLED
Power 1 LED
Power 2 LED
Power Fault LED
(P8)
(P7)
A
P1 P2
P3 P4
P5 P6
1
(P8)
(P7)
B
C
IES-1000 Series (Slim Type)
IES-1042FX-SS
IES-1080A
IES-1000 Series
G
IES-1062GT
IES-1062FX-MM
IES-1080
IES-1050
IES-1082GP
Industrial 5-port Unmanaged Redundant
Ethernet Switch with 5x10/100TX
D
Model name Model Description Accessory
Front Panel
Power
Accessory
Wall-mounted kit
145mm DIN-Rail kit
2Flat Screw (M3 X5)
3
7 Pin Terminal block
43 Pin Terminal block
5
Dust Cover (RJ-45)
7
QIG
9
IES-1062FX-SS
IES-1062GF-MM
IES-1062GF-SS
IES-1050R
Industrial 10
2x1000 SFP
-port Unmanaged Ethernet
Switch and
QIG www.oring-networking.com
Quick Installation Guide
ORing Industrial Networking Corp.
SWITCH
INDUSTRIAL
Version 1.1
Quick Installation Guide
IES-104XFX
1
2
3
4
5
6
TX
RX
TX
RX
LINK/
ACT
P1 P2 Fault
10/100M
1
2
3
4
5
6
7
8
P1 P2 Fault
10/100M
IES-10X0A
Power Fault LED
Power LED
Fiber Port LNK/ACT LED
G
P1 P2
P3 P4
LINK / ACT
LINK / ACT
G1
G2
P5 P6
P7 P8
IES-1082GP
IES-1082GP
SFP 1000BaseX Fiber Port
Giga Fiber Port
ACT LEDLNK /
FE
Dust Cover (SFP)
8
Packing list
Wall-mounted kit (for Slim Type)
10 25mm DIN-Rail kit
11
6 Pin Terminal block
6
712
LNK/ACT LED
(Green)
LAN Port
Full Duplex LED
(Amber)
PRINTED ON RECYCLED PAPER
No.6 Fiber Port
(IES-1042FX Only)
No.6-8 LAN Port
(IES-1080A Only)
Industrial 5-port slim type Unmanaged
Ethernet Switch with 4x10/100TX and
1x100FX (Multi-mode)
Industrial 5-port
Ethernet Switch with 4x10/100TX and
1x100FX (Single-mode)
slim type Unmanaged
IES-1041FX-MM
Industrial 5-port slim type Unmanaged
Ethernet Switch with 5x10/100TX
F
E
F
IES-1041FX-SS
IES-1050A
No.5 Fiber Port
Installation
8-port /10-port Switches
5-port Switches
5-port / 6-port / 8-port Switches (Slim type)
DIN-Rail Install Step
DIN-Rail Install Step
DIN-Rail Install Step Wall-mounted Install Step
Wall-mounted Install Step
No.2 Giga Port
No.1 Giga Port
LNK/ACT LED
(No.8 LAN Port)
(No.7 LAN Port)
No.2 Fiber PortGiga
Fiber ACTLEDLNK/
(No.8 Fiber Port)
No.1 Fiber PortGiga
(No.7 Fiber Port)
LNK/ACT LED
(Green)
LAN Port
Full Duplex LED
(Amber)
10/100 LAN Port
IES-1050R
Ready
P1
P2
P3
P4
P5
Reset/
Mode
Switch Ready
LED
Wall-mounted Ear
Reset/Mode Button
LAN Port
LNK/ACT LED
Ring Master LED
10/100 LAN Port
Ring Enabled LED
D
Round Screw (M3 X3)
12
5-port Switches
10/100 LAN Port
Power Connection Guide
5-port / 6-port / 8-port Switches
Frame Ground
PWR-1PWR-2
V2+V2- V1+V1-
G
1A@24V DC12-48V
DIP Switch Function
Warning
Device
GND+24V
DIP Switch Select for
Power Alarm Output
Power
Supply
PWR-1 PWR-2
PWR-3 12-45VDC
G V1+ V1- Relay V2+ V2-
-
+
Frame Ground
Terminal Block Power-1 Input
Relay Output Pin
Terminal Block Power-2 Input
Power-3 12-45VDC
8-port / 10-port Switches
8-port Switches
5-port Switches
5-port / 6-port / 8-port Switches
Industrial Unmanaged Switch
IES-1000 Series
IES-1000 Series
Terminal Block Power-1 Input
Terminal Block Power-2 Input
Terminal Block Power Input 9-30VDC
Frame Ground
V+ V-
1X1, 2X1, 3X6,
X8,
4X1,
7
1X1, 2X1, 3X6,
X6,
4X1,
7
1X1, 2X1, 3X6,
X6,
4X1,
7
1X1, 2X1, 3X6,
X6,
4X1,
7
1X1, 2X1, 3X6,
X6,
4X1,
7
5X1, 7X5, 12 X1
1X1, 2X1, 3X6,
X8, X2,
4X1,
78 X1 12
6X1, 7X4, 9X8, 10 X2,
11 X1, 12 X1
6X1, 7X4, 9X8, 10 X2,
11 X1, 12 X1
6X1, 7X5, 9X8, 10 X2,
11 X1, 12 X1
6X1, 7X4, 9X8, 10 X2,
11 X1, 12 X1
6X1, 7X4, 9X8, 10 X2,
11 X1, 12 X1
G
P5
Ring Ring
Reset/
Mode
Ready
P1
P2
P3
P4
P5
X1
12
X1
X1
12
X1
12
X1
12
X1
12
X1,
2
5X1, 7X5, 12 X1
X1,
2
DIP-2
OFF
OFF
ON
DIP-1
Power failure relay alarm disabled
PWR-1 failure, alarm enablerelay
PWR-2 failure, alarm enablerelay
OFF
ON
OFF
Description