Dura Trel Kingston 11300 Installation guide

Model# 11300
Kingston Pergola
W221122-A5080
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
QUESTIONS? COMMENTS? CONTACT US!
115 Vision Parkway 1-877-258-6020
P.O. Box 122 www.dura-trel.com
Sheboygan Falls, WI 53085 [e-mail]
Assembly Instruction Manual
Please read instructions thoroughly before beginning assembly.
Check boxes carefully for contents listed. Some parts are packaged inside of others.
Assemble on a clean, flat, non-abrasive surface to prevent scratching.
In the event of missing or damaged parts please call or email our customer service department at
the contact info below.
Tools Required
-Battery or Electric Drill (#2 phillips bit)
-Tape Measure
-Hammer or Rubber Mallet (recommended)
-Shovel or Post Hole Digger (recommended)

Kingston Pergola - Page 2

Lay out one lower support rail(part
2).
[Lower support has six pilot
holes drilled in top edge]
Using ¾" painted screws, fasten
three upper support brackets (part
5) to lower support.
Insert ends of lower support rail
through bottom routed holes of two
posts (part 1).
Do not screw together at this time.
REPEAT steps 1 and 2 using
remaining lower support, upper
support brackets and posts.
Insert ends of two upper
support rails (part 3) through
top routed holes of posts.
[Upper support have seven
equally spaced pilot holes
drilled in top edge]
Do not screw together at this
time.
1
2
3
Kingston Pergola - Page 3

Lay two top cross rails (part 4) onto
upper supports. To set width of
pergola, line up outer most holes of
top rails with outer most pilot holes of
upper supports. Using 1¼” painted
screws, fasten top rails to upper
supports.
Using 2” painted screws, screw
together all posts and supports.
5
4
6
Slide three remaining upper support
rails (part 3) through upper support
brackets, underneath top rails.
Kingston Pergola - Page 4

Using 1¼” painted screws, fasten top
cross rails to upper supports.
[This will center remaining upper
supports]
9
9
7
Using 1¼” painted screws, fasten
remaining top cross rails (part 4) to
upper supports.
Using included Super Glue, glue post
caps (part 6) to top of posts. Glue
support end caps (part 7) to ends of
upper and lower supports. Glue ⅞ x
1½" end caps to ends of top cross
rails.
8
Kingston Pergola - Page 5

Option 1 (soft ground)
Slide one ground anchor (part 8) into bottom of
each post (approximately 8 inches). Using two 1”
self-tapping screws per post, screw the post to
ground anchor using the pilot holes for guides.
Using ground anchor installation layout drawing,
dig holes approximately 18” deep. Set arbor in
holes and level. Back fill with soil removed from
holes.
Option 2 (permanent installation)
NOTE: There is very little room for error with this
installation method.
Using ground anchor installation layout drawing,
dig holes 18” deep according to dimensions. Fill
with cement and place ground anchors in wet
cement. Be sure that ground anchors are straight
and in accordance with dimension of ground
anchor installation layout drawing. Allow cement
to dry.
Slide pergola over ground anchors. Using two 1”
self-tapping screw, fasten post to ground anchor.
Kingston Pergola - Page 6

Warranty Statement
20 Year Guarantee
Please call manufacturer direct with questions concerning missing or defective parts at Toll Free:
877-258-6020.
Dura-trel, Inc. products are warranted to be free from manufacturing defects resulting in delaminating,
peeling, flaking, corroding, cracking, crazing, or extreme amounts of fading or bleaching causing the
PVC to change to its natural color for a period of 20 years from the date of purchase.
Normal weathering is defined as exposure to sunlight and extremes of weather and atmosphere which
will cause any colored surface to gradually fade.
CONDITIONS NOT COVERED BY THIS WARRANTY:
A. Physical abuse, misuse, neglect, or improper storage.
B. Improper installation or installation not in strict adherence to the instructions written by Dura-Trel,
Inc.
C. This warranty does not apply if materials are painted, varnished, or coated with any substance.
D. Dura-Trel, Inc. is not responsible for damages to product during shipping.
E. Damage attributable to atmospheric pollutants, hail, lightning, hurricane, tornado, wind borne
objects, earthquake, fire, mildew, casualty, act of God, building or ground settlement, or subjection to
stress or weight.
CLAIMS AND REMEDIES:
If a Dura-Trel, Inc. product is determined to have a manufacturing defect which is covered by this
warranty, Dura-Trel, Inc. will replace the material containing the defect (labor not included) F.O.B from
the point of manufacture. Dura-trel, Inc. will not be responsible for any cost incurred in the removal or
reinstallation of the product.
Important: All claims must be sent to the following address and should describe the defect claim.
Dura-Trel, Inc., P.O. Box 122, Sheboygan Falls, WI 53085
Dura-Trel, Inc. reserves the right to discontinue or change its design and/or color. If the original color
or style is not available, Dura-Trel, Inc. shall have the right to substitute a product designated by Dura-
Trel, Inc.
Dura-Trel, Inc. shall not be liable for any incidental, special, or consequential damages arising out of the
use of these products.
Kingston Pergola - Page 7