Dura Trel Lancaster Trellis 11192 Installation guide

Model# 11192
Lancaster Trellis
W221122-A5080
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
*W201121-A2040*
QUESTIONS? COMMENTS? CONTACT US!
115 Vision Parkway 1-877-258-6020
P.O. Box 122 www.dura-trel.com
Sheboygan Falls, WI 53085 [e-mail]
Assembly Instruction Manual
Please read instructions thoroughly before beginning assembly.
Check boxes carefully for contents listed. Some parts are packaged inside of others.
Assemble on a clean, flat, non-abrasive surface to prevent scratching.
In the event of missing or damaged parts please call or email our customer service department at
the contact info below.
Tools Required
-Battery or Electric Drill (#2 phillips bit)
-Tape Measure
-Hammer or Rubber Mallet (Recommended)
-Shovel or Post Hole Digger (Recommended)
-PVC, Super or Crazy Glue

85"
38"
Lancaster Trellis - Page 2

Lay out one right post (part 2). Starting at
bottom, insert 1 -top/bottom cross rail (part 3)
and center cross rails (part 4).
Slide vertical rails (part 5) through center rails and
into bottom rail.
Insert remaining top/bottom cross rail (part 3)
into right post and each vertical rail into top
cross rail.
1
2
3
Lancaster Trellis - Page 3

Slide left post (part 1) over corresponding
support and cross rails.
Using ¾" painted screws, screw together the
trellis. Be sure that all parts are fully inserted
into the posts before securing.
Using PVC, crazy or super glue, glue post
caps onto posts.
To secure to the wall, slide the 6" screw
through clear screw backer. Insert screw
through pre-drilled hole in post. To set
trellis away from the wall, slide screw
through the spacer tube. After securing,
snap screw cover over screw backer.
(NOTE: The wall mounting screws included
will not fasten to stone, brick or concrete
walls.)
4
5
6
Lancaster Trellis - Page 4

Option 1 (soft ground)
Slide one ground anchor (part 12) into bottom of each
post until it meets bottom cross rail. Using two 1” self-
tapping screws per post, screw the post to ground
anchor using the pilot holes for guides.
Using ground anchor installation layout drawing, dig
holes approximately 12” deep. Set trellis in holes and
level. Back fill with soil removed from holes.
Option 2 (permanent installation)
NOTE: There is very little room for error with this
installation method.
Using ground anchor installation layout drawing, dig
holes 12” deep according to dimensions. Fill with
cement and place ground anchors in wet cement. Be
sure that ground anchors are straight and in accordance
with dimension of ground anchor installation layout
drawing. Allow cement to dry.
Slide trellis over ground anchors. Using two 1” self-
tapping screws, fasten post to ground anchor.
Ground Anchor Installation
Ground Anchor Layout Drawing
37.75"
Lancaster Trellis - Page 5

Warranty Statement
20 Year Guarantee
Please call manufacturer direct with questions concerning missing or defective parts at Toll Free:
877-258-6020.
Dura-trel, Inc. products are warranted to be free from manufacturing defects resulting in delaminating,
peeling, flaking, corroding, cracking, crazing, or extreme amounts of fading or bleaching causing the
PVC to change to its natural color for a period of 20 years from the date of purchase.
Normal weathering is defined as exposure to sunlight and extremes of weather and atmosphere which
will cause any colored surface to gradually fade.
CONDITIONS NOT COVERED BY THIS WARRANTY:
A. Physical abuse, misuse, neglect, or improper storage.
B. Improper installation or installation not in strict adherence to the instructions written by Dura-Trel,
Inc.
C. This warranty does not apply if materials are painted, varnished, or coated with any substance.
D. Dura-Trel, Inc. is not responsible for damages to product during shipping.
E. Damage attributable to atmospheric pollutants, hail, lightning, hurricane, tornado, wind borne
objects, earthquake, fire, mildew, casualty, act of God, building or ground settlement, or subjection to
stress or weight.
CLAIMS AND REMEDIES:
If a Dura-Trel, Inc. product is determined to have a manufacturing defect which is covered by this
warranty, Dura-Trel, Inc. will replace the material containing the defect (labor not included) F.O.B from
the point of manufacture. Dura-trel, Inc. will not be responsible for any cost incurred in the removal or
reinstallation of the product.
Important: All claims must be sent to the following address and should describe the defect claim.
Dura-Trel, Inc., P.O. Box 122, Sheboygan Falls, WI 53085
Dura-Trel, Inc. reserves the right to discontinue or change its design and/or color. If the original color
or style is not available, Dura-Trel, Inc. shall have the right to substitute a product designated by Dura-
Trel, Inc.
Dura-Trel, Inc. shall not be liable for any incidental, special, or consequential damages arising out of the
use of these products.
Lancaster Trellis - Page 6